2020 Subaru Ascent Powertrain & Transmission Problems

My 2020 Subaru Ascent struggles to retain power when accelerating, especially from stopping and especially when the fuel is low. The vehicle stalls or loses some power when trying to accelerate. The check engine light is not on and there is no other indication that there is a problem with the vehicle. I have discussed it thoroughly with my mechanic and we both think it sounds like a fuel pump issue. He looked at the other Subaru recalls and thinks my vehicle should be included in the other Subaru fuel pump recall (NHTSA ID Number: 21V587000). Does my vehicle qualify for this fuel pump recall? Thank you.

Vehicle: 2020 Subaru Ascent (Build Date: March 2020) Component: Power Train – Automatic Transmission – Hydraulic Pressure Sensor / Wiring Harness The vehicle developed a flashing "Transmission Service" warning and check engine light. It was inspected by a certified technician at Lithia Reno Subaru. Diagnostic scan identified multiple transmission-related codes including P0137, P0700, P2096, P1867, P0867, P2723, and P0841. The technician documented the root cause as: "Found pressure sensor leaking oil through all harnesses." According to the dealership diagnosis, the transmission hydraulic pressure sensor failed and allowed transmission fluid to migrate into the vehicle's electrical wiring harness system. Fluid traveled through the transmission harness and continued into the bulkhead and engine harnesses, contaminating multiple electrical systems. Due to the extent of contamination, the dealership determined that all three harnesses must be replaced. The repair estimate is approximately $8,933. Transmission fluid entering the wiring harness can disrupt communication between the transmission control system and other powertrain components. This electrical contamination can cause erratic transmission operation or sudden loss of propulsion while the vehicle is in motion, increasing crash risk. Subaru has issued recalls and service bulletins involving CVT transmission and hydraulic pressure sensor failures in earlier Ascent vehicles using the same drivetrain. My March 2020 vehicle appears to have experienced the same failure pattern. Despite the documented component failure and extensive wiring contamination, the manufacturer declined to fully cover the repair. I request that NHTSA review this failure mode to determine whether hydraulic pressure sensor seal failures allowing transmission fluid to migrate into wiring harness systems represent a broader defect affecting Subaru Ascent vehicles.

Replaced front multi plate transfer clutch at 96,987 miles.

The contact owns a 2020 Subaru Ascent. The contact stated that while depressing the accelerator pedal to make a turn, the vehicle hesitated to respond. There was no warning light illuminated. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,900.

My 2020 Subaru Ascent experienced a sudden failure of critical safety systems due to CVT fluid leaking through the transmission pressure switch into multiple electrical components. This fluid leak damaged several wire harnesses and the Engine Control Module (ECM). The check engine light came on and all Eyesight safety features disabled. Subaru has confirmed this will cost over $9,400 to repair. This issue appears to be related to known Subaru Technical Service Bulletins, including TSB 16-103-16R and TSB 02-170-17R, and matches the description in NHTSA Campaign WUV-07. Subaru of America has refused to fully cover the repair, even though my car is well maintained, has only 54,000 miles, and is just 4 months outside the powertrain warranty. This is not normal wear—it’s a serious defect that causes electronic failure and disables safety systems while driving.

Ever since our car went in for re-programing CVT drive chain it progressively has been having a problem of something slipping in drive and in cruise control. feels like a loss of power and a feeling chatter from transmission. Now when you put it in drive it makes a jerking noise. the thing is that we never had this problem until it went in for this recall. it's been back twice and they claim they can't find any problem but continues to get worse. it happens every time we drive it . just returned a 700 mile trip and it's very annoying. Also we do have an extended warranty.

While driving the vehicle between 30 - 40 mph, the vehicle will intermittently studder. I have mentioned this issue multiple times to the dealership and they have attempted to fix the issue but the problem still continues. The issue is occurring more frequently and I’m concerned this may create additional engine/powertrain problems down the road.

