2019 Chevrolet Bolt EV Complaint Log

I have a 2019 Chevy Bolt EV, with a potential for the High Voltage Battery to catch on fire. There was a first recall back in Nov. 2020, Manufacture states that there was a final fix for the High Voltage Battery. I took the vehicle in for the final fix. Recently there was a 2019 Chevy Bolt that caught on fire with the final fix for the recall. Now there’s a second recall for the same issues, now I can NOT park my car inside the garage and not charge it at night, because of a potential for the vehicle to change on fire. I have 2 boys that lives about the garage and I live in a Townhouse. This recall is a safety problems for everyone, it poses a safety risk while the vehicle is charging. The vehicle is a safety hazards to the public and building structures.

After having the car's software "fixed" in May 2021 according to the previous recall instructions, we are informed that battery fires may occur in 2017-2019 Chevy Bolt EVs with defective battery packs manufactured in S Korea by LG Energy. Based on our VIN, GM informs us that the battery pack in our 2019 BoltEV was made by LG Energy and instructed us to limit charging and keep the battery within a limited charge range. In our living situation we cannot park the car outside as also advised by GM due to the battery fire hazard. Therefore, we now face severe limitations in owning and driving this car. 1. the danger of a car fire originating in the battery, endangering residents and common property in our condo building, including cars parked in neighboring spaces in the building's ground-floor garage, potentially leading to a condo association requirement that we park the car off-site, at considerable expense and inconvenience; 2. greatly reduced battery range: only 110-mile range instead of the advertised 238-mile range, greatly reducing the feasibility of longer-range travel in the car; 3. massively reduced resale value due to these issues, making it financially impossible for us to replace the car on our own; Due to the problems with this vehicle, we cannot drive or charge it as advertised, nor easily replace it. GM should either promptly replace the entire battery pack to entirely eliminate the chance of a battery fire from this defect or buy the vehicle back for a reasonable sum that compensates us for this grave disappointment and allows us to purchase a new BoltEV with minimal cost to us, the innocent consumers.

We own a 2019 Chevy Bolt affected by the July 23 recall. There have been 9 2019 Bolts that have caught fire. The 2019 Bolts with batteries made in Korea are significantly impacted. We find the level of risk associated with continuing to use the vehicle to be unacceptable. Fire departments need special training to put out EV battery fires. We have no idea if our small local fire department has this kind of training. The new guidelines are difficult and probably inadequate. Parking in the driveway leaves the car still too close to our house. The fires in other cars have occurred 3-6 hours after charging. Could the car catch fire after being driven in that 6 hour window after charging? Could it catch fire while parked near other cars? What if a child was waiting for a parent in that car? With charging to only 90% and not letting the battery drop below 30%, we are left with far less safely usable range than what we paid for when we bought this expensive vehicle. Too many times this week we have watched the range drop with a level of fear that is just not OK. GM already tried to use software to detect defects, and they admit that it failed. They won’t say how things will be different this time. They also won’t say how the replaced cells will work effectively with the older cells. So even after the remedy is applied, can we trust the integrity of the battery pack? GM has given no timeline for this remedy. We have been told loaners or rental vehicles will be offered by GM, we don’t have it in writing and the dealership we are working with seems unaware of this policy and/or unwilling to part with any of its loaners. And we’ve been told that GM will not reimburse until the loaner or rental period ends, leaving owners to front the cost. What about the owners who can’t do that? GM must replace all battery backs, provide vehicle replacements, or buy back the cars from affected owners.

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification for NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount for the recall repair. The dealer was contacted and informed the contact that no parts were available for the recall repair. The contact had not experienced a failure. The manufacturer was made aware of the issue however, no further assistance was taken. Vin tool confirms parts not available

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification for NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was not available. The contact had not experienced a failure. The manufacturer was not notified of the failure. VIN tool confirms parts not available.

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact was concerned that the vehicle may catch on fire in his senior townhome community. The dealer was made aware of the recall but informed the contact that they were not aware when parts would be available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified but no further assistance was provided. The contact had not experienced a failure. Parts distribution disconnect.

As a 2019 Bolt owner I am once again being asked by GM to limit my charging to 90%, do not charge unattended ( overnight while you sleep) , and do not park in the garage or carport. My family does not want to ride in my vehicle due to fire risks. Trade in values are greatly affected to any 2019 Bolt now. I do not feel safe and I want GM to buyback my 2019 Bolt asap. How many more fires must 2019 Bolt owners endure until GM is forced to buy all of them back? How many people will need to die first???

Owners of 2019 Bolts are being cautioned to keep their cars parked outside. Some 2019 Bolts have ignited even after both recall battery fixes. My Bolt can only be parked outside, very close to neighbors and under trees.

There is an open recall on my vehicle, but Chevy NEVER notified me about it. I received an email about the initial recall in November 2020, but found out about this most recent recall ONLY from the Chevy Bolt EV Facebook group I am part of. Searching my VIN on the Chevy website did not yield any results for a couple of weeks (now it says that there is an open recall but no remedy yet), but now searching the VIN and looking at the battery sticker information tells me that I am, indeed, part of this recall and have never heard anything directly from Chevy. Many others in the group reported receiving an email but I have not received any communication. This seems very suspect and very dangerous. I purchased the car used from a dealer but since I received the original Nov 2020 recall information I know that Chevy has my information, they just didn't contact me for some reason.

