2004 Chevrolet Suburban Complaint Log

I RECEIVED A LETTER DATED JULY 2, 2012 THAT INDICATED THAT THE TIRES I PREVIOUSLY PURCHASED FROM PEPBOYS WERE DEFECTIVE AND COULD BLOW APART WHILE DRIVING. THE TIRES HAD DOT SERIAL NUMBER UT T6 PA7. SO, I TOOK THE LETTER AND VEHICLE BACK TO PEPBOYS BUT THEY WERE NOT AWARE OF THE RECALL. IN ANY EVENT, THEY DID REPLACE ALL FOUR TIRES FREE OF CHARGE. HOWEVER, IT SEEMS THAT ARE STILL SELLING THE DEFECTIVE TIRES BECASE THE TIRES THEY INSTALLED ON MY VEHICLE, FOR THE SECOND TIME, HAD DOT SERIAL UT T6 PA7. SO, IT APPEARS THAT I AM STILL DRIVING ON THE HIGHWAY WITH DEFECTIVE TIRES.

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TURNED THE VEHICLE OFF HOWEVER, THE ABS CONTINUED IN OPERATION, CAUSING THE BATTERY TO DRAIN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS UNAVAILABLE.

THE SPEEDOMETER GIVES A FALSE READING THAT COULD CAUSE OPERATION OF THE VEHICLE AT AN UNSAFE SPEED. THIS FIRST HAPPENED WHILE DRIVING WITH MY FAMILY. I NOTICED THAT THE SPEEDOMETER SEEMED TO BE GIVING A FALSE READING. USING A GPS MY WIFE WAS ABLE TO CONFIRM THAT I WAS UNKNOWINGLY TRAVELING AT A SPEED VERY DIFFERENT THAN THE SPEED LIMIT. THE ISSUE IS INTERMITTENT . THE DEALER SAYS THIS IS A KNOWN PROBLEM BUT WILL NOT FIX IT DESPITE THE OBVIOUS SAFETY CONCERNS. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE PARKED, THE DRIVER DEPRESSED THE BRAKE PEDAL BUT THE BRAKES WOULD NOT RESPOND. THE PARKING BRAKE WAS APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE BRAKE LINES HAD CORRODED FROM THE INSIDE AND WOULD HAVE TO BE REPLACED ALONG WITH THE BRAKE PADS AND ROTORS. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000. ...UPDATED 10/17/12 *BF THE CONSUMER STATED THE VEHICLE DID NOT SHOW ANY WARNING LIGHTS. GM OFFERED A CREDIT TOWARDS PURCHASING A NEW CHEVROLET VEHICLE. THE CONSUMER DECLINED. UPDATED 10/17/2012 *JS THE CONSUMER ALSO STATED THE CALIPERS WERE SEVERELY RUSTED, ALONG WITH THE FRONT CALIPER HOSES AND FRONT ROTORS, WHICH CAUSED THE BRAKE PADS TO CRACK AND WEAR UNEVENLY. UPDATED EVOQ 10/24/12 UPDATED EVOQ 11/21/12

THE BRAKE LINES ON MY SUBURBAN WERE ROTTED (I DID NOT KNOW THIS UNTIL AFTER) AND THEY RUPTURED WHILE I WAS ON THE HIGHWAY TOWING A TRAILER. I ONLY AVOIDED A CRASH BY DOWNSHIFTING AND USING MY EBRAKE. THIS IS A WIDESPREAD ISSUE FROM SEARCHING THE WEB AND I AM SHOCKED THIS IS NOT ALREADY A RECALL. *JS

THE BRAKE LINES ON MY 2004 SUBURBAN HAVE NOW FAILED THREE TIMES. THE FIRST TIME ONE OF THE LINES HAD TO BE REPLACED AT A COST OF OVER $1000, THE SECOND TIME A SEPARATE LINE WAS PATCHED, AND NOW THE THIRD TIME THE SAME SECOND LINE THAT WAS PATCHED HAS FAILED AGAIN. ALL OF THE BRAKE LINES ARE INCREDIBLY CORRODED, SO MUCH SO THAT A FRIEND OF MINE WONDERED IF IT HAD BEEN SUBMERGED DURING HURRICANE KATRINA. BUT NOW UPON READING UP ON THE SUBJECT IT APPEARS THAT IS IS ALL GMS OF THAT TIME FRAME THAT LIVE IN SALTIER AIR. WHILE GM APPEARS TO THINK THAT THESE ARE COMPONENTS THAT SHOULD WEAR DOWN OVER TIME, THIS IS ONLY THE SECOND TIME IN THE 30 YEARS THAT I HAVE OWNED CARS TO FIND THIS PROBLEM.

