2000 Toyota Tundra Body & Structure Problems

2000 toyota tundra SR5 4door 4.7 liter V8. Sunroof glass blew off on freeway at 65mph almost hit car behind me. No police report, no person injured. November 3, 2025.

Excessive frame rust that is quickly progressing despite efforts to remedy. There was a recall due to this issue but I was told a few years ago by Toyota that my VIN was not covered. All the 2000 Tundra's have this issue with the frame rust but I was told I am not in the north east and would not be covered.

The contact owns a 2000 Toyota Tundra. The contact stated that while driving approximately 30 MPH and hauling a boat, the subframe nearby the transmission cross member detached from the vehicle. The vehicle was towed to the residence. The contact was able to inspect the vehicle and became aware of severe rust on the subframe with several areas where the subframe had rusted through and had holes. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 230,000.

Frame of truck rusting apart Rust problem identified by independent dealer. I was told by repair shop that the frame could twist apart at any moment.

The contact owns a 2000 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 09V444000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the rear cross member was rusted. The local dealer was contacted and informed the contact that the recall repair could not be performed at their location. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and contacted the dealer; however, the dealer advised that the recall repair could not be performed at the dealer location. The failure mileage was approximately 327,000. Parts distribution disconnect.

The contact owns a 2000 Toyota Tundra. The contact stated that upon investigation, he became aware that the VIN was included in NHTSA Campaign Number: 09V444000 (Structure). The contact took the vehicle to the local dealer, where it was diagnosed with needing the frame to be replaced due to corrosion. The dealer informed the contact several unknown components needed to be repaired before the recall repair could be performed. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 190,000.

The contact owns a 2000 Toyota Tundra. The contact received notification of NHTSA Campaign Numbers: 01E041000 (Trailer Hitches) and 09V444000 (Structure). The contact stated that while driving at various speeds, the vehicle lost motive power. The vehicle was able to restart. The dealer was made aware of the failure but declined to perform the recall repairs due to extensive corrosion to the subframe of the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 298,845.

2000 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO CORROSION ON THE FRAME.

Frame rust really bad

THE FRAME IS DAMAGED AND WAS TOLD MY MANUFACTURE WAS SUPPOSED TO REPLACE WITH A NEW ONE. THE TRUCK LOOKS TO BE BENT IN BETWEEN THE MIDDLE. I TOOK IT TO MY LOCAL DEALER AND THEY ARE HAVING ME PAY FOR OTHER AREAS AND NOT REPLACING THE FRAME EVEN THOUGH IT'S UNDER RECALL.

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT BECAME AWARE THAT THE FRAME SUPPORTING THE ENGINE WAS CORRODED THROUGH. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN NUMEROUS TIMES FOR AN OIL CHANGE TO PARKWAY TOYOTA (50 SYLVAN AVE, ENGLEWOOD CLIFFS, NJ 07632) AND IT WAS NEVER DISCLOSED THAT THE SUBFRAME WAS CORRODED. THE CONTACT WAS CONCERNED FOR HIS SAFETY AND STATED AT ANY TIME THE ENGINE MAY DETACH. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC TO BE INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

REAR FRAME RUSTED OBVIOUS MANUFACTURER DEFECT. WILL NOT PASS SAFETY INSPECTION.

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT AFTER PURCHASING THE VEHICLE, THE UNDERCARRIAGE WAS INSPECTED AND IT WAS FOUND TO BE EXTREMELY CORRODED. THE CONTACT ALSO STATED THAT THE SPARE TIME COMPARTMENT WAS ALSO EXTREMELY CORRODED. (YOUNG TOYOTA (1945 MAIN ST, LOGAN, UT 84341) WAS CONTACTED AND INFORMED OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 240,000.

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT STATED THAT HE PREVIOUSLY RECEIVED AN UNKNOWN RECALL NOTICE REGARDING FRAME CORROSION. THE REMEDY FOR THE RECALL STATED THAT FOR FRAMES THAT WERE SEVERELY CORRODED, THEY WOULD BE REPLACED. IN CASES WHERE REPLACEMENT WAS NOT NEEDED, THE FRAMES WOULD BE UNDERCOATED IN ORDER TO PREVENT CORROSION. SHOTTENKIRK TOYOTA QUINCY (LOCATED AT 5333 BROADWAY ST, QUINCY, IL 62305, 217-929-9852) DID NOT PERFORM EITHER REMEDY REFERENCED IN THE RECALL. WHILE THE VEHICLE WAS HAVING AN ALIGNMENT PERFORMED, THE CONTACT WAS INFORMED THAT THE FRAME WAS SEVERELY CORRODED. THE CONTACT CALLED SHOTTENKIRK TOYOTA AND WAS INFORMED THAT THEY COULD NOT REPLACE THE FRAME BECAUSE THE RECALL REPAIR WAS DEEMED COMPLETED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY WERE UNABLE TO PERFORM THE REMEDY FOR THE RECALL DUE TO THE TIME LIMITATION. THE APPROXIMATE FAILURE MILEAGE WAS 23,000. *TR

