2009 Volkswagen Jetta Complaint Log

JETTA WAGON TDI CLEAN DIESEL VEHICLE WAS BEING DRIVEN ABOUT 35 MPH ON BUSY ROAD WITH FULL TANK OF FUEL. VEHICLE STARTED STUMBLING AND LOSING POWER. WITHIN 30 SECONDS OF STUMBLING VEHICLE THEN STALLED. INITIALLY WAS ABLE TO BE RESTARTED BUT WAS STUMBLING SEVERELY AND WAS ONLY ABLE TO CREEP A FEW FEET BEFORE STALLING. VEHICLE WAS UNABLE TO BE RESTARTED AND HAD TO BE TOWED 23 MILES TO NEAREST DEALERSHIP WHERE THE INTERCOOLER (CHARGE COOLER) WAS FOUND TO HAVE ICED UP AND CONTAIN ICE AND WATER. THIS SEEMS TO BE KNOWN ISSUE WITH THE VEHICLE AS VW HAS A TSB OUT ON THE ISSUE. THE DEALERSHIP STATED THAT THEY ACTUALLY HAD ANOTHER VEHICLE WITH THE SAME ISSUE COME IN THE DAY AFTER OURS AND LAST WINTER HAD MANY WITH THIS ISSUE. THIS APPEARS TO BE A KNOWN ISSUE AND IS CLEARLY A SAFETY ISSUE IF IT CAN CAUSE THE VEHICLE TO SUDDENLY AND UNPREDICTABLY LOOSE POWER AND STALL. VW TSB # 21 11 06 / 2025464 REFERENCES THIS ISSUE. *TR

MY VW JETTA HAD SAT FOR A FEW DAYS IN A INDOOR PARKING SPACE IN THE MIDWEST DURING WINTER DECEMBER TO BE EXACT. WHEN I STARTED THE CAR, IT STARTED WEAK, THEN GAVE AN ERROR ON THE DISPLAY OF "ENGINE FAULT WORKSHOP.". THE CAT CONTINUED TO DRIVE, BUT LACKED POWER AND SEEMED TO SURGE. AFTER I RETURNED HOME, I DISCONNECTED THE LOWER INTERCOOLER HOSE TO FIND A LARGE ICE FORMATION AND WATER RESTRICTING THE OUTLET OF THE INTERCOOLER. THIS PROBLEM CAN CAUSE MAJOR ENGINE DAMAGE AND IS CAUSED.BY THE EXHAUST GASES AND WATER VAPOR FREEZING IN THE INTERCOOLER. EVERY VW WITH THIS STYLE INTERCOOLER SETUP HAS POTENTIAL FOR THIS PROBLEM. IT SHOULD BE RECALLED DO TO ITS SEVERITY. ALSO, THERE IS A TSB ALREADY WRITTEN FOR THE "FIX". BUT VW HAS NOT INFORMED ANYONE, NOR WILL TAKE CARE OF THE PROBLEM FOR ANYONE BEYOND THE 36000 MILE WARRANTY. EVEN THOUGH THIS IS A DESIGN FLAW. *TR

VW VOLKSWAGEN JETTA SPORTWAGEN TDI 2009. WAS DRIVING ABOUT 35 MPH WHEN ENGINE LOSES MOST OF ITS POWER. A GLOW PLUG INDICATOR LIGHT TURNED ON AND I SAW AN ENGINE FAULT/WORKSHOP ERROR. I QUICKLY TURNED ONTO A SIDE STREET AND STOPPED THE ENGINE. AFTER A COUPLE MINUTES I RESTARTED THE CAR BUT IT STILL HAD LOW POWER. AFTER ABOUT 10 SECONDS IT STALLED AND COULD NOT BE RESTARTED. HAD IT TOWED TO A VW DEALERSHIP AND 5 DAYS LATER THEY RAN DIAGNOSTICS AND SAID IT WAS A FAILED FUEL PUMP AND THAT METAL SHARDS WERE THROUGHOUT THE FUEL SYSTEM AND EVERYTHING NEEDED TO BE REPLACED. *TR

DOOR LOCKS BEGAN TO MALFUNCTION. LOCKS WILL NOT LOCK OR RELEASE WITH KEY FOB OR DOOR LOCKING MECHANISM. THIS PROBLEMS WAS IDENTIFIED BY THE SERVICE TECH AT THE DEALERSHIP AS NORMAL AND A REGULAR REPLACEMENT FOR MODEL YEARS 2006-2010. *TR

MY 2009 JETTA SPORTWAGEN TDI HAS EXPERIENCED A DISTURBING NO-START CONDITION SEVERAL TIMES. CRANKING THE ENGINE DID NOT RESULT IN A START. ONLY AFTER REPEATED CRANKING (5-10 TIMES) DID THE CAR ACTUALLY START. FIRST IT WOULD NOT START SEVERAL TIMES, THEN START AND DIE IMMEDIATELY, AND FINALLY START, RUN VERY ROUGH,AND THEN SMOOTH OUT ITS IDLE. THIS ENTIRE SEQUENCE (WHICH HAS HAPPENED AT LEAST 4 TIMES IN THE LAST MONTH, TO VARYING DEGREES) OCCURRED IN THE DECEMBER-JANUARY TIME FRAME, WITH THE FIRST INCIDENT OCCURRING WHEN TEMPS WERE RIGHT AROUND FREEZING, WITH PRECIPITATION (RAIN-SNOW MIX) AND HIGH HUMIDITY. AT LEAST 2 TIMES, THE VEHICLE SIMPLY DIED SUDDENLY WHILE DRIVING, WHEN I TOOK MY FOOT OFF THE THROTTLE AND REVS DROPPED DOWN TO IDLE. IN ADDITION, THE CAR HAS DISPLAYED A SOLID CHECK ENGINE AND FLASHING GLOW PLUG LIGHT, WHICH HAVE COME AND GONE SEVERAL TIMES (INTERMITTENTLY: ONE DAY THEY WILL BE ON, THE NEXT DAY NOT). THE LAST SYMPTOM TO REPORT IS A P0638 OBDII CODE (THROTTLE BODY OUT OF RANGE). THIS CODE, HOWEVER, COULD BE A FALSE INDICATION THAT IS RELATED TO THE NUMBER OF FAILED ENGINE START ATTEMPTS? I TOOK THE CAR TO THE DEALER, AND THEY COULD NOT FIGURE OUT WHAT THE PROBLEM IS. I HAVE A STRONG INDICATION TO SUSPECT, AFTER RESEARCHING OTHERS' EXPERIENCES ON SEVERAL ONLINE FORUMS, THAT THIS MAY BE RELATED TO THE ACCUMULATION OF WATER AND/OR ICE IN THE INTERCOOLER, WHICH THEN EITHER BLOCKS THE AIRFLOW OR BECOMES INGESTED INTO THE INTAKE. MY SYMPTOMS ARE CONSISTENT WITH THOSE REPORTED IN THE VOLKSWAGEN TECHNICAL SERVICE BULLETIN (TSB) # 21 11 06 / 2025464 - FROZEN AIR CHARGE COOLER. HOWEVER, WHEN I PRESENTED THIS TSB DATA, ALONG WITH REPORT OF MY SYMPTOMS TO THE DEALER (AFTER THEY INSPECTED THE CAR AND COULD NOT FIND ANYTHING) THEY TOLD ME THAT THEY COULD NOT HELP ME, SINCE THE VEHICLE IS OUT OF ITS WARRANTY PERIOD. *TR

