2001 Chevrolet Suburban Complaint Log

The ABS and Brake lights illuminate as per GM recall 05v379000. This occurs each time the vehicle is driven. I purchased this vehicle on 12/6/2023 from Kyle's Kars which is a used car dealership in Slatington, PA. A warranty was not offered due to the age, however I did purchase a warranty from Car Shield. This repair would not fall under the warranty guidelines.

this vehicle has a non-functioning parking brake. There was a recall in 2004 for 880,000 trucks and suv's. I have taken it to my garage twice but they cannot fix this problem because it is not fixable

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING BEHIND HIS FATHER'S VEHICLE, THEY HAD APPROACHED A STOP AND ATTEMPTED TO DEPRESS THE BRAKE PEDAL. AS HIS FOOT WAS ON THE PEDAL, THE CONTACT COULD HEAR THE ABS MAKING AN ABNORMAL NOISE AS THE BRAKE PEDAL FAILED TO OPERATE AS NEEDED. DUE TO THE FAILURE, THE CONTACT HIT THE BACK OF HIS FATHER'S VEHICLE WITHOUT WARNING. DUE TO THE LOW IMPACT OF THE CRASH, THE AIRBAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS THEN NOTIFIED OF THE FAILURE AND THEY INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000(SERVICE BRAKES, HYDRAULIC) AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 159,000.*DT*JB

FUEL PUMP MAY FALTER OR FAIL; FUEL PUMP RELAY WAS NON-FUNCTIONAL, REPLACED IT; OTHER FUSES PASSED TESTING WITH METER; VEHICLE STARTED, WOULD NOT RUN MORE THAN A FEW MINUTES. NEW FUEL FILTER. GUY AT SERVICE STATION BANGED ON GAS TANK, AND IT WOULD START THEN RUN GREAT FOR A MINUTE, THEN WILL NOT RESTART. ORDERING A REPLACEMENT FUEL PUMP. BOUGHT THIS VEHICLE IN 2005 ABOUT THE TIME OF GM RECALL 05027. IN DOING ONLINE TROUBLE-SHOOTING TODAY, I DISCOVERED THE 2001 GM RECALL 05027. HAVE HAD THIS PROBLEM SEVERAL TIMES. FUEL FILTER WAS LAST CHANGED IN JULY 2009. COMPLETE FAILURE WHEN IN MOTION, BACKING OUT OF SERVICE STATION ONTO MAIN STREET (US 64 BUS), JUST INCHES FROM LANE OF TRAVEL (6.14.19).WHAT COULD BE WORSE THAN FUEL PUMP FAILURE AT A BUSY INTERSECTION DURING LUNCH HOUR? GRATEFUL IT DIDN'T CATCH FIRE, OR GET HIT. AS THE SERVICE ATTENDANT TRIED TO RESTART IT, OVER AND OVER, THE RELAY IN THE ECU MAY HAVE FAILED AT THAT TIME. IN THE INTERIM, MY HUSBAND DIED. I REPLACED RELAY/FUSES TODAY 9/14/19, AND VEHICLE STARTED, BUT WOULD NOT STAY RUNNING. ANOTHER MECHANIC BANGED ON FUEL TANK, IT RAN FOR A WHILE, SO HE ADVISED REPLACING PUMP, WHICH IS NOT ROCKET SCIENCE AFTER VIEWING YOUTUBE HOW-TO VIDEOS. WITH THE PUMP FAILING SPORADICALLY, AND RESPONDING TO THE VIBRATION OF BEING BANGED, IT SEEMS LIKE FAULTY WIRING OR CONNECTION PROBLEM, OR THAT SOMETHING IS LOOSE OR NOT FULLY SEATED ANYMORE. LOTS OF FOLKS SAY THE CHEVY 1500 IS WIDELY KNOWN FOR FUEL SUPPLY PROBLEMS. GAS GAUGE HAS NOT BEEN ACCURATE EVER. WHEN FULL, IT MAY SHOW EMPTY WHEN TURNING OR HITTING A SLIGHT BUMP IN THE ROAD. (TRACK BY COMPUTING MPG AND MILEAGE, TO DETERMINE RANGE). IN SHORT DISTANCES, IT SWINGS FULL-> EMPTY->FULL. WIRING DIAGRAM SHOWS TINY FUSE LABELED PRIME, NONE THERE. ABS INDICATOR LIGHTS UP BECAUSE SENSOR CABLE AT RIGHT FRONT TIRE MAY FAIL ON LEFT TURN, OR HARD RIGHT TURN, YET BRAKES ARE FINE.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT LOW SPEEDS, THE VEHICLE EXPERIENCED INCREASED STOPPING DISTANCE WHEN BRAKING. THE VEHICLE WAS TAKEN TO COMMONWEALTH CHEVROLET (155 MARSTON ST, LAWRENCE, MA 01841, (978) 687-3000) WHERE IT WAS DIAGNOSED THAT THE DRIVER AND PASSENGER SIDE WHEEL BEARING ASSEMBLIES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE WAS PUT ON A LIFT AND IT WAS DISCOVERED THAT THE BRAKE LINE WAS CORRODED, CAUSING A LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE CONTACT CALLED THE ED BOZARTH CHEVROLET DEALER (877-721-4901, 3731 SW TOPEKA BLVD, TOPEKA, KS 66609) AND WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000. *TT CONSUMER STATED BRAKE LINES CORRODED AND WAS LEAKING. UPDATED 12/18/18*JB

