2019 Toyota RAV4 Complaint Log

Braking while pulling into a parking space. Instead of slowing down the car accelerated and went over the curb. Maintained pressure on the break but it did not slow the car. Instead the car kept accelerating down an embankment, across an empty street and towards a telephone pole. Turning the steering wheel to the left to avoid the telephone pole the car further descended into a ditch. The car had to be towed and is now deemed to be totaled. The brake- pads had been inspected during a routine maintenance check the day before this accident occurred and they were good. No other vehicle was involved. My personal injury was an abrasion and bruise where my seat belt did it's job. My muscles are sore. The side airbags did deploy after the car stopped. The floor mats were locked in place.

Safety Defect: Data Communication Module (DCM) Failure Affecting Hands-Free Microphone and Safety Connect / SOS Emergency System Vehicle: 2019 Toyota RAV4 Hybrid LE The DCM (which controls both the CarPlay/Bluetooth hands-free microphone and the Safety Connect SOS emergency button) suddenly failed without any warning or accident. Symptoms: - No one can hear me during CarPlay or Bluetooth calls (microphone inoperative). - Safety Connect / SOS light became intermittent or inoperative (directly impacts emergency calling, crash notification, and roadside assistance). This is a known recurring issue documented in Toyota TSBs T-SB-0112-20 and T-SB-0089-21. Toyota of Hackensack diagnosed it and quoted $1,300 for DCM replacement/update while charging me $200 for diagnosis. They did not disclose during the multipoint inspection that this is a documented safety-related DCM fault. I performed the manufacturer-recommended 12V battery disconnect reset (standard TSB procedure), which fully restored the microphone and returned the SOS light to solid green. However, this is only a temporary fix for a known defect. This failure compromises hands-free calling while driving and the emergency SOS system — both critical safety features. I request NHTSA investigation and urge Toyota to issue a recall or service campaign for all affected 2019–2025 RAV4 Hybrids.

While driving, the moonroof on my 2019 Toyota RAV4 XLE AWD suddenly exploded with a loud bang and the glass blew outward. There was no impact, debris, or external cause. The sound was similar to a gunshot. The remaining glass appeared to be pushed upward/outward, not inward. This created a safety hazard due to potential driver distraction and risk of injury from falling glass. This appears consistent with other reported incidents involving spontaneous sunroof shattering. No warning light. Moonroof was shut.Sunny day about 40 degrees outside. Traveling at 68 mph. Dog in crate in back

At 92,000 miles my transmission went out and Toyota told me I need a brand new one. It goes in for routine services. It’s available for inspection. For the last few years I addressed the issues of jerky shift motion and it was blown off every time. It is only 7 years old. It stalled out in a busy intersection and wouldn’t move forward or backwards. There were no warning lamps before it went out.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message "Engine Maintenance Required - Visit the Dealer" was displayed on the screen. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the coolant flow control valve needed to be replaced. The vehicle was repaired out-of-pocket. Upon further investigation, the contact related the failure to Customer Support Program: 24TE04. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 116,000.

I have a 2019 Toyota Rav4 and my liftgate hinges are breaking . The welds are breaking and its causing my truck to no close all the way. Also is truck itself had misaligning itself to the driver side and its also breaking my tail light from the truck hitting it. This is a known problem with this model of car. Toyota has refuse to fix this problem. Leaving people to pay for this repair out of their pocket. The price i have quote for is $2,288.27 that's alot of money. This problem needs to be fix without us coming out of our pocket to fix something that Toyota has known about for some time now. I have been back and forward with my local deal ship snice 3/20/2026. Today i s 3/24/2026 and nothing has changed. I have called Toyota corporate to see if i can some help with is repair. All they keep saying is my car" doesn't meet the reequipments. There should be a recall cause this isnt one two RAV4s its hundreds maybe even tens of thousands.