THE EXHAUST FLAP IS STICKING IN THE OPEN POSITION, THUS CAUSING WARNING LIGHT ON DASH TO COME ON. *TR

CAR: 2009 VOLKSWAGEN TDI SPORTWAGEN ON DECEMBER 16TH AT APPROXIMATELY 1230PM, I ENTERED INTERSTATE I-95 VIA EXIT 19 IN SOUTHPORT, CT HEADING SOUTHBOUND. AS I ACCELERATED AND MERGED INTO THE LANE FROM THE ONRAMP AS I GOT UP TO SPEED (@60 MPH) THE "GLOW PLUG LIGHT" CAME ON AND THEN THE ENGINE LIGHT CAME ON. THE CAR IMMEDIATELY BEGAN LOSING POWER AND I PULLED OVER TO THE SIDE OF THE VERY BUSY INTERSTATE. IT WAS DANGEROUS AS I LOST POWER AND HAD TO MANEUVER BETWEEN PASSING CARS IN ORDER TO GET TO THE SHOULDER TO PULL OVER. I TURNED OFF THE ENGINE AND LET THE CAR REST FOR A MINUTE OR SO. I TURNED THE ENGINE BACK ON AND THE CHECK ENGINE LIGHT CAME ON AGAIN. I ATTEMPTED TO ACCELERATE AND THE CAR HAD VERY LIMITED POWER SO I IMMEDIATELY STOPPED THE CAR AGAIN AND TURNED OFF THE ENGINE. I GOT OUT OF THE CAR, OPENED THE HOOD, AND NOTICED WHAT APPEARED TO BE GASOLINE COATING THE ENGINE AS WELL AS TRAILING BEHIND THE CAR. I CALLED AAA AND HAD MY CAR TOWED TO THE RIVERBANK VOLKSWAGEN DEALERSHIP IN STAMFORD, CT WHICH WAS CLOSED DUE TO THE FACT THAT IT WAS SUNDAY. THE FOLLOWING DAY I SPOKE WITH THE SERVICE MANAGER AND WAS INFORMED THAT THE CAR WOULD NOT BE LOOKED AT UNTIL FRIDAY DECEMBER DEC 21ST WHEN A "SPECIALIST" FROM VW WOULD ARRIVE TO INSPECT THE CAR. I HAVE PERFORMED MY OWN DILIGENCE AND HAVE FOUND THAT SIMILAR ISSUES WITH THE 2009 JETTA TDI'S HAVE BEEN FAIRLY COMMON AND I EXPECT (HOPE) VW WILL COVER ALL REPAIR AND RENTAL CAR COSTS FOR ME IN THIS MATTER. *TR

THIS IS THE SECOND COMPLAINT FILED ON THIS CAR. THE REF # FOR THE FIRST NHTSA COMPLAINT IS VOQ 10484807. ON NOV 26, 2012 (DATE TAKEN FROM DEALER REPAIR INVOICE) I PICKED THE CAR UP AT THE DEALERSHIP AFTER THE INITIAL FAILURE REPAIRS. I RESET THE TRIP METER (I DON'T REMEMBER THE EXACT MILEAGE THE VEHICLE HAD WHEN I PICKED IT UP). LATER THAT SAME DAY (26 NOV 12) I TOOK THE CAR BACK TO THE DEALERSHIP AND TOLD THEM THE ENGINE WAS MAKING A WEIRD SOUND. THE MECHANIC AGREED THAT THE ENGINE WAS MAKING A WEIRD SOUND AND SAID HE THOUGHT IT WAS THE NEW SECONDARY FUEL PUMP MAKING THE NOISE. THE DEALERSHIP AGREED TO ORDER A NEW SECONDARY PUMP FOR THE CAR AND THEY TOLD TO CONTINUE DRIVING THE CAR UNTIL THE NEW PUMP ARRIVED. ON OR ABOUT 12 DEC 2012, THE CAR SUFFERED ANOTHER RAPID DECELERATION FAILURE IDENTICAL TO THE ONE THAT OCCURRED ON 26 SEP 2012 WITH THE EXCEPTION THAT THE ENGINE DID NOT COMPLETELY QUIT. I WAS ABLE TO LIMP THE CAR HOME (TOP SPEED WAS APPROXIMATELY 20 MPH) USING SIDE STREETS AND STAYING OFF THE FREEWAY. THE TRIP METER HAD 349 MILES ON IT WHEN I GOT HOME. I CALLED THE DEALERSHIP AND HAD THE CAR TOWED TO THEM. THEY REPLACED THE FUEL TANK PUMPS (APPARENTLY THERE ARE TWO PUMPS IN THE FUEL TANK). WHILE THEY WERE TEST DRIVING THE VEHICLE, TO RETURN IT TO ME, THEY EXPERIENCED A RAPID DECELERATION (FROM THEIR DESCRIPTION IT APPEARED AS THE SAME FAILURE I HAD JUST EXPERIENCED). THE DEALERSHIP CALLED ME AND TOLD ME THEY WERE AT A LOSS TO EXPLAIN THE FAILURE AND THEY WOULD HAVE TO CALL THE VW TECH LINE FOR HELP. VW TOLD THEM THEY THOUGHT THE PROBLEM WAS THE HPFP. IN TOTAL, ALL THREE FUEL PUMPS WERE ONCE AGAIN REPLACED. TO VW AND HOY-FOX CREDIT THESE REPAIRS WERE DONE AT NO COST TO ME (EXCEPT FOR THE TOW BILL). THE CAR IS NOW ON ITS THIRD HPFP IN LESS THAN FOUR MONTHS. BOTTOM LINE, IN MY OPINION, THE VW TDI HPFP IS A SAFETY HAZARD AND SHOULD BE RECALLED. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE NOTICED THAT THE ABS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE THEN STALLED BY INDEPENDENTLY SHIFTING TO NEUTRAL WITHOUT WARNING. THE CONTACT HAD TO WAIT SEVERAL MINUTES IN ORDER TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THEY ADVISED HER THAT THE ABS MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 48,500. MAILED OUT 3/10/15*LJ UPDATED 03/31/15*LJ