I HAD A MAJOR BRAKE FAILURE THE OTHER DAY WHILE DRIVING. I HAD NO BRAKES, BUT I WAS ABLE TO STOP WITH THE EMERGENCY BRAKE. I HAD THE TRUCK TOWED TO THE MECHANIC AND THEY REPORTED THAT THE BRAKE FAILURE WAS DUE TO RUSTED BRAKE LINES.

THE PASSENGER SIDE SECOND SEAT SEAT BELT WILL NOT RETRACT.

THE PASSENGER SIDE REAR DOOR WINDOW BREAKS WHEN THE WINDOW IS DOWN FOR NO REASON. I HAVE HAD TO REPLACE IT 4 TIMES IN THE LAST 60 DAYS. THERE APPEARS TO BE NO DAMMAGE TO ANY OF THE INSIDE OF WINDOW OR THE WINDOW REGULATOR. THE VEHICLE WAS STATIONARY AND MY DAUGHTER OPENED THE DOOR AND THE WINDOW BROKE.

ON MARCH 16, 2017, I WAS TRAVELLING ON A MOUNTAIN HIGHWAY IN NORTHERN CALIFORNIA IN MY 2001 SUBURBAN WITH THE DRIVER'S SEAT HEATER ON. I WAS SITTING ON A THIN SEAT CUSHION. TWENTY MINUTES INTO THE 40 MINUTE TRIP, I TURNED MY SEAT HEATER OFF. TEN OR SO MINUTES LATER, I SMELLED A HORRIBLE RUBBER/PLASTIC BURNING SMELL. WHEN I REACHED MY DESTINATION, I LIFTED MY CUSHION AND SAW THAT THE SEAT HAD A BURNED HOLE THROUGH THE LEATHER AND INTO MY SEAT CUSHION. IT WAS WARM, BUT I DID NOT SEE A FLAME. WHEN I GOT HOME IN THE BAY AREA, I CONTACTED GM, AND THEY OPENED A CASE NUMBER AND TOLD ME TO TAKE MY VEHICLE TO A DEALER, AND THEY WOULD INVESTIGATE. I RECEIVED A CALL YESTERDAY FROM THE CUSTOMER SERVICE REP., AND SHE TOLD ME THAT THEY WOULD NOT BE COVERING THIS AS MY CAR WAS OUT OF WARRANTY, IN SO MANY WORDS. I ASKED WHAT THE DEALER HAD FOUND, AND SHE COULDN'T TELL ME. I REITERATED TO HER THAT THIS IS A SAFETY CONCERN FOR ME. MY PASSENGER SIDE SEAT HEATER IS NOW GETTING VERY HOT, AND I AM CONCERNED NOW ABOUT THAT. PLEASE NOTE, THE DRIVER'S SEAT HEATER IS STILL WORKING IF YOU ACCIDENTALLY HIT THE BUTTON ON THE DOOR. TODAY, I FOUND OUT FROM THE DEALER THAT THEY WERE NOT INSTRUCTED BY GM TO LOOK INTO THE SEAT TO SEE WHAT CAUSED THIS, ONLY TO TAKE PICTURES, ETC. NOBODY KNOWS WHY IT HAPPENED. HOW CAN THEY DENY ANYTHING WITHOUT DETERMINING THE CAUSE IS MY THOUGHT. AREN'T THEY CONCERNED THEIR SEATS OVERHEAT? SHOULD THEY BE WARNING THE PUBLIC? MY SEATS ARE IN VERY GOOD CONDITION, EVEN THOUGH IT IS AN OLDER VEHICLE. INTERESTING TO NOTE WHEN WE PICKED THE CAR UP FROM THE DEALERSHIP THAT THE SERVICE WRITER SAID I SHOULDN'T WORRY SINCE IT IS NOT WORKING NOW BECAUSE A WIRED PROBABLY BROKE (EVERYTHING IS PROBABLY OR MAYBE). I CORRECTED HIM AND SHOWED HIM THAT IT DOES. HE WAS VERY SURPRISED TO SEE THAT IT STILL DID. SO, THE QUESTION IS WHY DID IT OVERHEAT. PLEASE ADVISE.

