2006 Scion tC Complaint Log

The contact owns a 2006 Scion TC. The contact stated that after performing a vehicle inspection of the engine compartment, he became aware that the coolant reservoir was abnormally low; eventually finding a leak near the rear of the engine. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the cylinder head bolts resulting in a coolant leak. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: S-SB-0004-11. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 287,000.

WHILE DRIVING HEARD A NOISE LIKE SOMETHING FELL AND WAS DRAGGING IN THE BACK. PULLED OFF AND NOTICED THE PLASTIC PIECE FOR MY TRUNK HAD JUST FALLEN OFF. I HADN'T BEEN USING THE TRUNK.

TL* THE CONTACT OWNS A 2006 SCION TC. WHILE DRIVING APPROXIMATELY 65 MPH, THE SUN ROOF EXPLODED AND THE GLASS SHATTERED WITHOUT IMPACT OR WARNING. THERE WERE NO INJURIES. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

WHILE DRIVING ON A HIGHWAY, THE MOON-ROOF/SUN-ROOF SHATTERED SPONTANEOUSLY. THE DAMAGE DOES NOT APPEAR TO BE CAUSED BY ANY OBJECT STRIKING THE GLASS. I HAVE DASHCAM FOOTAGE OF THE INCIDENT, IN WHICH TWO DISTINCT POPS CAN BE HEARD WHEN THE GLASS SHATTERS. ADDITIONALLY, THE EXTENSION MECHANISM (TWO SUPPORTS ON THE SIDES OF THE GLASS) WERE FULLY EXTENDED. IT IS MY ASSUMPTION THAT ONE OF THE SUPPORTS FAILED AND FULLY EXTENDED, FORCING THE GLASS TO BEND AND ULTIMATELY PUT ENOUGH STRESS ON THE GLASS TO FAIL, AT WHICH POINT THE OTHER SUPPORT FULLY EXTENDED. PLEASE SEE ATTACHED PICTURES. IT APPEARS VIDEOS ARE NOT ABLE TO BE UPLOADED, BUT PLEASE CONTACT ME IF YOU WOULD LIKE THIS INFORMATION.

ENGINE BLOCK BOLTS ARE ATTACHED TO AN ALUMINUM BODY OF THE ENGINE CAUSING BOLTS TO BECOME LOOSE WITH TIME AND CAN NOT RETHREAD. CAUSING COOLANT TO LEAK FROM BOLT AREA

I WAS DRIVING DOWN HIGHWAY GOING 55-60MPH WHEN MY MOONROOF EXPLODED! IT LITERALLY SOUNDED LIKE A BOMB OR GUNSHOT OVERHEAD. THE DEALERSHIP SAYS THERE IS NO RECALL AND THIS IS NOT A MANUFACTURER ISSUE... I'D HAVE TO DISAGREE AS I'M NOT THE ONLY ONE WITH THIS ISSUE.

I WAS ON MY WAY HOME AND AS I WAS TURNING ON THE STREET TO PULL INTO MY APARTMENT COMPLEX I HEARD GUNSHOT SOUND BUT NO ONE WAS AROUND AND NO ONE WAS ON THE STREET I PULLED INTO MY APARTMENT COMPLEX AND PARK MY CAR AS I WAS GETTING OUT OF MY CAR GLASS STARTED TO FALL ON MY FACE I REALIZED THAT MY SUNROOF HAD SHATTERED.

THE WIND DEFELETOR SHADDERED AS I WAS DRIVING DOWN THE FREEWAY AT 8:30 PM DOING 60MPG. IT HAD BEEN OPEN ALL DAY,

CAR WAS INVOLVED IN A MULTIPLE FLIP/ROLLOVER IN WHICH THE DRIVER SIDE SEAT BELT DID NOT LOCK, CAUSING THE DRIVER TO THRASH ABOUT INSIDE THE VEHICLE RESULTING IN MULTIPLE SKULL, SPINE, AND OTHER BONE FRACTURES ULTIMATELY RESULTED IN THE DEATH OF THE DRIVER. THE PASSENGER SIDE SEATBELT DID LOCK AND THE PASSENGER SURVIVED. IN ADDITION TO THE SEATBELT NOT LOCKING, NONE OF THE AIR BAGS DEPLOYED. I MEAN NONE OF THEM!! PLEASE LOOK INTO THESE VEHICLES IN HOPES TO SAVE SOMEONE'S LIFE!! UPDATED 09/19/17 *BF ..UPDATED 12/11/17 *BF *JS *JS *JB