Battery catching on fire. Instead of replacing the battery they keep doing software update now they want us to park it outside , not charge at night when it’s whole purpose to charge cheaper, or babysit your car for 9 hrs so it’s unattended.

The car’s electronics under the hood got very hot when charging at Level 2 (ChargePoint wall charger) at home at night in mild ambient conditions (low 70s deg F). The surface of the electronic component boxes on top of the engine compartment were very hot to the touch but not burning the skin. It is not clear whether the propulsion battery also got very hot or not, but later on car’s display showed that car consumed 10% of used electricity for “battery conditioning” since the last full charge, namely since the car was unplugged and started to use battery power to keep battery cooling system going. This implies that it is quite possible that the battery also got hot (>100 deg F, since this temperature is what I have had observed in the past was the trigger temperature for initiating battery conditioning/cooling, e.g. 30 minutes into fast charging - FCDC - when ambient temperature was in the low 90s). The temperature measured by electronic thermometer on the surface of one of the electronics boxes under the hood indicated 113 deg F one hour after the car was unplugged and moved out of the garage, while the ambient temperature was measured to be 72 deg F. This implies the temperature of car components was even higher an hour earlier during and right after charging. If the car continued to charge, it is possible it would be in danger of catching fire since it appears the cooling system was not able to stop electrical component temperatures from rising. As far as I am aware, this car is the only Bolt EV that has been observed to reach unexpectedly high temperatures when Level 2 charging (240V 32A = 7.6 kW) without actually catching on fire.

Incident hasn't occurred YET. Worried about car and property. Leaving car outside is an invitation for car thieves in our area and we're having major hail storms.

My vehicle is under it's second recall for a potential battery fire. This has not happened as of yet but I am submitting this to support action by the NHTSA to improve the fire safety of BEVs It seems to me that these vehicles should be constructed so that they are more resistant to causing a major fire without any obvious indication that there is a problem prior to the fire. I believe that the problem is being minimized due to a rather low percentage of vehicles catching on fire so far. In addition, GM's latest instructions for customers places an undue burden on them to provide their own remedy. GM's instructions have requested customers to take actions they likely do not have the expertise to accomplish. For example, admonishments to park out side do not provide instruction as to what this means. I can park my vehicle outside but then it is adjacent to other vehicles and is still somewhat close to my house. This still seems rather dangerous.

The contact owns a 2019 Chevrolet Bolt EV. The contact received notification of NHTSA campaign number 21V560000 (Electrical system) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts are not available.

The manufacturer, GM, has failed to remedy this safety recall for my vehicle in a timely manner. The 2019 Bolt EV I purchased from GM presents a real and present danger as a fire risk, while I am being told to limit my vehicle's usage. I cannot easily follow their safety guidelines because this is the only car my family owns -- we cannot simply give up visiting relatives to not deplete the car below 70 miles of range nor can we personally watch the hours it takes to recharge the vehicle outdoors. This renders the vehicle wholly unusable as a modern car that I paid for in a new condition. I do not feel safe putting my daughter in this vehicle, nor parking it in our driveway. In addition, I live in California, and I would be devastated if my vehicle was the cause of a fire in this state. I have called the GM Concierge line 8 different times over the past 8 weeks (I have the records) to attempt a vehicle swap, and every single time after their initial conversation to gather details, GM has not responded to me with any updates. The latest incident was a Bolt EV that exploded in Sacramento. I want a working car, not a lemon waiting to kill me.

On May 11, 2021 I responded to GM's safety recall notice by bringing the car to a local Chevrolet dealer, who performed the service as per GM's instructions. Since then the battery has continued to charge or attempt to charge for several hours after it has been fully charged as indicated by the instrument panel readout and the dashboard indicator. I reported the problem to GM by phone several weeks ago and was instructed to bring the car back to the dealer that had performed the recall service. I did so on July 7 but I wasn't convinced that the dealer appreciated the seriousness of the problem, so I immediately called GM 's EV hotline (866-790-5600 ext. 5912316) where a case was opened. As of July 18 I am still waiting for further instructions from GM. My case number is 9-6818768332.

My Bolt was purchased in Sept. 2019. It was not part of the initial NHTSA recall because it has a battery made in the U.S. However, Chevrolet still issued a company recall on it and performed a software update, evaluation of battery health, and installed an on-board diagnostic module. The "final fix" as it is called. Even though my battery appears to be safe, it has the same design, materials and similar manufacturing practices by the same company, as the cars that have caught fire. Now there has been a battery fire in a Bolt in Vermont that had the "final fix" installed. (Not my car, it's in another state) I am concerned that the battery problem is in the design and how it is built, not due to a faulty manufacturing contaminiation that could only occur in Korea. And I'm also concerned that the "final fix" is not sufficient to take care of the problem. I am asking you to investigate all the LG batteries in all the Bolts to determine if they truly are safe.