I WAS DRIVING ON THE HIGHWAY 95 COMING BACK FROM DAYTONA WHEN A DRIVER LET ME KNOW THAT MY TIRES WHERE LOW SO I WHEN TO A GAS STATION TO PUT SOME AIR IN AND THATS WHEN I NOTICE THAT MY TIRES HAD A LOT OF NAILS LTHE 4 TIRES. THIS IS RIDICULOUS. MY TIRES ARE LNOT EVEN 2 YEARS OLD AND I HAVE THE RECEIPT TO PROVE IT. SOMEONE HAS TO DO SOMETHING. BECAUSE I HAVE A NEW BORN BABY WITH ME AND DRIVING WITH FLAT TIRES IS NOT AN OPTION. PLEASE TAKE MY COMPLAINT IN CONSIDERARATION. THANK YOU

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING THE VEHICLE, SMOKE EMITTED UNDER THE HOOD OF THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE CAUGHT ON FIRE, WHICH WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED AND DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT AN UNKNOWN SPEED, SMOKE EMITTED FROM THE ENGINE COMPARTMENT OF THE VEHICLE. THE CONTACT PULLED OVER AND DISCOVERED THAT THE FRONT END AND FRONT WHEELS WERE ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. FIRE AND POLICE REPORTS WERE FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 204,654.

WHILE THANKFULLY DRIVING AT A LOW SPEED, MY BRAKES COMPLETELY FAILED WITH NO WARNING..PEDDLE WENT TO THE FLOOR, I WAS ABLE TO STOP BY SHIFTING THE TRANS DOWN TO 2ND THEN 1ST. MECHANIC SAID KNEW EXACTLY WHAT THE PROBLEM WAS WHEN I EXPLAINED WHAT HAPPENED AFTER I STOPPED, PUMPED THE BRAKES AND BRAKE FLUID FLOWED FROM UNDER THE TRUCK GENERALLY UNDER WHERE THE DRIVER SITS. MECHANIC EXPLAINED THAT THE BRAKE LINE BROKE AND IS VERY COMMON, AND THAT IT JUST STARTED SHOWING UP A FEW YEARS AGO WHEN THESE "C" BODY TRUCKS AGED. I SPOKE TO ANOTHER MECHANIC AT A CHEVY DEALERSHIP NEAR MY HOME AND HE SAID THE SAME THING THAT IT'S VERY COMMON AND THAT GM NOW SELLS A KIT FOR A COMPETE BRAKE-LINE SYSTEM REPLACEMENT BECAUSE IT HAS BECOME SO COMMON. A FEW DAYS BEFORE I HAD BEEN DRIVING AT HIGH SPEEDS THROUGH THE MOUNTAINS ON I-81 WITH A CARLOAD FULL OF PEOPLE, HAD THIS HAPPENED AT THAT TIME IT COULD HAVE BEEN CATASTROPHIC. REVIEWING CONSUMER COMPLAINTS ON YOUR SITE I SEE THIS IS A REOCCURRING COMPLIANT AND I CAN'T BELIEVE THERE HAS NOT BEEN A RECALL ON THIS, AS THERE IS NO MORE IMPORTANT SAFETY SYSTEM ON A AUTOMOBILE THAN BRAKES....CHEVY HAD A RECALL ON MY 98' BUICK FOR A VALVE COVER GASKET LEAKING THAT DIDN'T COME CLOSE TO THIS POTENTIAL DANGER.