EXCESSIVE OIL CONSUMPTION BETWEEN OIL CHANGES, I NEED TO CHECK THE LEVEL EVERY MONTH AND ADD OIL IF NEEDED. WHEN I TURN ON THE VEHICLE, THE RADIO TURNS ON ALONE OR TURNS ITSELF OFF, WITHOUT PRESSING THE BUTTON. THESE 2 COMPLAINTS HAVE BEEN GOING ON FOR MORE THAN TWO YEARS.

TL* THE CONTACT OWNS A 2006 SCION TC. WHILE DRIVING APPROXIMATELY 50 MPH, THE GLASS WIND DEFLECTOR SHATTERED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE GLASS WINDOW REFLECTOR SHATTERED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V483000 (VISIBILITY); HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 157,400.

DRIVING SPEED LIMIT DOWN FREEWAY WHEN I HEARD A LOUD POP, ALMOST AS IF A GUN SHOT. MY SUNROOF HAD COMPLETELY SHATTERED. I HAD IT REPLACED AND LESS THAN 3 MONTHS LATER THE SAME THING HAPPENED.

CAR DOES NOT SHIFT WELL I REPLACED CLUTCH AND OTHER PARTS RELATED TO CLUTCH N CAR STILL CANT SHIFT GOOD I CANT DRIVE CAR

AT HIGHWAY SPEED, DRIVERS SIDE REAR TIRE FAILED. CAUSED THE VEHICLE TO BECOME UNSTABLE AND DANGEROUS. SUMITOMO IS THE MANUFACTURER, AND THE TIRES THEMSELVES STILL HAD APPRX. 12,000 MILES LEFT ON THE LIFE OF THE WARRANTY. GOING TO HAVE ALL OTHERS CHECKED, AND REPLACING THE AFFECTED TIRE.

BRACKET THAT LIMITS DOOR OPENING GETS CAUGHT ON WINDOW TRACK THEREFORE CREATING A TEAR AND PULLING TRACK BACK , WINDOW COMES OFF THE TRACK AND IS UNABLE TO WORK PROPERLY AND IF FORCED WINDOW WILL SHATTER, DEALER SOLUTION IS ONLY TO REPLACE AUTOMOBILE DOOR SINCE APPARENTLY TRACK CAN NOT BE REPLACE ITSELF.

TL* THE CONTACT OWNED A 2006 SCION TC. WHILE DRIVING 65 MPH, THE CONTACT NOTICED FLAMES UNDERNEATH THE VEHICLE AS IT SPREAD TO THE ENGINE COMPARTMENT OF THE VEHICLE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS FILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 186,594.

LEAKING ENGINE COOLANT FROM BACK OF CYLINDER HEAD. TOOK CAR IN TO HAVE HEAD GASKET CHANGED WAS TOLD THE GASKET WAS NOT THE PROBLEM. THE PROBLEM WAS THE ENGINE BLOCK THAT THE THREADS IN THE ENGINE BLOCK WERE STRIPPED. WAS TOLD BY TOYOTA THAT IT WAS A BIG PROBLEM AND IT WOULD COST BETWEEN 1500-1700 TO FIX THE HEAD BOLT THREADS. CONSIDER THE NUMBER OF CARS TRUCKS AND SUVS WITH THIS ENGINE THERE SHOULD BE A RECALL OR SOME TYPE OF OWNER ASSISTANCE FOR THIS PROBLEM.

I CHANGE MY OIL EVERY 3000 OR LESS MILES WITH FULL SYNTHETIC AMSOIL 5W-20. I HAVE TO PUT IN 1/2 A QUART OF OIL FOR EVERY GAS FILL UP. I'M A HIGHWAY DRIVER THAT SETS CRUISE CONTROL AT 75. I DON'T DIVE CRAZY. 2007 HAS AN EXTENDED WARRANTY, WHERE IS THE ONE FOR 2006?

