2006 Toyota Corolla Engine Problems

The contact owns a 2006 Toyota Corolla Matrix. The contact stated while driving 45 MPH, the check engine warning light and the battery warning light illuminated, and the vehicle lost motive power. The contact was able to restart the vehicle and pull over on the side of the road safely where the vehicle shut off again and failed to restart. The vehicle was towed to an independent mechanic who stated that the vehicle had experienced a similar failure as in NHTSA Campaign Number: 10V384000 (Engine and Engine Cooling) and advised to take the vehicle to the dealer. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 200,025.

THIS ISSUE HAS BEEN ON GOING FOR OVER 2 YEARS; THE ENGINE REVES UP WHEN STARTING THE CAR, RPM GOES INTO THE RED ON THE GAUGE & CONTINUES TO GO UP & DOWN FOR THE FIRST 30 MINUTES OR SO, WHILE DRIVING .THE CODES SAY IT IS AN EMISSIONS ISSUE/ CHARCOAL CANISTER, ACCORDING TO WHAT I'VE RESEARCHED. I TOOK THE CAR IN FOR THE ECU RECALL AS INSTRUCTED BY THE LETTER RECEIVED. I WAS NOT EXPERIENCING ANY OF THESE ISSUES PRIOR TO THE RECALL REPLACEMENT?? I TOOK THE CAR TO THE DEALERSHIP FOR A SCHEDULED OIL CHANGE AND EXPLAINED TO THE SERVICES PERSON, I WAS TOLD THE EMISSIONS WAS FINE, BUT THEY WOULD BE HAPPY TO RUN A DIAGNOSTIC ON IT FOR $200, I HAVE NOTICED THAT MANY OTHER ARE HAVING ISSUES WITH THE SAME CODES/ EMISSIONS ISSUES. COULD YOU PLEASE HELP ME WITH THIS, I DON'T KNOW WHERE OR WHO TO TURN TO FROM HERE. THANK YOU AND I LOOK FORWARD TO HEARING FROM YOU SOON. I WOULD LIKE TO SEND A VIDEO OF WHAT IS HAPPENING, BUT THERE ISN'T AN OPTION FOR VIDEOS. IF YOU NEED TO SEE THE ISSUE LIVE ON VIDEO, I WOULD BE HAPPY TO SEND IT TO YOU ANOTHER WAY. YOU CAN EACH ME AT [XXX] OR [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

ENGINE CUTS OUT UNDER ACCELERATION. ON HOTTER THAT 80 DEGREE DAYS IT WILL NOT RUN UP OVER 3000 RPMS. CUTS OUT AND WILL NOT ACCELERATE TO SPEED UNLESS VERY SLOWLY ACCELERATING. HAVE HAD TO DEALER AND THEY TELL ME IT'S THE ECM, BUT YEARS AGO THAT WAS REPLACED UNDER A RECALL FOR THE SAME REASON. 'SUPPOSEDLY'. I'M THINKING EITHER THE WORK WAS NOT PERFORMED OR THE REPLACEMENT UNITS ARE FAULTY AS WELL.

TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN INDICATING THAT THE A/C CONDENSER IS NOT PROPERLY PROTECTED THE NUMBER FOR THIS REPORT IS AC002-06. HOWEVER, TOYOTA HAS REDESIGNED THE COROLLA TO CORRECT THIS IN 2007 BY PROPERLY PROTECTING THE A/C CONDENSER LEAVING THE 2005-2006 CUSTOMERS IN THE DUST. TOYOTA COROLLA AIR CONDITIONING PROBLEMS ALL MODELS 2005-2006. I OWN A 2006 TOYOTA COROLLA CE AND MY A/C HAS BEEN FAILING FOR THE PAST 10 YEARS, NOW I NEED HELP AND GET TOTAL REPLACEMENT OF THE A/C CONDENSER AND FULL PROTECTION.

TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 10V384000 (ENGINE AND ENGINE COOLING). WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AND THE CHECK ENGINE WARNING INDICATOR INTERMITTENTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE CONTROL MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED ON THREE OTHER OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA. WHILE DRIVING AT 35 MPH, THE ACCELERATOR FAILED TO RESPOND. THE CONTACT TURNED OFF AND PARKED THE VEHICLE. THE VEHICLE WAS UNABLE TO BE RESTARTED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED SYMPTOMS SIMILAR TO THE ONES LISTED IN NHTSA CAMPAIGN NUMBER: 10V384000 (ENGINE, ENGINE COOLING); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE STARTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.

ENGINE STALLED DURING DRIVING, THE CAR ALL SUDDENLY LOST POWER. NO INDICATION OF USUAL BEFORE. REIGNITE THE CAR, RUN LOOKS LIKE NORMAL AGAIN. HAS NO PROBLEM FOR 10 DAYS SO FAR. NOT QUITE SURE HOW CAUSED IT? *TR

CHECK ENGINE LIGHT CAME ON RANDOMLY 5 TIMES OVER THE PAST 2 MONTHS. FILED COMPLAINT WITH TOYOTA. ECM SEEMS TO BE ACTING UP, THEY THINK IT'S AN ISSUE WITH A MANIFOLD GASKET. TAKING VEHICLE TO DEALER THIS WEEK TO HAVE THEM DIAGNOSE THE ISSUE. *TR

TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN INDICATING THAT THE A/C CONDENSER IS NOT PROPERLY PROTECTED, CAUSING PREMATURE FAILURE OF THE CONDENSER UNIT. THE NUMBER FOR THIS REPORT IS AC002-06. MY A/C CONDENSER HAS FAILED DUE TO THE FAULTS IN THIS CONDENSER UNIT. I SPOKE WITH TOYOTA AT 1-800-331-4331, AND THEY ACKNOWLEDGE THAT THE PART IS FAULTY, BUT REFUSE TO COVER THE REPLACEMENT OF THIS FAULTY UNIT AS PART OF A RECALL. I'M CONCERNED THAT, IF TOYOTA ACKNOWLEDGES THAT THIS PART IS FAULTY, THEY REFUSE TO REALL AND REPLACE THIS PART. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE ECM HAD FAILED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER 10V384000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. THE VIN WAS NOT AVAILABLE.

ON MAY 19, 2013 MY HUSBAND AND CHILDREN WERE AT A REST STOP...OUR 2006 TOYOTA COROLLA WAS PARKED ENGINE ON WITH THE AIR CONDITION ON AS WELL WHEN THEY HEARD A LOUD EXPLOSION FROM THE BACK OF THE CAR THE REAR WINDSHIELD HAD SHATTERED INTO A MILLION PIECES. IT IS STILL BEING HELD UP BY THE TINT. WE TOOK THE CAR IN TO ATKINS KROLL TOYOTA DEALERSHIP AND THEY JUST KEPT TELLING US THERE WAS NOTHING THEY COULD DO BECAUSE IT WASN'T A RECALL. THIS IS A HUGE SAFETY ISSUE... MY CHILDREN COULD HAVE HAD SHARDS OF GLASS ALL OVER THEIR FACES IF IT WASN'T FOR THE TINT OR HAD THEY BEEN DRIVING ON THE ROAD COULD HAVE CAUSED AN ACCIDENT. THERE SHOULD DEFINITELY BE A RECALL ON THIS. WHILE STILL AT THE DEALERSHIP WE WERE REFERRED TO THE BODY SHOP TO GET IT INVESTIGATE IT AND THE BODY MAN SAID IT COULD HAVE BEEN CAUSED BY THE METAL CLIPPINGS THAT HOLD THE WINDSHIELD TOGETHER BUT STILL TO NO AVAIL. *TR