I WAS SLOWING FOR A STOP SIGN WHILE LEAVING A PARKING LOT WHEN THE STEEL REAR BRAKE LINE SPONTANEOUSLY SPLIT AND DUMPED ALL LINE PRESSURE. THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, AND I ROLLED RIGHT INTO TRAFFIC BEFORE I WAS ABLE TO PUMP THE PEDAL ENOUGH TIMES TO STOP THE VEHICLE AGAINST A CURB. HAD I NEARED THE STOP SIGN 2 SECONDS EARLIER OR LATER, I WOULD HAVE EITHER BEEN T-BONED BY A BOX TRUCK, OR T-BONED A SMALL SEDAN. I EMPHASIZE THAT THE BRAKE LINES SHOWED NO WARNING SIGNS BEYOND THE TYPICAL SURFACE RUST THAT CAN BE FOUND ON ANY VEHICLE THAT HAS BEEN DRIVEN FOR MORE THAN A FEW WINTERS IN THE "RUST BELT". HOWEVER, THOSE VEHICLES DO NOT HAVE BRAKE LINES SPONTANEOUSLY FAIL AT THE RATE THAT THESE GM TRUCKS DO. THIS TRUCK'S PRIMARY PURPOSE IS TOWING A CAMPING TRAILER FOR VACATIONS WITH MY YOUNG FAMILY, SO THIS COULD HAVE ENDED VERY DIFFERENTLY. I URGE YOU TO TAKE GM TO TASK AND FORCE THEM TO FIX THEIR MISTAKE OF CHEAPING OUT ON BRAKE LINE MATERIALS!

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500 EQUIPPED WITH FIRESTONE WILDERNESS LETIRES, TIRES SIZE: 265/70R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY AT 55 MPH, THE VEHICLE BEGAN TO VIOLENTLY SHAKE AND VIBRATE BEFORE A LOUD BOOMING SOUND WAS HEARD. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT THE REAR PASSENGER SIDE TIRE HAD EXPERIENCED A BLOWOUT. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

THIS ISSUE OCCURRED IN JULY OF 2016 WHILE WE WERE ON VACATION IN FLORIDA. WE BEGAN TO LOSE BRAKING ABILITY UNTIL FINALLY THE VEHICLE BECAME ALMOST INOPERABLE, ONLY ABLE TO TRAVEL AT ABOUT 20 MPH AND STILL BE ABLE TO STOP WITHOUT HITTING ANYTHING. ONE OF THE STEEL BRAKES LINES HAD BLOWN A HOLE IN IT. WE HAD A SHOP REPAIR IT AND WHEN THEY TESTED IT, IT BLEW ANOTHER LINE. WE ENDED UP HAVING ALL THE LINES REPLACED BECAUSE OF THE LEVEL OF CORROSION.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 5 MPH, THE ANTI-LOCK BRAKES ACTIVATED WITHOUT WARNING, WHICH MADE THE VEHICLE HARD TO STOP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

THREE TIMES I HAD COMPLETE BRAKE FAILURE. DRIVING TWO TIMES AND HAD JUST ARRIVED AT MY DESTINATION THIRD TIME, WHICH WAS TODAY -- SURPRISE!!!! HAD TO SLOWLY DRIVE HOME, YET AGAIN, WITH NO BRAKES!!!!!