DRIVING ON SMALL RESIDENTIAL STREET. AS I APPROACHED A STOP SIGN I APPLIED BRAKES AND PEDAL WENT TO THE FLOOR AND I STEERED INTO THE CURB TO STOP VEHICLE. WHEN I STOPPED SHAKING I CALLED MY HUSBAND AND HE CAME WITH A FRIEND WHO IS A MECHANIC. WHEN THEY RAISED THE HOOD THEY SAW BRAKE FLUID EVERYWHERE. WHEN WE GOT THE CAR HOME AND INSPECTED IT FURTHER THE MECHANIC WAS HORRIFIED TO SEE THAT EVERYTHING UNDER THERE WAS CORRODED AND RUSTED. INCLUDING BUSHINGS GAS LINES, NUTS AND BOLTS ETC. HE CLAIMED HE HAD NEVER SEEN ANYTHING LIKE IT IN HIS LIFE. THIS IS THE THIRD SUBURBAN I HAVE OWNED AND I AM VERY UPSET THAT THIS WOULD HAPPEN. I WAS ALL SET TO HAVE MY 20 YR OLD SON TAKE THIS UP TO SCHOOL SO HE COULD MOVE OUT OF HIS DORM. HE COULD HAVE BEEN SERIOUSLY HURT IF THIS HAD HAPPENED ON THE NEW JERSEY TURNPIKE. *TR

THE STEEL BRAKE LINE FAILED ON THE DRIVERS SIDE BELOW THE DOOR. *JS

WAS DRIVING AT A VERY LOW RATE OF SPEED; TRYING TO STOP WHEN WHAT FELT LIKE THE ANTILOCK BRAKES KICKED ON AND THE MESSAGE "TRACTION ACTIVE" APPEARED ON MY CONSOLE. THIS MADE IT VERY DIFFICULT TO CONTROL AND STOP THE VEHICLE. THEN WHEN TRYING TO ACCELERATE, VEHICLE WOULD LUG DOWN AND NOT WANT TO GO. THERE WAS ALSO A NOISE, LIKE A PUMP OR SOMETHING WHEN TRYING TO BRAKE OR ACCELERATE. TURNING OFF THE STABILITRACK SEEMS TO STOP THIS FROM HAPPENING, WHICH IN TURN MEANS I DO NOT HAVE ANTILOCK BRAKES. THIS IS A HUGE SAFETY ISSUE, ESPECIALLY IF TRYING TO MERGE, PASS THROUGH AN INTERSECTION OR WHILE DRIVING AT A HIGH RATE OF SPEED. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE BRAKE LINES FRACTURED WHILE THE BRAKES WERE APPLIED ON THE HIGHWAY. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE DEALER WAS NOT NOTIFIED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 84,905 AND THE CURRENT MILEAGE WAS 85,049. UPDATED 5/7/12 *CN THE CONSUMER STATED HER HUSBAND DISCOVERED THE FRONT BRAKE LINE HAD RUPTURED. THERE WAS A HOLE IN THE BRAKE LINE IN THE ENGINE COMPARTMENT NEAR THE DRIVER'S SIDE FRONT WHEEL AND THE BRAKE LINE WAS SEVERELY CORRODED. UPDATED 05/25/12

DRIVING DOWN THE ROAD, WHEN ALL OF A SUDDEN "REDUCED ENGINE POWER". REPLACED THE THROTTLE BODY, PEDAL SENSOR, AND WIRING HARNESS WITHOUT ANY SUCCESS. GM WANTS 150 JUST TO PLUG IT INTO THEIR COMPUTER TO TELL ME WHAT I CAN GET DOWN FOR FREE WITH MY BUDDIES CODE READER....NO I WON'T LET MY WIFE OR CHILDREN DRIVE THE CAR. I ONLY DRIVE IT TO AND FROM WORK. HAD TO GO OUT AND BUY A TOYOTA JUST TO KEEP MY MIND AT EASE SO MY WIFE AND OR KIDS WON'T GET KILLED FROM THIS PROBLEM. IT SEEMS LIKE CHEVY/GMC DOESN'T CARE ABOUT THIS ISSUE UNTIL MULTIPLE PEOPLE DIE FROM THIS. I HOPE TO SEE THAT THEY WILL DO THE RIGHT THING. THINKING OF CONTACTING MY CONGRESS REPRESENTATIVE TO SEE WHAT THEY CAN DO TO HELP OUT US THAT ARE DEALING WITH THIS ISSUE. NOBODY ELSE IS. *TR

THE ENGINE LIGHT WOULD COME ON AND IMMEDIATELY THE STABILITY SYSTEM DISENGAGE LIGHT WOULD COME ON ALSO. THE VEHICLE WOULD GO DOWN TO APPROXIMATELY 1500 RPM AND DROP THE SPEED TO 50-55 MPH, ON THE FREEWAY. THE SPEED LIMIT IS 65 AND WE WERE IN THE MIDDLE LANE OF 3 LANES. IT HAS HAPPENED NUMEROUS TIMES NOW. I HAVE TAKEN THE VEHICLE TO A MECHANIC 3 TIMES. A DIAGNOSTIC TEST WAS RAN EACH TIME AND EVERY TIME THERE DIFFERENT CODES THAT POP UP, ONE DIFFERENT FROM THE PREVIOUS. *TR

CRACKED DASH, NEVER REMOVED, GARAGE KEPT. CRACKED RUNS THROUGH DASH FROM FRONT WINDOW TOWARDS RADIO CLUSTER. DASH HAS SHARP PIECES THAT IN ACCIDENT CAN EASILY BE BROKEN OFF.

