BMW · X5 · 2004
4
Recalls
64
Complaints
-
Not Rated
The 2004 BMW X5 has 4 recalls and 64 owner-reported complaints on file with NHTSA. Most reported issue: power train (8 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 BMW X5 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is power train with 8 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
Remedy Status
DEALERS WILL REPROGRAM THE VEHICLE'S DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON SEPTEMBER 8, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
Remedy Status
DEALERS WILL INSPECT THE IN-TANK SUCTION JET PUMP FUEL LINE AND IF NECESSARY, REATTACH ACCORDING TO SPECIFICATIONS. THIS RECALL BEGAN SEPTEMBER 9, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
Remedy Status
DEALERS WILL INSTALL A NEW DIGITAL ENGINE MANAGEMENT CONTROL UNIT. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
Remedy Status
DEALERS WILL INSPECT AND RETIGHTEN THE DRIVETRAIN FASTENERS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
No start no crank sos light battery drain
Vehicle rpm’s rev wildly in park and neutral. When driving vehicle speeds up on its own and rpm’s climbs out of control. When stopped at a light or in traffic, car leaps forward against the break .
MY STEERING IS WAY TO TIGHT. AND ITS HARD TO MOVE THEVCAR.
FRONT PASSENGER SEAT BELT DOESN'T WORK PROPERLY. *TR
TL* THE CONTACT OWNS A 2004 BMW X5. WHILE DRIVING 55 MPH ON THE FREEWAY, THE VEHICLE JERKED SEVERELY. SUDDENLY, THE ENGINE POWERED DOWN IN THE MIDDLE OF TRAFFIC. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER SAFELY ONTO THE SHOULDER. A MESSAGE INDICATING "FAIL SAFE" APPEARED ON T...
Preview excerpt
I BOUGHT 4 RUN-FLAT BRIDGESTONE TIRES FROM A BMW DEALERSHIP: DUELER H/L 400 [36110427162] ON JUNE 21, 2017 WITH MY SUV MILEAGE OF 169,318. YESTERDAY, 1/15/2018, I FOUND OUT MY TWO REAR TIRES WERE ALMOST BALD AFTER DRIVEN 10,384 MILES DUE TO SUMMER ROAD TRIP. SEVERAL TIMES THESE ...
Preview excerpt
VEHICLE STARTED SMOKING FROM UNDER THE CAR AND AIR VENTS WHILE CAR WAS IN MOTION AIR CONDITIONING WAS RUNNING AND THE OWNER PULLED OVER AND THE FIRE DEPARTMENT PUT OUT THE FIRE AND BROKE 3 WINDOWS UNNECESSARILY IN THE PROCESS. CAR ENDED UP BEING TOTALED AND RESIDES AT OWNERS PROP...
Preview excerpt
TL* THE CONTACT OWNED A 2004 BMW X5. WHILE DRIVING 15 MPH, THE CONTACT'S VEHICLE WAS STRUCK BY ANOTHER VEHICLE ON THE DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT SHOULDER, BACK, AND NECK, WHICH REQUIRED MEDICA...
Preview excerpt
TL* THE CONTACT OWNS A 2004 BMW X5. WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE STALLED WITHOUT WARNING AND THE OIL SERVICE AND BATTERY INDICATORS ILLUMINATED. THE DEALER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILU...
Preview excerpt
HAVE ACCIDENT.BECAUSE MY BMW X5 2004 WHEN START THE ENGINE..THE CAR JUMP. AND PROBLEMS WITH TRASMISSION NOT WORK GOOD WHEN L STAR DRIVING THE CAR JUMP THE SPEEDS NOT WORK GOOD THE GEARS 2 MONTHS AGO L HIT .THE FRONT CAR .BECAUSE MY CAR JUMP .IN HAVE TO PAY .THE OWNER THE OTHER CA...
Preview excerpt
Showing 10 recent complaints from 64 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 BMW models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 BMW X5 has 4 recalls recorded by NHTSA.
NHTSA has received 64 owner-reported complaints for the 2004 BMW X5.
NHTSA has not published a safety rating for the 2004 BMW X5.
The most commonly reported complaint categories for the 2004 BMW X5 are power train (8 reports), seats (7 reports), air bags (5 reports).
Yes. NHTSA has 4 recalls on record for the 2004 BMW X5. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.