WHILE PASSING THROUGH A BUSY INTERSECTION, ENGINE SUDDENLY SHUTDOWN, WITH ENGINE FAILURE WARNING MESSAGE. WOULD NOT RESTART. PUSHED VEHICLE OUT OF INTERSECTION AND TO SHOULDER, WHERE I AWAITED TOW TRUCK. HIGH PRESSURE FUEL PUMP HAD FAILED, CONTAMINATING THE ENTIRE FUEL SYSTEM WITH SHRAPNEL, REQUIRING THE ENTIRE SYSTEM TO BE REPLACED. THIS IS IN LINE WITH FAILURE DESCRIBED IN CAMPAIGN EA11003. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE ENGINE FAULT WORKSHOP LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY A FAILING FUEL PUMP. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 38,000. THE VIN WAS UNAVAILABLE.

I WAS DRIVING ON THE INTERSTATE, AT ABOUT 68 MPH, WHEN THE ENGINE COMPLETELY SHUT DOWN WITHOUT ANY WARNING WHATSOEVER. THE CAR, HAVING A MANUAL TRANSMISSION, WAS STILL IN GEAR AND SLOWED DOWN VERY QUICKLY WITHOUT ANY WARNING TO OTHER DRIVERS (NO BRAKE LIGHTS). I TRIED TO PUSH IN THE CLUTCH AND COAST TO THE SHOULDER, AND SUCCESSFULLY MADE IT OFF THE HIGHWAY. THE CAR RESTARTED, AND I MADE IT A FEW MILES TOWARDS THE DEALER BEFORE IT HAPPENED AGAIN, LUCKILY ON A LOW-TRAFFIC STREET. THE CAR WAS TOWED THE REST OF THE WAY TOWARDS THE DEALER AND DIAGNOSED AS A FAILED HIGH PRESSURE FUEL PUMP, CAUSING CATASTROPHIC FUEL SYSTEM DAMAGE. THE FUEL RAIL, INJECTORS, PUMP, TANK, AND ALL LINES WILL NEED TO BE REPLACED AS THE RESULT OF THE PUMP FAILURE CAUSED BITS OF METAL FLAKES TO CIRCULATE ABOUT THE FUEL SYSTEM. THE DIAGNOSIS AND LISTED REPAIRS WERE DETERMINED BY THE VOLKSWAGEN DEALER. *TR

I STARTED MY CAR AND FOR THE FIRST TIME EVER, IT HESITATED AND FAILED TO START. I RESTARTED MY CAR AND IT STARTED. I PROCEEDED TO DRIVE HOME AND ABOUT A HALF MILE INTO THE DRIVE IT HESITATED AND LOST MUCH OF ITS POWER. A FLASHING GLOW PLUG WARNING LIGHT CAME ON AND THEN A QUICK MESSAGE ON THE DISPLAY ABOUT AN ENGINE FAILURE AND BRING TO SERVICE. I WAS ABOUT A MILE FROM MY VW DEALERSHIP AND DROVE TOWARDS IT. ABOUT A QUARTER OF A MILE LATER, THE CAR (STILL HESITATING - NOW I KNOW IT IS CALLED "LIMP MODE") MADE A GRINDING NOISE FROM THE PASSENGER SIDE OF THE ENGINE BAY, AND THE CAR LOST ALL POWER AND STOPPED IN TRAFFIC. I HAD TO HAVE IT TOWED TO THE DEALERSHIP, WHERE THEY DIAGNOSED A HIGH PRESSURE FUEL PUMP FAILURE. THE ENTIRE FUEL SYSTEM (FUEL TANK, 3 PUMPS, ALL FUEL LINES, COMMON RAIL FUEL DELIVERY SYSTEM, FUEL FILTER HOLDER, FUEL FILTER, FUEL INJECTORS) WERE REPLACED UNDER POWER TRAIN WARRANTY. I AM THE ONLY PERSON TO FILL THIS CAR WITH DIESEL FUEL AND ALWAYS DO SO AT REPUTABLE STATIONS. THE FUEL WAS TESTED AND DID NOT CONTAIN GASOLINE OR ANY ADDITIVES. THIS CAR WAS FIRST PURCHASED IN NORTH CAROLINA AND IS A US VEHICLE. I BOUGHT IT FROM THE ORIGINAL OWNER (AT 6200 MILES) AND DROVE IT TO CANADA. IT IS REGISTERED IN ONTARIO. I HAVE HAD ALL SERVICE DONE IN BUFFALO NY AT NORTHTOWN VW WHILE UNDER WARRANTY AND THIS REPAIR WAS ALSO PERFORMED (AS PER VW OF AMERICA RESTRICTIONS) IN BUFFALO NY. I HAD TO PAY THE EXPENSE OF HAVING IT TOWED FROM TORONTO TO BUFFALO. *TR

WHILE STARTING TO ACCELERATE AFTER A STOP, MY 2009 JETTA TDI SHUDDERED AND DIED WITH A "MAJOR ENGINE FAILURE" ERROR AND WOULD NOT RESTART. THE CAR WAS BLOCKING TRAFFIC AT A MAJOR INTERSECTION. HAD TO HAVE THE CAR PUSHED OUT OF THE TRAFFIC LANE AND THEN WAITED FOR A TOW TRUCK TO TOW IT TO THE LOCAL DEALER. AFTER ONE DAY THEY SAID THE HAD NO IDEA WHAT WAS WRONG WITH IT. ON THE SECOND DAY THE DEALER CALLED TO SAY THAT THEY FOUND THE FUEL PUMP HAD BLOWN APART AND THERE WERE METAL SHARDS THROUGHOUT MY ENTIRE FUEL SYSTEM AND IT WOULD NEED TO BE COMPLETELY REPLACED (APPROX $8-9000 IN REPAIRS). THEY ALSO SAID THAT THE WARRANTY WOULD NOT COVER IT UNLESS I COULD PROVE THAT I ONLY PUT DIESEL FUEL IN SO HAD TO PROVIDE RECEIPTS FOR MY RECENT FUEL PURCHASES AS WELL AS FUEL SAMPLES. STILL WAITING FOR THE WARRANTY COMPANY TO DECIDE WHETHER OR NOT THEY WILL COVER THE REPAIR SO I AM WITHOUT A VEHICLE WHILE THEY HAGGLE. LUCKILY I WAS ALMOST STOPPED WHEN IT HAPPENED OR IT COULD HAVE BEEN A BIGGER SAFETY ISSUE (ALTHOUGH I WAS IN A CAR IN A BUSY INTERSECTION CAUSING A MAJOR TRAFFIC JAM WITH MANY POTENTIAL CRASHES ALL AROUND ME -- THE HONKING HORNS AND SWERVING CARS ATTEST TO THAT -- AS I SAT WAITING TO BE PUSHED OUT OF THE WAY). *TR