I WAS TRAVELING NORTH ON RT.1 IN DELAWARE I SEEN A CAR ROLLED OVER ON ITS SIDE AND OFF THE ROAD I APPLIED MY BRAKES HARD TO STOP AND HELP THAT IS WHEN MY BRAKES FAILED. AFTER CHECKING ON THE DRIVER I LIMPED MY TRUCK TO THE NEAREST GAS STATION AND DISCOVERS MY BRAKE LINE HAD ROTTED OUT UNDER MY TRUCK BY THE FRONT WHEEL. THE CLIPS THAT SECURE THE BRAKE LINE TO THE FRAME SEEM TO BE THE PROBLEM. *TR

STEEL BRAKE LINES ON VEHICLE ARE SEVERELY CORRODED WITH OBVIOUS SECTION LOSS. BASED UPON MY EXPERIENCE WITH A SIMILAR VEHICLE, A LINE FAILURE DUE TO RUPTURE IS IMMINENT AND ALL LINES NEED TO BE REPLACED. THIS WILL BE NEITHER AN EASY NOR AN INEXPENSIVE TASK. ADDING INSULT TO INJURY IS THAT GM DOES NOT OFFER REPLACEMENT LINE SETS; IT'S ROLL YOUR OWN OR BUY AN (INCOMPLETE) AFTERMARKET SET (NO ONE OFFERS COMPLETE SET FOR JL4 REAR BRAKE ARRANGEMENT). THIS REALLY IS RIDICULOUS GIVEN THE COST, AGE, MILEAGE AND OTHERWISE EXCELLENT CONDITION OF THE VEHICLE. *KB

WHILE APPROACHING A STOP SIGN, I TRIED TO BRAKE AND THE PEDAL WENT TO THE FLOOR. NO BRAKES!! I WAS ABLE TO COAST TO A STOP. UPON CHECKING, ALL BRAKE FLUID WAS GONE AND THE BRAKE LINES WERE ROTTED THROUGH. ALL BRAKE LINES HAD TO BE REPLACED ALONG WITH THE FRONT CALIPERS. CORROSION WAS THE PROBLEM WITH THE LINES AND CALIPERS.

FAILURE OF BRAKE LINE AND LOSS OF FLUID WITH NO WARNING LIGHT UNTIL PEDAL WENT ALL THE WAY TO THE FLOOR. MECHANIC HAS REPORTED SEVERE CORROSION OF THE BRAKE LINE, CALIPERS, SPARE TIRE ASSEMBLY AND NO ACCESS TO THE BRAKE LINE AREA ABOVE THE SPARE TIRE WITHOUT CUTTING THE SPARE TIRE HOLDER ASSEMBLY OUT. ESTIMATE IS OVER $1000 TO REPAIR. BRAKE FAILURE WITHOUT A WARNING - VERY SCARY. *TR

ON MY CHEVROLET SUBURBAN 2004; SPEEDOMETER FAILED. MY SPEEDOMETER DOES NOT WORK ANY MORE. IT NO LONGER CALCULATES SPEED. IT IS STUCK POINTING (RESTING) PAST FASTEST LABEL OF 120MPH. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE GAUGES IN THE INSTRUMENT PANEL WERE INOPERABLE. THE ALTERNATOR AND TEMPERATURE GAUGE WOULD DISPLAY THAT THE VEHICLE WAS OVERHEATING. THE DEALER DIAGNOSED THAT THE INSTRUMENT CLUSTER PANEL WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 67,000. THE VIN WAS UNAVAILABLE.

MY 2004 SUBURBAN IS EXTREMELY WELL CARED FOR. THE VEHICLE HAS ONLY 51,000 MILES AND IS KEPT IN PERFECT RUNNING AND PHYSICAL CONDITION. ON 10/8/2011 I WAS PERFORMING AN EXTENSIVE VISUAL CHECK OF THE BRAKE LINE ON THE VEHICLE AFTER READING OF SOME ISSUES WITH SIMILAR VEHICLE. UPON INSPECTION, I SAW THAT THE BRAKING SYSTEMS HYDRAULIC LINES ARE SEVERELY CORRODED IN MULTIPLE AREAS. THESE LINES MUST BE REPLACED TO AVOID CATASTROPHIC FAILURE. ON A VEHICLE OF THIS AGE AND LIMITED MILEAGE THIS IS HIGHLY WORRISOME. I HAVE MULTIPLE OTHER VEHICLES OF CONSIDERABLY GREATER MILEAGE AND OF OLDER VINTAGE THAT HAVE NOT HAD THIS CORROSION ISSUE. I MENTION THEM BECAUSE THEY HAVE SPENT THEIR ENTIRE SERVICE LIFE, TO DATE, IN THE SAME WEATHER/DRIVING CONDITIONS. THERE IS NO QUESTION THAT THE MATERIALS USED FOR THESE BRAKE LINES ARE OF AN INFERIOR MATERIAL. A RECALL IS ABSOLUTELY IN ORDER AS THIS IS AN EXPENSIVE AND TIME CONSUMING REPAIR THAT IS THE RESULT OF POOR QUALITY PARTS. *KB

