2005 Toyota Tacoma Complaint Log

IT'S BEEN OVER A YEAR SINCE I RECEIVED A RECALL NOTICE REGARDING THE REAR LEAF SPRING. WHAT IS TAKING TOYOTA SO LONG IN REPAIRING THIS PROBLEM? I'LL BE DEAD BEFORE IT'S FIXED. OR IS THAT WHAT THEY'RE COUNTING ON.

TOYOTA - NHTSA RECALL: 14V-604 REAR LEAF SPRING. I RECEIVED THIS RECALL NOTICE OVER A YEAR AGO. WHEN WE TOOK THE TRUCK IN LAST YEAR, THEY FIXED THE OTHER RECALL NOTICES BUT WE WERE TOLD THAT "THE MANUFACTURER IS TRYING TO DECIDE WHAT TO DO ON THE LEAF SPRING." I RECEIVED ANOTHER NOTICE A YEAR LATER AND CALLED THE DEALER AGAIN TODAY. I WAS TOLD THAT THEY DIDN'T HAVE THE PART ON HAND BUT WOULD CALL ME WHEN ONE CAME IN. FUTHERMORE THEY SAID IT WAS A FIRST COME FIRST SERVED SITUATION. IN TERMS OF RISK, THIS RECALL MAY NOT BE LIKELY TO BECOME AN ISSUE BUT IT HAS CATASTROPHIC RESULTS IF IT DOES. IT IS MY SON'S TRUCK SO I'M DEEPLY CONCERNED. CAN YOU HELP ME TO INCREASE THE URGENCY? THE DEALERSHIP I'M ATTEMPTING TO WORK WITH IS TOYOTA OF NORTH CHARLOTTE.

TOOK MY TACOMA INTO DEALER FOR NOISE COMING OUT THE BACK OF TRUCK TURN OUT THAT MY TRUCK HAD 2 ACTIVE RECALLS ON IT ONE WAS THE FRAME AND THE OTHER WAS REAR SPRING. THEY TOLD ME THAT THE FRAME HAD TO BE REPLACE BECAUSE THERE WAS SIGNIFICANT RUST AND HAD MADE A HOLE ON IT. MY PROBLEM IS THAT TOYOTA STILL HAS MY TRUCK WITH NO ATA ON REPAIR. THEY SAID THAT I CAN HAVE MY TRUCK BACK IF I SIGN A WAIVER IF MY TRUCK IS NOT SAFE WHY WOULD I WANT TO SIGN A WAIVER. THE DID PROVIDE A LONER CAR BUT ITS ONLY GOOD FOR 30 DAY AFTER THAT I AM ON MY OWN. AS YOU CAN SEE IT BEEN 6 WEEK SINCE THEY TOOK MY TRUCK. *TR

MY FATHER HAS AN '05 TACOMA SR5 V6 WITH THE TRD OFF-ROAD PACKAGE. HIS TRUCK IS A 6-SPEED MANUAL. WHEN PRESSING THE GAS PEDAL 1/2 WAY, THE ENGINE RESPONDS WITH A SEMI-VIOLENT JERK, AND THEN GOES. THIS SCARES ME, AS I COULDN'T EVEN IMAGINE MY FATHER GOING FULLY DOWN ON THE PEDAL. THIS IS VERY UNSAFE. PLEASE FIX THIS TOYOTA. *TR

2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME EXCESSIVE RUSTING RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED TOYOTA DETERMINED THERE WAS A PROBLEM WITH THE STEEL USED ON THE FRAMES OF THE TOYOTA TACOMA TRUCKS. THE CONSUMER STATED HE WAS MISLED ABOUT THE LENGTH OF TIME IT WOULD REQUIRE TO COMPLETE THE RECALL. THE DEALER INFORMED THE CONSUMER IT WOULD BE MONTHS BEFORE THE TRUCK WOULD BE FINISHED. *JB

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A CLANKING NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE, HE BELIEVED THAT THE REAR LEAF SPRINGS WERE FRACTURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 142,000.

I TOO EXPERIENCED THE STIFFNESS WHILE STEERING. I ALMOST SPENT LARGE DOLLARS BUT DECIDE TO DO SOME RESEARCH ON THE INTERNET. I LEARNED THAT THE CAUSE OF IT WAS A RUSTED JOINT. AFTER SOME HEAVY SPRAYING WITH LUBRICANTS, I REGAINED NORMAL OPERATIONS. BUT ONLY UNTIL NEXT WINTER..UGH! RECOMMEND TOYOTA TAKES NOTE OF THIS AND DECIDE ON A SOLUTION FOR THOSE WHO ARE NOT MECHANICALLY INCLINED.

