2003 Volkswagen Passat Electrical System Problems

I PURCHASED A USED 2003 VW PASSAT FROM A PRIVATE DEALER DROVE THE CAR FIVE MONTHS AND THE TIMING BELT CAME OFF WHILE I WAS DRIVING. I ALMOST GOT INTO AN ACCIDENT BUT AVOIDED IT. THIS PARTICULAR VEHICLE AND ONES LIKE IT WAS RECALLED IN 3/7/2014 FOR ENGINE AND ENGINE COOLING ENGINE PROBLEMS THAT CAUSES THE TIMING BELT TO COME OFF WHILE DRIVING. RECALL: 14E007000 BECAUSE OF THE TIMING BELT FAILURE. I CONTACTED A VW DEALERSHIP AND THEY SAID THE RECALL DIDN'T APPLY TO MY CAR. I FIND THAT INSULTING CONSIDER ING WHAT I JUST EXPERIENCED.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THE VEHICLE WAS PREVIOUSLY INCLUDED IN A RECALL THAT CALLED FOR THE IGNITION COIL TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION COIL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. DUE TO THE FACT THE VEHICLE WAS PREVIOUSLY REPAIRED PER THE RECALL, THE MANUFACTURER WAS NOT ABLE TO ASSIST. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 144,604.

MY FRONT DRIVER SEAT WARMER WAS TURNED ON LOW. I COULD FEEL THE SEAT GETTING WARMER AND CHECKED TO BE SURE THE SETTING WAS NOT ON HIGH WHICH IT WASN'T. I THOUGHT MAYBE I WAS BEING SENSITIVE AND STUCK MY MITTEN UNDER MY THIGH. I THEN NOTICED A FUNNY SMELL AND SUDDENLY THINGS GOT VERY HOT AND STARTED TO BURN MY LEG AS I WAS DRIVING. I LOOKED DOWN AND ACTUALLY STARTED TO SEE SMOKE. I WAS NOT ABLE TO JUST PULL OVER BUT QUICKLY TURNED THE SEAT OFF. I PULLED OUT MY MITTEN AND FLEECE WAS ACTUALLY MELTED. I WAS A BLOCK OR TWO FROM WORK AND TRIED TO KEEP FROM SITTING COMPLETELY DOWN AS IT BURNED. I ARRIVED AND JUMPED OUT TO SEE A BLACKENED AREA AND HOLE IN MY SEAT!! THE CAR WAS SMELLING AND I AM STILL IN SHOCK OVER THIS. I HAVE LOOKED AND CAN'T FIND A RECALL ON THE SEAT. THIS IS VERY DISTURBING AND DANGEROUS. THIS SHOULD NOT HAPPEN NO MATTER HOW OLD THE CAR IS.

DRIVING AT NIGHT, 65MPH, INTERSTATE HWY. LOW BEAM HEADLIGHTS WENT OUT. HIGH BEAMS DID WORK. REPLACED BOTH HEADLIGHT BULBS. DID NOT FIX. COST $95. REPLACE HEADLIGHT RELAY. DID NOT FIX. COST IN EXCESS OF $200. RECALL FOR LATER YEAR PASSAT FOR SAME PROBLEM CAUSED BY "HOOD SLAM?"

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE DRIVING AT VARIOUS SPEEDS. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO PERFORMED DIAGNOSTIC TESTING. THE ENGINE OXYGEN SENSOR, COIL SPRING, SPARKS PLUGS, AND WIRES WERE REPLACED; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE CONTACT STATED THAT THE TAIL LIGHTS ALSO FAILED. THE TAIL LIGHTS WERE NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 130,000.