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THERE WAS AN ABNORMAL NOISE AND THEN THE FRONT WIND DEFLECTOR FRACTURED. THE VEHICLE WAS TAKEN TO TWO WINDOW REPAIR SHOPS WHO RECOMMENDED THAT THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND DIAGNOSIS. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

I WAS DRIVING ON THE FREEWAY AND HEARD A LOUD CRACK. MY AC WAS ON AND IT WAS ABOUT 92 DEGREES OUTSIDE. MY FRONT SUNROOF WIND DEFLECTOR COMPLETELY SHATTERED....UPDATED 08/27/15 *BF

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. WHILE DRIVING AT ANY SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THERE WAS A FUEL ODOR. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH LEAKED. AS A RESULT, THE CHARCOAL CANISTER WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,841.

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. WHILE DRIVING 70 MPH, THE STEERING WHEEL SEIZED AND THE CHECK ENGINE, OIL, AND BATTERY WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. WHILE DRIVING APPROXIMATELY 70 MPH, THE SUN ROOF SUDDENLY EXPLODED CAUSING GLASS TO FALL ONTO THE HEAD OF THE DRIVER. NO INJURIES WERE REPORTED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V483000 (VISIBILITY). THE FAILURE MILEAGE WAS 96,000.

2006 SCION TC -BATTERY LIGHT ON -ENGINE TEMPERATURE INDICATOR NO WORKING -WHINING NOISE COMING FROM ENGINE TRY TO JUMPSTART MAKES THIS BURNING SMELL AND WONT START STARTED SEEING SMOKES FROM JUMPER CABLES SO TURN EVERYTHING OFF NOW IT'S TOTALLY DEAD. *TR

AS MY DAUGHTER WAS DRIVING DOWN THE FREEWAY, FOR NO APPARENT REASON, THE MOONROOF SHATTERED. THIS SEEMS TO BE A REOCCURRING PROBLEM WITH THIS PARTICULAR CAR. TOYOTA NEEDS TO ADDRESS THIS, NOW! *TR

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

THIS CAR IS CONSTANTLY BURNING OIL. MY OIL PRESSURE LIGHT NEVER FAILS TO TURN ON SOMEWHERE BETWEEN 1000-2000 MILES AFTER EACH OIL CHANGE, AND I HAVE TO REFILL TO STOP THE LIGHT FROM COMING BACK ON.

OUR TOYOTA 2006 SCION TC WAS INVOLVED IN A HEAD ON COLLISION WHEN IT WAS PULLING OUT SLOWING ON A MAIN ROAD AND THE OTHER TRUCK INVOLVED WAS PROBABLY TRAVELING CLOSE TO 45MPH, THE CAR WAS TOTALED BUT NOT ONE AIR BAG WORKED. THIS CAR WAS PURCHASED BECAUSE IT HAD A HIGH SAFETY RATING, HOWEVER IT IS JUST LUCKY THE DRIVER AND PASSENGER WERE NOT SERIOUSLY HURT. HAD THE CAR NOT BEEN TOTALED WE WOULD HAVE INSISTED IT BE TOTALED, WOULD NEVER PURCHASE ANOTHER TOYOTA AGAIN.

THE ENGINE SOUND INCREASED WHILE I WAS DRIVING ON HIGHWAY. GOT BACK HOME CHECK THE OIL LEVEL IT WAS DRY. FOUND OUT THAT THESE SCIONS HAVE A PROBLEM WITH OIL CONSUMPTION. *TR

P043E, PO444F, P2401,P2402,P2419 CODES CHARCOAL CANISTER ASSEMBLY FAILED SEEMS TO BE A VERY COMMON PROBLEM WITH THIS PARTICULAR TOYOTA MODEL AND TOYOTA SHOULD PAY FOR THE REPLACEMENT. FAULTY EQUIPMENT EXPENSIVE TO REPLACE. WANT TOYOTA TO REPLACE THESE PARTS / TSB NOTICE. *TR