BRAKE LINES FAILED TWICE DUE TO RUST AND CORROSION BECAUSE CHEVY USED A INFERIOR STEEL PRODUCT ON ALL TRUCKS FROM 1998 TO 2005. THE DEALER REPAIRED MY 2002 AVALANCHE FOR $600.00 TO REPLACE ALL THE BRAKE LINES. HOWEVER THEY WILL NOT REPAIR MY 2001 SUBURBAN WHICH HAS THE SAME PROBLEMS. GM NEEDS TO RE-CALL ANY VEHICLE OR AT LEAST MAKE A REPAIR KIT AND INSTALLATION AT A REDUCED RATE BECAUSE THIS VEHICLE IS UNSAFE TO DRIVE. THIS IS NOT DUE TO OWNER ERROR OF WASHING THE FRAME DURING WINTER OR WINTER MAINTENANCE. THERE IS NEW LINES THAT ARE COATED TO RESIST COROSION AND WERE USED TO REPAIR MY AVALANCHE. MY 2001 SUBURBAN BRAKE LINES FAILED IN MOTION WHILE IN TRAFFIC APPLYING THE BRAKE PETAL TO STOP.

WHEN VEHICLE IS IDLING WHILE NOT MOVING EXTREME AMOUNTS OF EXHAUST FUMES ARE ENTERING THE CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS DUE TO DEFECTIVE EXHAUST MANIFOLD BOLTS WHICH ARE BREAKING ALLOWING THE EXHAUST MANIFOLD TO OPEN AND ALLOW FUMES TO ENTER THE ENGINE COMPARTMENT WHICH RESULTS IN THE EXHAUST FUMES ENTERING THE PASSENGER CABIN AREA THROUGH THE VENTILATION SYSTEM. THIS IS A HEALTH ISSUE FOR PASSENGERS INSIDE THE CABIN BREATHING THE TOXIC EXHAUST FUMES. THIS SHOULD BE A SAFETY RECALL ON GM TO FIX THE PROBLEM DUE TO POOR ENGINEERING DESIGN AND FOR USING POOR QUALITY COMPONENTS WHICH FAIL FOR NO REASON. ALSO THIS IS AN EXTREMELY DANGEROUS SITUATION FOR PASSENGERS INSIDE THE VEHICLE, WHICH HAVE TO BREATH THE DANGEROUS EXHAUST FUMES. GM SHOULD BE MADE TO REPAIR ALL VEHICLES AFFECTED BY THIS PROBLEM WHICH WERE DESIGNED AND ENGINEERED WITH INFERIOR PARTS WHICH ARE CAUSING THIS DANGEROUS SITUATION FOR MILLIONS OF PEOPLE ACROSS THIS COUNTRY.

PREMATURE REAR SECTION OF BRAKE LINE RUST OUT 2001 CHEVY SUBURBAN.

EXHAUST BOLTS BROKEN AND CAUSING A LEAK MAKING THE VEHICLE UNABLE TO PASS EMISSIONS ALSO. STEERING STABILIZERS BROKEN.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING. THE ENGINE WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, WHICH LOCATED A FAILURE CODE AT THE CRANKSHAFT POSITION SENSOR. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V521000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,000.

WHILE TRAVELLING ON THE HIGHWAY AT APPROXIMATELY 50 MPH, VEHICLE STRUCK AN ADULT DEER - FRONT END SQUARE HIT OFFSET TO PASSENGER SIDE. FRONT PASSENGER LIGHTS, GRILL, RADIATOR SUPPORTS, BUMPER, SIDE FENDER, AND HOOD ALL SEVERELY DAMAGED. AIRBAGS DID NOT DEPLOY. DAMAGE TO THE VEHICLE ENDED UP AT $4,386.

I WAS APPLYING THE BRAKES ON MY 2001 CHEVROLET SUBURBAN, MODEL 2500, AS I TURNED INTO MY DRIVEWAY. THE BRAKES FAILED TO ENGAGE. THIS RESULTED IN THE VEHICLE RUNNING INTO THE FRONT OF THE GARAGE. THE BRAKES NOW APPEAR TO BE WORKING FINE. THE BRAKES HAVE FAILED ON PREVIOUS OCCASIONS, BUT NEVER TO THE POINT OF ALLOWING THE VEHICLE TO HIT ANYTHING. ACCORDING TO THE GM DEALER, THEY CAN'T FIX THE PROBLEM WITHOUT A FAILURE CODE IN THE COMPUTER. AN INDEPENDENT SERVICE GARAGE SAID THE SAME.

