Saturn · Ion · 2006
6
Recalls
1,235
Complaints
-
Not Rated
The 2006 Saturn Ion has 6 recalls and 1,235 owner-reported complaints on file with NHTSA. Most reported issue: steering (455 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Remedy Status
General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Remedy Status
GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Remedy Status
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Remedy Status
UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Remedy Status
DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
The contact owns a 2006 Saturn Ion. The contact stated that the instrument panel and radio were intermittently inoperable. The contact stated that the ignition switch failed to turn to the OFF position as needed intermittently. Additionally, the contact stated that while driving and turning the steering wheel to the right to make a right turn, the steering was significantly wobbly. The contact related the failure to NHTSA Campaign Numbers: 14V171000 (Electrical System) and 14V153000 (Steering). Additionally, the contact stated that the vehicle was experiencing a fuel leak. The vehicle was taken to the Subaru dealer, where it was purchased. The vehicle was not diagnosed or repaired. An unknown Chevrolet dealer was contacted and confirmed that the VIN was not included in a recall. The manufacturer was notified of the failure and informed the contact that unknown recalls were previously performed on the vehicle. The failure mileage was approximately 85,200.
Airbags
The contact owns a 2006 Saturn Ion. The contact stated while exiting a driveway and making a turn, the steering wheel became difficult to turn. There was no warning light illuminated. The contact checked the power steering fluid reservoir and there was power steering fluid in the reservoir. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 90,000.
The contact's mother owns a 2006 Saturn Ion. The contact stated that after driving the vehicle to his residence and parking the vehicle in the garage, he observed that a puddle of gasoline had accumulated overnight underneath the vehicle from the fuel tank by the driver's side rear wheel. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The contact stated that the failure might be related to NHTSA Campaign Number: 09V419000 (Fuel System, Gasoline). The manufacturer had been informed of the failure. The failure mileage was approximately 84,000.
The contact owns a 2006 Saturn Ion. The contact stated that upon switching gears to reverse, the vehicle made an abnormal grinding sound. The contact stated that she was unable to shift gears and continued to drive the vehicle in third gear. There were no warning lights illuminated. The independent mechanic diagnosed that the clutch was fractured and needed to be replaced. The manufacturer was notified of the failure and referred the contact to the dealer. The dealer was notified of the failure and informed the contact to take the vehicle to their location in two weeks for diagnosis. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 195,000.
The year, make, and model of my car has a factory recall for the fuel pump failing. I went to the dealership and they informed me my Vin # wasn't included and their was nothing they could do about it. My vehicle started leaking fuel last week so I dropped the tank and removed the fuel pump. I have done my homework on this including watching several videos on YouTube concerning this issue and I'm 100% positive this fuel pump has failed in the exact location that all the other recalls have and yet my Vin number isn't on the recall according to this GMC service department manager. I am going to have to put a fuel pump in at my expense today because it's my transportation for work but I'm very upset about this situation and GMCs failure to have my vehicle included and having to replace their defected fuel pump. It's very frustrating knowing I'm putting my time and money towards it because I have my hands full trying to replace the house that Hurricane Ida destroyed about a month ago. We need help with this situation because our money is very tight and don't really have it to fix GMCs mistake. I will keep the fuel pump that came out of it along with the receipt for it so anyone can clearly see that I'm not only correct but being shafted on the recall. Thanks have a nice day I'll be eagerly awaiting your response
We purchased this vehicle recently. 1 week later we discovered loss of power steering assist while attempting to parallel park. We spoke with the seller (repair shop) and they discovered the Recall Notice 14V153000: Loss of Power Steering Assist. When I attempted to schedule a recall service at a GM dealership it was shown that this vehicle already had this particular recall service performed on the vehicle. 1. Power steering Assist 2. Loss of control of steering. 3. No (issue is intermittent) 4. No (original recall was performed though; it is happening again) 5. No warnings.
The car is leaking gas from the gas tank. I see recalls from this year, make and model from this vehicle yet when I put my VIN in it says 0 recalls.
2006 SATURN ION. CONSUMER WRITES IN REGARDS TO DEFECTIVE SHIFTER SWITCH SAFETY RECALL. THE CONSUMER STATED THE VEHICLE BECAME DIFFICULT TO TO TURN OFF. THE CONSUMER HAD TO JIGGLE THE KEY TO GET THE VEHICLE TO POWER OFF. THIS OCCURRED ON MULTIPLE OCCASIONS. REPAIR ATTEMPTS HAVE BEEN MADE BUT, THE FAILURE PERSISTED. THE MANUFACTURER WAS CONTACTED AND REIMBURSED THE CONSUMER FOR THE REPAIR.