I WAS DRIVING EAST BOUND ON THE 105 FWY AND WAS KEEPING A SAVE DISTANCE GOING AT APPROXIMATELY 45 MPH SINCE TRAFFIC WAS STOP AND GO, WHEN TRAFFIC STOPPED ON FRONT OF ME. I STARTED TO APPLY THE BRAKES WITH LITTLE TO NO RESPONSE AND COULD NOT STOP IN TIME TO AVOID A COLLISION WITH THE VEHICLE ON FRONT OF ME. A FEW MINUTES BEFORE AND PRIOR TO ENTERING THE FREEWAY I HAD FELT SOMETHING SIMILAR ON THE STREET AND THOUGHT IT WASN'T AN ISSUE, HOWEVER THE BRAKES FELT AS IF THEY WERE NOT RESPONDING. THE BRAKES BEGAN TO RESPOND ONCE AGAIN AND I PROCEEDED TO CONTINUE TO DRIVE. AFTER THE ACCIDENT I THOUGHT THAT THIS MAY NOT BE AN ISOLATED INCIDENT AND THOUGHT OF REPORTING THIS INCIDENT TO MAKE SURE IT'S ADDRESSED FOR FUTURE SCION TC OWNERS. MY CAR IS NOW A TOTAL LOSS AND MY INSURANCE DIDN'T COVER IT. I'M NOW SEEKING FOR AN ALTERNATE VEHICLE SO I CAN CONTINUE MY INTERNSHIP/WORK EXPERIENCE. *TR

AS TRAVELING DOWN THE FREEWAY ON WAY TO WORK, I HEARD A SOUND THAT WAS SIMILAR TO A GUNSHOT OR EXPLOSION OF SOME KIND. GLASS STARTED TO FLY IN MY FACE AND ALL OVER THE CAR BARELY MISSING MY EYE. IT CUT MY ARM AND HAND. THE INJURY WAS NOT SERIOUS, MY WIFE SAID IF SHE HAD BEEN DRIVING SHE PROBABLY WOULD HAVE CRASHED WHEN IT HAPPENED. WHEN I GOT HOME I CALLED THE BOTH THE DEALERSHIP THAT SOLD ME THE CAR AND TOYOTA HEADQUARTERS IN TORRANCE. THEY ASKED ME WHAT I WANTED AND I SAID I JUST WANT IT FIXED THEY TOLD ME THEY WOULD GIVE ME A GOOD PRICE TO FIX IT, BUT IT IS NOT COVERED UNDER ANY WARRANTY. JOHN GOT BACK TO ME A FEW DAYS LATER AND SAID THAT I COULD TAKE IT DOWN TO THE DEALERSHIP AND HAVE IT FIXED, PAY FOR IT MYSELF AND THEN TOYOTA WOULD THINK ABOUT IT. THAT'S NOT ACCEPTABLE. I WORK HARD FOR MY MONEY AND TRUST THAT A CARS MOONROOF ISN'T GOING TO EXPLODE WHILE I'M DRIVING IT. FROM THE OTHER COMPLAINTS, THIS DOESN'T SEEM TO BE A RARE OCCURANCE. IF A PIECE OF GLASS HAD LANDED IN MY EYE, I WOULD HAVE SURELY GONE BLIND. *TR

MOONROOF SHATTERED. DRIVING DOWN THE ROAD UNDER CALM WEATHER CONDITION NO ROAD HAZARD. *TR

SHORTLY AFTER PARKING THE VEHICLE, IT CAUGHT ON FIRE. THE FIRE CAPT. STATED IT WAS AN ELECTRICAL FIRE NEAR THE ALTERNATOR FRONT SIDE OF THE ENGINE CABIN.

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. WHILE PARKED, THE VEHICLE ACCELERATED WITHOUT NOTICE. THE VEHICLE WAS ALSO MOVED FORWARD WHILE THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO STATED THAT THE THROTTLE BECAME STUCK. THE VEHICLE WAS TOWED TO A DEALER WHO COULD NOT DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 79,300.

