2022 Volkswagen Atlas Fuel System Problems

The contact owns a 2022 Volkswagen Atlas. The contact stated that while stopped at a traffic light, the vehicle experienced a loss of automotive power, and the vehicle failed to start. There was no warning light illuminated. The contact stated that after several attempts, the vehicle restarted and the contact drove to a parking lot, and then the vehicle was towed to a local dealer, where it was diagnosed, and the contact was informed that the fuel pump was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 77,048.

My Volkswagen Atlas has a recurring check engine light and start/stop error light. The LD pump and valve have been replaced multiple times, but the issue persists. Volkswagen now says the problem is the carbon canister, which is covered by TSB VWP-23-04 (NHTSA ID MC-10235143-0001) extending warranty to 15 years/150,000 miles. The bigger concern is safety: the vehicle has stalled multiple times while driving, including once in an intersection where I completely lost steering and control until the car was towed. This creates a major safety hazard for myself and others on the road. Despite the TSB coverage, Cardinale Volkswagen in Salinas, CA is refusing to replace the carbon canister under warranty. They also charged me a $240 diagnostic fee, even though the issue diagnosed was later found to be warranty-related. My understanding is that diagnosis and repair of warranty defects should be performed at no cost. This is a clear safety defect: sudden stalling in traffic, loss of steering, and repeated failures of emission-related parts. I am requesting that NHTSA investigate these incidents and Volkswagen’s handling of warranty claims, as drivers are being put at risk of accidents, injury, or worse.

Randomly stalled out and shut off. Had the auto start disabled. This happened three times today and has happened totaling 4 more before this- all randomly.