hello good afternoon my name is [XXX] I have a Toyota Tacoma 2005 could you help me with some information it has a chassis with holes and rotten. Toyota was changing all chassis that had this defect in 2018 to 2020 at no cost, the first owner didn't know about it and I wasn't even warned. I would like to know if I am entitled to a free chassis exchange? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE HAD SEVERE CORROSION ON THE FRAME. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER :14V604000(SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR REPAIR; HOWEVER, THE PART WAS NOT MADE AVAILABLE BY THE MANUFACTURER. THE CONTACT STATED THAT THE DEALER AND MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE VEHICLE HAS SIGNIFICANT FRAME RUST. THERE ARE SEVERAL AREAS ON THE FRAME WHERE LARGE SECTIONS OF METAL HAVE DELAMINATED. THIS PRESENTS A STRUCTURAL INTEGRITY ISSUE IN KEY SUPPORTING AREAS OF THE FRAME ASSEMBLY FOR MAJOR COMPONENTS TO INCLUDE DRIVE TRAIN, BRAKING AND SUSPENSION. THE OVERALL CRASH WORTHINESS IS IN QUESTION DUE TO THE STRUCTURAL INTEGRITY ISSUE PRESENTED BY THE FRAME DESIGN, METAL COMPOSITION AND PREMATURE RUSTING AND METAL FATIGUE. TOYOTA HAS STARTED A LIMITED SERVICE CAMPAIGN TO APPLY A CORROSION RESISTANCE PROTECTION, BUT THIS ISSUE SHOULD BE A SAFETY RECALL. BASED ON THE MAGNITUDE OF DAMAGE FROM RUSTING IN MY CASE THE ONLY RESOLUTION WOULD BE A FULL FRAME REPLACEMENT. I HAVE PICTURES OF THE FRAME DAMAGE AND RUST AVAILABLE. I WILL ALSO BE SENDING TOYOTA A LETTER REQUESTING AN INSPECTION BY THE REGIONAL FACTOR REPRESENTATIVE PRIOR TO ANY REPAIRS. *TR

I WAS SLOWLY TURNING INTO MY DRIVEWAY WHEN THERE WAS A SUDDEN ACCELERATION OF THE GAS PEDAL. MY TRUCK SHOT LIKE A BULLET (ABOUT 40-45 FEET) INTO THE CORNER OF MY HOUSE AND DECK. THE FORCE OF THE IMPACT SHEARED A 6X6 DECK CORNER POST, KNOCKED THE GARAGE SMALL ENTRY DOOR COMPLETELY LOOSE FROM IT'S FRAME, AND DID EXTENSIVE DAMAGE TO A SOLID BRICK WALL, AS WELL AS DAMAGE TO THE INSIDE OF GARAGE. LUCKILY, I DID STILL HAVE MY SEAT BELT FASTENED; HOWEVER, THE AIR BAG DID NOT DEPLOY. I FILED A CLAIM WITH TOYOTA, THEY SENT AN INSPECTOR, AND NOW HAVE DENIED THAT THERE WAS ANY MALFUNCTION. I AM 100% SURE THAT THE ACCELERATION WAS NOT "DRIVER'S ERROR" AND THAT THERE IS A SAFETY ISSUE HERE AND TOYOTA SHOULD BE HELD ACCOUNTABLE. THE BODY DAMAGE TO MY TRUCK HAS BEEN REPAIRED, BUT I WILL BE GETTING RID OF IT. THE CONVERSATIONS I HAVE HAD WITH THE PEOPLE AT TOYOTA'S HEADQUARTERS IN TORRANCE, CALIFORNIA HAVE CERTAINLY BEEN MOST UNPLEASANT AND HAVE LEFT ME WITH A VERY BAD OPINION OF TOYOTA AS A COMPANY. I WILL NEVER HAVE ANOTHER OF THEIR VEHICLES! I JUST HOPE THE NEXT PERSON IS AS LUCKY AS I WAS AND DOES NOT GET KILLED OR BADLY INJURED WHEN HIS TOYOTA TACOMA ACCELERATES FOR NO REASON! *TR

WHEN TURNING THE STEERING WHEEL IN EITHER DIRECTION I HAVE EXTREMELY STIFF STEERING. IT SEEMS TO STICK AND IS NOT FLUID WHEN TURNING. I AM CONCERNED THAT THIS CAN CAUSE AN ACCIDENT WHILE DRIVING. I HAVE CHECKED THE STEERING POWER FLUID LEVEL AND IT IS AT THE CORRECT LEVEL.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V607000 (SUSPENSION). THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND AGREED TO SEND THE PARTS FOR REPAIR. THE VEHICLE WAS NOT REPAIRED BY THE DEALER BECAUSE THE MANUFACTURER HAD NOT YET SENT THE PARTS. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I TOOK MY TACOMA TO THE LOCAL DEALERSHIP FOR LEAF SPRINGS AND A CHECK OF CORROSION OF FRAME ON DECEMBER 7, 2014 AND FOUND OUT I HAD TWO HOLES IN THE FRAME. THE WOULDN'T LET ME TAKE MY TRUCK, BECAUSE OF SAFETY ISSUES. THE DEALER GAVE ME A RENTAL CARE FOR NOW AT TOYOTA'S EXPENSE. THEY SAID TOYOTA WANTS TO JUST REPLACE THE FRAME? THEN MY TRUCK WILL HAVE A SALVADGED TITLE IN PA. I NEED TO HELP, I WANT THE SAME DEAL OTHER TACOMA OWNERS GOT THE LAST TIME FOR THE SAME PROBLEM. *TR