Component: We don't know for sure. The was a recall on the battery, and several other of these cars have had thier batteries explode in similar fashion. The primary remnants of the car are missing and are being investigated as being stolen and are unavailable for inspection. The melted remnants of the car left in the driveway are still available. Safety: We inhaled toxic vapors. Our home has been severely damaged. If the incident had happened in the middle of the night instead of in the morning, our neighbors wouldn't have been awake to call 911 and my wife and I could have died when the fire spread to the house. Has the problem been reproduced? Unknown, though this is a known issue that has happened to other cars. Has the compenent been inspected? No. The wreckage is missing and presumed stolen. Were there any warning messages: I do not believe so. My wife claims she heard a car alarm when we we awakened by the first loud noise. She does not know if the alarm came from our car. In the early AM of 7/2/2021 I awoke to smell an acrid smell. Our neighborhood often has an odd smell, so I went back to sleep. About 6 AM on 7/2/2021 my wife and I were awakend by a loud bang originating outside the house. I investigated and noted a police officer outside my home using a fire extinguisher on my 2019 Chevy Bolt. I saw flames coming from the right passenger side. The police officer asked us to exit our home. I told my wife that the house was on fire, because I believed that's what was happening. When we left the home, I noticed that, at first, it was only the car. The fire got worse very quickly., and the police officer asked us to move farther back.We heard and saw several explosions.The fire spread to the house. At some point the fire department arrived and extinguished the fire, but not before the car was completely consumed and significant damage was done to our home. My wife, I and our pets were all examined for smoke inhalation and the cats were treated.

My Bolt falls under the recall for a main battery pack defect that has resulted in several car fires. Chevy states we should part outside our garage if the car is parked and charged there. This is a major inconvenience to owning the car. I requested a buyback several months ago when they were being offered by Chevy. Since Ohio's Lemon Laws are poor I was denied. I had little faith Chevy could find the problem with software and I was correct.

I have a Chevrolet Bolt EV that was recalled due to risk of battery fires. It took many months of waiting and being unable to charge the car fully, but a fix was issued that scanned the battery and added monitoring software. Two fires have since occurred on 2019s with the fix applied. So now GM has said to follow these guidelines until they can find and fix a separate issue. My car is unusable under the guidance that GM has issued, which includes no charging overnight, no parking inside, no charging to 100% and try not to run below 70 miles of charge. There is no timeline for the repair for the recall and I have no confidence that they will fix the batteries appropriately since they are saying they will replace parts of the batteries rather than whole batteries, but as I understand it, new and old battery parts aren't safe to mix. The car is unusable, unsafe and a fire hazard on my property despite having less than 15k miles on it, but I cannot get GM to give me a loaner or let me park it at a dealership while I wait four or more weeks for a review on a potential buy back case.

I was denied the buyback by GM due to the weak lemon law in the state of Michigan. GM should be replacing these batteries if they are not allowing a buyback or trade up. There were 16,418 Bolts produced in the US-market for the model year 2019. If I take a ballpark half of the vehicles with Korean cells, and half of the vehicles produced with cells in Holland Michigan (The Holland cells not having the defect), to-date we are looking at 5 in 8,209 cars catching fire due to the battery defect. That translates to 1 in every 1,641 2019-model-year Korean-cell Bolts catching fire, to-date. Statistically, this number cannot go down. This represents a much higher percentage than what GM is publicly stating. This is a much higher, unacceptable risk. I do not have faith in a software update and battery voltage spread test for the latest "fix." GM is very secretive on what the defect or defects are. A battery may test fine today, as it made it into the production vehicle and passed the test then. Though, tomorrow it may fail due to the defect. When it fails, I don't want my family to be anywhere near it. Please hold GM's feet to the fire on this to prevent the possibility of the unsuspecting consumer to get burned.

Re: GM Recall Number N202311731 I am dissatisfied with the GM’s response to this recall that addresses fires involving their battery charging system in the Chevy BOLT. The long-awaited final remedy is a setup for failure. Installing a software monitoring system to look for the theoretical cause of the problem is inadequate and fails to protect consumer safety. They allege, without providing consumers with the undisclosed engineering analysis that underpins their solution, that this is the best they can offer. Their plan is to monitor for electrical aberrations in the cars’ electrical/battery system instead of replacing the faulty system. By analogy this is like a home builder acknowledging that they installed faulty wiring in your home that does not meet code and there have been a number of fires. However, instead of replacing the faulty wiring, they are installing a monitoring system that looks for changes in resistance or areas of high temperature in your walls and shuts down your power before they think your house will explode into flames. GM has not provided any testing in the real world of this "remedy", and asks that we trust their engineers. I would like to see an independent assessment of this, not paid for by Chevrolet or GM. I have no confidence in this or with GM's assertions that it is the best they can do to protect the safety of the public. As a health and safety professional, I am appalled at this solution at its acceptance. I cannot believe that this would be approved as a remedy for an aircraft problem. The more recent and less publicized Boeing MAX airliners’ electrical problems require replacement of the bonding between electrical panels and their contacts. NHTSA should demand full disclosure of all studies done for GM’s BOLT recommendation, and publication on the NHTSA site for a period of public comment. I adamantly reject that this has been conducted by GM in a transparent manner or that it is the safest response. Thank you

The center touchscreen will intermittently freeze when started and not recover when driving. When this occurs the HVAC and radio hard buttons also stop responding which prevents control of the defrost, creating a visibility hazard that could result in a crash. Sometimes the freeze will result in the backup camera remaining on while driving forward. When in reverse the freeze results in the backup camera guidelines, parking collision warning and rear cross traffic warning being unavailable. Failure of these systems intended to prevent collisions is a safety hazard because unavailability of these systems could result in a collision. The freezing did not occur frequently when the vehicle was new, but over time this has become a frequent occurrence. The vehicle is available for inspection upon request. The problem has been reproduced by a dealer and been subject to repair twice, but the issue has continued to occur after each repair attempt. The vehicle was subject to bulletin 20-NA-119 which was intended to correct radio screen black/freezes after boot up, but this does not appear to have resolved the issue.