I have noticed visible rust forming on the roof, specifically the front drivers side adjacent to the inside edge of the roof rail that runs forward to aft on the vehicle. The same stated rust spot is near where the roof meets the windshield. It is available for inspection upon request. My 2019 Toyota Rav4 along with several other 5th generation Rav4 owners online are experiencing rust in the same exact spot. This rust may be a result of the Toyota Customer Service Program (CSP) #22TE05 and T-SB-0016-23 that came of a result of the Fishkind v. Toyota Motor Sales, USA et al. No. Case 2:23-cv-02279 Class Action Lawsuit. This rust may have been formed by the leaking roof rail gaskets that have a slow enough leak rate to penetrate the roof rail clip holes and create moisture and rust over an extended period of time but not high enough of a leak rate to cause excess leakage into the vehicle that would immediately alarm the driver to have the vehicle taken into the dealership for immediate repair before the corrosion and rust can have a chance to spread. After several conversations with Toyota Corporate and my Toyota dealership they have denied me CSP inspection and any coverage or good will assistance through the CSP# 22TE05 & T-SB-0016-23 despite evidence of water residue buildup on the headliner visible through a UV blacklight. Even if the rust is not caused from the roof rail gasket leakage, there are still multiple other instances online of other 5th gen rav4 owners experiencing roof rust in the same exact spot adjacent to the drivers side roof rail near the windshield, which points to a manufacturing defect. My safety will be put at risk when the corrosion worsens and leaks through into the electrical components of the vehicle. My dealership witnessed the rust but denied performing an inspection of the roof rail clips since there is currently visible rust, likely due to the roof rail clips leakage. No manufacturer inspection. No noticeable warning symptoms.

The contact owns a 2019 Toyota Rav4. The contact stated that while seated in the vehicle, while the vehicle was parked, there was an abnormally strong plastic burning odor inside the vehicle. The contact stated that a top light was plugged in the trunk, but the light was turned off. After opening the trunk, the contact became aware that the wiring in the trunk had overheated and burned the laundry that was inside the vehicle and the rear passenger's side seat. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 129,000.

The hinge has broken from the body, causing the liftgate to fail to close the back trunk area of the vehicle. The defective hinge has caused misalignment of the door and an unsecure compartment which is a violation of NC State Law according to NC GS 20-116. This puts the passenger's and driver of the vehicle and other surrounding vehicles at risk by failing to stay aligned or seal properly. I fear that glass may crack due to the currently misalignment. I have sought out further information from a Vehicle Repair Center, who confirmed there is a current Lawsuit on the Case No.: 5:24-cv-00912ZACH HUGHES, individually and on behalf of all others similarly situated, Plaintiffs, v. TOYOTA MOTOR SALES, U.S.A., INC., TOYOTA MOTOR CORPORATION, and TOYOTA MOTOR.

On February 2, 2026, while driving approximately 65 mph on the freeway in Wisconsin, the panoramic sunroof glass on my 2019 Toyota RAV4 XLE Premium (VIN: [XXX] ) spontaneously exploded. The ambient temperature was approximately 20°F. Crucially, the glass buckled outward, indicating the failure was caused by internal pressure or a structural defect, rather than an external impact (such as a rock). There were no other vehicles immediately ahead of me that could have kicked up debris. Safety Risk: The explosion created a loud, gunshot-like noise that caused severe driver distraction at highway speeds. While no crash occurred and no injuries were sustained this time, the sudden structural failure posed a significant risk of loss of vehicle control. Status: No warning lights or messages appeared prior to the failure. The vehicle had no prior damage to the roof area. Photos of outward buckling available upon request INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear trunk door would occasionally fail to open or shut for the last several years. It was inconsistent with this behavior and I was never able to get it to fail when at the dealership servicing department. This weekend when at the store, it failed shutting and I had to force it to shut. While driving home it rattled itself open. I had to pull over to inspect it and could not get it to close. When I looked closer, the hinge of the door had been ripped from the body on the passenger side of the vehicle. I have never been in an accident nor have I ever had any impact on this door.

I was driving down a road and my engine just stopped working lights came on saying there were several issues including the engine. I researched online and found there were recalls due to this same problem for the same make, model and year as my Vehicle, but there is no recall on my vehicle. The dealer confirmed the engine was seized up or whatever wording they used. No one has inspected it other than Rodland Toyota. There were no warning lights or messages or symptoms before the issue.

The contact owns a 2019 Toyota RAV4. The contact stated that the headlights failed to produce adequate lighting at night. While driving at 30 MPH in the dark with the headlights on, making a turn into her subdivision, she crashed into the stop sign, pedestrian crossing sign, and a street sign. There were no reported injuries, fire, or airbag deployment. A police report was filed. The local dealer was contacted, who informed her that the headlights were working as designed. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 15,000. The VIN was not available.

My 2019 Toyota RAV4 8 speed transmission has died. There are 105,000 miles on it. I’ve read that my year and model of car have deficient transmissions and multiple class action lawsuits on this issue.