DRIVING ON US 19 AT APPROXIMATELY 50 MPH WHEN MY CAR ACCELERATED TO 70 MPH. I APPLIED THE BRAKES AND IT SLOWED BACK DOWN AND WAS FINE AFTER THAT. ON DECEMBER 5TH I WAS STOPPED AT A RED LIGHT WHEN IT SUDDENLY STARTED TO ACCELERATE AND I HAD TO PUSH HARD ON THE BRAKE PEDAL TO KEEP FROM GOING INTO THE INTERSECTION BUT, BY THE TIME THE LIGHT TURNED GREEN IT WAS BACK TO NORMAL. I BROUGHT IT TO SUN TOYOTA AND THEY COULD NOT FIND ANYTHING ON THE COMPUTER. THEY CLEANED A PART THAT THEY FOUND TO BE DIRTY AND SAID EVERYTHING CHECKED OUT FINE. ON JANUARY 9TH I WAS PULLING INTO THE PARKING LOT OF SAM'S WHEN IT ACCELERATED SUDDENLY AGAIN AND I HAD TO USE THE CURB TO GET IT TO STOP. ON JANUARY 18TH I WAS AT RED LIGHT AND IT ACCELERATED SO LOUDLY THAT THE VEHICLE IN FRONT OF ME PULLED OVER TO THE SIDE THINKING I WAS GOING TO HIT HIM. I PUT THE CAR INTO NEUTRAL AND IT CONTINUED TO REV AND MAKE A LOUD CLICKING SOUND. BY THE TIME THE LIGHT TURNED GREEN IT HAD STOPPED AND WHEN I PUT IT INTO DRIVE IT WAS FINE. I WENT DIRECTLY TO THE DEALER AND THEY GAVE ME A 18003314331 #3 TO CALL AND REPORT IT BECAUSE AGAIN THEY COULD NOT FIND ANYTHING WRONG. I HAVE PARKED THE CAR AND I DON'T KNOW WHAT I SHOULD DO BECAUSE I NO LONGER FEEL SAFE DRIVING IT. *TR

HEAT SHIELD HANGER ASSEMBLY FAILED AND NOW HEAT SHIELD VIBRATES AGAINST EXHAUST PIPE MAKING TERRIBLE NOISE. THIS IS A VERY COMMON PROBLEM AS RESEARCHED ON THE NET. TOYOTA NEEDS TO FIX THIS FREE. *TR

WHILE PARKED IN AN OPEN PARKING LOT AT MY VFW POST, THE CAR BEGAN TO SMOKE AND, EVENTUALLY, WENT UP IN FLAMES. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA COROLLA MATRIX. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER AND STALL WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE CHECK ENGINE LIGHT ILLUMINATED AFTER THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 52,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 52,100.

AC CONDENSER STATED LEAKING ON 12/18/2011. STEAM WAS COMING OUT OF FRONT OF THE CAR AS IT WAS PARKED AT A STORE. I NOTICED THIS WHEN I WAS EXITING THE STORE. TWO GARAGES CONFIRMED THAT IT WAS THE CONDENSER. I WENT TO DO RESEARCH ON THE CONDENSER ONLINE AND THE COMPLAINTS ABOUT DEFECTIVE CONDENSERS ON THE 2005 AND 2006 COROLLA APPEARED ON THE WEB. PROBLEM WAS CORRECTED ON THE 2007 AND AFTER COROLLA. CONDENSER HAS TO PROTECTION. COULD HAVE THE CONDENSER REPLACED TODAY AND BECAUSE OF NO PROTECTION, THE PROBLEM COULD HAPPEN AGAIN THE NEXT DAY. VERY POOR DESIGN...THIS LEAVES THE OWNERS OF 2005 AND 2006 COROLLAS OUT IN THE COLD! WHY NO RECALL??? ONE OF THE GARAGES THAT I WENT TO WAY A TOYOTA DEALERSHIP...THEY WANT $735 (ESTIMATE) TO CORRECT THE PROBLEM. IT WAS POOR DESIGN! I SHOULD NOT HAVE TO PAY FOR HEIR MISTAKE! *TR

LETTER FROM SENATOR HAGAN ON BEHALF OF CONSTITUENT, RE DEFECTIVE ENGINE CONTROL MODULE IN HIS 2006 TOYOTA COROLLA *TGW THE CONSUMER STATED THE DEFECTIVE ENGINE CONTROL MODULE CAUSED THE VEHICLE TO NOT STOP OR JUST COMPLETELY STALL WHILE DRIVING. THE CONSUMER STATED HE DID NOT RECEIVE A RECALL NOTICE, UNTIL A WEEK AFTER PAYING FOR THE REPAIRS. HE IS SEEKING REIMBURSEMENT. *JB