BACKING UP SNOWMOBILE TRAILER WHEN BRAKE PEDAL WENT TO FLOOR. LARGE PUDDLE UNDERNEATH TRUCK RIGHT BELOW WHERE THE 4 BRAKE LINES EXIT THE ABS AND GO OVER THE FRAME RAIL. *KB

THE VEHICLE WILL SHUT OFF AT INTERSTATE AND LOW SPEEDS AND SHOW REDUCED POWER AND STABILITY SYSTEM DISABLED. THIS IS VERY DANGEROUS, I WAS NEARLY KILLED ON THE INTERSTATE BY AND 18 WHEELER COMING UP BEHIND ME WHEN THE ENGINE SHUT DOWN.. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 2500. WHILE DRIVING APPROXIMATELY 50 MPH UP AN INCLINE, THE BRAKE WAS APPLIED AND SUDDENLY THE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE FAILED TO SLOW DOWN AND THE EMERGENCY BRAKE WAS ENGAGED TO SLOW THE VEHICLE. THE VEHICLE WAS TAKEN TO A NEARBY INDEPENDENT MECHANIC WHO ADVISED THAT THE FOUR BRAKE LINES RUPTURED DUE TO RUST AND CORROSION. THE VEHICLE WAS LEFT FOR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

WHEN DRIVING IT WILL TRY AND ENGAGE THE 4 WHEEL DRIVE LOW. IT HAPPENED A YEAR AGO AND THEN AGAIN THIS WEEK. *TR

AT RANDOM YOU WILL JUST BE DRIVING DOWN THE ROAD AND A MESSAGE COMES ON THAT SAYS REDUCE ENGINE POWER AND THE T/C LIGHT COMES ON ALONG WITH THE CHECK ENGINE LIGHT. THIS HAS HAPPENED SEVERAL TIMES, IS VERY UNSAFE, AND IS GETTING WORSE. WE HAVE HAD WORK DONE TO TRY AND FIX THE PROBLEM BUT ITS STILL HAPPENING. WE DON'T HAVE TONS OF MONEY TO FIX THIS, LIVE IN THE COUNTRY, AND HAVE 5 KIDS. THIS IS OUR ONLY TRANSPORTATION AND WE HAVE A RATHER LARGE LOAN ON THE THING AND ITS TURNING INTO YARD ART. *TR

2004 CHEVROLET SUBURBAN GOES INTO REDUCED POWER ENGINE W/O REASON CHANGE THE ENGINE, BECAUSE HIGH MILES, CHANGE TRANSMISSION, CHANGE THROTTLE BODY,CHANGE GAS PEDAL MODULE, CHANGE CATALYTIC CONVERTER SPEND OVER 4,000 ON THE TRUCK WITHOUT COUNTING THE ACCIDENT CAN OCCUR IN THE INTERSTATE 78 WEST BECAUSE OF THE LOST OF POWER, DEALERS DON'T KNOW WHAT IS THE PROBLEM NEITHER THE LOCAL MECHANICS CAN YOU PLEASE TAKE ACTION IN THIS MATTER AND READ AT EDMONDS.COM AND SEE ALL THE COMPLAINS ABOUT THE SAME PROBLEM

WITH CRUISE CONTROL ON AT 70MPH, ATTEMPTED TO CHANGE FROM LEFT TO RIGHT LANE. ANOTHER CAR SPED UP THE RIGHT LANE TO PASS ME. TURNED STEERING WHEEL BACK TO LEFT LANE AND SUDDENLY HAD NO CONTROL OVER STEERING, BRAKING AND THE STEERING WHEEL STARTED VIOLENTLY SHAKING. CAR ROLLED TWICE, OVER METAL MEDIAN AND TURNED 180 DEGREES FACING THE OPPOSITE DIRECTION ON THE INTERSTATE W/ ROOF CRUSHED IN. NEITHER SIDE OR FRONT AIR BAGS DEPLOYED. FRONT AND SIDES SMASHED IN AND FRAME BENT. VEHICLE WAS DEEMED TO BE TOTALED BY STATE FARM. HAVE BEEN DRIVING 40 YEARS AND HAVE NEVER HAD AN ACCIDENT IN MY LIFE. ONLY GOOD THING WAS THE SEATBELT HELD TIGHT AS I WAS HANGING UPSIDE DOWN WHEN THE CAR FINALLY STOPPED. THE DAY BEFORE THIS OCCURRED I NOTICED THAT THE STABILITY CONTROL SYSTEM WOULD RANDOMLY ENGAGE DURING STRAIGHT DRIVING ON A PERFECTLY DRY SURFACE. I PURCHASED THIS VEHICLE BRAND NEW FROM THE DEALER IN 2004 AND THE CAR WAS METICULOUSLY MAINTAINED. (IT LOOKED BRAND NEW). *TR