This is another complaint with the same issue. Got gas on January 1, 2026, the truck did not how any indication that it was going to have any problems. Engine shut down and wouldn’t turn back on. This has happened twice after getting gas, no dealership knows the problem. This is casing me stress and putting myself and family in danger. Considering it stops out of no where

Toyota RAV4 LE gas pump burst and caught fire leading to total fire damage along with major water damage from the firefighters putting out the fire. The vehicle was idle for hours at the time of explosion of the fuel pump. This was a major safety hazard/risk especially being that myself and two others were minutes away from going out to the vehicle before it all happened as I was getting ready to take a friend home for the night. A claim representative will look into this matter in coming days.

Jerks during acceleration. Lurching sensation when acceleration from a stop or after slowing down for a turn. The engine control module (ECM) not communicating effectively with the transmission, leading to searching for gears, rough shifting and low speed hesitation.

Steering wheel is making a buzzing noise when you turn the wheel towards the left or right while you’re driving. It will make the noise in park doing the same back and forth. I’m afraid that my power steering will go out while driving.

Strong gas smell when the engine is turned on. I started feel this issue about 2 year ago, now the gas smell is more stronger every time engine is turned on.

my 2019 Toyota 8 speed transmission jerking in stop and go traffic

My 2019 Toyota RAV4 experienced a dangerous electrical and transmission failure that ultimately caused the vehicle to stall while driving and made me lose control. For several weeks before the incident, the vehicle showed subtle hesitation when accelerating but no warning lights. After the car stalled and spun out coming off the Ben Franklin Bridge onto I-76 near downtown Camden, police responded, confirmed the vehicle had unexpectedly shut off, and verified there was no crash damage. I later brought the car to the Toyota dealership, where they discovered corrosion on the battery cable, failed ABS sensors, and a weak battery. I paid $668 for a new battery, new cable, and ABS sensor repairs. At that time, the dealership did not inform me of any transmission issues and released the vehicle back to me. I made it only a short distance up the road before realizing the vehicle could not accelerate past 40 mph and was still malfunctioning, so I immediately returned it. The next day, the dealership initially claimed there was nothing wrong with the vehicle, but after I insisted they re-evaluate the car, they then informed me that the transmission was failing and needed replacement. This sequence of electrical instability, combined with the transmission malfunction, ultimately led to the earlier stall where I lost all power steering and braking assist and spun out into the median. The vehicle, diagnostic records, and replaced components are available for inspection. The sudden loss of power and control created a major safety risk to me and other drivers in a high-traffic area.

While traveling back from out of state, the fuel sensor and fuel gauge failed causing me to run out of gas when the fuel gauge stated I had just a tick under a 1/4 tank of gas left and the app read 35 miles left. While driving on freeway at freeway speed, the car sputtered, bogged down and then stalled, placing me in a very dangerous situation broken down on the shoulder of the freeway in the desolate country at night with semi trucks and cars flying by at estimated between 70-80 mph. While stalled and waiting for help, all the lights except the hazard flashers went out. The Sheriff assisted and added 2 gallons of gas that finally got the car restarted and I was able to get to the gas station which was 1 mile ahead of where I had been stranded. I kept filling the gas tank not allowing it to go under 1/2 tank on the fuel gauge the remainder of the trip home. I took the car to Tansky Sawmill Toyota for service, who thought it was a fuel sensor in fuel tank, which had to be dropped, resulting in a tube from the fuel sender being disconnected and not taking fuel from the other side of the tank and corrosion was cleaned out. They had to go through electrical system to check the fuel gauge which had corrosion on the electrical harnesses and sensors not caused by water or rodents - still unknown cause - resulting in $6500.00 to replace both electrical harnesses 82152-0R370 wire FR Door LH and 82141-oRB80 wire Instrument Panel! Known Toyota defect as the 2019 Rav4 Hybrids have already been recalled. Issues of this type with the regular Rav4s are posted all over the online Toyota boards. My platinum extended warranty on my well cared for 2019 RAV4 with 45,131 miles (purchased at 3 year lease end) refused to all of the charges and the dealership did not budge, sticking me with 6 hours of diagnostic fees over what the warranty allowed in the sum of $1014.37. These harnesses need recalled so no one else is stranded in a very dangerous place on the side of the freeway!