THE RPMS JUMP AROUND AND THE A/C MAKES NOISE AND LIGHTS FLICKER AT TIMES. THE CAR WILL JUST STALL IN THE MIDDLE OF AN INTERSECTION OR WHEN I'M TURNING ONTO ANOTHER ROAD. IT'S QUITE SCARY WITH CHILDREN IN THE CAR. MY MAIN CONCERN IS A LARGE SUV PUT IT IN REVERSE AND HIT THE FRONT OF MY CAR BEFORE ENDING UP ON THE HOOD NEAR THE WINDSHIELD. SHE WAS GOING PRETTY FAST AND PUSHED MY CAR PRETTY FAR BUT NO AIRBAG! THEN ON A SEPARATE OCCASION I WAS DOING 55 MILES WHEN A LARGE ANIMAL DARTED OUT IN FRONT OF ME. MY FRONT END AND RADIATOR AND FRONT END WERE SHOT. EVEN SPLIT MY PASSENGER SIDE DASH OPEN AND HAD TO BE TOWED OFF BUT NO AIRBAGS!! EXACTLY HOW DO I HAVE TO BE GOING FOR ME TO HAVE PROTECTION????
I HAD CLEARED MY WINDOWS OF SNOW AND TURNED ON MY REAR DEFROST WHEN I HEARD A LOUD POP AND DISCOVERED MY REAR WINDOW HAD IMPLODED.. I WAS PARKED IN MY DRIVEWAY
TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE THE VEHICLE WAS BEING INSPECTED BY INDEPENDENT MECHANIC, SHE WAS INFORMED THAT THE VEHICLE HAD A FUEL LEAK AND NEEDED THE FUEL PUMP AND FUEL TANK TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 154,917.
Fuel and evap line rusted out inside heat wrap for exhaust pipe near rear drivers tire. Pumped out fuel onto street.
DIFFICULT TO STEER OR TURN STEERING WHEEL.
STILL HAVING IGN. KEY PROBLEMS NOT TURNING AND CAN NOT REMOVE, AN ELECTRONIC STEERING SYSTEM LIGHT COME ON WHEN STARTING AND HARD TO STEER. BOTH PROBLEMS ARE INTERMITTENT AND DEALER CAN'T REPAIR UNLESS THEY SEE IT
I STARTED SMELLING GAS WHEN GETTING OUT OF CAR. THEN IT GOT PROGRESSIVELY STRONGER GAS SMELL THAT LINGERED ON STRONG AN HOUR AFTER THE CAR HAD BEEN SITTING. SO I CHECKED FOR GAS LEAK ON EXTERIOR OF GAS TANK AND FOUND EXTREME AMOUNT OF GAS COMING FROM BOTH OF THE FUEL LINES OF THE FUEL MODULE ON TOP OF TANK. THIS DIDN'T START UNTIL THE WEATHER HAS BECOME WARM IN THE 80 S AND 90S. *TR
STEERING ERRORS
The contact owned a 2006 Saturn Ion. The contact stated while driving at 50 mph and there was a stopped vehicle in the middle of the road, in order to avoid crashing the contact veered to the right lane but crashed into the rear of a truck. The air bags failed to deploy. A police report was not filed. The contact sustained neck, shoulder, arm, and chest injuries that required medical attention. The vehicle was not drivable and was towed to an impound lot. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact was relating the failure to NHTSA campaign number: 14V047000 (Air bags, Electrical system). The manufacturer had been informed of the failure and informed the contact to file for the class action lawsuit. The failure mileage was 90,000.
TL* THE CONTACT OWNS A 2006 SATURN ION. WHEN THE VEHICLE WAS STARTED, THE POWER STEERING FAILED WITHOUT WARNING. WHEN THE VEHICLE WAS RESTARTED, THE POWER STEERING RETURNED TO NORMAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE FAILURE MILEAGE WAS 140,000.
AIR BAG IF IS A RE CALL I WILL LIKE TO KNOW IF I HAVE TO TAKE MY CAR WHERE TO.
Showing 1–20 of 25 complaints
The 2006 Saturn Ion has 6 recalls recorded by NHTSA.
NHTSA has received 1,235 owner-reported complaints for the 2006 Saturn Ion.
NHTSA has not published a safety rating for the 2006 Saturn Ion.
The most commonly reported complaint categories for the 2006 Saturn Ion are steering (455 reports), electrical system (247 reports), fuel system, gasoline (106 reports).
Yes. NHTSA has 6 recalls on record for the 2006 Saturn Ion. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.