TOYOTA SENT ME A RECALL NOTICE (THAT WAS NOT LISTED ON YOUR SITE) FOR RUST ON THE FRAME. I HAD THE DEALERSHIP INSPECT IT AND THEY SAID THAT IT IS BAD AND TOYOTA WILL REPLACE THE FRAME. THE DEALERSHIP IS TELLING ME THAT SPECIFIC PARTS (THE POWER STEERING RACK AND LINES) THAT ARE RUSTY WILL NOT BE ABLE TO BE PUT BACK WHEN THE FRAME IS REPLACED (AND THE TRUCK ASSEMBLED AGAIN) BUT I HAVE TO PAY THE COST. I HAD THOSE SPECIFIC PARTS LOOKED AT BY MY MECHANIC AND ALTHOUGH A PORTION (THE LINES ARE BAD AND I AM HAVING REPLACED) THE PS RACK IS NOT IN BAD CONDITION. I CONTACTED TOYOTA TO SEE WHAT THEY WILL COVER AND WAS TOLD THEY WILL NOT COVER PARTS THAT ARE NOT THE FRAME. MY TRUCK IS 10 YEARS OLD. IT IS IN GREAT CONDITION AND RUNS GREAT AND I PLANNED TO KEEP IT FOR A LONG TIME. MY CONCERN IS THAT WHEN YOU TRY TO DISASSEMBLE A WHOLE VEHICLE (WHICH IS 10 YEARS OLD) SOME OF THE PARTS THAT ARE IN GOOD WORKING CONDITION, ONCE BANGED AROUND TRYING TO REMOVE THEM, WILL BREAK. I AM CONCERNED THAT I HAVE TO PAY FOR THESE PARTS. IF TOYOTA IS REPLACING THE FRAME DUE TO SAFETY ISSUES, ISN'T IT THEIR RESPONSIBILITY TO REPLACE OTHER PARTS THAT WERE FINE PRIOR TO MAKING THE RECALL FIX? *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. THE VIN WAS NOT PROVIDED.

I LIVE IN NE PENNSYLVANIA AND WAS JUST INFORMED BY MY MECHANIC THAT MY TRUCK MAY NOT PASS ANOTHER INSPECTION DUE TO FRAME RUST. SPECIFICALLY ALONG SIDE THE CATALYTIC CONVERTER. MY DEALER SAID THERE IS A LIMITED RECALL IN THE NEW ENGLAND STATES BUT NOT PA. WILL TOYOTA EXPAND THE RECALL? *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

FOR MY INFORMATION I WOULD LIKE TO KNOW IF WHAT I WAS READING IN THE INTERNET ABOUT MY TRUCK IS REAL. SO THIS IS MY QUESTION, I OWNED A 2005 TOYOTA TACOMA WITH A 4.0 V6 ENGINE THAT IS MAKING A KNOCKING SOUND WITH 60,186 MILES ON THE ENGINE. WHAT I FOUND IS THAT THOSE ENGINES IS, THAT THEY HAVE PROBLEMS WITH THE # 1AND 2 CYLINDERS AND WILL CREATE A HAZARDOUS SITUATION ON THE ROAD. I REED THAT IS A NON-PUBLIC RECALL ON THOSE ENGINES(VO-6) IS THE CODE FOR THAT. PLEASE WRITE (ASAP) BECAUSE IS DIFFICULT TO ENTER WITH A CONVERSATION WITH ANY TOYOTA DEALER ABOUT MY CONCERN. NOW THEY SAID THAT THEY DON'T HAVE ANY INFORMATION ABOUT THE RECALL. TO FIX MY TRUCK IS GOING TO TAKE ME TO SPEND THOUSANDS OF DOLLARS. IF THE RECALL IS TRUE WHAT IS MY RIGHT TO GET THE TOYOTA CORP. TO HONOR THIS ISSUE? *JS

NOV 17, 2014, I BROUGHT MY TACOMA IN FOR RECALL FRAME INSPECTION. IT FAILED. I WAS TOLD THEY WOULD ORDER REPLACEMENT FRAME. I WAS TOLD IT WOULD BE IN MID JANUARY '15. I CALLED THE DEALER TODAY. THEY SAID NO FRAME ARRIVED AND NO ETA WHEN IT WOULD ARRIVE. THEY GUESSED MID MARCH, ANOTHER TWO MONTHS AWAY, BUT NO ASSURANCE IT WAS TRUE. I DON'T DRIVE MY TRUCK DUE TO THE WEAK FRAME. I STILL PAY INSURANCE ON IT. WHY CAN TOYOTA OFFER FREE FRAME REPLACEMENT AND NOT DELIVER A NEW FRAME IN A TIMELY MANNER? *TR