AROUND 11:00AM ON 5/1/21 SATURDAY MORNING NOTICED THICK SMOKE COMING OUT OF THE REAR SIDE OF THE CAR PARKED IN THE GARAGE AND IT WAS NOT CONNECTED TO THE CHARGER AND SHOUTED AT MY FAMILY & KIDS TO COME OUT OF THE HOUSE AND WHEN I OPENED THE GARAGE SHUTTERS I SAW FIRE IN THE REAR OF CAR FROM BENEATH AND THE REAR SEATS, WHICH MY NEIGHBORS WITNESSED TOO WE CALLED 911 MEANWHILE WE TRIED TO EXTINGUISH THE FIRE USING THE KITCHEN FIRE EXTINGUISHER WHICH DID NOT HELP AT ALL AND IT TURNED INTO A BIG BLAZE AND SET THE WHOLE GARAGE ON FIRE AND BURNING THE MOTOR CYCLE AND SNOW THROWER PARKED IN THE GARAGE AND ALSO GOT TO THE NISSAN AMADA SUV PARKED RIGHT IN FRONT OF THE GARAGE AND THE FIRE WENT INTO THE MASTER BED ROOM UPSTAIRS AND FIRE TEAM LATER PUT OFF THE FIRE BUT THE CAR BATTERY WAS STILL SMOKING UNTIL 2-2:30PM. THE CAR WAS SERVICED ON 3/25/2021 AT POHANKA CHEVY, CHANTILLY AND THEY DID APPLY THE SAFETY RECALL-HIGH VOLTAGE BATTERY MAY MELT OR BURN HYBRID POWER TRAIN CONTROL MODULE 2 REPROGRAMMING WITH SPS AND ATTACHED IS COPY OF INVOICE STATING THE SAME.

I just want the battery pack to be replaced with one that does not catch fire due to manufacturing defects. Nearly all of the fires have been 2019 model years. There were 16,418 Bolts produced in the US-market for the model year 2019. If I take a ballpark half of the vehicles with Korean cells, and half of the vehicles produced with cells in Holland Michigan (The Holland cells not having the defect), to-date we are looking at 5 in 8,209 cars catching fire due to the battery defect. That translates to 1 in every 1,641 2019-model-year Korean-cell Bolts catching fire, to-date. Statistically, this number cannot go down. This represents a much higher percentage than what GM is publicly stating. This is a much higher, unacceptable risk. GM needs to be replacing these defective batteries, or we will continue to see more fires. A software update and battery voltage check is unacceptable, as these defective cells made passed the test to make it into these cars in the first place. Model year 2019 fires: Ashburn, https://insideevs.com/news/505346/chevy-bolt-ev-blaze-ashburn/ Port St Lucie, https://www.tcpalm.com/story/news/local/st-lucie-county/2020/10/06/electric-vehicle-thought-have-caught-fire-garage-psl/3635092001/ Vienna, https://abcnews.go.com/US/wireStory/us-investigates-fire-reports-chevy-bolt-electric-vehicles-73582418 Miami, https://bid.cars/en/lot/0-27990292/2019-Chevrolet-Bolt-1G1FY6S07K4113757 Jacksonville, https://www.chevybolt.org/attachments/jacksonville-bolt-png.31467

THIS FRONT COLLISION WARNING SYSTEM DOESN'T WORK WELL, TODAY I WAS DRIVING ON A CAR POOL LANE AT A SPEED ABOUT 65-70 MPH, A WHITE FORD EXPLORER SUDDENLY CUT IN, THE SYSTEM DIDN'T MAKE ANY WARNING OR BRAKE AT ALL. I HAVE A DASH CAM RECORDED IT. WHEN THIS HAPPENED, IT WAS SUNNY, CLEAR DAY, ON A STRAIGHT FREE WAY. AFTER A WHILE, WHEN I LEFT THE FREE WAY, THE SYSTEM STARTED TO MAKE WARNINGS WHILE THE SPEED DROPPED TO 50 MPH.

GENERAL MOTORS REFUSES TO SERVICE MY VEHICLE AND CLAIMS I'M BLACK LISTED FROM EVERY DEALERSHIP IN THE AREA. THEY REFUSE TO COMPLETE THE SAFETY RECALL FOR BATTERY FIRES ON MY VEHICLE, THE WINDSHIELD WIPERS ARE SLAPPING EACH OTHER AND REAR SUSPENSION IS MAKING METAL ON METAL CLANKING NOISES. GM HAS HAD ME BLACK LISTED FROM ALL DEALERSHIPS IN THE AREA AND REFUSES TO COMPLETE NECESSARY SAFETY REPAIRS ON MY VEHICLE. I HAVE ABSOLUTELY NO WAY OF GETTING THESE NECESSARY SERVICES COMPLETED ON MY VEHICLE. GM CUSTOMER EXPERIENCE CENTER WON'T ASSIST IN FINDING A DEALERSHIP IN THE AREA. PLEASE HELP.