TDI DIESEL ENGINE. ENTERED HIGHWAY, CAR STUTTERED, ENGINE DIED, DISPLAYED WORKSHOP CODE PROBLEM, GLOWPLUG LIGHT FLASHING. RESTARTED ONE TIME, TRAVELED TO PARKING AREA, ENGINE DIED AND WOULD NOT RESTART. CODE WAS P0087, FUEL PUMP PRESSURE FAILURE. NO PREVIOUS PROBLEMS OR HINTS OF THIS ISSUE. SUDDEN ENGINE FAILURE. VERY DANGEROUS, WAS DRIVING UPHILL, THE ONE RESTART ALLOWED ME TO LEAVE ROAD. DEALER NOTED NO FUEL CONTAMINATION. SYSTEM WAS PROPERLY PRIMED ON FUEL FILTER CHANGES. USED A ROSS-TECH CABLE AND SOFTWARE. REPAIR IS EXPECTED TO BE ABOUT $7000.00. PREVIOUS DIESEL 2001 MODEL WAS STILL RUNNING WITH 332,000 MILES WHEN THIS ONE WAS PURCHASED. TDICLUB.COM WEBSITE HAS NOTED MANY OF THESE FAILURES, SEARCH HPFP, HIGH PRESSURE FUEL PUMP. VW IS NOT FURNISHING PUMPS DESIGNED WITH THE US DIESEL FUEL QUALITY IN MIND. VW NEEDS TO CORRECT THIS PROBLEM, THERE HAVE BEEN A LOT OF THESE FAILURES. *TR

I WAS ON THE EXIT RAMP OF THE INTERSTATE AND THE GO TO WORKSHOP WARNING CAME ON ALONG WITH THE GLOW PLUG WARNING LIGHT. VEHICLE LOST POWER, I WAS ABLE TO GET TO A SIDE STREET AND TURNED OFF VEHICLE, IT RESTARTED AND SEEMED FINE DROVE ABOUT 2 MILES AND STOPPED FOR A LIGHT, CAR STALLED AND WARNING LIGHTS CAME BACK ON. CAR DID NOT RESTART HAD PUSH TO SIDE OF ROAD AND TOW HOME. TOWED TO DEALER FIRST OF WEEK. FOUND TO BE HIGH PRESSURE FUEL PUMP FAILURE OF THE DIESEL ENGINE. THIS IS THE SECOND ONE TO GO BAD FIRST ONE AT 135380 MILES AND NOW AT 228605 MILES ONLY 93225 MILES ON REPAIR JOB. VW REPAIRED THE FIRST ONE, REPLACED ENTIRE FUEL SYSTEM AT NO CHARGE, DO TO FAULTY HPFP. EVEN THOUGH THIS PUMP HAS LESS MILES THEY WILL NOT HELP WITH REPAIR COST. BOTH TIMES CAR DIED AT A MAJOR INTERSECTION AND HAD TO BE PUSHED TO SIDE OF ROAD. *TR

I WAS STOPPED AT A TRAFFIC LIGHT ON A BUSY STREET WHEN MY JETTA TDI SPORT WAGON MADE A LOUD RUMBLING NOISE AND STALLED. IT WOULD NOT RESTART AND WAS TOWED TO THE DEALER. THE DEALER FOUND METAL SHAVINGS IN THE FUEL SYSTEM AND SUGGESTED THIS WAS DUE TO GAS CONTAMINATION OF THE DIESEL FUEL SINCE I HAD JUST FUELED MY CAR. HOWEVER THE DIESEL FUEL WAS NOT CONTAMINATED WITH GAS AND THE DEALER REPLACED THE ENTIRE FUEL SYSTEM, BLAMING THIS ON A PUMP FAILURE. I'M GLAD IT DID NOT HAPPEN 15 MIN EARLIER WHEN I WAS TRAVELING 55MPH. *TR

WHILE DRIVING THE DASH WARNING LIGHTS ILLUMINATED AND THE CAR STALLED CAUSING COMPLETE LOSS OF ALL POWER STEERING ALMOST CAUSING ME TO LOSE CONTROL AND WRECK. I WAS ABLE TO STEER CAR TO SIDE OF ROAD AND STOP. ONCE STOPPED WAS ABLE TO GET CAR TO RESTART BUT WAS BARELY ABLE TO DRIVE HOME (PERIODICALLY DIED AND HAD TO RESTART, WOULDN'T STAY RUNNING OR IDLE). HAD CAR TOWED TO REPAIR SHOP. THEY HAVE DIAGNOSED PROBLEM AS LOW RAIL FUEL PRESSURE CAUSED BY FAILED HIGH PRESSURE FUEL PUMP. THIS FAILURE CAUSED METAL SHAVINGS TO BE DISPERSED THROUGHOUT ENTIRE FUEL SYSTEM. I'M TOLD THAT THE HP FUEL PUMP, LOW AND HIGH PRESSURE FUEL REGULATORS, AND TANK FUEL PUMP ALL MUST BE REPLACED ALONG WITH A COMPLETE REMOVAL AND CLEANING OF ALL FUEL SYSTEM COMPONENTS. ESTIMATED COST TO REPAIR IS BETWEEN $7,000 AND $10,000. THIS CAR IS A DIESEL TDI. *TR

THIS IS A 2009 VW JETTA, TDI PURCHASED NEW. DRIVING AT APPROXIMATELY 65 MPH, THE POWER STEERING LIGHT CAME ON AND THE VEHICLE, IMMEDIATELY HAD NO FUNCTIONING POWER STEERING. STEERING WHEEL WAS EXTREMELY DIFFICULT TO TURN. VEHICLE HAD TO BE TOWED IN. SERVICE REPLACED SEVERAL PARTS AMONG THEM STEERING ASSEMBLY AND HARNESS (PART NO.'S 1K1-423-055MX AND 1K1-971-111AJ RESPECTIVELY). *TR