ABS MODULE FAILURE, ABS LIGHT ON BRAKE LIGHT BLINKING AND THEN ASR LIGHT ON, HAPPENS RANDOMLY, NO SPECIFIC REASON, DRY WEATHER, HUMID, DAY OR NIGHT. STILL COMES ON RANDOMLY, NO SPEEDING, PROBLEM GOES AWAY WHEN CAR IS TURNED OFF. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT IT TOOK MULTIPLE ATTEMPTS FOR THE VEHICLE TO BECOME OPERABLE EVEN WHEN THE STARTER WAS ENGAGED. THE VEHICLE ALSO EXPERIENCED AN INTERIOR WATER LEAK AND THE DRIVER SIDE DOOR LATCH WOULD NOT PROPERLY LATCH. IN ADDITION, THE VEHICLE EXPERIENCED A COMPLETE LOSS OF ENGINE POWER AND THE CHECK ENGINE, BRAKE, AND VARIOUS OTHER WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED AS A SOFTWARE FAILURE, AND THE IGNITION COIL SPRINGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE IGNITION COIL SPRINGS WERE REPLACE HOWEVER THE FAILURE RECURRED. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000.

THE TURN SIGNAL WOULD CONTINUE TO MAKE A CLICKING NOISE EVEN AFTER THE SIGNAL HAD BEEN SHUT OFF. THIS CONTINUED TO HAPPEN FOR SEVERAL MINUTES AND THEN SMOKE BEGAN TO RISE FROM BEHIND MY STEERING WHEEL WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. I BEGAN TO PULL OVER AT THE NEXT SAFE AREA AND BEFORE I COULD I NOTICED SMALL FLAMES COMING FROM THE SAME AREA WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. WHEN I TURNED OFF THE CAR THE SMOKE/FIRE SLOWLY SUBSIDED. I ENDED UP REMOVING THE TURN SIGNAL FUSE IN ORDER TO DRIVE TO A REPAIR SHOP. AFTER SOME RESEARCH THIS SEEMS TO BE A COMMON ISSUE WITH NO RECALLS ISSUED YET. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND POURING INSIDE THE VEHICLE. THE CONTACT FOUND WATER AND COOLANT LEAKING FROM THE DASHBOARD AND ONTO THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS ALSO OVERHEATING. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED FLAMES COMING FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE HOWEVER, THE CONTACT SUSTAINED BURNS TO HER LEGS DUE TO THE HOT LEAKING COOLANT. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE BLEW AND THE INSTRUMENT PANEL CLUSTER WAS DAMAGED. THE CONTACT WAS UNAWARE OF WHAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 174,256.

HEATED SEAT COILS OVERHEATED AND BURNT SEAT ON DRIVER SIDE. 1 YEAR AFTER RECALL WAS DONE BY [XXX] VW BROCKTON MA, THEY TOLD ME THE HEATERS IN THE SEAT ARE NO LONGER UNDER WARRANTY AND TOLD ME TO CALL VW USA WITH MY PROBLEM, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY 2003 VOLKSWAGAN PASSAT WAGON HAS ROOF/CHASSIS DRAINS THAT ARE BACKING UP INSIDE THE VEHICLE CAUSING THE VEHICLE ELECTRONICS TO SHORT OUT AND FAIL. MY REAR DOOR WILL NOT OPEN. THIS IS A SAFETY ISSUE. *TR