My car is in the Chevy Bolt recall due to battery fires. Many months ago Chevy took away 5 to 10% of my e-MPG in order to lessen the likelihood of fire. When I heard they had a fix, I immediately called. I was told I will not be able to have my car checked and repaired/restored until November. This is an inordinately long time to be driving a car on recall due to possible battery fire.

VEHICLE WILL NOT CHARGE FULLY DUE TO BATTERY CATCHING ON FIRE

My 2019 Chevrolet Bolt Premier has the battery made in Korea that is part of the current investigation Chevrolet is doing, announced yesterday July 14, 2021. This is the announcement from Chevrolet: JULY 14 2021 IMPORTANT UPDATE FROM GENERAL MOTORS General Motors has been notified of two recent Chevrolet Bolt EV fire incidents in vehicles that were remedied as part of the safety recall announced in November 2020. Out of an abundance of caution, we are asking owners of 2017-2019 Chevrolet Bolt EVs who were part of the recall population to park their vehicles outdoors immediately after charging and not leave their vehicles charging overnight while we investigate these incidents. This has been a known problem for several months, since November 2020, as noted in Chevrolet's announcement above. I limited my charging to 90% the minute the news broke about the possibility of a battery fire. I have had "the remedy" done to my car, which is all that one can do at this point. live in a condo building in a busy downtown setting and my only parking spot is two levels underground. It is both unsafe and very costly/inconvenient for me to have to park on the street at meters while waiting to hear ANYTHING from Chevy regarding next steps. I want to get my situation on your radar, as I am sure many other Bolt owners do. I want to stop worrying about the potential of a fire that would kill or maim any person or living creature, destroy any property, especially my home, my neighbors' homes, cars, etc. HELP!

I'VE HAD THE RECALL WORK DONE. BUT BECAUSE OF THE VERBIAGE IN THE RECALL ITSELF IT'S REMAINING OPEN ON NHTSA AND CARFAX. THIS IS PREVENTING ME FROM USING MY CAR AS INCOME.

GM recalled Bolt for possible battery fire in 2020 & 2021. At the 2nd recall, I started MSRP Swap with GM. Since GM dragged my case intentionally, I filed BBB auto complaint. Though BBB, GM agreed with MSRP Swap on 9/9 (verbal agreement between BBB & GM). Since then GM has been silent. GM claimed they can't find a dealership to do MSRP Swap. However, as a consumer, this isn't my problem, but GM needs to step up to find a dealership for MSRP Swap. Otherwise, GM's MSRP Swap agreement is useless. Meanwhile, GM recommended Bolt owners to charge up to 90% of battery capacity, maintain battery mileage above 70M, park 50ft from building/other cars, and park open space. The car is basically useless, and we fear our car might burn down our house/life as well as neighbors.

DASH REFLECT EXCESSIVE LIGHT ONTO WINDSHIELD BLINDING DRIVER. I HAVE A TURN FROM SR-95 SOUTH TO I-15 NORTH RAMP AND I AM BLINDED WHILE MAKING THE TURN POTENTIALLY CAUSING A CRASH. SEEMS THIS HAS BEEN A KNOWN ISSUE SINCE 2017 AND NO FIXES HAS BEEN MAD.

I currently lease a 2019 Chevrolet Bolt which is part of the recall announced today by GM. This is the second recall in less than a year for the same battery-related issue. It was supposed to have been fixed with a software update that I had completed in March. This software was supposed to identify defective batteries but it has not been successful as evidenced by the mounting number of fires that have happened after the “fix”. As such, we are now under a recall a second time. As a result of their own manufacturing issue, we are now limited to how we charge our vehicles, where we park and even the mileage range that we paid for, while GM attempts another fix. GM stated that they will again be using software to identify defective cells in our batteries and only the ones that are deternined to be defective will have those cells or battery packs replaced. As you can imagine, I no longer trust GM to be able to successfully identify whether or not my battery is defective. This is a serious safety issue. My family, my property and even people I park next to while out in public are at risk. GM must be forced to either replace the entire battery pack in every vehicle affected by this recall or replace them with newer models containing safer batteries. They must also provide loaner vehicles, or details on reimbursement for rental cars, to those who need them due to the fact that their vehicle is virtually unusable until GM provides a complete, effective solution.

Since about November of 2020 this vehicle has been under a recall, due to potential fire danger of the batteries. The interim solution was to not charge the battery above 90%. Within the last couple of months a "final" solution was initiated by GM, to solve this potential fire situation. I have had this "final" solution performed on my vehicle by the dealer. Now, we are informed that fires are still happening on these vehicles, even with the final repair. We are now told do not charge overnight un-monitored. Do not let the battery get below 30% or above about 80%. Do not store the vehicle in doors. I now read that GM does not expect any sort of "new" solution until September, or perhaps later. None of this works for us, with our current usage of this vehicle as our main transportation.

