2011 Toyota Tundra Speed Control & Cruise Problems

The contact owns a 2011 Toyota Tundra. The contact stated while driving approximately 55-70 MPH, the check engine warning light illuminated and the vehicle started losing power. The contact veered to the side of the road and turned off the vehicle. The contact restarted the vehicle and was able to continue driving. Additionally, the contact stated that upon starting the vehicle, the accelerator pedal was depressed; however, there was a delay in the vehicle response. The contact stated that the failure reoccurred several times while driving. The contact stated that the vehicle shifted into LIMP mode. The vehicle was taken to a local Pep Boys who provided diagnostic test codes to the contact but did not physically diagnose the vehicle. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact they could not assist as the vehicle had not been diagnosed by the dealer. The failure mileage was approximately 165,000.

THIS PROBLEM IS DANGEROUS IT WILL NOT PICKUP TH SPEED ON A BUSY ROAD IT IS COMMON PROBLEM WHICH IS NOT COVERED BY TOYOTA WARRANTY. *TR

ON SUN. 10/11/14, I DROVE OUR TUNDRA ON THE HIGHWAY WHEN IT LOST POWER. THE ENGINE RACED AND RPMS INCREASED, BUT THE SPEED FELL AND NO ACCELERATION WAS POSSIBLE. ON A HILL, SPEED FELL TO ABOUT 15 MPH. I WAS ON MY WAY TO PICK UP MY HORSE AND TRAILER; IF I HAD BEEN TOWING THEM, IT WOULD HAVE BEEN CATASTROPHIC ESPECIALLY GIVEN THE HIGHWAY SPEED TRAFFIC. IT WAS STILL DANGEROUS EVEN WITHOUT THE TRAILER. I TURNED ON MY HAZARD LIGHTS AND LIMPED OFF. "CHECK ENGINE" LIT UP. TOOK TO DEALERSHIP THE NEXT DAY, WHO SAID CHECK ENGINE CODE WAS "P2445" FOR "SECONDARY AIR INJECTION SYSTEM WATER INTRUSION" REQUIRING REPLACEMENT OF THE AIR PUMP ASSEMBLY, AIR PUMP INLET, EMISSION VALVE SET, ETC. FOR $2600 BECAUSE WATER INVADED THE SYSTEM. THE SERVICE TECH SAID THAT THIS WAS NOT A KNOWN ISSUE, BUT MY INTERNET SEARCH SHOWED THAT TOYOTA ISSUED A 12-PAGE 2011 TECHNICAL SERVICE BULLETIN, STATING THAT "THE AIR PUMP ASSEMBLY INLET HAS BEEN UPDATED TO PREVENT WATER INTRUSION." TOYOTA HAS NEITHER RECALLED THE DEFECTIVE INLETS NOR NOTIFIED OWNERS. THE TSB SAYS ONLY TRUCKS UNDER THE 36,000/ 3 YEAR WARRANTY ARE COVERED. TUNDRAS ARE TOW VEHICLES AND IT IS FORESEEABLE HOW UNSAFE THIS IS. BECAUSE MY TRUCK WAS SOLD JUST OVER 3 YEARS AGO, THE LOCAL DEALERSHIP AT FIRST COULD NOT COVER IT. I CONTACTED TOYOTA HEADQUARTERS, WHO REFERRED ME BACK TO THE LOCAL SERVICE MANAGER, WHO THEN REACHED SOUTHEAST REGIONAL TOYOTA OFFICE, WHICH FINALLY AGREED TO COVER THE REPAIR. WHEN THIS AIR PUMP INLET FAILS, IT ALLOWS WATER TO ENTER THE AIR INJECTION SYSTEM AND THE SYSTEM TO THEN FAIL IN THE DANGEROUS WAY THAT OCCURRED IN MY CASE, RESULTING IN A SUDDEN LOSS OF POWER. I AM CONCERNED ABOUT THIS HAPPENING TO OTHERS AND THAT THE DEALERS SEEM UNAWARE OF THIS TSB AND THIS "KNOWN ISSUE." TSB LINK IS HERE: HTTP://WWW.AUTOSAFETY.ORG/SITES/DEFAULT/FILES/IMCE_STAFF_UPLOADS/T-SB-0160-11.PDF. *TR

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE PARKED AND SHIFTING TO DRIVE, THE VEHICLE ACCELERATED INDEPENDENTLY. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY APPLYING THE BRAKES. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST BUT THE TECHNICIAN WAS UNABLE TO LOCATE A FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND ADVISED THE CONTACT THAT THEY WOULD FURTHER ASSESS THE FAILURE. THE FAILURE MILEAGE WAS 16,600.

TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 1 MPH, HE NOTICED A GRINDING NOISE FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WOULD NOT ACCELERATE AND THE BRAKE PEDAL SEIZED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE AND STATED THAT THE ANTI-SLIP HAD ACTIVATED, CAUSED THE THROTTLE TO DISENGAGE AND THE BRAKES TO ENGAGE, WHICH HE STATED WAS A CHARACTERISTIC OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. ON A LATER DATE WHILE THE CONTACT WAS DRIVING 75 MPH IN INCLEMENT WEATHER, THE BRAKES ENGAGED INDEPENDENTLY AND CAUSED HIM TO CRASH INTO A DITCH. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40. *TR