The contact owns a 2020 Subaru Ascent. The contact stated that while operating the vehicle, the transmission malfunctioned, and the vehicle would not properly accelerate. The vehicle was taken to the local dealer who serviced the rear differential but later the failure reoccurred. The vehicle was taken back to the local dealer to be diagnosed, and it was determined that the transmission was faulty and needed to be replaced. The transmission was replaced. No further information was available. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 106,100.

The contact owns a 2020 Subaru Ascent. The contact stated that while his wife was driving at 55 MPH, the vehicle stalled. No warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 21V955000 (Power Train). The vehicle was towed to the local dealer where it was diagnosed that the transmission needed to be repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 62,000.

Bolt holding the driveshaft support bracket backed out causing driveshaft to come out. This is a known issue with the 2019 and 2022 Subaru Ascents and have active service advisories but Subaru of America does not recognize it for the 2020 models even know it is also happening in the 2020 vehicles. If the driveshaft would have came out at a high speed it could have caused a crash. Based on the research the bolts do not hold the torque from the factory due to a bolt manufacturing issue and slowly back out after time unknown to the driver. Subaru is not recognizing the problem, so they are not notifying the 2020 owners of the problem, instead they are offering a 50% payment on the repairs as a goodwill payment to offset the cost since it is not a warranty issue. I had had my car in for oil changes in the past and the dealership did not know to check for the tightness of the bolts as there were no service advisories. There should be a recall for this problem before someone dies in a crash caused by this problem.

When driving, Ascent sudders while under normal highway conditions. Has had all 4 recalls completed but this specific event has been consistently present even after each recall was completed. Now that Ascent is out of powertrain period, Subaru of America acknowledged transmission finally needs complete replacement but only offering portion as a one time offer.

The contact owns a 2020 Subaru Ascent. The contact stated while driving 30 MPH, the transmission was slipping, and there was a loud sound coming from the vehicle. The contact stated that the vehicle lost motive power while accelerating. The contact was unsure if any warning lights were illuminated. The contact pulled over and left the vehicle for several hours. Upon return to the vehicle, the contact stated that the vehicle drove normally. The vehicle was taken to the dealer and an unknown module was reprogrammed; however, the failure recurred several times. The vehicle was taken back to the dealer and a diagnostic test was performed; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure and stated that if the failure could not be duplicated the vehicle could not be repaired. The approximate failure mileage was 25,000.

The vehicle hesitates like it doesn’t want to get up to speed, despite pressing the gas pedal to accelerate. The RPM needle bounces. Dealership has not been able to “replicate the hesitation I feel when accelerating.” They originally tried to say I didn’t tell them the problem was happening when it had time to warm up, which is a lie, I have all the scheduling notes made by the employee who set the appointment up. Dealership said it passes diagnostic testing despite my serious concerns as the owner driving it daily. No lights are lit up on the dashboard which is another reason why the dealership is saying everything is fine. It’s already had a firmware update in July and the dealership is very dismissive of my concerns. I made multiple calls before appointment telling them it’s happening more frequently around 20-30 minutes of drive time and to make sure I have them the full picture well enough in advance for them to make adequate time to look at my vehicle

For the past month, the engine revs up higher than normal at slow and highway speeds. It had the feeling of the engine skipping gears and staying at to high of an RPM even with the accelerator being eased off. Initially it was brought to Subaru service dealer in November and they could not replicate the issue. On 12/13/23, it began to constantly go into very high RPMS, much more frequently then it had been, and the check engine light came on as well as a warning light for the automatic transmission oil temperature light. We brought it into the dealer and the evaluated and said the transmission is failing and said it is not safe to drive. We were given a loaner and they are in the process of submitting paperwork for a new transmission under their powertrain warranty.