The contact owns a 2019 Chevrolet Bolt EV. The contact received a notification for NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

IN THE EARLY MORNING HOURS OF OCTOBER 21ST, AROUND 3AM, WE WERE WOKEN UP BY SMOKE/FIRE ALARMS. WE STARTED RUNNING AROUND OUR HOME TO IDENTIFY THE CAUSE OF THE ALARM. AFTER ABOUT 5 MINUTES OF SEARCHING INSIDE THE HOME AND FINDING NOTHING, WE REALIZED THAT THERE WAS SOME SMELL OF SMOKE COMING FROM THE GARAGE AND WHEN THE MUDROOM DOOR WHICH LEADS TO THE GARAGE WAS OPENED, WE FOUND THAT THE CHEVY BOLT WAS ON FIRE AND THERE WAS LOT OF SMOKE IN THE GARAGE. THE CHEVY BOLT WAS PARKED/STATIONARY IN DOOR 3 SECTION OF THE GARAGE AND OUR OTHER CAR WAS PARKED IN DOOR 1 SECTION OF THE GARAGE. THE DOOR 2 SECTION OF THE GARAGE WAS EMPTY AT THE TIME OF THE INCIDENT. WITH CHEVY BOLT ON FIRE, WE SAW THAT THE DOOR 3 SECTION OF THE GARAGE WAS ENGULFED IN FLAMES AND FILLED WITH SMOKE. WE TRIED TO USE THE FIRE EXTINGUISHER TO PUT-OFF THE FIRE BUT COULD NOT CONTAIN THE SPREAD OF THE FIRE. THE CHEVY BOLT WAS KEPT FOR CHARGING OVERNIGHT , AS HAS BEEN THE GENERAL PRACTICE THAT WE HAVE BEEN FOLLOWING FOR AROUND 2 YEARS. WE CALLED 911 AS SOON AS WE SAW THE GARAGE IN FLAMES AND FIRE ENGINES ARRIVED WITHIN 15 MINUTES BUT THE FIRE HAD SPREAD WIDELY AND CAUSED RAMPANT DAMAGES TO THE ENTIRE GARAGE INCLUDING THE OTHER CAR, BEDROOM ON THE TOP OF THE GARAGE IN THE SECOND FLOOR AND THE BEDROOM ADJOINING THE GARAGE IN THE FIRST FLOOR. WHILE ALL THE OCCUPANTS OF THE HOME GOT OUT WITHIN AROUND 8 MINUTES OF HEARING THE FIRE ALARM, THE FIRE AND HEAT/SMOKE SPREAD QUICKLY TO WASHER/DRYER SECTION, EAT IN DINING, KITCHEN, FAMILY ROOM AND FORMAL DINING ROOM. THE OTHER SECTIONS OF THE HOME INCLUDING THE FOYER, OFFICE ROOM, SUN ROOM AND ALL OF THE BEDROOMS UPSTAIRS WERE QUICKLY FILLED BY SMOKE AND SOOT. THE HEAT INSIDE THE HOME WAS SO MUCH THAT ONE CAN LITERALLY SEE THE FRAMING STUDS. THE TOWNSHIP FIRE AND POLICE DEPARTMENT ARRIVED PROMPTLY ON THE SCENE AND HAVE BEEN DILIGENTLY FOLLOWING UP ON THE INVESTIGATION.

CHEVY BOLT FINISHED CHANGING AND THEN STARTED TO SMOKE FROM UNDER THE CAR. THE SOUND OF POPPING NOISES WERE HEARD AND THEN 10 MINUTES LATER THE CAR WAS ENGULFED IN FLAMES. THE CARS BATTERY PACK STARTING POPPING THEN EXPLODED IN FLAMES.

Within the first 20 months of ownership of my vehicle - I became aware of multiple reported fires due to the battery on other similar 2019 Chevy Bolts (and other years) where (like my vehicle) had batteries manufactured in Korea which subsequently found to contain a number of defects which pose a fire risk. For many months and currently I have had harsh limitations placed on how far I am able to drive my vehicle due to requested safety measures GM is requesting (to NOT charge over 90% and to NOT let the vehicle go below 30% - effectively limiting range by 60%). Additionally, we are not able to charge the vehicle overnight and must remove the vehicle from the garage after charging due to fire risk. This is unacceptable! I requested a buyback from GM or MSRP swap but was denied. There is currently NO FIX available and it's unclear to when if this will be fully resolved. I am afraid to use my vehicle as my charger is located in my garage where my sons bedroom is directly above the garage. My vehicle poses a great risk to my families safety.

I WAS DRIVING MY CHEVY BOLT AT APPROXIMATELY 40-45 MPH WHEN IT WAS AT ABOUT 50% CHARGE CAPACITY WHEN ALL OF A SUDDEN THE CAR SHARPLY DECELERATED AND WARNING LIGHTS CAME ON SAYING THE CHARGE WAS DOWN TO 0 AND THAT IT NEEDED TO BE RECHARGED IMMEDIATELY. I PULLED OVER TO THE SIDE OF THE ROAD AND CALLED FOR HELP. THERE'S NO WAY THE CAR SHOULD HAVE LOST 50% OF IT'S CHARGE OUT OF NOWHERE LIKE THAT. I WAS NOT ABLE TO RESTART THE CAR OR REGAIN POWER. IT HAS TO BE TOWED TO THE DEALER.