Safety issue: The vehicle experiences intermittent loss of acceleration and transmission “slip/rev” events, especially when cold, from a stop, or at low speed. At times, the vehicle revs as if in neutral, then re-engages. The driver sometimes must press the accelerator fully to gain speed. In one instance, the vehicle was driven slowly for several miles, pulled over, shut off, restarted, and the function temporarily improved. When it started: Symptoms began immediately after a routine service visit at a Toyota dealership ([XXX]). First noted deceleration going uphill with recovery. Next day, multiple warning indicators/messages appeared and vehicle was towed to the same dealership. Dealer response: Dealership advised transmission replacement based on diagnostic codes and quoted approximately $10,000, stating fluid check was not necessary. Second opinion: Independent shop found transmission fluid level extremely low (reported approx. 1/4 full). They refilled fluid; initially vehicle drove normally, but intermittent slipping/revving continued after pickup (worse when cold/low speed). No external leaks observed by second shop at that time. Current status: Vehicle continues to show intermittent loss of acceleration/slipping behavior, creating a safety risk in traffic. No current check engine light, but symptoms persist. Codes/records available: Codes: P07457F, P28167F, P088A7F, P27137F, C137BA2, C1241, C1280, U1117, B2227. Location: New York. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The design of some Rav4 grilles (particularly 2019-2024 models) allows rocks and road debris to easily pass through and damage the vulnerable A/C condenser, or radiator behind it, which leads to very expensive repairs. This is what happened to my 2019 Toyota Rav 4. Now I have to pay 1300.00 to get it repaired.

Rear door liftgate hinges defective. They are too week combined with electric power struts. They are being pulled away from body of vehicle and become misshapen (bent, deformed,etc) and causes door/liftgate to be unbalanced and and stick out too far away from body. Now the door/liftgate can not close and be secured

UNKNOWN

My 2019 Toyota RAV4 Hybrid (VIN: [XXX] ) suffered sudden engine failure due to coolant intrusion. On Nov 20, 2025, Johnstons Toyota in Harriman, NY (RO#XXX) diagnosed the issue and recorded DTCs P26CA31 and P26CB, which indicate failure of the coolant flow control/bypass valve. The dealer confirmed heavy white smoke from the exhaust with a strong coolant smell and advised the engine had failed, recommending a replacement. This vehicle is part of the early 2019 Japan-built batch widely known for premature electric water pump and coolant-flow system failures. Internal impeller swelling, seal leakage, and bearing seizure can cause coolant pressure spikes and ultimately head-gasket failure with coolant entering the cylinders. This defect has been reported by thousands of RAV4 Hybrid owners (2019–2021). Toyota has addressed it quietly through internal TSBs such as XXX and XXX but no public recall has been issued. The safety risk is severe: the engine began emitting thick white smoke and ran roughly, risking sudden power loss, overheating, or engine seizure while driving. A stall at highway speed could easily cause a collision. Toyota USA opened Case #XXX but declined assistance despite the defect being well documented. This failure was sudden, with no warning lights prior to the incident. Given the widespread nature of this defect and its clear safety implications, I request that NHTSA open a formal investigation into the electric water pump/coolant system failures in 2019–2021 Toyota RAV4 Hybrids and consider requiring a safety recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 Toyota Rav4. The contact stated while driving 70 MPH, the vehicle experienced a loss of motive power. No warning light was illuminated. The contact managed to push the vehicle over to the shoulder of the road, and the vehicle was towed to the residence. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

One week ago one section of the heated steering wheel was very hot. So much so that I could not touch that area. I took it to the Anderson Toyota dealership in Rockford today. On the way there, I turned on the heated steering wheel, and it started smoking. They said they couldn’t find what was wrong with it, and to replace it would be 1800 because it isn’t in warranty. They suggested I not use it.

The contact owns a 2019 Toyota Rav4. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle stalled. The contact was unsure if the vehicle could be coasted to the side of the road. Several unknown warning lights were illuminated. The vehicle was towed to a collision center. The vehicle was then towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 116,248.

Stopped for gas on 11/6/2025 immediately after getting gas the truck shook twice, the power steering light and engine shut down light came on and the truck turned off. Waited for a few minutes to turn the engine again it wouldn’t start. Got it towed to my nearest dealership who kept it for a day. Said there was nothing wrong with the truck, there was no code showing and they couldn’t determine the cause of the problem.

It happened yesterday , November 3rd at 8:45 am Approx. speed was 35mph to 40 •Location: 934 York Road, Towson, MD •Description: Front-right impact at 40 mph, no airbag deployment, two children in back seat, vehicle had recent 50K service and roof-rail repair, CSP 22TE05, at Sheehy Toyota Cockeysville. Vehicle now at Caliber Collision Cockeysville. Claim #060381946 I am experiencing neck, shoulder and rib pain right now, my 5 year old complain about right ankle pain and apparently hit his head on the right side.My 3 year old complain about neck pain yesterday. There was no sign showing any kind of failure on my dashboard. I asked my vehicle to be investigated formally by Toyota engineer asap or forensic expert. I asked my vehicle to be freeze right until proper airbag inspection have been conducted. I have picture of the car showing clearly that none of the airbags worked.