COMPLETE BREAK FAILURE. BREAK PEDAL WENT TO FLOOR AND ALMOST KILLED MY FAMILY. NOTICED LEAKING BREAK FLUID COMING OUT OF RUSTED BREAK LINE UNDER VEHICLE.

DRIVING ON HIGHWAY AT 75MPH BATTERY, SECURITY AND LOW FUEL POPPED ON INTO MESSAGE CENTER. GAS GAUGE, VOLT METER, AND TEMPERATURE GAUGE QUIT WORKING, HAD TO PULL OFF THE SIDE OF THE HIGHWAY BECAUSE OF IT ALMOST GOT HIT. I KNOW NUMEROUS PEOPLE WITH SAME ISSUE.

TL* THE CONTACT OWNED A 2001 CHEVROLET SUBURBAN. WHILE DRIVING AT 55 MPH UPHILL, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE HYDROPLANED. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF A PICK-UP TRUCK. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WAS ONE INJURY THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 270,000.

MY SON WAS DRIVING AND REAR ENDED A MAN GOING APPROXIMATELY 50 MPH. THE FRONT END SUSTAINED A GREAT DEAL OF DAMAGE, INCLUDING, BUT NOT LIMITED TO, THE ENGINE BEING PUSHED BACK SEVERAL INCHES. THE AIR BAGS DID NOT DEPLOY. MY SON SUSTAINED MINOR WHIPLASH TYPE INJURIES TO HIS NECK AND BACK.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. WHILE DRIVING AT 65 MPH, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. UPDATED 7/28/15*CN UPDATED 10/18/2017*CN

DRIVING AT 65 MPH DOWN THE INTERSTATE, SUDDENLY THE SUNROOF GLASS SEPARATED FROM THE FRAME AND FLEW AWAY INTO THE ROAD BEHIND US. THE INSIDE SUN SHADE WAS ALSO SUCKED OUT. THE SUNROOF WAS CLOSED AT THE TIME. THE FRAME AND MOTOR ARE INTACT AND STILL OPERATE NORMALLY. SUNROOF WAS MADE BY VERMEULEN-HOLLANDIA, MODEL: TVS S/N 461569. THERE IS A RECALL ON 2002-UP MODELS FROM THEM BUT NOT FOR THIS SERIAL NUMBER. COMPANY NAME IS NOW WEBASTO. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL PUMP WAS DISABLED AND THE ODOR OF FUEL WAS PRESENT. ALSO, THE CONTACT INDICATED THAT THE FUEL GAUGE DISPLAYED INACCURATE FUEL LEVELS WHILE OPERATING THE VEHICLE AND THE SERVICE ENGINE SENSOR LIGHT HAD ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V155000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 260,000.

I WAS TRAVELING AROUND 40MPH ON A LOCAL ROAD ON MY WAY FROM DROPPING THE KIDS OFF AT SCHOOL. I TRIED TO SLOW DOWN TO TURN ONTO MY STREET, AND THE SUBURBAN BRAKES DID NOT RESPOND AT ALL. THANKFULLY, THERE WAS NOBODY AHEAD OF ME, AND I SLOWED THE TRUCK GRADUALLY. I THEN IDLED BACK HOME, WITHOUT ANY FUNCTIONALITY IN MY BRAKES. UPON INSPECTION, WE DISCOVERED THE BRAKE LINES HAD RUPTURED. ALL MAINTENANCE IS AND HAD BEEN UP TO DATE. *TR

WENT TO START MY 2001 CHEVY SUBURBAN AND IT WOULDN'T START. I LISTENED FOR THE FUEL PUMP TO ENGAGE AND IT WASN'T WORKING. I CHECKED THE RELAY AND NOTICED IT WAS MELTED ON ONE CORNER. I HAVE RESEARCHED THIS ONLINE AND FOUND SEVERAL COMPLAINTS ABOUT THE SAME PROBLEM. ALSO NOTICED THAT GM HAS DONE NOTHING TO FIX THIS ISSUE. I HAVE BEEN A GM FAN ALL MY LIFE AND WOULD LIKE TO CONTINUE BEING ONE. PLEASE RECALL THIS ON GOING PROBLEM GM. *TR