SINCE NEW I'VE HAD AN ISSUE WITH THE BOLT EV'S INFOTAINMENT DISPLAY GOING BLACK TO INCLUDE THE BACKUP CAMERA. I CANNOT CONTROL THE SCREEN, THE CLIMATE CONTROL SETTINGS OR ANYTHING. I'VE BEEN BRINGING IT IN SINCE IT WAS NEW AND WAS TOLD BY CHEVROLET THAT IT'S NORMAL OPERATION. NOW IT'S FRIED WITH A BURNING ELECTRICAL SMELL IN THE CENTER OF THE DASHBOARD AND UNCONTROLLABLE OR UNRESETTABLE. I HAVE VIDEO OF THE INCIDENT AND HAVE TAKEN VIDEOS OF PRIOR INCIDENTS WHICH GM STATES THEY CANNOT FIX BASED OFF OF A VIDEO OF THE OCCURRANCE. IT WON'T ALLOW ME TO UPLOAD HERE. I CAN PROVIDE IF NEED BE.

AT APPROXIMATELY 4 AM ON 10/6/2020, WE (MYSELF AND MY CHILDREN) WOKE UP TO AN EXPLOSION. I RAN TO FIND OUT WHAT IT WAS AND SAW SMOKE ENTERING OUR HOME UNDER THE DOOR GOING OUT TO THE GARAGE. I GRABBED MY CHILDREN AND GOT OUT OF THE HOUSE AS FAST AS I COULD. WHEN I OPENED THE FRONT DOOR OF MY HOUSE TO GO OUTSIDE, THERE WERE FLAMES COMING OUT THE FRONT OF THE GARAGE AND THE GARAGE WAS ENGULFED IN FLAMES. WE RAN ACROSS THE STREET TO OUR NEIGHBORS HOUSE AND I CALLED 911, BY THIS TIME, OUR ENTIRE GARAGE WAS ENGULFED IN FLAMES. OUR 2019 CHEVY BOLT WAS PLUGGED IN CHARGING IN THE GARAGE OVERNIGHT, AS I HAVE DONE REGULARLY SINCE PURCHASING THE VEHICLE IN DECEMBER 2019 WITHOUT ISSUE. AFTER CALLING 911, THERE CONTINUED TO BE A BUNCH OF LOUD 'POP' SOUNDS AND ANOTHER SMALLER EXPLOSION. THE FIRE DEPARTMENT ARRIVED, AND WHILE THEY WERE ABLE TO EXTINGUISH THE FIRE PRIOR TO THE FLAMES SPREADING TO THE REST OF THE HOUSE, OUR ENTIRE HOUSE IS A TOTAL LOSS FROM SEVERE SMOKE AND WATER DAMAGE AND BLACK SOOT COVERING EVERY INCH OF THE HOUSE. ALSO, MY DAUGHTER'S ROOM THAT 'SHARES' THE GARAGE WALL WAS COMPLETELY DESTROYED. THE SMELL IN THE ENTIRE HOUSE IS INDESCRIBABLE, I IMAGINE WORSE THAN A 'REGULAR' HOUSE FIRE BECAUSE IT HAS A CHEMICAL SMELL TO IT. THE COUNTY FIRE INVESTIGATOR DETERMINED THE ORIGINATION WAS IN THE BATTERY COMPARTMENT OF THE VEHICLE, AND SINCE THE INCIDENT, THERE HAS BEEN AN INVESTIGATION WHERE MULTIPLE FIRE INVESTIGATORS, ENGINEERS FROM GM AND A REPRESENTATIVE FROM NHTSA ALL WERE PRESENT TO INVESTIGATE AND REMOVE THE VEHICLE FROM THE GARAGE. WE, PERSONALLY, HAVE NOT RECEIVED ANY REPORTS FROM THIS EXTENSIVE INVESTIGATION TO PROVIDE ANY FURTHER INFORMATION TO THE CAUSE.

GENERAL MOTORS WILL NOT PROVIDE A SOLUTION TO POTENTIAL BATTERY FIRES, AS IDENTIFIED IN THEIR RECENT RECALL OF CHEVROLET BOLTS. MINE IS A 2019 AND IS PART OF THE CURRENT RECALL.

THIS IS A NOTE REGARDING THE MANUAL DISCONNECT FUSE ON CHEVROLET BOLTS, INCLUDING THE 2019 MODEL. FAILURE OF THE FUSE WHILE DRIVING CAN CAUSE INJURY/DEATH. MY CHEVROLET DEALER IS TAKING THREE WEEKS TO FIX THE ISSUE. CHEVROLET IS NOT ALLOWING THE DEALERS TO KEEP THE REPLACEMENT FUSE IN STOCK, SO YOU HAVE THE CAR INSPECTED, THEN THEY ORDER THE FUSE. IN MY CASE IT TOOK TWO WEEKS FOR THE FUSE TO ARRIVE, ANOTHER WEEK TO AN APPOITMENT. TOTAL OF THREE WEEKS.

I PURCHASED A 2019 CHEVY BOLT ON DEC. 20, 2019. THE CAR HAS ABOUT 7,200 MILES. WHILE I WAS TURNING ONTO A THOROUGHFARE , A WARNING LIGHT SAID THERE WAS A PROBLEM WITH THE HIGH VOLTAGE BATTERY. THIS HAPPENED ON AUG. 6, 2020. CHEVY REPLACED THE BATTERY UNDER WARRANTY. I TOOK THE CAR TO ALFANO CHEVROLET IN SAN LUIS OBISPO, CA WHERE I BOUGHT IT. I MENTION THIS BECAUSE I'VE HEARD OF BOLT BATTERIES CATCHING FIRE OR MELTING RESULTING IIN DESTRUCTION OF THE VEHICLE.