THIS IS MY SECOND COMPLAINT ON THIS WEBSITE FOR THE SAME PROBLEM WITH MY 2009 JETTA SPORTWAGEN WITH DSG TRANSMISSION. MY MECHATRONIC UNIT WAS REPLACED IN JULY 2012, BUT IT WASN'T 2 WEEKS BEFORE THE CAR STARTED BACK TO IT'S OLD TRICKS AGAIN. THIS TIME THE HESITATING FROM A STOP, JERKING, ROLLING BACK AND FORTH WHEN YOU PARK, AND ROLLING BACKWARD ON AN INCLINE WHEN SHIFTING INTO DRIVE FROM REVERSE WAS EVEN WORSE THAN BEFORE THE MECHATRONIC UNIT REPLACED. THIS MORNING, WHILE BACKING OUT OF THE GARAGE (WHICH IS ON A SLOPE) WHEN I SHIFTED INTO DRIVE AND LIFTED OFF THE BRAKE THE CAR QUICKLY ROLLED BACK 2 TO 3 FEET BEFORE I COULD STOP THE CAR WHILE NARROWLY MISSING OUR TRUCK'S BUMPER. WE WENT STRAIGHT TO VW AND AS BEFORE THEIR IS NO CODE AND THE FLUID IS AT APPROPRIATE LEVELS. THERE IS NOTHING THEY CAN DO... VW CUSTOMER CARE WAS CONTACTED WITH ANOTHER CASE NUMBER. IT APPEARS THAT VW IS NOT STANDING BEHIND THEIR WARRANTY, SO I GUESS WE'LL HAVE TO ESCALATE TO THE NEXT LEVEL. *TR

VEHICLE DOWN SHIFTS HARD WHEN COMING TO A STOP AND SEEMS TO HAVE DELAYED SHIFTS WHEN ACCELERATOR IS PRESSED. VERY UNSAFE DUE JERKING MOTION WHEN TRYING TO STOP OR START. *TR

CAR FLASHED ENGINE MALFUNCTION, DIED SOON AFTER, WILL NOT START UP AGAIN. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE MALFUNCTION ENGINE WARNING LIGHT FLASHED ON THE DASHBOARD AS THE VEHICLE STALLED. THE CONTACT WAS ABLE TO MOVE THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT TOWED THE VEHICLE TO A DEALER. THE DEALER STATED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE REPLACED DUE TO METAL FLAKES ENTERING THE FUEL SYSTEM WHEN THE FUEL PUMP MALFUNCTIONED. THE FAILURE MILEAGE WAS 115,986. UPDATED 11/14/12*LJ UPDATED 11/15/12

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH THE VEHICLE STALLED. THE DRIVER WAS ABLE TO MERGE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE FUEL SYSTEM HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 90,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE STEERING WHEEL COVER SLIP IN THE AIR BAG HORN AREA WAS DEFECTIVE AND THE CONTACT WAS CONCERNED THAT THE AIR BAG WOULD ERRONEOUSLY DEPLOY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 71,000. UPDATED 08/27/13*LJ THE STEERING AIR BAG COVER ALSO SERVED AS THE HORN CONTACT AREA I.E. THE CONSUMER HAD TO PRESS THE AIR BAG COVER TO ACTIVATE THE HORN. THE STEERING WHEEL AIR BAG COVER WAS SPLITTING IN MULTIPLE AREAS DUE TO HORN USAGE I.E PRESSING ON THE COVER TO ACTIVATE THE HORN. THE STEERING WHEEL AIR BAG COVER SHOULD WITHSTAND A LIFETIME OF USE WITHOUT FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE, BUT THEY REFUSED TO REPLACE THE STEERING WHEEL AIRBAG WHICH INCLUDED THE COVER. UPDATED 08/29/13 UPDATED 09/24/13

ON SEPTEMBER 26, 2012 WHILE TRAVELING IN ARKANSAS, EASTBOUND ON INTERSTATE 30, AT 75 MILES PER HOUR, MY 2009 VW JETTA SPORTS WAGEN TDI SUFFERED A HIGH PRESSURE FUEL PUMP FAILURE. I WAS TOLD BY THE LITTLE ROCK VW DEALERSHIP THAT I HAD CONTAMINATED FUEL. I FILED AN INSURANCE CLAIM. THE INSURANCE COMPANY HAD AN INDEPENDENT LAB DO AN ANALYSIS ON THE FUEL. THE INSURANCE COMPANY DENIED MY CLAIM BECAUSE THE FUEL WAS NOT CONTAMINATED. THE INSURANCE COMPANY INFORMED ME THAT THE NHTSA HAS REVIVED NUMEROUS COMPLAINTS ABOUT HIGH PRESSURE FUEL PUMP FAILURES ON VOLKSWAGEN TDI ENGINES. I WANT TO ADD MY VEHICLE TO THAT LIST WITH AN INDEPENDENT LAB ANALYSIS STATING THAT THE FUEL WAS NOT CONTAMINATED. IT IS DEFINITELY A SAFETY HAZARD WHEN YOUR VEHICLE STOPS ON A CONGESTED HIGHWAY. ADDITIONALLY, WITH REPAIR BILLS FOR THIS FAILURE RANGING FROM $6,000 TO $10,000 THE NHTSA SHOULD REQUIRE VW TO RECALL THEIR VEHICLES WITH THE TDI ENGINES. *TR

TRAVELING ON INTERSTATE 10 FROM TALLAHASSEE, THE CAR ENGINE SUDDENLY STOPPED RUNNING. AFTER DRIFTING ONTO THE SHOULDER THE ENGINE LIGHT WAS ON AND THE GLOW PLUG LIGHT WAS ON. THERE WERE NO INDICATIONS OF ANY PROBLEM PRIOR TO THE ENGINE STOPPING. NO INDICATOR LIGHTS CAME ON, NO SPUTTERING, NO LOSS OF POWER ETC. AFTER MANY ATTEMPTS TO RESTART WITH NO SUCCESS, IT WAS TOWED INTO MARION FLORIDA. THEY COULD NOT TELL WHAT WAS WRONG AND I HAD TO HAVE IT TOWED TO THE CLOSEST DEALER IN VALOUSA GA. THERE THEY FOUND METAL PIECES IN THE FUEL FILTER AND SAID THIS WAS GOING TO BE A MAJOR REPAIR. PLEASE CONTACT ME IF YOU NEED MORE INFORMATION ABOUT THIS INCIDENT. *TR