THE STEERING WHEEL AIRBAG SENSOR LIGHT CAME ON AND THE HORN STOP WORKING. *TR

OIL CONSUMPTION!!! I'VE OWNED MY 2006 SCION TC FOR ABOUT 5 YEARS AND HAVE RECENTLY BEEN EXPERIENCING A HUGE OIL CONSUMPTION ISSUE. IT DIDN'T PHASE ME AT FIRST, ALTHOUGH NOW I NEED TO SET MY ODOMETER TO ZERO AND REFILL MY OIL EVERY 800 MILES. I BELIEVE IT IS CERTAIN INTERNAL PARTS THAT ARE CAUSING THIS PROBLEM, SUCH AS THE PISTONS AND THE PISTON RINGS . I'VE NOTICED THAT THIS HAS BEEN AN ONGOING PROBLEM FOR A LOT OF SCION TC'S LATELY, WHICH HAS BEEN TAKEN CARE OF THROUGH AN EXTENDED WARRANTY PROGRAM FOR THE MODEL YEARS OF 2007-2009. I'M TRYING TO PROVE THAT ISSUE IS ALSO AFFECTING THE 2006 MODEL YEAR TOO, AND WOULD GREATLY APPRECIATE IT IF I COULD RECEIVE SOME HELP CONCERNING THIS ISSUE. I WILL UPLOAD A PHOTO OF AN OLD PISTON THAT SHOWS THIS EXACT PROBLEM.

I WAS IN A CAR ACCIDENT I WAS THE PASSENGER .WE WERE ON CAR ACCIDENT WE ROLLED SEVERAL TIMES IN THE AIRBAGS NEVER COME OFF. I'M A QUADRIPLEGIC I BROKED C6. I FLEW OUT OFF THE SUN ROOF.THE CAR WAS ON MOTION ON A STREE. I WAS FOUND 62 FEET FROM THE CAR

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS WITH THE AIR CONDITIONER ACTIVATED THE SUN ROOF EXPLODED AND GLASS FRAGMENTS SCATTERED INSIDE AND OUTSIDE OF THE VEHICLE. THE PIECES OF GLASS SCRATCHED THE REAR END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A COLLISION CENTER TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

I WAS DRIVING WITH MY SUNROOF OPEN. I HEARD A LOUD POP FOLLOWED BY A PIECE OF THE GLASS DEFLECTOR SHIELD FELL INTO MY VEHICLE, HITTING ME ON THE HEAD. I STOPPED AND LOOKED AT MY SUNROOF AND SAW A SPIDERWEB LIKE CRACK ON THE WIND DEFLECTOR WITH NO POINT OF IMPACT. THERE IS A RECALL ON THIS PART AS I AM TOLD BY A DEALERSHIP, SCION'S CORPORATE OFFICE, AND ONLINE. THE RECALL ID IS 50S. EVEN THOUGH THERE IS A RECALL THAT DESCRIBES EXACTLY WHAT HAPPENED TO MY VEHICLE, AND IT IS A DEFINITE SAFETY ISSUE IN REGARDS TO THE PART, I AM BEING TOLD THAT BECAUSE MY VIN NUMBER WAS NOT INCLUDED THAT THEY WILL NOT COVER THE COST OF REPLACING THE PART. I PUT IN A COMPLAINT AND DO HAVE A CASE NUMBER FOR IT IF NEEDED FOR INVESTIGATION. *TR

I WAS DRIVING ON I10 (SPEED LIMIT OF 70) AND HEARD A LOUD NOISE THEN A LOT OF WIND. MY SUNROOF HAD SHATTERED. *TR

SCION TC 2006 - TEMPERATURE WENT ALL THE WAY TO HOT ON THE GAUGE. THE CHECK ENGINE LIGHT CAME ON. THE CAR STARTED RUNNING ROUGH. TOOK THE CAR TO LOCAL SERVICE STATION. THEY TOOK THE HEAD OFF. SAID THE ENGINE BLOCK BOLTS ARE STRIPPED. MECHANIC IS CHARGING $3000+ TO FIX. SEE THIS ISSUE POSTED HERE AND ELSEWHERE ON LINE WITH THE 2006 SCION. *TR

HATCHBACK DOOR HANDLE BROKE OFF IN MY HUSBAND'S HAND WHEN HE WAS OPENING THE HATCH. THE HANDLE IS MADE OF THIN PLASTIC AND BROKE OFF WITH NORMAL PRESSURE AND USE. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA SCION TC. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS UNABLE TO STEER THE VEHICLE AND CRASHED INTO A GUARD RAIL. THE CONTACT AND THE PASSENGER SUSTAINED MINOR INJURIES AND THE VEHICLE WAS DESTROYED. THERE WAS A POLICE REPORT FILED. THE INSURANCE COMPANY STATED THAT THEY WOULD NOT INSPECT THE VEHICLE TO DIAGNOSE THE CAUSE OF FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 68,000.