2006 TOYOTA COROLLA. CONSUMER STATES ECM FAILURE*TGW THE CONSUMER STATED ON JULY 20, 2011, HIS VEHICLE SUDDENLY STOPPED AND ALMOST CAUSED AN ACCIDENT. THE VEHICLE WAS TOWED TO A PRIVATE SHOP WHERE IT WAS DETERMINED THE ECM FAILED. THE VEHICLE WAS THEN TOWED TO THE DEALER TO HAVE THE ECM REPLACED. THE CONSUMER RECEIVED A RECALL LETTER ON AUGUST 1, 2011 REGARDING THE EXACT FAILURE.*JB THE CONSUMER IS SEEKING REIMBURSEMENT FOR TOWING EXPENSES, THE MECHANICS TIME AND CAB FARE. UPDATED 09/14/11.*JB

I AM THE OWNER OF A 2006 COROLLA 4-DR SEDAN. VIN - OMITTED CURRENT MILEAGE 48820 ABOUT A WEEK AGO, I NOTICED THAT THE AIR CONDITIONER WAS NOT WORKING. I TOOK IT TO MY LOCAL DEALERSHIP (MICHAEL'S TOYOTA IN BELLEVUE) FOR SERVICE WHERE THEY TOLD ME THAT THE A/C CONDENSER HAS A HOLE IN IT AND WILL NEED TO BE REPLACED - TO THE TUNE OF $685. I WAS SHOCKED BY THIS SO STARTED DOING A LITTLE RESEARCH ONLINE ONLY TO LEARN THAT THOUSANDS OF OTHER 2006 COROLLA OWNERS ARE EXPERIENCING THE SAME PROBLEM. TECHNICAL SERVICE BULLETIN AC002-06 WAS RELEASED BY TOYOTA ADMITTING TO THE FAULTY DESIGN OF THE CONDENSER WHICH LEFT IT UNPROTECTED AND VULNERABLE TO ROAD DEBRIS. I'M SHOCKED AND APPALLED BY THIS. WITH ALL OF THE NEGATIVE PRESS THAT TOYOTA HAS RECEIVED IN RECENT YEARS, I WOULD EXPECT YOU TO BE GOING ABOVE AND BEYOND TO ENSURE THAT ALL KNOWN PROBLEMS ARE CORRECTED. I TURNED DOWN THE SUGGESTED REPLACEMENT AND WILL CONTINUE TO SEEK ARBITRATION. I HAVE FILED A COMPLAINT WITH TOYOTA. I WAS SURPRISED TO FIND THAT SEVERAL OFFICIAL COMPLAINTS HAVE ALREADY BEEN FILED, YET NO RECALL. I COME FROM A LARGE FAMILY OF TOYOTA OWNERS, WE STAND BY OUR CARS & TRUCKS AS THEY HAVE ALWAYS BEEN EXTREMELY RELIABLE. I WILL CONTINUE TO ENDORSE THEM. I JUST HOPE THAT THEY'LL MAKE THIS SITUATION RIGHT. *TR

THE A/C BLOWS COOL AIR NOT COLD FOR ABOUT 20 MINUTES AND STOPS BLOWING COOL. YOU CAN TURN THE A/C OFF FOR A FEW MINUTES AND THEN TURN IT BACK ON AND THE AIR BLOWS COOL AGAIN FOR A FEW MINUTES THEN GOES BACK TO WARM. I'VE NOTICED A SLIGHT SMELL (NOT BAD) COMING THRU THE VENTS SOMETIMES AND WHEN I HAVE THE AC ON, IT SEEMS TO FLUCTUATE BETWEEN COOL (NEVER COLD) AND LUKEWARM. I ALSO FEEL LIKE I HAVE TO HAVE IT ON THE 2ND SETTING TO FEEL AIR MOVING. *TR