FRAME RUST RECALL. *TR

DUE TO A FAULTY PAINT OR MANUFACTURING PROCESS MY VEHICLE IS EXPERIENCING EXCESSIVE PAINT CHIPPING, NOT CAUSED BY EXTERNAL FORCES. THE MANUFACTURER'S LOCAL DEALER AS WELL AS LOCAL REPUTABLE BODY SHOPS, ARE AWARE OF THE PROBLEM. THE MANUFACTURER WAS CONTACTED WITHOUT RESOLUTION. WHILE RESEARCHING MY PARTICULAR SITUATION, I CAME ACROSS NUMEROUS WRITE UPS OF OTHER CONSUMERS EXPERIENCING THE SAME ISSUE. *TR

FRAME ON MY TACOMA IS BAD RUST HOLE FOUND LEFT FRONT AREA. *TR

I OWN A 2005 TOYOTA TACOMA ACCESS CAB. I GOT A "LIMITED SERVICE CAMPAIGN NOTICE" THAT MY TRUCK MIGHT HAVE ABNORMAL RUST ON THE FRAME. I PUT IT ON A LIFT AND BEHOLD THERE WAS A HUGE HOLE IN MY FRAME MAKING IT NOT DRIVABLE. APPARENTLY TOYOTA IS NOT BEING UP FRONT WITH ITS CUSTOMERS AND HAS KNOWN ABOUT THIS DEFECT IN THE 2005-2011 MODEL YEARS. MY DEALER SAID A NEW FRAME WILL COST AROUND $14,000 TO REPLACE. THEY SAID TOYOTA WOULD PAY FOR THE FRAME BUT WILL NOT BUY BACK THE TRUCK. I STILL DO NOT UNDERSTAND HOW THEY ARE WILLING TO SPEND $14,000 ON A FRAME ON A TRUCK THAT IS WORTH $15,000 I HAVE HEARD FROM DEALERS THAT THE FRAMES ARE ON NATIONAL BACK ORDER AND ARE AT LEAST 3 MONTHS OUT. PLEASE INVESTIGATE THE 2005-2011 TACOMA CLAIMS. I THINK A FULL RECALL IS DUE. MY TRUCK COULD OF KILLED SOMEONE. I AM SURE THERE IS A LOT OF TICKING TIME BOMBS OUT THERE. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE LEAF SPRING FRACTURED WITHOUT WARNING AND THERE WAS A PUNCTURED HOLE, WHICH DAMAGED THE FUEL TANK. PRIOR TO THE FAILURE, THE CONTACT TRIED FOR SEVERAL MONTHS TO SCHEDULE A REPAIR. THE DEALER INDICATED THAT THEY DID NOT HAVE A REMEDY FOR SEVERAL MONTHS. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V604000 (SUSPENSION), 12V092000 (AIR BAGS), AND 09V388000 (VEHICLE SPEED CONTROL). THE DEALER DID NOT KNOW WHEN THE PARTS WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIRS. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THE LEAF SPRINGS AND FUEL TANK WERE REPLACED AS A TEMPORARY REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

The contact owns a 2005 Toyota Tacoma. The contact stated while inspecting the vehicle, he noticed punctures and corrosion on the main subframe. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The contact stated that an unknown recall repair was performed to the subframe in August 2014. The failure mileage was approximately 255,000.

MY TRUCK FRAME HAS AN INORDINATE AMOUNT OF RUST AND A PERFORATING RUST ON THE DRIVERS SIDE FRONT OF THE FRAME APPROXIMATELY 7X6 INCHES OF FRAME THAT HAS JUST CRACKED AWAY WITH RUST, I AM SURE MY TRUCK WILL NOT PASS STATE INSPECTION THIS YEAR. UNDER TOYOTA'S LIMITED SERVICE CAMPAIGN MY TRUCK SHOULD QUALIFY FOR REPAIRS BUT TOYOTA CORPORATE DOES NOT RECOGNIZE MY TRUCK AS NEEDING REPAIR BASED ON THE VIN NUMBER. *TR

FRAME IS RUSTED AND WE HAVE WAITED SINCE OCTOBER 27 OF 2014 WITH NO NOTIFICATION FROM DEALER AS THEY ARE SUPPOSED TO REPLACE IT UNDER WARRANTY TOYOTA RECALLED THIS MAY 8TH OF 2014: LIMITED SERVICE CAMPAIGN E0D (SPECIFIC 20 COLD CLIMATE STATES ONLY) - CERTAIN 2005-2008 MODEL YEAR TACOMA VEHICLES - CORROSION-RESISTANT COMPOUND APPLICATION TO THE VEHICLE'S FRAME THE VEHICLE WAS INSPECTED BY HURLBERT TOYOTA EPPING NH 03042 ON 10/27/2014 AND NOTHING HAS COME FROM THEM. *TR