THE TRUCK IS IN AWESOME CONDITION EXCEPT THE FRAME. TOYOTA HAS REPLACED THE FRAMES IN OTHER TRUCKS IN THE PAST BUT ARE UNWILLING TO TAKE INTO CONSIDERATION THE ONE I OWN. I FEEL VERY UNSAFE DRIVING IT, AND DON'T WANT TO GET RID OF IT BECAUSE OF ITS ONE NEGATIVE THING . I'M GOING TO INCLUDE SOME PHOTOS SO YOU CAN JUDGE IF YOU WISH. IF THEIR IS ANYTHING YOUR COMPANY DO TO HELP ME, IT'LL BE GREATLY APPRECIATED. I HAVE REACH OUT TO TOYOTA IN THE PAST AND ALL THEY'VE SAID WAS THAT THEIR IS NO RECALL ON THE TRUCK ANYMORE. ITS VERY SAD BECAUSE THEIR IS PLENTY OF THESE TRUCKS OUT THERE, AND ARE VERY UNSAFE TO THE OWNER AND PEDESTRIANS AROUND US. THEY SHOULD RECALL CERTAIN ONES LIKE THE ONE I OWN ON ACCOUNT OF ITS CONDITION. THANK YOU VERY MUCH FOR YOUR TIME.

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE THE VEHICLE WAS BEING INSPECTED BY RELIABLE TOYOTA (LOCATED AT 3521 E SUNSHINE ST, SPRINGFIELD, MO 65809, (417) 459-4400), RUST WAS DISCOVERED ALL OVER THE ENTIRE FRAME. THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 188,000.

FRAME RUST SO BAD TRUCK WILL NOT PASS STATE INSPECTION. THIS CONDITION FOUND ON ANNUAL STATE INSPECTION. FROM PICS MECHANIC TOOK, I AM NOW AFRAID TO DRIVE VEHICLE. SOME ATTACHMENT BRACKETS/BARS NOT EVEN CONNECTED AND RUSTED COMPLETELY IN HALF. I CALLED TOYOTA CORPORATE AND THEY SAID THERE WAS NO RECALL ON THIS VEHICLE NOR ANY TYPE OF BUY BACK PROGRAM FOR IT. SAD THAT THIS TRUCK WAS NOT REPAIRED AS THIS WAS A KNOWN ISSUE WITH 2000-2003 TUNDRAS AND NOW I AM STUCK WITH A VEHICLE THAT TOYOTA WILL NOT REPAIR DUE TO AGE. SEEMS THIS REPAIR WORK SHOULD BE AVAILABLE TO ANY CONSUMER WHO OWNS THE VEHICLE IF THE RECALL WORK HAS NEVER BEEN PERFORMED ON THE VEHICLE? I AM JUST SECOND OWNER OF VEHICLE AND HAVE ONLY OWNED THE VEHICLE JUST OVER A YEAR. ALTHOUGH HIGH MILEAGE, THIS TRUCK RUNS AND LOOKS GREAT.

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO LAKE COUNTRY TOYOTA (7036 LAKE FOREST RD, BAXTER, MN) WHO INDICATED THAT THE RECALL REMEDY COULD NOT BE PERFORMED DUE TO EXCESSIVE RUST AND CORROSION TO THE FRONT SUBFRAME OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 157,000. *TT CONSUMER STATED 3/4'S OF THE RIGHT FRAME WAS RUSTED AND FRAME WAS WELDED FOR $250.00 CONSUMER LOST RECEIPT WAITING FOR RECALL PARTS TO ARRIVE.*JB

I HAS A LOT CORROSION IN THE CHASIS HOLES I CAN'T PLACE THE SPARE TIRE BECAUSE THE CORROSION IT'S EVERYWHERE

TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO TOYOTA OF BRAINTREE (781-848-9300, LOCATED AT 210 UNION ST, BRAINTREE, MA 02184) AND THE RECALL WAS REPAIRED IN FEBRUARY OF 2012. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC FOR AN EXHAUST SERVICE IN OCTOBER OF 2018 AND THE MECHANIC NOTICED THAT THE ENTIRE FRAME WAS SEVERELY RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THE RECALL REPAIR WAS COMPLETED; THEREFORE, NO FURTHER ASSISTANCE WAS OFFERED. THE DEALER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,957.