Was insinuating engine was over heating even in -4° weather has no hot air plenty of coolant. This is causing the vehicle to "buck" amd having to have to pull over and waiting several minutes to let the engine "cool off" I can make it about 3 miles in-between pull overs. After some research I feel like the issue falls under a current lawsuit against Toyota regarding the coolant valve based on reading other issues and what my rav is doing. It is a several thousand dollar fix through a dealership and one my family can not afford especially if it is a poorly manufactured part of the car. It is one of two vehicles we have and need to daily living especially having a child and no means yo offered another safe vehicle at this time. The coolant pump itself

There is a known TSB out for 2019 toyota rav4 and some select other years. The issue is a slow speed transmission issue. It is due to a programming issue. At slow speeds, if you try to go from the brake pedal to the gas pedal too quickly, there is a serious lag before power is delivered to the wheels. Which is very dangerous when making specific turns. An example is what happened to my wife and myself the other day. We were in a median turning lane, cars were coming, as we were coming to almost a stop, my wife went to apply the gas. There was a serious lag before power was delivered and it almost resulted in a T bone collision. My wife went to apply gas, there was no power for several seconds, which caused her to panic and hit the brakes again. In that process, the power was finally delivered to the wheels and caused the car to pull about halfway into the oncoming traffic before it stopped from her applying the brakes. She then hard to quickly reverse to avoid the collision. The TSB calls for a flash of the TCM and a relearn procedure to be done. Which I am having done today due to the severity of the incident we had. This could have 100% caused a serious or fatal accident. The two dealerships I spoke with severely down played it as an issue. This deserves a investigation and a recall to be sent out. I was never advised of the TSB or anything.

My check engine light is on due to O2 sensor being dirty. While this light is on some features in the car are disabled like cruise control. It might also be that the ABS braking system is turned off! I am not sure but once when the car in front of me abruptly stopped I was surprised my emergency braking did not kick in.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at 40 MPH, the steering wheel seized, and the contact had to use force to maneuver the steering wheel. A yellow light was illuminated, followed by a red light. The message "Power Steering Malfunction" was displayed. The vehicle was taken to the dealer, where it was diagnosed, and determined that the power steering unit sensor had failed. The vehicle was not repaired due to the cost. The contact retrieved DTCs: C05D604 (Electronic Power Steering (EPS) System Internal Failure); C151287 (Malfunction in the Electric Power Steering (EPS) System Torque Sensor); and C15D11C (Electric Parking Brake Failure). The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The contact related the failure to NHTSA Campaign Number: 20V373000 (STEERING); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,500.

The car transmission hesitates to accelerate at slow speeds and jerks or lurches forwards in a uncontrollable way. Dangerous at stop signs or on slow or hilly roads. Dealership does not directly acknowledge this issue, despite mechanic mentioning very clearly it is related to T-SB-0107-19 which Toyota dealerships charge to repair. No warning messages. Issue has existed as long as I have owned the vehicle 1.5 years from 61,000 miles to 71,000 miles.

I stopped for gas; my car would not start. The power steering fluid light came on. I went inside to purchase some but when I returned to the car, there was no place to pour it. After a few minutes the car started. About a month later, my husband stopped for gas and the car killed right after he left the gas station, about 10 minutes later, it started. Took it to a mechanic, they couldn't find anything wrong with it because the check engine light wasn't on and the car wasn't giving any problem codes. About two weeks ago, I stopped for gas, the car wouldn't start. Finally got it started, and the check engine light came on. However, it's still not reading any codes.

I was driving to Kansas on a road trip and we stopped for gas when we noticed the rear drivers side tire tilting inwards (top of tire angled towards the car). We then drove it to a mechanic in Kansas to see if it is safe to drive further. She noticed the bolt for the rear suspension loose and almost out entirely. She then told us we could not drive the car any further because a few more bumps and the bolt would fall out and create major safely concerns. She also noted that she could see where the bolt was rubbing on the rear suspension sub-plate and could see the old rusted damage along with the new damage from recent driving. She also noted the uneven wear on the tire with the tread worn significantly more on the inner side of the tire. We towed it to Denver to have it looked at and the said the bolt and nut need to be replaced along with a tire alignment. There were no warning signs other than my car felt more bouncy than normal. The car bolt has been replaced but you can inspect the surrounding damage if needed. Both the safety of the people in my vehicle and those around me would have been at risk if we didn't notice the tilt and continued the road trip.