FRAME RUST/AND ALL CONNECTORS WITH HOLES, BUCKLING AND STALLING. *TR

TL- THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE HAD DEVELOPED SEVERE CORROSION AND A HOLE NEAR THE DRIVERS SIDE TIRE. THE CONTACT WHO WAS A CERTIFIED MECHANIC STATED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000. PAM

MY VEHICLE WAS PARKED IN THE DRIVEWAY. I STARTED THE VEHICLE AND PUT THE GEAR IN DRIVE TO MOVE IT FORWARD. AS SOON AS I DROPPED IT INTO DRIVE, THE VEHICLE SUDDENLY ACCELERATED FORWARD WITH THE THROTTLE APPEARING TO BE WIDE OPEN. I HAD MY FEET FIRMLY ON THE BRAKE TO KEEP THE VEHICLE FROM MOVING, THE BACK WHEELS STARTED TO SLIP AND "CHIRP" SINCE THE REAR END IS LIGHT. WITH THE ACCELERATOR STILL WIDE OPEN, I PUT THE GEAR IN NEUTRAL AND WATCHED AS THE RPM'S SHOT OVER 4000. AFTER A FEW SECONDS, THE ACCELERATOR SHOWED NO SIGNS OF DISENGAGING, SO I TURNED THE VEHICLE OFF AND PUT THE GEAR IN PARK. THIS HAS HAPPENED BEFORE, SO I AM ALWAYS READY IN CASE IT HAPPENS AGAIN. I MUST CONSTANTLY DRIVE WITH ONE HAND ON THE GEAR SHIFT, READY TO PUSH IT INTO NEUTRAL AT THE FIRST SIGNS OF THIS SUDDEN UNINTENDED ACCELERATION. THIS IS THE FIFTH TIME THIS HAS OCCURRED IN THE PAST YEAR. TOYOTA CONTINUES TO CLAIM THERE IS NOTHING WRONG WITH THE VEHICLE, THAT I AM ACCIDENTLY HITTING THE GAS PEDAL MYSELF. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. WHILE THE VEHICLE WAS BEING INSPECTED, THE MECHANIC DISCOVERED THAT THE REAR LEAF SPRINGS FRACTURED. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). AFTER THE RECALL REPAIR WAS PERFORMED, THE REAR OF THE VEHICLE BEGAN TO LOWER TOWARDS THE GROUND. IN ADDITION, THE VEHICLE WAS DIFFICULT TO VEER AND SWERVED WHEN DRIVING. THE CONTACT MENTIONED THAT THE RECALL PART INSTALLED WAS THE INCORRECT SIZE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 174,764.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) AND STATED THAT THE PART WAS NOT AVAILABLE WITHIN A REASONABLE TIMEFRAME TO SCHEDULE THE RECALL REPAIR. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE STEERING SEEMED TO SEIZE UP ALMOST INSTANTLY AS IF THE POWER STEERING WAS GOING OUT. ONCE I REALIZED THAT THE PROBLEM WASN'T A TIRE ISSUE; I.E. UNDER- INFLATION, I BEGAN TO MAKE ARRANGEMENT TO HAVE TOYOTA IDENTIFY AND CORRECT THE PROBLEM. THE TOYOTA DEALERSHIP DID AGREE TO DIAGNOSE THE PROBLEM FOR $100+ BUT THIS DIAGNOSIS CHARGE WOULDN'T BE APPLIED TO THE REPAIR. THIS,METHOD OF SERVICE SEEMED ODD TO ME SO I USED ANOTHER AUTO REPAIR SERVICE CENTER THAT PROMPTLY IDENTIFIED THE PROBLEM AND SCHEDULE THE REPAIR. IT WAS IDENTIFIED AS THE LOWER STEERING COLUMN WITH A NEAR FROZEN U-JOINT. THIS PROBLEM RESULTED IN A VERY ERRATIC STEERING PATTERN. MOST OF THE TIME THE STEERING WHEEL WOULDN'T RETURN TO THE NEUTRAL POSITION AFTER MAKING A TURN AND AT OTHER TIMES IT WOULD RETURN TO THE NEUTRAL POSITION RESULTING IN OVER STEERING. THE ANTICIPATED LACK OF RETURN TO THE NEUTRAL POSITION CAUSED ME ON OCCASION TO ATTEMPT TO STEER TO THE NEUTRAL POSITION RESULTING IN THE OVER STEERING. THIS ISSUE SHOULD BE BROUGHT TO OTHERS ATTENTION AND POSSIBLY HAVE ANY VEHICLES SUSPECT FOR A SIMILAR STEERING ISSUE INSPECTED SO REPAIRS CAN BE MADE BEFORE AN ACCIDENT OCCURS. *TR