CHEVROLET HAS CONTINUED TO IGNORE THE ABS BRAKE ISSUE WITHIN THE BRAKE CONTROL MODULE. THIS IS SEPARATE FROM THEIR WHEEL SENSOR ISSUE.THE BRAKE CONTROL MODULE.HAS A CIRCUIT BOARD ISSUE WHICH DEACTIVATES THE ABS SYSTEM AND SHOWS A BRAKE AND ABS LIGHT ON DASH.IN SNOW TODAY MY ABS FAILED AND I SLID THROUGH AN INTERSECTION NARROWLY MISSING A SCHOOL BUS A F$%^ING SCHOOL BUS.THERE IS SO MUCH INFO ON THIS ISSUE ON THE INTERNET BUT CHEVROLET SEEM TO BE IGNORING IT.THE PROBLEM IS CENTERED AROUND A CIRCUIT BOARD IN THE BRAKE CONTROL MODULE.

BRAKE LINES SEVERELY CORRODED AND BLEW OUT. SEVERE CORROSION UNDER TRUCK TOO. *TR

BRAKE LINE RUPTURED CAUSING LOSS OF BRAKING ABILITY RESULTING IN CAR PASSING THROUGH RED LIGHT. *TR

DRIVING APPROX 50 MPH ON 4 LANE HIGHWAY. WHEN SLOWING FOR RED LIGHT AHEAD, NOTICED BRAKE PEDAL GOING CLOSER TO FLOOR THAN NORMAL. VEHICLE WAS NOT SLOWING AS NORMAL, AND BRAKE PEDAL WAS STAYING CLOSE TO THE FLOOR. GOT STOPPED AND PULLED TO SIDE OF ROAD. CHECK OF MASTER CYLINDER REVEALED BRAKE FLUID LEVEL TO BE APPROX. HALF FULL. UPON CHECKING UNDER VEHICLE, I SAW BRAKE FLUID POURING OUT FROM THE GAS TANK SHIELD. *TR

EXHAUST AND MANIFOLD COVER BOLTS ARE TOO WEAK AND THE HEADS BREAK OFF. I HAD TO REPLACE ALL OF THEM WITH RACING BOLTS. MUCH BETTER NOW.

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN EQUIPPED WITH HERCULES ALL TRAC A/T TIRES, SIZE: 265/70R16 (NA). WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED WITH A SPARE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE TECHNICIAN WHO REPLACED THE TIRE. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 5,000 AND THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 205,000.

BRAKES FAILED ON A RURAL ROAD BUT I WAS ABLE TO STOP. TRIED TO PUSH THE BRAKES LIKE NORMAL, BUT THEY WENT ALL THE WAY TO THE FLOOR. I WAS ABLE TO STOP, BUT WITH MUCH DIFFICULTY. TOOK IT TO THE SHOP AND EVEN THOUGH I JUST HAD NEW BRAKE PADS, ROTORS AND CALIPERS PUT ON, I NEED TO BUT NEW BRAKE LINES IN WHICH IS OVER $1000. SUDDEN BRAKE FAILURE IS THE MOST DANGEROUS THING THAT CAN HAPPEN IN A CAR. I WAS LUCKY TO BE ON A RURAL STRETCH OF ROAD WHERE I WAS ABLE TO STOP WITHOUT HURTING MYSELF OR OTHER PEOPLE. *TR