WHILE DRIVING DOWN THE ROAD, MY WARNING LIGHT FLASHED A COIL SYMBOL, PULLED THE CAR TO THE SIDE OF THE ROAD AND LOOKED UP THE PROBLEM IN THE MANUAL. BLINKING COIL INDICATED 'DRIVE TO LOCAL SERVICE' SO I TRIED TO CRANK THE CAR, WHICH STARTED. BEGAN TO DRIVE, BUT AS I APPROACHED A HILL AND INTERSECTION THE VEHICLE BECAME SLUGGISH AND SLOW. UPON BRAKING AT INTERSECTION, THE VEHICLE SHUT OFF. I WAS IN THE CAR WITH THREE OF MY FOUR CHILDREN, THE OLDEST IS 17 AND HAS A DL, SO I PUT HER IN THE DRIVERS SEAT AND MY 12 YEAR OLD AND I PUSHED THE CAR OUT OF THE INTERSECTION TO AVOID COLLISION. CALLED DEALERSHIP, THEY SAID TOW IT IN, AND I HAVE EXTENDED WARRANTY TO COVER DEFECTS. THE NEXT DAY I AM TOLD THAT THERE IS BAD FUEL, NOT GASOLINE BUT SWEET SMELLING DIESEL.( SC IS RUNNING CARS ON BIODIESEL WHICH HAS A SWEETER SMELL), WARRANTY COMPANY SENDING INSPECTOR. HIS REPORT SAYS HE SMELLED GASOLINE, BUT TECH SAYS IMPOSSIBLE AS THE VEHICLE WOULD NEVER HAVE GONE 450 MILES ON GASOLINE BEFORE THIS MALFUNCTION. WE FEEL THAT VW IS TRYING TO HIDE THE PROBLEM UNDER THE GAS COMPANIES AND AVOID MAJOR COST. STARING AT $8000 REPAIR BILL FOR A CAR NOW WORTH $12K. WE CANNOT AFFORD THIS KIND OF EXPENSE AS I AM SURE MOST CONSUMERS IN AMERICA WOULD CONCEDE. WE HAVE READ AND DOCUMENTED MANY CASES WHERE VW HAS REPAIRED THIS PROBLEM IN OR OUT OF WARRANTY BECAUSE OF THE DEFECTIVE PART. FEEL THAT THIS IS JUST NOW AN ISSUE WITH THE FUEL, THEY KNEW THE STANDARDS FOR HIGHWAY DIESEL WHEN THEY PUT THE PART IN THE CAR, SHOULDN'T HAVE SOLD IT IF IT WOULD NOT STAND UP TO THE PRESSURE. WILL NOT ACCEPT THIS AS OUR FAULT. CANNOT ACCEPT THIS AS OUR FAULT. *TR

VEHICLE STALLED AND WOULD NOT RESTART WHILE WAITING IN THE LEFT TURN LANE OF EUCLID AVE IN BAY CITY, MICHIGAN. VEHICLE WAS TOWED TO THELEN VW SERVICE 0.5 MILES AWAY. I WAS ALLOWED TO REMOVE PERSONAL ITEMS WHILE TECH WAS INVESTIGATING. HE SHOWED ME THE FILTER AND THERE WAS A LITTLE BIT OF METAL SHAVINGS. HE THEN OPENED A PORT ON THE PUMP AND FOUND A LOT OF METAL SHAVINGS. THE TECH THEN SAID THE PUMP FAILED AND THE ENTIRE FUEL SYSTEM WOULD NEED TO BE REPLACED. THE SERVICE REP SAID HE WOULD TALK TO VW TO SEE WHAT NEEDS TO BE DONE NEXT. THIS INFORMATION IS ALL I KNOW AS OF THE END OF THE DAY ON 9/18/2012. *TR

VEHICLE ENGINE STOPPED COMPLETELY DEAD AND WAS NEARLY REARENDED . WAS NOT ABLE TO RESTART VEHICLE AND WAS TOWED BACK TO VOLKSWAGEN DEALERSHIP. VOLKSWAGEN TOLD ME THE HIGH PRESSURE FUEL PUMP WAS BAD AND REPAIR WOULD COST $10,000.00 AFTER A FURIOUS ARGUMENT WAS TOLD THEY WOULD FIX IT. THIS PROBLEM HAS HAPPENED TO MANY VEHICLES THAT HAVE NOT REPORTED IT TO NHTSA WHEN ARE YOU GOING TO PUT A STOP TO THIS MAJOR PROBLEM. MAYBE WHEN SOMEONE GETS KILLED *JS

I HAD JUST LEFT MY VW DEALERSHIP IT HAVE AN UNRELATED ISSUES LOOKED AT, I HAD A SERVICE THAT WED. I PULLED OUT OF THE DEALERSHIP DROVE ABOUT A MILE AND MY CAR FLASHED SO KIND OF WARNING. I TURNED AROUND TO GO BACK TO THE DEALERSHIP AND IT DIED. I WAS LESS THAN A MILE AWAY FROM GETTING ON THE INTERSTATE WHERE I WOULD HAVE BEEN TRAVELING AT 70 MPH. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH LOCATED THE FAILURE WITHIN THE EXHAUST CONTROL MODULE. THE DEALER REPLACED THE EXHAUST MODULE UNDER THE WARRANTY; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE EXHAUST SYSTEM CONTROL MODULE FAILED AGAIN. A SECOND DIAGNOSTIC TEST WAS PERFORMED BY A LOCAL MECHANIC WHICH LOCATED THE FAILURE IN THE EXHAUST SENSOR WHICH MADE IT IMPOSSIBLE FOR THE EXHAUST EMISSION GATE TO OPEN OR CLOSE. THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS REPAIRED AND THE EXHAUST FLAP DOOR WAS LUBRICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 110,000.

VEHICLE BEGAN STALLING AT STOPS AT ABOUT 55000 MILES. VEHICLE AT COMPLETE STOP, TAKE FOOT OF BRAKE AND IT EITHER (1) ROLLS THEN MOVES FORWARD, (2) LURCHES/SHUTTERS AND MOVES FORWARD OR (3) STALLS BEFORE PUTTING FOOT ON GAS. THE STALLING HAS BECOME MORE FREQUENT IN THE LAST MONTH AND ON MAY 31 2013, THE VEHICLE STALLED MULTIPLE TIMES AND ON ONE OCCASION DID NOT RESTART AFTER APPROXIMATELY HALF DOZEN ATTEMPTS BUT FINALLY MANAGED TO RESTART. THE VEHICLE IS GOING IN FOR SERVICE TO HOPEFULLY IDENTIFY AND FIX THIS ISSUE ON JUNE 3 2013. THE LURCHING FORWARD CAN BE DRASTIC AND THE POTENTIAL FOR "JUMPING" FORWARD INTO ANOTHER CAR AND CAUSING AN ACCIDENT IS NOW A REAL CONCERN. *TR