I STARTED THE HOMEWARD SEGMENT OF AN 800 MILE TRIP ON JULY 4TH WEEKEND. SPEEDOMETER APPEARS TO BE WORKING CORRECTLY BECAUSE I MADE IT THROUGH THE FIRST POLICE RADAR CHECKPOINT WITHOUT ANY PROBLEMS. I EXITED THE INTERSTATE AND ENTERED A 4 LANE HIGHWAY. AFTER DRIVING AN ESTIMATED 50 MILES FOR THE DAY I WAS STOPPED BY THE STATE POLICE. HE SAID THAT HIS RADAR HAD ME GOING 74 IN A 55 SPEED ZONE WHEN ME SPEEDOMETER INDICATED 55 MPH. WHEN THE OFFICER INFORMED ME OF MY SPEED, I LOOKED AT MY SPEEDOMETER AND SAW THE NEEDLE WAS BELOW 0 MPH. THE SCARY PART OF THIS IS THAT I DID NOT REALIZE THAT I WAS GOING OVER THE SPEED LIMIT, PROBABLY BECAUSE I WAS ACCLIMATED TO THE HIGHER INTERSTATE SPEED, MY SPEED ODOMETER INDICATED I WAS TRAVELING THE SPEED LIMIT, AND UP UNTIL THIS TIME I HAD NO INDICATION THAT MY SPEEDOMETER WAS NOT WORKING PROPERLY. I CONTINUED WITH THE TRIP AND USED MY GPS TO KEEP ME AT A SAFE SPEED THE REST OF THE TRIP. I COMPARED THE SPEEDOMETER MPH WITH THE GPS MPH MANY TIMES THROUGHOUT THE REST OF THE TRIP. THE SPEED ODOMETER WENT DOWN TO 0 MPH WHEN I WAS DRIVING 65 MPH AFTER DRIVING AN ESTIMATED ADDITIONAL 40 MILES. AFTER DRIVING AN ADDITIONAL 30 MILES THE SPEED ODOMETER WAS INDICATING THE CORRECT SPEED. THE SPEEDOMETER MALFUNCTIONED ABOUT 70% OF THE TRIP. IT WOULD ALTERNATE BETWEEN NOT WORKING CORRECTLY AND WORKING CORRECTLY THROUGHOUT THE TRIP. I TOOK THE VEHICLE TO THE CHEVY DEALER THE FIRST BUSINESS DAY BACK HOME. THE DEALER SAID THE WHOLE INSTRUMENT CLUSTER MUST BE REPLACED. I AUTHORIZED THE DEALER TO REPLACE THE INSTRUMENT CLUSTER AND THE DEFECTIVE INSTRUMENT CLUSTER IS GOING BACK TO BE REFURBISHED. THIS FAILURE COMPROMISED NOT ONLY MY SAFETY BUT ALSO MY FAMILY'S SAFETY AND THE SAFETY OF OTHER DRIVERS. RESEARCHING THE INTERNET, I AM FINDING THIS PROBLEM SEEMS TO BE WIDESPREAD. *TR

WHILE DRIVING AT APPROXIMATELY 65 MPH ON AN INTERSTATE, THE SUN ROOF ON MY 2004 CHEVROLET SUBURBAN RIPPED OFF NARROWLY MISSING THE CAR FOLLOWING US. THE SUN ROOF WAS CLOSED AT TIME OF THE INCIDENT. OTHER THAN WHAT SOUNDED LIKE AN AIR LEAK, THERE WAS NO WARNING OR OTHER INDICATION OF PROBLEMS. THE SUN ROOF HAS RARELY BEEN OPENED SINCE THE CAR WAS PURCHASED AND DEFINITELY HAD NOT BEEN OPENED IN THE PAST 2 YEARS AT LEAST. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 1500. WHILE DRIVING APPROXIMATELY 35 MPH THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE IT FELL TO THE FLOOR BOARD. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIANS STATED THE BRAKE LINE FAILED DUE TO AN ENVIRONMENTAL CLIMATE DAMAGE. THE BRAKE LINE WAS REPLACED WITH STAINLESS STEEL BRAKE LINES. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 71,920. UPDATED 08/05/11*LJ UPDATED 3/02/2012 *LN