THE ABS ACTIVATE WITHOUT REASON WHEN I SLOW TO A STOP. THE PROBLEM BEGAN INFREQUENTLY AND I ATTRIBUTED IT TO POSSIBLE SLIPPERY SURFACE CONDITIONS. OVER THE PAST YEAR THE PROBLEM HAS GOTTEN MUCH WORSE AND HAPPENS FREQUENTLY NOW. RESEARCH INDICATES THAT THIS IS A KNOWN PROBLEM AND THE SUBJECT OF A RECALL FOR "SNOW" STATES - LIKE DC AND MARYLAND WHICH ARE JUST ACROSS THE POTOMAC RIVER FROM WHERE I LIVE AND USE MY SUBURBAN. THIS IS THE SECOND SERIOUS BRAKE ISSUE WITH THIS VEHICLE. ALL THREE BRAKE LINES HAVE BEEN REPLACED OVER AN APPROXIMATE 18 MONTH PERIOD TWO YEARS AGO AS A RESULT OF SUDDEN BRAKE FAILURE CAUSED BY CORRODED BRAKE LINES. THIS IS ALSO A WELL KNOWN PROBLEM (THOUGH NOT ONE I WAS AWARE OF WHEN MY BRAKES FAILED AND WERE REPAIRED). MY RESEARCH INDICATES THAT MANY OWNERS HAVE SUFFERED FROM THESE PROBLEMS. THE NHTSA SHOULD FURTHER INVESTIGATE THESE PROBLEMS AND EXPAND/INITIATE RECALLS FOR THESE PROBLEMS.

DRIVING DOWN A HILL ON MY STREET THE BRAKES GAVE WAY. I PUSHED THE PEDAL TO THE FLOOR AND THE VEHICLE DID NOT STOP. I WAS ABLE TO PULL OVER AND STOP THE VEHICLE. UPON INSPECTION, THE SERVICE STATION INDICATED THE REAR BRAKE LINES FAILED DUE TO RUSTING. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THE TWO REAR BRAKE LINES WERE REPLACED AS WELL AS A FROZEN CALIPER. UPDATED 08/27/14

TL* THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 60 MPH, THE BRAKES FAILED. THE FAILURE OCCURRED MULTIPLE TIMES. A LOCAL MECHANIC STATED THAT THE BRAKE LINES WERE RUSTED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

WHILE DRIVING THROUGH DOWNTOWN BETHESDA, BRAKE PEDAL LOST PRESSURE ALL THE WAY TO THE FLOOR, RESULTING IN EXTENDED STOPPING DISTANCE THROUGH AN INTERSECTION. PULLED OVER AND NOTED FLUID LEAKAGE UNDER FRONT RIGHT SIDE OF CAR. DROVE CAR TO DEALER AT 5MPH; IDENTIFIED EXTENSIVE RUST THROUGH BRAKE LINES. CAR WAS NOT DRIVABLE. I WAS CHARGED $430 FOR PARTS AND $2351 FOR LABOR TO 'COMPLETELY REBUILD BRAKE LINES MANUALLY' BECAUSE GM STOPPED MAKING THE KIT. TOTAL $2808 AND NINE DAYS OUT OF SERVICE. *TR

I WAS DRIVING ON MAY 12 FROM FILLMORE CA TO LAX AIRPORT I WAS ON FREEWAY 5 PASSING VALENCIA BY THE EXIT OF FREEWAY 14 WHEN A WHITE BAN HIT THEIR BRAKES I DID THE SAME THING BUT I THINK THE BRAKE OF MY CAR DID WORK PROPERLY AND I LOST CONTROL OF MY CAR SO I WENT TO THE LEFT LINE AND A GREY CIVIC HIT ME ON MY DRIVER SIDE BY THE FRONT TIRE I HAD MY TWO KIDS WITH ME THEY WERE SO SCARE BECAUSE I WAS BLINDING FROM MY HEAD MY AIR BAGS NEVER CAME ON IF YOU HAVE ANY PLEASE CALL [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

TIGHT TURN IN DRIVEWAY ABS BRAKES LOCKED UP AND THERE WERE NO BRAKES, VEHICLE KEPT ROLLING ALMOST RUNNING INTO GARAGE DOOR. IF HAD BEEN AT INTERSECTION I WOULD HAVE HIT CAR ON FRONT OF ME! CAR TOWED TO CHEVROLET DEALERSHIP IN ARLINGTON TX

TL* THE CONTACT OWNS 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE PARKING IN A RESIDENTIAL DRIVEWAY, THE BRAKES FAILED TO RESPOND. THE CONTACT STATED THAT THE ABS AND THE BRAKE WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 140,000.

TL*THE CONTACT OWNS A 2001 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.