2009 JETTA VOLKSWAGEN TDI, WITH ONLY 50500 MILES ON IT. THE CAR DIED IN THE MIDDLE OF INTERSECTION AT 35MPH. THIS WAS DURING RUSH HOUR TRAFFIC. IN THE CAR WAS ME 32, MY WIFE 36, MY DAUGHTER OF 8 YEARS OLD AND SON OF 2 YEARS OLD. IT WAS A VERY SCARY EVENT. I HAD IT TOWED TO THE NEAREST VW DEALERSHIP. IT TOOK THEM 3 DAYS TO LOOK AT THIS CAR AND AFTER I CALLED 15 TIMES, THEY TOLD ME THAT THIS FUEL PUMP HAD BEEN SLOWLY BREAKING DOWN INSIDE THE FUEL TANK, RUNNING THROUGH THE LINES AND INTO THE INJECTORS. THEY HAVE TOLD MY THIS COULD BE EXTREMELY EXPENSIVE. I HAVE ALWAYS USED CLEAN DIESEL, AND FILLED UP AT NEW GAS STATIONS. THIS WAS JUST TODAY I SPOKE WITH THEM, AND I HAVE DONE SOME RESEARCHING AND FOUND THIS TO BE CALLED HPFP ISSUE. FROM AS MANY CASES I HAVE SEEN POSTED ON THE INTERNET, THIS SHOULD DEFINITELY BE A RECALL. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE SUDDENLY STALLED AND AN ENGINE MALFUNCTION MESSAGE DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP BROKE APART INTERNALLY AND THE METAL SHAVINGS FROM THE FUEL PUMP WERE FOUND THROUGHOUT THE FUEL SYSTEM. AS A RESULT, ALL FUEL RELATED COMPONENTS NEEDED TO BE REPLACED. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11003 (FUEL SYSTEM, DIESEL) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

WE WERE DRIVING ON A TWO LANE HIGHWAY. THE CRUISE CONTROL WAS SET. OUT OF NOWHERE THE CAR JUST QUIT. THE GAUGES WENT TO ZERO. THE CAR DIDN'T HAVE POWER. WE COASTED UNTIL WE FOUND A CLEARING WHERE WE COULD PULL OFF THE ROAD. WE WERE ABLE TO APPLY THE BRAKES TO COME TO A COMPLETE STOP. WE WERE VERY LUCKY WE WERE ABLE TO COAST FAR ENOUGH TO FIND A SPOT TO PULL OFF. THERE WAS NOT AN EMERGENCY LANE ON THE ROAD. THE CLOSEST TOWN WAS 18 MILES AWAY. WE PUT THE CAR IN PARK AND TRIED TO START IT WITHOUT ANY LUCK. AFTER AWHILE IT DID TURN BACK ON AND WE WERE ABLE TO DRIVE TO THE DEALERSHIP. *TR

STARTED MY CAR FOR THE SECOND TIME THAT DAY, NOTHING OUT OF THE ORDINARY. ABOUT A MILE AWAY I EXPERIENCED THE CAR SHUTTING DOWN. I DOWNSHIFTED INTO SECOND, TURNED BACK ON BUT WHEN I GAVE IT GAS IT SPUTTERED. I WAS ON THE SIDE OF THE ROAD FOR 1.5HRS WAITING FOR TOW TRUCK. MECHANICS COMPUTER DESCRIBES THE PROBLEM AS LOW FUEL PRESSURE. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER, WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE AND THE CURRENT MILEAGE WAS 87,000.

ENGINE WARNING LIGHT GOES ON, CAR SHUTS DOWN. DEALER SAYS IT IS THE EMISSION FLAPPER ON THE EXHAUST SYSTEM AND A NEW ONE COSTS $918 DOLLARS. VW CUSTOMER SERVICE CAN'T AND WILL NOT DO A THING ABOUT IT. THE DEALER KEEPS A STOCK ON THIS EXHAUST FLAPPER AND COULD DO THE JOB RIGHT AWAY. VW KNOWS THE PROBLEM IS OUT THERE , AND RIGHT NOW IT PROVES TO BE A PROFITABLE ONE FOR THEM. *TR

THIS IS THE TDI MODEL. GLOW PLUG LIGHT CAME ON. THEN CAR LOST POWER, AND ENGINE WARNING LIGHT CAME ON. CAR DIED ON EXIT RAMP AND WOULDN'T RESTART. HIGH PRESSURE FUEL PUMP DIED SENDING METAL SHARDS THOUGHOUT SYSTEM. *TR

I WAS DRIVING MY 2009 VW JETTA TDI ON I-81 N. NEAR THE WYTHEVILLE EXIT MY ENGINE MALFUNCTION LIGHT CAME ON. THE CAR IMMEDIATELY BEGAN TO LOSE SPED AND POWER. I WAS ABLE TO COAST UP THE EXIT RAMP AND INTO THE EXXON STATION. I TURNED OFF THE CAR. THE CAR WOULD NOT RESTART. THERE WERE NO VW DEALERS WITHIN 80 MILES SO I HAD IT TOWED TO A CHRISTIANSBURG, VA SHOP THAT WORKS ON VW'S. ITS NAME IS CAR FORCE. THEY SAID IT WAS THE FUEL LOAD LIFT. THEY PUT IN THE PART AND IN STILL WOULD NOT START. AFTER FURTHER INVESTIGATION IT WAS FOUND THAT EVERYTHING, INCLUDING THE FUEL PUMP, WAS DAMAGED. I HAD IT TOWED ANOTHER 40 MILES TO ROANOKE, VA. THE COST TO REPAIR IS $7,000 - $10,000. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE BUT IT WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THE FUEL SYSTEM WOULD HAVE TO BE REPLACED BECAUSE IT BECAME CONTAMINATED BY THE FUEL PUMP. THERE WAS AN INVESTIGATION UNDER NHTSA ACTION NUMBER: EA11003 (FUEL SYSTEM, DIESEL) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 114,000. UPDATED 09/18/12*LJ UPDATED 09/19/2012 *JS

