Volkswagen · Passat · 2002
4
Recalls
643
Complaints
-
Not Rated
The 2002 Volkswagen Passat has 4 recalls and 643 owner-reported complaints on file with NHTSA. Most reported issue: electrical system (179 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2002 Volkswagen Passat page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is electrical system with 179 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Remedy Status
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Remedy Status
DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
CERTAIN SEDANS AND STATION WAGONS EQUIPPED WITH 4.0L W8 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE AFFECTED VEHICLES ARE EQUIPPED WITH TIRES OF THE MAXIMUM LOAD RATING INDEX 93H; HOWEVER, THEY SHOULD HAVE BEEN EQUIPPED WITH TIRES WITH THE LOAD RATING INDEX 97H.
Remedy Status
DEALERS WILL REPLACE ALL FOUR TIRES WITH THE PROPER SIZE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VW AT 1-800-822-8987.
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
Remedy Status
DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
To Whom It May Concern, I am submitting this letter as a formal complaint regarding an authorized automobile dealer’s refusal to perform an open safety recall on my vehicle. Vehicle information: * Year/Make/Model: 2002 Volkswagen Passat 1.8T GLS * VIN: [XXX] I contacted Plati...
Preview excerpt
I was letting my car run for a couple of minutes for the AC to cool down the car and I went into my house. When I came out about 2 minutes later, there was a large puddle of gas under the car in front of the right rear wheel and gas was running down the driveway all the way to t...
Preview excerpt
WHILE DRIVING INTO THE MALL PARKING LOT AT SPEED OF 20 MPH ALL AIRBAGS EXPLODED EXCEPT THE STEERING WHEEL AIRBAG AND MY DAUGHTER SUFFERED FROM ARM AND AIR INJURIES
WHEN IT RAINS THE CAR GETS FLOODED CAUSING THE WHOLE WIRING SYSTEM THROUGH THE CAR TO GET DAMAGE. THE CAR WILL SUDDENLY LOSE POWER AND DIE AS YOUR DRIVING. SEEMS TO HAPPEN. WHEN ON HIGHWAY MOST. THE CAR WILL NOT START OR CRANK. I'VE HAD TO VACUUM THE FLOOR BOARDS AND TRUNK, SEARC...
Preview excerpt
THE ABS LIGHT CAME ON AND BRAKE LIGHT IS FLASHING RED. THE ABS MODULE SEEMS TO BE BAD. THE VEHICLE HAS THESE LIGHTS WHEN ITS MOVING AND STATIONARY
FUEL LEAKING FROM FITTING ON TOP OF TANK NEAR FUEL LEVEL SENDING UNIT.
I GET AN AUDIO AND VISUAL ALERT ON MY DASH STATING TO 'STOP, BRAKE FAILURE' IT HAS OCCURRED MANY TIMES WHILE DRIVING, TURNING, AND PARKED WITH THE CAR ON. THE CAR'S BRAKES HAVE NEVER FAILED TO BRAKE APPROPRIATELY. I BROUGHT THE CAR INTO MY MECHANIC. THE OBD 2 SCAN SHOWS NO FA...
Preview excerpt
I PURCHASED A 2002 PASSAT W8 4-MOTION, HAVING ONLY 126,000 MILES ON THE ODOMETER, IN OCTOBER 2017 OFTEN AFTER REFUELING THE VEHICLE, I WOULD NOTICE THE FAINT SCENT OF GASOLINE. UPON INVESTIGATING WHERE THE GASOLINE SMELL WAS ORIGINATING, I FOUND IT HAD DEVELOPED A VERY LARGE FUEL...
Preview excerpt
ABS LIGHT IS ON
AIR BAG FAULT MESSAGE WHEN STARTING MY CAR EVERYTIME.
Showing 10 recent complaints from 643 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2002 Volkswagen models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2002 Volkswagen Passat has 4 recalls recorded by NHTSA.
NHTSA has received 643 owner-reported complaints for the 2002 Volkswagen Passat.
NHTSA has not published a safety rating for the 2002 Volkswagen Passat.
The most commonly reported complaint categories for the 2002 Volkswagen Passat are electrical system (179 reports), engine and engine cooling (109 reports), fuel system, gasoline (47 reports).
Yes. NHTSA has 4 recalls on record for the 2002 Volkswagen Passat. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.