CVT jerks the vehicle and stutters when at certain rpms, making long car rides very uncomfortable. Feels like whiplash every so often. Very dangerous when trying to speed up to pass another vehicle because the vehicle doesn't respond and accelerate as it should. The dealer said its normal because of the CVT technology. They said they tried to reproduce it, but were only gone 5 minutes. The highway is 5 minutes away from dealership, one-way. I explained it happens after about 20 minutes of continously driving at speeds over 50 mph. The vehicle had only been inspected once for this issue. The dealer refuses to look at it again because they, "already explained it to [me]". There are no warnings or indicators prior to it happening.

CVT transmission skips in high gear and shudders randomly while driving down the road. Randy Marion in Hickory NC is where we purchased and replaced the rear transfer clutch and insists the problem has been corrected. It is not. Our regular mechanic and Moderna Subaru of Boone NC both agree the transmission is bad. It has been sitting at the dealership for 2 months while all parties argue over who is responsible for repair. (Original selling dealership, Subaru of America, 3rd party warranty) meanwhile I have no car but am expected to make payments. There are no warning lights or indicatator lamps to show an issue which is even more scary. I do not feel safe driving the vehicle without repair as the stutter and slipping between gears can cause hesitation that could cause an accident or worse. We did not test drive the vehicle at high gear and that was our mistake, but I drove it on a trip 2 days after purchasing and it had transmission issues the entire time. Dropped back off at dealership Monday morning and have been dealing with headaches since then.

Between October of 2021 and February of 2022): Shuddering (like driving on rumble strips) and sluggish transmission (slow to respond acceleration and sometimes jumping when depressing the gas pedal) - reported this multiple times to dealership but was told they couldn’t replicate what I was feeling/experiencing. I also reported that the CVT would not adjust to the lower RPM (remained between 2000-3000) after ascending a hill. I was told in a dismissive manner that it was throttle control, which it was not. Brought vehicle back in June 2022 reporting the same issues. Determined it was the WRK-21 service bulletin. WRK-21 repair was done in July/August of 2022. I was without my car from June through August 30th. Transfer case was replaced. By March of 2023, the exact same symptoms returned and got worse on a much shorter timeline than the first time this happened. On 5/31/23 I brought the car back in. Approx 2.5 weeks later it was determined that it was the WRK-21 issue again. Today 6/30/23, I was told that a regional service technician from Subaru of America has determined that the transfer case needs to be replaced again. I opened a case at Subaru of America (case #[XXX]), requesting that a new transmission be installed into the vehicle, citing major safety concerns about repairing/replacing a repair. No warning lights ever went on at anytime in this reported timeline. Car is not in my possession so it would only be accessible at the dealership. It has been there since 5/31/23. Ultimately, I feel like driving the vehicle is dangerous. I’ve wondered if it’s just going to die while driving at times when it shudders. I have a young child and need a safe vehicle. I do not feel safe in this vehicle. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The CVT transmission has failed and been replaced three times despite proper maintenance. Subaru has replaced the transmission multiple times under warranty, but the failure continues to recur. •First CVT replacement at 50,542 miles •Second CVT replacement at 88,175 miles •Third CVT replacement at 92,832 miles This shows repeat failure, not wear-and-tear. It is a safety risk: The vehicle hesitates and loses power intermittently, which creates a safety risk when accelerating or merging into traffic. The most recent replacement is incorrectly listed as pan replacement.

Transmission is lurching and surging when driving. Pressing gas pedal from a stop the belt continues to slip. Took it to Paul Moak Subaru they claimed to do the inspection told me they don’t do test drives for malfunction checks. They said they completed the inspection for transmission recall. The Ascent continues lurch and slip with grinding noise and loss of speed. I told them about the issues for over a year and they continue to give run around I was having trouble while it was still under warranty. I’ve contacted Subaru Customer Care they would only provide me recall information and told me the trans inspection is all they have to do.

Transmission still slipping when accelerating between 20-30mph. Brought car in for recall but it continues to have the same issue. AC stopped working even when leak was fixed. Now smells like exhaust fumes when warming up the car.