THE CATALYTIC CONVERTER SHIELD ON MY 2005 TACOMA FELL OFF WHILE DRIVING AND ALMOST CAUSED AN ACCIDENT. AFTER PICKING UP THE LARGE METAL PARTS AND INSPECTING UNDER THE VEHICLE, I NOTICED THAT NEAR TO WHERE THE CATALYTIC CONVERTER SITS, THAT THERE WAS EXTENSIVE CORROSION ON THE TRUCK'S FRAME AND EVEN A LARGE HOLE. I AM EXTREMELY WORRIED ABOUT THE SAFETY OF THE VEHICLE AND AM AFRAID THAT THE FRAME MAY CRUMPLE WHILE DRIVING CAUSING AN ACCIDENT OR DEATH. TOYOTA IS AWARE OF THE ISSUE. I CONTACTED THE CORPORATE OFFICES, BUT WAS TOLD THAT TOYOTA IS ONLY REPLACING THE FRAME ON VEHICLES REGISTERED IN WHAT THEY HAVE DESIGNATED AS A "SNOW STATE". I PURCHASED MY TOYOTA AT A DEALERSHIP IN ILLINOIS (A "SNOW STATE") AND HAVE DONE A LOT OF TRAVELING WITHIN THE "SNOW STATES", YET BECAUSE I LIVE 25 MILES AWAY ON THE MISSOURI SIDE, TOYOTA IS REFUSING TO COVER THE REPAIR. THE WOMAN FROM TOYOTA CORPORATE DID NOT SEEM TO CARE WHEN I TOLD HER THAT I WAS WORRIED ABOUT THE SAFETY OF THE VEHICLE AND THAT IT COULD RESULT IN AN ACCIDENT OR DEATH. I OFFERED TO EMAIL THE PHOTOS OF THE FRAME CORROSION, BUT WAS REJECTED. TOYOTA NEEDS TO COVER THIS REPAIR ON ALL VEHICLES WITH FRAME CORROSION REGARDLESS OF THE STATE THEY LIVE IN. *TR

VEHICLE'S FRAME IS RUSTING AND FLAKING APART. THE VEHICLE WAS TAKEN TO A TOYOTA DEALERSHIP PER THEIR LIMITED SERVICE CAMPAIGN TO APPLY A CORROSION-RESISTANT COMPOUND. ONE YEAR LATER THAT COMPOUND IS STARTING TO FALL OFF AS THE RUST BENEATH IT LETS LOOSE. SINCE THERE IS PHYSICALLY LESS FRAME MATERIAL THAN WHEN THE TRUCK WAS BUILT I FEEL THAT THIS VEHICLE WOULD SUFFER CONSIDERABLE DAMAGE IN A COLLISION AS THE THE STRENGTH OF THE FRAME HAS BEEN COMPROMISED. I AM ALSO CONCEREND THAT THE VEHICLE COULD LOOSE CONTROL IF THE FRAME FAILS AT HIGHWAY SPEED AFTER ENCOUNTERING A LARGE POTHOLE. YOU CAN SEE HOW THE RUST HAS AGGRESSIVELY ATTACKED THE MANY WELDS ON THIS FRAME AND WEEKEND THE JOINTS. WHILE THE MANUFACTURER DID MAKE AN ATTEMPT TO COAT THE FRAME AND HIDE THE RUST THERE ARE SEVERAL PLACES ON THE INTERIOR OF THE FRAME THAT RECIEVED NO TREATMENT AT ALL. YOU CAN STILL SEE THE METAL FLAKING AWAY IN THOSE UNTREATED AREAS. TO HAVE SOME SURFACE RUST ON A 10 YEAR OLD VEHICLE IS NORMAL BUT THIS PROBLEM IS WAY BEYOND SURFACE RUST. WHILE TOYOTA HAS AGREED TO REPLACE FRAMES WITH CONSIDERABLE SIZE HOLES I THINK THAT FRAMES LIKE MINE ARE BEING OVERLOOKED. RATHER THAN HAVE A SINGLE POINT OF FAILURE MY ENTIRE FRAME IS WEEKEND AND WILL CONTINUE TO WEAKEN AS THE COMPOUND THEY APPLIED IS FAILING TO STOP THE RUSTING. WHILE THE FRAME DOES NOT CURRENTLY HAVE A HOLE IT IS ONLY A MATTER OF TIME BASED ON THE FLAKING RUST. TOYOTA IS NOT WILLING TO OFFER ANY HELP WITH FUTURE HOLES BECAUSE THEY SPRAYED THE COMPOUND ON THE FRAME. UNFORTUNATELY THE COMPOUND DOESN'T PROTECT THE ENTIRE FRAME AND IT IS PRONE TO PEELING OFF. EVEN IF THE COMPOUND WERE APPLIED CORRECTLY IT IN NO WAY PROVIDES THE STRUCTURAL INTEGRITY THAT THE FRAME ONCE HAD.