MY 2019 CHEVY BOLT WAS FULLY CHARGED AND DRIVEN FOR 12 MILES TO OUR DESTINATION, A TOWNHOUSE DEVELOPMENT WITH PRIVATE OUTDOOR OPEN PARKING. WE ARRIVED AROUND 7:30PM, PARKED IT AND TURNED IT OFF. 20 MINS LATER A NEIGHBOR RANG OUR DOORBELL BECAUSE THERE WAS 20 FOOT HIGH HEAVY WHITE/GRAY SMOKE CLOUD COMING OUT THE BACK OF THE CAR. I CALLED 911 AND FIREFIGHTERS DOUSED THE CAR WITH WATER FOR AN HOUR AFTER SMASHING THE REAR WINDOW TO GET ACCESS TO THE SMOKING AREA.THEY LEFT, LESS THAN AN HOUR LATER I CALLED 911 AGAIN B/C THE SMOKE RESTARTED. SMOLDERING WAS SO HOT IT PARTLY BURNED THE BACKSEAT. ONCE THE CAR WAS COOL ENOUGH IT WAS TOWED TO THE DEALERSHIP WHERE IT WAS ORIGINALLY PURCHASED. THERE IT BEGAN TO SMOKE AGAIN. 911 WAS CALLED AND FIREFIGHTERS PUT OUT THE SMOKE ONCE AGAIN. THIS TIME THE SMOKE WAS SMALL AND STARTED ON THE AREA WHERE THE BACKSEAT WAS PREVIOUSLY LOCATED; MINUTES LATER THE SAME HEAVY SMOKE CAME OUT FAST FROM UNDERNEATH THE FRONT PASSENGER SIDE. THE POLICE WERE THERE TO WITNESS THAT INCIDENT. IT WAS AROUND MIDNIGHT THEN. 3 SPONTANEOUS COMBUSTIONS IN 4 HOURS; DOOR CAMERA VIDEOS DIDN'T PICK UP MOVEMENT BETWEEN OUR ARRIVAL AND THE NEIGHBOR RINGING THE BELL; ONSTAR REPORTS DON'T SHOW ANYTHING ELECTRICALLY WRONG WITH THE CAR; NO ALTERATIONS HAD BEEN MADE TO IT; AND THE DASHBOARD DIDN'T SHOW ANY WARNINGS DURING THAT ONE LAST TRIP. BASED ON THE ABOVE, I BELIEVE THE PROBLEM WAS A HIGH VOLTAGE BATTERY RUNAWAY THERMAL EVENT. EVEN THOUGH THE CAR IS STILL UNDER GM'S WARRANTY, THEY REFUSE TO INVESTIGATE BECAUSE WE CALLED OUR INSURANCE FIRST INSTEAD OF GM (PER GM'S PRODUCT ASSISTANCE CLAIM TEAM). THE CAR IS CURRENTLY AT AIIA AND GM COULD GO INVESTIGATE. BUT THEY WON'T. HOW MANY OTHER BOLTS ARE SPONTANEOUSLY COMBUSTING AND PEOPLE GETTING HURT? HOW MANY WILL IT TAKE FOR GM TO CARE? THIS CAR'S DAMAGE LOOKS SIMILAR TO MINE ('LOSS: FIRE') IAAI.COM/VEHICLEDETAILS/36707410

The car battery lit on fire and the car burned.

I AM AN OWNER OF 2019 CHEVY BOLT. I HAD THIS CAR SINCE THE DAY 1, BAUGHT IT BRAND NEW FROM THE DEALERSHIP, AND NOT ONLY WHEN I PURCHASED IT THE DEALER HAD NO PROPER INFORMATION ABUT IT, I HAVE TRIED CONTACTING THE GM CUSTOMER CARE REGARDING THE FIRST, SECOND AND THIRD RECALL. I HAVE ASKED THE GM REGARDING THE RECALL, IF THE RECALL THAT THE DEALER WILL TRY TO FIX WILL NOT SOLVE THE ISSUE, WILL I STILL BE IN THE RISK OF HAVING MY CAR CATCH ON FIRE? CAN THE GM GUARANTEE ME THAT AFTER HAVING ALL OF MY RECALLS DONE PRIOR TO THE FINAL ONE THAT JUST CAME IN THAT THEY HAD FIXED THE ISSUE AND THAT MY VEHICLE IS SAFE NOW CONSIDERING I HAVE A CHILD. THE RESPONSE WAS: " WE CANNOT GUARANTEE THAT TO YOU, BECAUSE WE CAN ONLY TRY AND SEE IF THIS WILL SOLVE THE ISSUE." SO THE ISSUE IS NOT SOLVED, MY VEHICLE IS A DANGER NOT ONLY TO ME BUT TO MY NEIGHBORS AND TO MY FAMILY. FOREMORE, GM DOES NOT WANT TO BUY BACK THE VEHICLE EVEN THOUGH THEY KNOW IT IS THEIR MISTAKE AND IT IS THEIR DEFECT.

VEHICLE UNEXPECTEDLY & WITHOUT WARNING LOST POWER WHILE TRAVELING ON HIGHWAY. VEHICLE WAS UNABLE TO ACCELERATE AND ALL POWER FROM THE HIGH VOLTAGE SYSTEM WAS LOST. *TR