I HAVE A 2004 CHEVY SUBURBAN WITH 93409 MILE, HAS BEEN WELL TAKEN CARE OF. A FEW MONTHS AGO I NOTICE IT WAS HAVING A HARD TIME STARTING. LAST WK WE RAN OUT OF GAS AT 1.4 TANK AND THIS WEEKEND WHILE THE FAMILY WAS ON A TRIP PULLING A TRAILER WE RAN OUT OF GAS AT 1/2 TANK, IF YOU GO BY THE GAS GAGE. WE COULD HAVE BEEN BADLY HURT IF WE WERE ON A HILL, OR SOMETHING WHEN WE ALL OF A SUDDEN HAVE NO POWERSTEERING, BRAKES, ETC. *TR

INSTRUMENT CLUSTER FAILED .TOOK VEHICLE TO DEALER ,THEY WANTED $500 TO REPLACE. TOOK IT BACK SEVERAL MONTHS LATER AND TRIED TO NEGOTIATE A LOWER PRICE AND ALSO FOUND THAT THIS HAS BEEN A WIDESPREAD PROBLEM AND THAT SOME CUSTOMERS REPORT ONLINE THAT THEY HAVE GOT THE DEALER TO REPLACE AT NO COST. MY CLUSTER HAS NOT BEEN REPAIRED AND I AM SEEKING TO HAVE GM REPAIR IT FOR FREE.. *TR

SPEEDOMETER BEGAN READING INCORRECTLY, PEGGED OUT AT MAXIMUM, DRIFTS AIMLESSLY, THEN STICKS AGAIN. CANNOT GET SPEEDOMETER TO RESET OR READ CORRECTLY. *TR

OUR 2004 CHEVROLET SUBURBAN LT HAS APPROXIMATELY 115K MILES. PERIODICALLY THE ENTIRE INSTRUMENT CLUSTER, WITH THE EXCEPTION OF A COUPLE OF LIGHTS, STOPS WORKING. NO GAUGES, NO SPEEDOMETER, ETC. SOMETIMES WHEN THIS HAPPENS THE DRIVER INFORMATION CENTER DISPLAYS STRANGE AND RANDOM CHARACTERS, SOMETIMES THE DIC SECTION IS ALL BLUE, AND SOMETIMES IT IS BLANK. I HAVE TRIED DISCONNECTING THE BATTERY TO RESET THE COMPUTER. THIS SEEMED TO WORK ONE TIME, BUT THE REST OF THE TIME THIS HAD NO EFFECT. THERE DOESN'T SEEM TO BE ANY PATTERN (DAY/NIGHT, HOT/COLD, ETC.) AS TO WHEN THIS MALFUNCTION WILL OCCUR, OR WHEN IT WILL RETURN TO NORMAL. WE ARE IN DAY 2 OF AN INSTRUMENT PANEL FAILURE AT THIS TIME. *TR

THE SPEEDOMETER IS COMPLETELY GONE ALONG WITH SEVERAL GAUGES SUCH AS THE OIL, GAS, AND RPM METERS. I AM UNABLE TO TELL HOW MUCH GAS I HAVE OR HOW FAST I AM GOING. THIS HAS HAPPENED A LOT TO THESE VEHICLES OVER THE PAST 10 YEARS. GM OFFERED A REPAIR BUT ONLY FOR VEHICLES WHO WERE NOT OVER A CERTAIN MILEAGE. THIS IS A SAFETY ISSUE AND NEEDS TO BE REPAIRED IN ALL VEHICLES. ADDITIONAL, THE ELECTRICAL SYSTEM IS OUT OF WHACK. MY HEATED SEATS TURN ALL THE WAY UP TO HIGH WITHOUT ME PRESSING ANYTHING. MY TV SYSTEM IS NOT WORKING. EVERYTHING SEEMS TO BE FALLING APART. *TT

TL*THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 3-5 MPH THE VEHICLE STALLED. THE WARNING LIGHT DISPLAYED REDUCED ENGINE POWER. SHE ENGAGED HER HAZARD LIGHTS AND PULLED OVER TO THE RIGHT SIDE OF THE ROAD. SHE TURNED THE VEHICLE OFF AND WAITED A FEW SECONDS AND WAS ABLE TO RESTART IT. WHEN SHE RESTARTED THE VEHICLE THE REDUCED ENGINE LIGHT WAS STILL ON AND SHE TURNED THE VEHICLE OFF AGAIN AND RESTARTED IT. THE VEHICLE BEGAN TO FUNCTION NORMALLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 104,788.