TOYOTA ISSUED A LIMITED SERVICE CAMPAIGN NUMBER CSC-10056075-4484 FOR 2005 THRU 2008 TOYOTA TACOMA TRUCK WITH FRAME RUST PROBLEMS, MINE WAS INSPECTED AT THE LOCAL TOYOTA DEALER AND WAS TOLD THAT IT WOULD NOT PASS THE WV STATE INSPECTION YEARLY PROCEDURE. BUT WAS TOLD BY TOYOTA USA THAT MY VIN IS NOT ONE INCLUDED IN THE CAMPAIGN EVEN THOUGH IT FITS THE YEAR AND MODEL. SO I AM STUCK WITH A TRUCK THAT IS UNSAFE TO OPERATE. I HAVE ONLY ONE VEHICLE AND RETIRED AND NEED THE TRUCK. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

IN THE SUMMER OF 2013 MY REAR TIRE FEEL OUT FROM BENEATH MY TRUCK WHILE I WAS DRIVING. THE CROSS BARS THAT HELD THE TIRE HAD RUSTED THROUGH. I FILED AN NHTSA COMPLAINT. EARLY THIS SPRING I BROUGHT MY TACOMA TO MY TOYOTA DEALER TO COMPLAIN ABOUT A LARGER PERFORATION THAT APPEARED IN MY FRAME. THERE DEALER PHOTOGRAPHED IT, SENT IT TO TOYOTA, AND INFORMED ME THEY WOULD CALL ME IF TOYOTA WAS GOING TO TAKE ANY ACTION. THE SERVICE MANAGER TOLD ME HE WAS HEARING RUMORS OF A FRAME RECALL AND THAT I SHOULD CHECK IN PERIODICALLY. EARLY IN OCTOBER OF THIS YEAR I READ ON HE INTERNET ABOUT THE TACOMA "LEAF SPRING" RECALL AND BROUGHT MY TRUCK BACK TO TOYOTA. MY TRUCK WAS AGAIN INSPECTED, PHOTOGRAPHED, AND A FEW DAYS LATER I WAS TOLD TO BRING MY TRUCK IN. I WAS TOLD THAT TOYOTA WAS MAILING OUT NOTICES TO QUALIFIED TOYOTA OWNERS AND THAT I SHOULD BE GETTING MY RECALL NOTIFICATION LETTER SOON. I HAVE NEVER YET RECEIVED THAT LETTER. HOWEVER, I BROUGHT MY TRUCK BACK TO THE DEALER ON OCTOBER 10 AND THEY PROMPTLY IMPOUNDED IT, SAYING IT WAS UNSAFE TO DRIVE. THE SERVICE MANAGER TOLD ME THAT ALTHOUGH THE FRAME REPLACEMENT WOULD TAKE JUST A FEW DAYS, THE FRAMES HAD NOT YET ARRIVED AND I SHOULD EXPECT A TWO TO THREE MONTH DELAY. I FILED A COMPLAINT WITH TOYOTA AND A FEW DAYS LATER THE CUSTOMER SERVICE REPRESENTATIVE WHO CALLED ME OFFERED NO FURTHER SOLUTION (I SUGGESTED THAT TOYOTA BUY BACK MY TRUCK AND OFFERED ME A CREDIT TOWARDS THE PURCHASE OF A NEW TOYOTA), BUT DID ADD THAT SHE THOUGHT THE FRAMES WOULD TAKE LONGER STILL TO COME IN AND THAT I SHOULD EXPECT TO BE WITHOUT MY TRUCK FOR FOUR MONTHS. I AM CURRENTLY DRIVING A LOANER PAID FOR BY TOYOTA, BUT ONE THAT DOES NOT WELL MEET THEN NEEDS MET BY MY PERSONAL TRUCK. *TR

I TOOK MY VEHICLE FOR MAINTENANCE AND WAS TOLD THAT THE FRAME ON MY 2005 TACOMA X-RUNNER IS RUSTED AND SHOWING SIGNS OF CRACKING. I CALLED TOYOTA CORPORATE TO COMPLAIN ABOUT THE ISSUE AND WAS TOLD THERE WAS NOTHING THEY CAN DO ABOUT IT SINCE THERE IS NO RECALL OR TSB. THE RUST IS SO BAD THAT I CAN NO LONGER DRIVE MY VEHICLE. THERE WAS A RECALL NOTICE FOR THE COLD WEATHER STATES TO RECOAT OR REPLACE RUSTED FRAMES SO TOYOTA KNOWS OF THE PROBLEM ESPECIALLY SINCE THEY HAD THE SAME ISSUE WITH 95-04 TACOMAS. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 3/3/15*CN UPDATED 03/17/15. *JB