I PURCHASED A 2003 PASSAT 6 MONTHS AGO. I HAVE HAD NOTHING BUT TROUBLE FROM IT. IT IS JUST ONE THING AFTER ANOTHER. I HAVE HAD TO TAKE IT IN TO BE FIXED ABOUT SIX TIMES. I CAN'T EVEN REMEMBER EVERYTHING I HAVE HAD TO HAVE FIXED. I DO REMEMBER THE LAST THING THOUGH. IT WAS THE TAIL LIGHTS, THE TAIL LIGHT WOULD NOT GO OUT EVEN WHEN I HAD NO LIGHTS ON AND EVEN WHEN THE CAR WAS TURNED OFF. MY CAR IS IN THE SHOP AGAIN RIGHT NOW. IT HAS BEEN THERE SINCE MONDAY DECEMBER 27TH. IT IS A FOUR CYLINDER AND HAS BEEN RUNNING ON THREE. I FOUND OUT FOR THE FIRST TIME MONDAY THAT MY CAR HAS 5 RECALLS ON IT. I WAS NEVER NOTIFIED OF NONE OF THEM. AFTER LEAVING IT FOR ALL THE RECALLS TO BE FIXED, I HAD TO RENT A CAR FOR 30.00 TO GET HOME. NOW I HAVE NO WAY TO PICK UP MY CAR BECAUSE I HAD TO RETURN THE RENTAL CAR THE NEXT DAY BECAUSE I COULD NOT AFFORD TO PAY 30.00 PER DAY. I HAVE NOBODY TO TAKE ME TO PICK UP MY CAR, I GUESS I WILL HAVE TO TAKE A TAXI AND THAT WILL PROBABLY COST ME ABOUT 50.00. I AM VERY UPSET WITH VW I PAID MY HARD EARNED MONEY FOR A RELIABLE CAR AND NOW I AM STUCK WITH NOTHING BUT A LEMON, SOMETHING NEEDS TO BE DONE ABOUT THIS. I HAVE NO WAY TO GO ANYWHERE, WHAT AM I SUPPOSED TO DO? *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE MALFUNCTION INDICATOR WARNING LIGHT ILLUMINATED INTERMITTENTLY, CAUSING THE VEHICLE TO SHAKE EXCESSIVELY. THE DEALER MADE SIX ATTEMPTS TO DIAGNOSE THE FAILURE BUT TO NO AVAIL. THE MANUFACTURER WAS NOTIFIED WHO CONTACTED THE LOCAL DEALER BUT OFFERED NO ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 91,252 AND THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.

VW 2003 PASSAT AWD 2.8 L V6 GASOLINE ENGINE...WIFE CALLED ME SAID CAR WAS MISS FIRING BADLY AND THEN SMOKE WAS REPORTED COMING FROM UNDERNEATH CAR. SHE PULLED OVER AND SAW FLAMES COMING FROM UNDERNEATH THE CAR. TURNED CAR OFF AND FIRE LUCKILY WENT OUT...I CHANGED COIL AND PROBLEM WAS FIXED FOR ABOUT THREE MONTHS. NOW CAR IS MISS FIRING AGAIN AND RUNNING ROUGH....I HATE THAT I'VE FIXED THIS SAME COIL THREE TIMES NOW AND IT IS ACTING UP AGAIN... *TR

ON APRIL 20, 2010 MY 2003 VOLKSWAGEN PASSATS CHECK ENGINE LIGHT CAME ON AT AROUND 4:45 PM. I IMMEDIATELY CALLED THE PLACE WHO DOES ALL MY REPAIR WORK, AND WAS TOLD I COULD DROP OFF THE CAR THAT NIGHT, AND THEY WOULD CHECK IT OUT THE FOLLOWING MORNING. I ARRIVED AT THE LOCATION AROUND 5:10, PARKED THE CAR AND WENT TO PLACE MY KEY IN THE NIGHT DROP BOX. WHEN I WALKED BACK TO THE CAR I SAW SMOKE COMING OUT FROM UNDER THE HOOD. I RAISED THE HOOD AND SAW FLAMES COMING FROM WHAT LOOKED LIKE UNDER THE BACK OF THE ENGINE COMPARTMENT. THEN I NOTICED THAT THERE WERE FLAMES COMING OUT FROM UNDER THE DASHBOARD INSIDE THE CAR. I CALLED 911 AND RAN TO A NEARBY GAS STATION TO GET A FIRE EXTINGUISHER. WHEN I GOT BACK TO THE CAR THERE WERE FLAMES VISIBLE INSIDE THE CAR. I USED THE ENTIRE FIRE EXTINGUISHER AND IT DID NOT EVEN PHASE THE FIRE. WITHIN 1 MINUTE THE ENTIRE CAR WAS ENGULFED IN FLAMES. THE FIRE DEPT. ARRIVED WITHIN 6 MINUTES AND THE CAR WAS GONE. *TR