2009 VOLKSWAGEN JETTA TDI. VEHICLE RAN OUT OF DIESEL FUEL, UPON FILLING WITH NEW FUEL VEHICLE FAILED TO START. VEHICLE WAS TOWED TO VOLKSWAGEN DEALER TO PERFORM REPAIRS. DEALERSHIP INFORMED ME THE FUEL INJECTION PUMP WENT OUT AND THE ENTIRE FUEL SYSTEM NEEDED REPLACEMENT AT A TOTAL COST OF $8600.00. DUE TO THE FUEL INJECTOR PUMP GOING OUT CAUSED METAL SHAVINGS TO ENTER THE ENTIRE FUEL SYSTEM AND ALLEGEDLY REQUIRING A COMPLETE SYSTEM REPLACEMENT. SIMPLY BECAUSE THE VEHICLE RAN OUT OF FUEL. PEOPLE RUN OUT OF FUEL EVERY DAY AND ARE NOT PUT IN MY CURRENT SITUATION WITH MY VOLKSWAGEN. THIS MUST BE FAULTY ENGINEERING TO RESULT IN A COMPLETE FUEL SYSTEM REPLACEMENT FOR THE SOLE REASON OF RUNNING OUT OF DIESEL FUEL. WHAT I WAS TOLD BY THE DEALERSHIP O THE NECESSARY REPAIRS AND COSTS ARE ABSURD. ANY HELP IS APPRECIATED. THANK YOU. *TR

FELT A SHUDDER IN THE DRIVE TRAIN; A FEW SECONDS LATER THE GLOW PLUG LIGHT BEGAN TO FLASH; THE MULTI-FUNCTION COMPUTER FLASHED THAT THERE WAS AN ENGINE FAULT AND TO SERVICE THE ENGINE; THE ENGINE SHUTDOWN AND I PULLED OVER TO THE SIDE OF THE ROAD; ENGINE WOULD NOT RESTART; DEALER ANALYSIS REVEALED THE HIGH PRESSURE FUEL PUMP FAILED APPARENTLY SENDING SHARDS OF METAL PARTICLES DOWNSTREAM OF THE PUMP; PUMP AND OTHER HARDWARE DOWNSTREAM OF THE PUMP ARE SCHEDULED FOR REPLACEMENT *TR

LEFT SIDE HEADLIGHT, TURN SIGNAL AND TAIL LIGHT WENT OUT. I WENT TO THE DEALER TO HAVE IT FIXED AND THEN 3 WEEKS LATER THE RIGHT SIDE WENT OUT. CHANGED THE HEADLAMP AND NOTHING WAS FIXED. THE COMPLETE RIGHT SIDE LIGHTING OF THE CAR IS OUT. AT CERTAIN TIMES DURING THIS PERIOD IT WOULD START WORKING, THEN STOP. *TR

WHILE LEAVING A CONCERT, THE VEHICLE WAS FINE LEAVING THE PARKING LOT. ONCE WE INCREASED SPEEDS TO 45 MPH, THE ENGINE COMPLETELY SHUT DOWN. THE DIALS ON THE DASHBOARD ALL FELL TO ZERO AND THE GAS PEDEL NO LONGER WORKED. WE COASTED INTO A SMALL CAMPGROUND AREA OFF TO THE SIDE OF THE ROAD. AFTER TRYING TO RESTART THE CAR THREE TIMES, IT FINALLY STARTED AND WE PROCEEDED TO GO DOWN THE ROAD, ONLY TO MAKE IT 500 MORE YARDS AND PULLED IN TO A HAY STACK PAD. AFTER NUMEROUS ATTEMPTS TO START WHILE SITTING ON THE PHONE WIHT OUR INSURANCE COMPANY, THE CAR STARTED ONCE AND DIED AFTER SITTING IDLE FOR THREE MINUTES. WE THEN ATTEMPTED TO START IT ONE LAST TIME AND DROVE 25 MPH TO THE NEAREST GAS STATION. WE ALL GOT OUT OF THE CAR, LOCKED IT UP THINKING IT MAY HAVE SOMETHING TO DO WITH AN ANTITHEFT FEATURE. WE GOT BACK IN THE CAR AND WERE ABLE TO DRIVE 41 MILES HOME AT HIWAY SPEEDS. THE FOLLOWING DAY WE DROVE 5 MILES INTO TOWN AND IT DIED AGAIN GOING 25 MPH. THE CLOSEST VOLKSWAGON IS ANOTHER 25 MILES AWAY. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. AS THE CONTACT MERGED THE VEHICLE TO THE SHOULDER, IT RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INSPECTED THE VEHICLE AND STATED THAT THE FAILURE WAS DUE TO A BLOWN TURBO. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE REPAIR WAS COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 73,800.

A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP LEFT MY WIFE WITHOUT POWER AS SHE WAS DRIVING IN TRAFFIC. THERE WAS NO PRECEDING INDICATION AND IN OTHER CIRCUMSTANCES COULD HAVE CAUSED A TRAFFIC ACCIDENT. WHEN THE HPFP FAILED, ALL NON-ELECTRICAL POWER FAILED WITH A POTENTIAL FOR SIGNIFICANT CONTROL AND BRAKING PROBLEMS. *TR

DRIVING AT LOW SPEED IN THE CITY, WHEN A ENGINE FAILURE WARNING DISPLAYED AND THE VEHICLE STARTED RUNNING ROUGH. TOOK IT TO THE DEALERSHIP AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP FAILED SENDING METAL SHARDS THROUGHOUT THE FUEL SYSTEM. THIS HAS APPARENTLY TRIGGERED REPLACEMENT OF THE ENTIRE FUEL SYSTEM FROM THE PUMP TO THE ENGINE. AFTER RESEARCHING THIS ONLINE, I HAVE FOUND THAT THIS IS A KNOWN ISSUE. TO MY KNOWLEDGE THE HPFP'S HAVE NOT BEEN RECALLED. VW AND YOUR WEBSITE SO FAR STATES THAT THE PROBLEM IS A FUEL CONTAMINATION ISSUE, BUT I HAVE ONLY BOUGHT DIESEL FROM MURPHY USA I CONFIRMED THIS WITH RECEIPTS. ( A HIGH VOLUME DEALER IN MY AREA). THE DEALERSHIP STATES THAT THE REPAIR SHOULD BE COVERED EVEN THOUGH THE WARRANTY HAS EXPIRED. THIS IS SUSPECT TO ME. EITHER OUR FUEL STANDARDS ARE NOT PAR WITH THE REST OF THE WORLD AND NEED FURTHER REGULATION OR THE PUMPS NEED TO BE RECALLED. BUT A CAR DESIGNED TO SAVE MONEY BY CONSERVING FUEL IS NOT DOING THAT IF THE 27000 DOLLAR CAR NEEDS 10000 DOLLARS OF WORK. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 45 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE HIGH PRESSURE DIESEL FUEL PUMP FAILED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS TRADED DUE TO THE DEFECT. THE FAILURE AND CURRENT MILEAGES WERE 111,000.