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V604000 (SUSPENSION) AND STATED THAT THE PART WAS NOT AVAILABLE FOR SEVERAL MONTHS. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT DID NOT EXPERIENCE A FAILURE. UPDATED 3/31/15*CN UPDATED 04/14/15

I FIRST RECEIVED RECALL NOTICE NHTSA OCTOBER 2014. I CALLED THE LOCAL TOYOTA DEALER AND THEY INFORMED WHEN THE PARTS ARE AVAILABLE THEY WILL REPLACE THE DEFECTIVE PART (LEAF SPRINGS). I CALLED A MONTH LATER AND RECEIVED THE SAME STORY. ADDITIONALLY, THE DEALER INFORMED ME THAT THEY WILL CALL ME WHEN THE PARTS ARE AVAILABLE FOR INSTALL. I WAITED AN ADDITIONAL TWO MONTHS BEFORE CALLING AGAIN AND WAS GIVEN THE SAME STORY. AT THE ONE YEAR MARK UPON RECEIVING THIS FIRST NOTICE I CALLED THE DEALER AND ASKED THE STATUS OF THIS RECALL. I WAS GIVEN THE SAME STORY, AS THE PARTS BECOME AVAILABLE THEY WILL CALL ME AND LET ME KNOW THEY ARE READY TO INSTALL THEM ON THE VEHICLE. I HAVE SINCE CALLED THEM MONTHLY AND RECEIVED THE SAME STORY OVER AND OVER AGAIN. IT APPEARS TOYOTA DOES NOT WANT TO PAY FOR THIS PROBLEM THEY CREATED.

I RECEIVED SEVERAL RECALL NOTICES FROM TOYOTA AND TOOK MY VEHICLE TO THE DEALER MULTIPLE TIMES, BUT THE REPAIR DEPT KEPT INFORMING ME THAT A FIX HASN'T BEEN FINALIZED YET. CONTRADICTING TO TO RECALL NOTICE, THEY TOLD ME THIS ISSUE WAS NOT A "BIG DEAL." ACCORDING TO THE RECALL, THERE IS A POSSIBILITY THAT A LEAF COULD FRACTURE DUE TO STRESS AND CORROSION. AND, IF THIS OCCURS AND THE VEHICLE CONTINUES TO BE OPERATED, THE BROKEN LEAF COULD MOVE OUT OF POSITION AND CONTACT SURROUNDING COMPONENTS, INCLUDING THE FUEL TANK. IF THE BROKEN LEAF CONTACTS THE FUEL TANK REPEATEDLY, IT COULD PUNCTURE THE TANK AND CAUSE A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, THIS COULD RESULT IN A FIRE. TOYOTA CLAIMED THEY WOULD REPLACE THE LEAF SPRINGS WITH NEWLY DESIGNED ONES, BIT THIS HAS YET TO HAPPEN.

ON MY OLD 1998 TOYOTA TACOMA I GOT THE DEAL ON BUYBACK WHEN THE FRAME RUSTED OUT SO BAD WITH HOLES IN IT.THEN I WENT OUT AND BOUGHT A 2005 TOYOTA TACOMA AND THIS TRUCK HAS RUST FROM END TO END ON THE FRAME AGAIN. WHEN I BOUGHT IT IN 2006 TOYOTA SAID THEY HAD THAT FIXED BUT THIS 2005 IS ALOT WORSE WITH ALOT MORE RUST THEN THE 1998.I ALSO TOOK IT TO THE GARAGE TO HAVE THE POWER STEERING PUMP AND ALTERNATOR AND AC PUMP REPLACED BECAUSE EVERYTHING WAS RUSTED UP ON THE ALTERNATOR AND AC PUMP AND POWER STEERING SO BAD THE MECHANIC TOLD ME TO KEEP THE PARTS AND SHOW THE TOYOTA DEALERSHIP AND NHTSA.I WAS LUCKY THAT EVERYTHING SHUT DOWN ON THE TRUCK WHEN I GOT IT TO THE BOTTOM OF MY DRIVEWAY AND THEN GOT IT TOWED TO THE MECHANIC AND 1790.00 DOLLARS LATER WITH LABOR AND PARTS LET ME TELL YOU NOT HAPPY WITH TOYOTA.PLEASE NHTSA LOOK AT THIS PROBLEM AND IF YOU NEED A TRUCK TO TAKE PICS OF MINE IS THE ONE I USED TO WORK AT A BODY SHOP SO I KNOW THIS TRUCK WOULD DO THE JOB FOR NHTSA MY TRUCK HAS 78000 MILES ON IT I WILL TAKE PICS OF IT FOR YOU IF YOU WISH. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER AND MANUFACTURER WERE NOTIFIED MULTIPLE TIMES. THE CONTACT WAS INFORMED NOT TO CALL BACK AND THAT HE WOULD BE NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO PROVIDE THE PART TO DO THE REPAIR. THE MANUFACTURER WAS NOTIFIED AND MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.