GAUGE FAILURE, SPECIFICALLY THE SPEEDOMETER, ON THE INSTRUMENT PANEL. THE SPEEDOMETER WORKS INTERMITTENTLY AND ALSO GETS STUCK AT A SPEED > THAN 75 MPH WHEN MY VEHICLE IS GOING MUCH SLOWER THAN THAT AND THEN REGISTERS > 120MPH WHEN I AM GOING AROUND 60-65 MPH. *TR

TRANSFER CASE HAD TO BE REPLACED BEFORE 70000 MILES DUE TO BEARING. PASSENGER AIR WENT OUT AND ONLY BLEW HOT AFTER A BATTERY CHANGE, HAD TO REPLACE ENTIRE AIR SYSTEM. AIR SYSTEM WENT OUT AGAIN WITH 2ND BATTERY REPLACEMENT, BUT DEALER WAS ABLE TO "RESET" IT. SPEEDOMETER ONLY WORKS SOMETIMES. BINDING NOISE IN STEERING COLUMN , HAS BEEN LUBED NUMEROUS TIMES WHILE WAITING FOR CHEVY TO ISSUE A RECALL ACCORDING TO DEALER. THIS VEHICLE IS DRIVEN UNDER 15000 MILES A YEAR. *TR

WE HAD TO CHANGE A REAR DRIVER SIDE TIRE BECAUSE WE NEEDED TO ADD AIR TO THE TIRE AND THE SENSOR CONTROL WAS BROKEN. WE TOOK THE TIRE OFF AND REPLACED IT WITH THE SPARE. WHEN RETRIEVING THE SPARE WE HAD A VERY DIFFICULT TIME GETTING IT OFF THE SPARE TIRE HOLDER WINCH. AFTER STRUGGLING WITH THE SPARE TIRE FOR 30 MINUTES WE GOT IT RELEASED AND WHEN WE TRIED TO HOIST THE WINCH BACK UP, IT WOULD NOT GO UP. WE TRIED REPEATEDLY FOR ANOTHER 30 MINUTES WITHOUT ANY SUCCESS. WE HAD TO REMOVE THE ENTIRE TIRE WINCH HOLDER PART SO IT WOULDN'T HANG DOWN WHILE DRIVING. I HAVE BEEN CALLING ALL MORNING TO TRY TO FIND THE PART AND DRAPER CHEVROLET SAID THEY HAVE HAD A LOT OF PROBLEMS WITH THIS PART BUT MAINLY WHEN CUSTOMERS ARE TRYING TO RETRIEVE THE TIRE. MY INCIDENT IS DIFFERENT SINCE IT WOULDN'T GO BACK UP. DRAPER CHEVROLET DID NOT HAVE THIS PART IN STOCK AND I HAVE BEEN CALLING SALVAGE SHOPS AS WELL WITHOUT ANY SUCCESS. I AM CURRENTLY DRIVING WITHOUT A SPARE AND I DRIVE 60 MILES A DAY ON THE HIGHWAY AND THIS IS UNSAFE TO BE DRIVING WITHOUT A SPARE TIRE BECAUSE THE OTHER TIRES SENSOR STEM BROKE ON ITS OWN. WHEN CALLING DRAPER CHEVROLET THEY SAID THE PART COST $170.42 NEW BUT THEY DO NOT HAVE THE PART IN STOCK. I WORK 8:30 A.M. TO 6:00 P.M. MONDAY THRU FRIDAY AND CAN ONLY TAKE CARE OF THIS ON THE WEEKEND. WHICH THIS WEEKEND IS CHRISTMAS DAY. I HOPE YOU UNDERSTAND MY PREDICAMENT AND CAN HELP ME IN SOME WAY TO RECTIFY THIS PROBLEM. I COME FROM A GENERAL MOTORS FAMILY AND HAVE ALWAYS BEEN ABLE TO COUNT ON GENERAL MOTORS DOING THE RIGHT THING. THANK YOU FOR YOUR CONSIDERATION. *TR

INSTRUMENT CLUSTER FAILED AFTER EXTREME COLD TEMPERATURES, FUEL GAUGE, TEMPERATURE GAUGE, OIL PRESSURE GAUGE AND BATTERY CHARGING SYSTEM GAUGE. GM KNOWS ABOUT THE FAULTY GAUGES AND AS OF THIS DATE HAS NOT MADE A RECALL OF THE INSTRUMENT PANEL. CONSIDERING ALL LEGAL REMEDIES AFFORDED BY LAW AS THIS IS A PROBLEM THAT CAN BE RECTIFIED BY GM BY REPLACING THE AFOREMENTIONED FAULTY FACTORY EQUIPMENT. *TR

THE SPEEDOMETER QUITS WORKING OR GETS JUMPY AND SPORADIC IN WHEN AND HOW IT WORKS. VEHICLE ONLY HAS 57000 MILES ON IT. THE ONLY EVENT THAT WE THOUGHT CAUSED IT WAS THE REALLY COLD TEMPERATURES BUT ITS WARMER NOW AND COMPLETELY QUIT WORKING. IT IS EVERYTIME WE ARE IN THE VEHICLE DRIVING THAT IT DOESN'T WORK. WE HAVE NOT GOT IT FIXED YET. RESEARCHING PROBLEM FIRST TO MAKE SURE NO RECALLS WERE DONE ON IT FIRST. *TR