Vehicle states engine maintenance required. Is a consistent reoccurring problem according to dealer. System failure due to manufacturer always puts the user at risk.

Engine stopped power steering low, notification. When in Reverse. Car shuts off and I coast backwards. Have to put it in park and then restart the car.

The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to open the fuel door, the latch failed to unlock as needed. There was no warning light illuminated. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the spring in the latch was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 54,900.

26Aug2025 I notified Maplewood Toyota MN I had not been notified of safety recalls when nhtsa site confirmed 7 safety recalls. I had absolutly no response. Now nhtsa site says there are no unrepaired recalls when Toyota of Maplewood has done No repairs.

I’m reporting a safety issue with my 2019 Toyota RAV4 that has recently started and is getting worse. The problem seems related to the start-stop system or something in the powertrain. When I come to a stop—at a stop sign, red light, or roundabout—the car doesn’t always respond normally when I try to start moving again. Sometimes there’s a hesitation, and other times it lurches forward unexpectedly when I lightly press the gas pedal, like you normally would. It feels like a jolt, almost like whiplash. It’s especially dangerous in roundabouts or tight traffic situations because I can’t predict how the car will respond. I’m worried I could accidentally hit another car, or get rear-ended myself because the car doesn’t move smoothly or reliably when restarting from a stop. Even when I turn off the start-stop system, the issue still happens. It feels like a hesitation followed by a sudden surge. The RPMs don’t change, but the car still lurches. Yesterday, for the first time, I noticed the car slightly accelerated on its own after stopping, which was very concerning. I found out through Toyota’s official website that there is a technical service bulletin about this issue that came out before we owned the vehicle. But because it’s not a full recall, the dealership said they wouldn’t fix it unless we paid the $80 diagnostic fee. We’re now just out of warranty. We’re making $580 monthly payments on a car that I don’t currently feel is safe to drive. There are no warning lights or messages on the dash. I’ll be taking it to Le Mieux Toyota in Ashwaubenon, Wisconsin, in two weeks to have it inspected, but I wanted to report this because I believe it’s a safety issue that should be looked into. I have two small kids and I’m genuinely worried about getting into an accident, especially when merging onto highways or driving in busy intersections. I’ve seen people say this system can be recalibrated, but the fact that this is happening without any dashboard warning and is worse.

Lift cylinders of power liftgate are operating at different times causing gate to twist. Liftgate fails to open and close automatically, causing prolonged beeping while liftgate is open. Hinges holding liftgate in place have started to bend and crack apart from the body of the car. An independent auto body shop inspected this issue and recreated the tailgate failure. Quote to repair included replacing hinges, lift cylinders and to recheck electronic connections.

The DCM is nonfunctional, which renders the safety connect features of the car inoperable. Additionally, the Bluetooth microphone is powered by the DCM causing the driver to have to switch the call output on their phone manually taking their focus off the road. This seems to be a widespread issue with many reporting this on online threads and Toyota offering many internal service bulletins. To me this is a major safety concern that is extremely costly to repair.

The contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the contact noticed fluid leaking from the driver’s side rear door. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 40,000.

2019-2023 model year Toyota RAV4s and Toyota Corollas are equipped with defective coolant bypass valves prone to premature failure which can cause coolant to leak out of a vehicle’s closed-loop coolant system, harming its ability to properly regulate engine temperature. This can cause overheating, stalling, increased emissions, and total engine failure and also allows coolant to leak into and damage surrounding engine components, including a vehicle’s electrical system, the complaint relays. The warning message that common appears for this issue is "Engine maintenance required Visit your dealer "

Vehicle consistently accepts only approximately 9–10 gallons of fuel when the fuel gauge indicates empty, resulting in significantly reduced driving range. Issue has been widely reported by other Toyota RAV4 Hybrid owners and appears related to fuel tank design. Manufacturer declined assistance and referred responsibility to selling dealer despite known complaints.

I am reaching out regarding a structural issue I’ve experienced with my 2019 Toyota RAV4, specifically with the rear power liftgate. Recently, I noticed that the liftgate hinges are beginning to crack and pull away from the body of the vehicle. The alignment of the trunk has shifted slightly, and there is visible damage around the hinge area. This appears to be worsening over time and is beginning to affect the liftgate’s ability to close properly and securely.