WENT TO START MY CAR AND THE MALFUNCTION INDICATOR LAMP LIGHT WAS ON AND MY CAR WAS SHAKING UNCONTROLLABLY. I CALLED THE DEALERSHIP THEY HAD TOLD ME TO HAVE MY CAR TOWED IN. AS I DID, THE PROBLEM WAS THE IGNITION COILS, THEY DID MENTION THAT THERE WAS A RECALL ON THE 4 CYLINDERS AND THEY HAVE HAD SEVERAL PEOPLE COME IN WITH THIS PROBLEM AFTER THE ARTIC BLAST CAME THROUGH LAST WEEK. THE REASON WHY I'M WRITING IS BECAUSE I THINK ITS KIND OF WEIRD AFTER THIS RECALL CAME OUT SO MANY PEOPLE HAVE HAD THIS PROBLEM RECENTLY AND JUST WONDERING WHY THIS PARTICULAR PART IS NOT COVERED UNDER A RECALL FOR A V6. TO ME IT DOESN'T MAKE ANY SENSE WHY NOT, MY PROBLEM IS OCCURRING EXACTLY WHEN ALL THESE OTHER CARS ARE BEING RECALLED FOR THE SAME THING. *TR

POLLEN FILTER AND/ OR SUNROOF DRAINS BECOME BLOCKED AND WATER LEAKS BEHIND BATTERY AND INTO CABIN OF CAR. THE WATER THEN POOLS UNDER AND BEHIND THE DRIVERS SEAT WHERE THE CONVENIENCE MODULE IS STORED. I AM CONCERNED BECAUSE IT CAUSED MY CAR TO BE UNABLE TO START BECAUSE IT IS AFFECTING THE ELECTRICAL COMPONENTS OF THE CAR. IN ADDITION, THE POOLING UNDER THE DRIVERS SEAT IS TROUBLING SINCE IT IS A HUB FOR INTERIOR ELECTRICAL EQUIPMENT. THE CONVENIENCE MODULE IN MY CAR NOW HAS TO BE REPLACED. *TR

CYLINDERS MISFIRE CAUSING ACCELERATION HESITATION. SPARK PLUGS AND COIL WERE REPLACED FEB.2009, DEC. 2013, AUG. 2014, JUNE 2015. THE CONDITIONS ARE REPETITIVE AND IDENTICAL.

TL*THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE BEGAN TO SMOKE AND DRIVE SLUGGISH. SHE CONTINUED TO DRIVE TO HER DESTINATION AND THEN EXITED THE VEHICLE. APPROXIMATELY 20 MINUTES LATER, THE VEHICLE BEGAN TO SMOKE HEAVILY UNDERNEATH THE HOOD AND IN THE PASSENGER COMPARTMENT. THE VEHICLE CAUGHT FIRE FROM THE INSTRUMENT PANEL AND WAS COMPLETELY ENGULFED WITHIN MINUTES. THERE WERE NO INJURIES. A NEARBY VEHICLE SUSTAINED DAMAGE TO ITS PASSENGER SIDE. NHTSA CAMPAIGN ID NUMBER 08V156000 (FUEL SYSTEM, GASOLINE:DELIVERY) WAS REFERENCED. THE CURRENT AND FAILURE MILEAGES WERE 64,000.

IN 4/08 AND 5/08 HAD MALFUNCTION LIGHT INDICATOR COME ON, THEN HAD SEPARATE REPAIRS AT BAYSIDE VOLKSWAGEN. SAME LIGHT CAME ON 7/6/08. ITS SEEMS EVERY MONTH OR SO, ITS AN ISSUE WITH THE CAR AND HAVING DIFFERENT REPAIRS. *TR