HEAD GASKET LEAKING FOUND 6 HEAD BOLTS LOOSE. INSTALLED NEW HEAD GASKET SET, NEW INTAKE MANIFOLD. PAID 2000 DOLLARS FOR REPAIRS, NOW HAVING PROBLEM WITH THE ENGINE. MAKES LOUD NOISE AND OVERHEATS. MECHANIC AND BAR AGENT ADVISED IT WAS A MANUFACTURING PROBLEM. HEADBOLTS CAME LOOSE AGAIN AND NOW I NEED NEW ENGINE. PREVIOUS TO THIS MY INSURANCE HAD PAID A TOTAL OF 5000 DOLLARS FOR SOME MECHANICAL AND BODY WORK. I HAVE BEEN WITHOUT A VEHICLE FOR ALMOST SEVEN MONTHS NOW. CALLED TOYOTA MANUFACTURE COMPANY THEY TOLD ME THE ONLY WAY THEY WOULD INSPECT THE VEHICLE WOULD BE IF THEY CHARGED ME. I DO NOT HAVE THE MONEY TO AFFORD THE REPAIR AGAIN AND TO BUY A NEW ENGINE. I JUST NEED IT TO BE INSPECTED ESPECIALLY SINCE I HAD A GOVERNMENT OFFICIAL FROM THE BUREAU OF AUTO REPAIR CONFIRM THAT THERE WAS A MANUFACTURING DEFECT. *TR

REAR CURTAIN AIRBAGS BEGAN SWELLING, CAUSING SEPARATION OF INTERIOR PANELS. CALLED SCION CUSTOMER RELATIONS AND WAS ADVISED THAT, BECAUSE MY VIN DID NOT MATCH THE RECALLED UNITS, THERE WAS NOTHING THAT COULD BE DONE AND THAT THE OWNER WOULD BE CONSIDERED RESPONSIBLE EVEN THOUGH I WAS EXPERIENCING A SIMILAR ISSUE AS DOCUMENTED IN TOYOTA RECALL NO. SSC 60H. ACCORDING TO THEIR RECORDS THE PROPER REPAIRS WERE ALREADY MADE PRIOR TO MY PURCHASE. EITHER THIS IS A CONTINUED DEFECT, OR THE REPAIR WAS COMPLETED IMPROPERLY AS NO INCIDENT HAS OCCURRED THAT WOULD OTHERWISE COMPROMISE THE INTEGRITY OF THE AIRBAG UNITS. *TR ..UPDATED 11/05/12 *BF UPDATED 11/14/2012 *JS

ON 08/28/2012 I WAS DRIVING ON THE FREEWAY ON MY WAY HOME FROM WORK WHEN I NOTICED THE RADIO WENT OUT. I EXITED THE FREEWAY. I MADE IT ABOUT 2 BLOCKS AND WAS AT A STOP LIGHT WHEN SUDDENLY MY CAR WOULDN'T ADVANCE. A POLICE OFFICER A FEW CARS BEHIND WAS ABLE TO PUSH MY CAR TO THE SIDE OF THE ROAD. I HAD MY CAR TOWED FOR SERVICE TO AN INDEPENDENT NON-TOYOTA MECHANIC. I WAS TOLD I NEEDED A NEW ALTERNATOR. GIVEN THIS WAS A NECESSARY REPAIR I WENT AHEAD AND HAD THE REPAIR DONE. THE CAR WAS RUNNING PRETTY WELL UNTIL 01/01/2013. ON 01/01/2013 I WAS DRIVING HOME WHEN I NOTICED THE HEATER STOPPED WORKING. THINKING NOTHING OF IT, I KEPT DRIVING. ON 01/04/2013 (ABOUT 75,000 MILES ON THE VEHICLE) I WAS RETURNING FROM AN ERRAND (DRIVING ABOUT 35 MPH) WHEN I NOTICED THE CHECK ENGINE LIGHT HAD TURNED ON. I PULLED OVER AT A GAS STATION TO FILL UP AND CALLED AN INDEPENDENT NON-TOYOTA MECHANIC TO SEE IF I COULD BRING MY CAR IN. I WAS INSTRUCTED TO BRING MY CAR IN ON 01/05/2013. AFTER I PULLED OUT OF THE GAS STATION AND DROVE A FEW BLOCKS I NOTICED THE NEEDLE FOR THE THERMOSTAT WAS AT THE HOTTEST LEVEL POSSIBLE. THE NEXT MORNING I TOOK MY CAR IN, IT OVERHEATED IN THE 5 MINUTES IT TO ME TO ARRIVE TO THE SHOP. I WAS INFORMED THE ENGINE HAD STRIPPED HEAD BOLTS AND I WOULD NEED A NEW ENGINE . I CALLED TOYOTA/SCION AND THEY DIDN'T ACKNOWLEDGE EITHER THE ALTERNATOR OR STRIPPED HEAD BOLTS BEING AN ISSUE. THE REPRESENTATIVE, [XXX] SAID THEY WOULD OPEN UP A CASE AND I WAS GIVEN THE FOLLOWING CASE # 1301070610. I HOWEVER CAME ACROSS VARIOUS SCION/TOYOTA OWNERS ONLINE WHO HAVE HAD THIS ISSUE. A SIMPLE GOOGLE SEARCH FOR "SCION STRIPPED HEAD BOLTS" WILL SHOW JUST HOW MANY PEOPLE HAVE THIS PROBLEM. I WAS TOLD BY [XXX] THAT IF IN THE FUTURE SCION/TOYOTA RECOGNIZES THE ISSUE(S) I MAY RECEIVE A REIMBURSEMENT BUT THERE IS NO GUARANTEE. THIS IS AN EXPENSIVE FIX THAT I JUST CAN'T AFFORD. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I HAVE A 2006 SCION TC. THE REAR HATCH HANDLE GARNISH BROKE OFF WHILE DRIVING. IT SEEMED TO ONLY BE HELD ON BY A FEW PLASTIC CLIPS. I CANNOT OPEN MY BACK HATCH, AND AM CONCERNED FOR MY SAFETY. MULTIPLE REPORTS HAVE SHOWN THIS TO BE A SAFETY HAZARD- IN THE EVENT OF AN ACCIDENT WHERE DRIVER/PASSENGER DOORS CANNOT OPEN, I WILL NOT BE ABLE TO EXIT THE VEHICLE VIA THE BACK HATCH. ALSO STUDIES HAVE SHOWN THE HOLE CREATED BY THE MISSING PART MAY ALLOW CARBON MONOXIDE FUMES FROM THE EXHAUST TO ENTER THE VEHICLE WHILE DRIVING. I HAVE RESEARCHED THERE IS CURRENTLY A CLASS ACTION LAWSUIT IN THE WORKS AND THIS ISSUE HAS EFFECTED THOUSANDS OF PEOPLE. SCION REFUSES TO DO ANYTHING ABOUT IT. I HAVE CONTACTED THEM AND WAS INFORMED THERE IS NO RECALL AND THEY WILL DO NOTHING TO HELP WITH THE COST OF REPLACING THIS DEFECTIVE PRODUCT. *TR

ENGINE HAS SEVER OIL CONSUMPTION TO WHERE WE ARE ADDING A QUART OR MORE EVERY 1000 MILES OR SO IN BETWEEN OIL CHANGES. WORRIES ME TO WERE I CHECK EVERY WEEK JUST TO MAKE SURE THERE IS ENOUGH OIL. I SHOULD NOT HAVE TO WORRY ABOUT THAT SORT OF THING. WHILE DRIVING OM STREETS OR HIGHWAYS, HAPPENS EVERY WHERE, AS YOU SHIFT AT A CERTAIN RPM (ABOUT 1500-2500-3000 ECT) THE CAR WILL HESITATE FOR A FEW SECONDS. WE ORIGINALLY THOUGHT IT WAS FROM THE A/C SINCE I BOUGHT THE CAR IN THE SUMMER TIME BUT ONCE THE A/C IS OFF THE CAR STILL HESITATES. WE HAVE NOTICED WE ARE NOT THE ONLY ONES WITH THIS ISSUES BUT WE ARE THE ONLY YEAR THAT IS REPORTING THEM. WHAT IS GOING ON WITH MY ENGINE AND FUEL SYSTEM?! PLEASE HELP!!!!

TRUNK HANDLE TO HATCH SNAPPED OFF AS I WAS TRYING TO OPEN MY TRUNK. NOW I CAN'T ACCESS MY TRUNK. *TR