DRIVING DOWN THE ROAD ONE DAY AND REDUCED ENGINE LIGHT COMES ON. MY SUBURBAN SLOWS TO ABOUT 35MPH AND WILL NOT GO ANY FASTER. THIS OCCURS ABOUT 15 TIMES A MONTH. I AM CONCERNED ABOUT PEOPLE DRIVING BEHIND ME WHEN IT COMES TO A SUDDEN SLOW IF I CAN NOT GET OFF THE ROAD. WE HAVE BROUGHT IT TO A DEALERSHIP 3 TIMES. THEY DID NOT KNOW WHAT WAS WRONG. WE HAVE CHANGED THE THROTTLE PEDAL POSITIONING SENSOR, MAP SENSOR, CRANK SENSOR, KNOCK SENSOR, SPARK PLUGS, SPARK PLUG WIRES. NOTHING HAS WORKED. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE SPEEDOMETER GAUGE AND FUEL GAUGE WOULD NOT DISPLAY AN ACCURATE READING WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TESTING WHERE THEY DETECTED THAT THE NEEDLE WITHIN BOTH GAUGES WAS STUCK AND INFORMED THAT THE INSTRUMENT PANEL WOULD NEED TO BE REPLACED TO CORRECT THE PROBLEM. THE MANUFACTURER PREVIOUSLY ISSUED A VOLUNTARY RECALL ASSOCIATED WITH THE INSTRUMENT PANEL HOWEVER THE CONTACT DID NOT RECEIVE THE NOTIFICATION. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE EXCESSIVE MILEAGE, ALTHOUGH THE MANUFACTURER STATED THAT THEY WOULD CONSIDER EXTENDING THE SPECIAL COVERAGE UNDER THE RECALL. THE CONTACT WAS WAITING UPON A RESPONSE FROM THE MANUFACTURER REGARDING THE REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE FUEL GAUGE WAS READING INACCURATELY AND HE WAS UNABLE TO DETERMINE HOW MUCH FUEL WAS IN THE VEHICLE. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 95,000 AND THE FAILURE MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE.

2004 CHEVROLET SUBURBAN AIR CONDITIONING INTERMITTENTLY BLOWS HOT AIR ONLY ON THE DRIVER'S SIDE USING THE DUAL ZONE AC CONTROL. GM HAS NO IDEA HOW TO FIX THIS ISSUE. WHILE RESEARCHING FOUND THOUSANDS OF CHEVY OWNER ALL WITH THE SAME COMPLAINT AND WITH NO REAL FIX. THERE SEEMS TO BE SOME CONNECTION BETWEEN THE BATTERY/LOSS OF POWER AND THE CLIMATE CONTROL MODULE BEING DEFECTIVE. *TR

SPEEDOMETER QUIT WORKING CORRECTLY IT DOES NOT GO BELOW 42 MPH AND SOMETIMES WILL NOT GO BELOW 90 MPH. *TR

FORWARD BRAKE LINES COMPLETELY RUSTED THROUGHOUT WHICH LED TO A LEAK AND SUBSEQUENT BRAKE FAILURE. OTHER BRAKE COMPONENTS WERE ALSO FOUND TO BE RUSTED SOMEWHAT PREMATURELY. *TR

2004 CHEVY SUBURBAN W/80,000 MI. USED FOR TOWING RV-"REDUCED ENGINE POWER". CODES ARE NOT SPECIFIC FOR THE PROBLEM AND MULTIPLE REPAIRS HAVE NOT FIXED PROBLEM. THIS IS AN EXTREME HAZARD WHEN TOWING AS RIG CANNOT MOVE OFF THE ROAD WITH SO LITTLE POWER. I AM READING MANY POSTS ONLINE FOR THE SAME ISSUE. *TR

SPEEDO DOES NOT READ CORRECT, IT GETS STUCK AT VARIOUS NUMBERS...WHILE DRIVING OR PARKED ON OR OFF (SPEED CAN BE PLUS OR MINUS ACTUAL SPEED BY 5-55 MPH AT ANY GIVEN TIME. AND YOU NEVER KNOW WHEN, ALSO THE OIL PRESSURE GAUGE WILL GO PAST THE MARKED LIMIT WHEN THE TRUCK IS OFF, NO KEY IN THE IGNITION. *TR

SPEEDOMETER HAS COMPLETELY FAILED ON MY 2004 CHEVROLET SUBURBAN. THIS IS A KNOWN, WIDESPREAD PROBLEM THAT GM REFUSES TO ACKNOWLEDGE AS A SAFETY ISSUE ... AND REFUSES TO MAKE GOOD ON ... DESPITE THE FACT THAT THEY HAVE ALREADY BEEN COMPENSATED BY THE PARTS SUPPLIER. IT'S TIME FOR THE DEPARTMENT OF TRANSPORTATION TO STEP IN, DECLARE THIS AS A SAFETY ISSUE (WHICH IT IS), AND ENCOURAGE GENERAL MOTORS TO MAKE GOOD ON THESE FAULTY PARTS ... IRRESPECTIVE OF THE ARBITRARY MILEAGE CUTOFF THEY HAVE IMPOSED. ADDITIONAL BACKGROUND ON THE ISSUE, FROM A MEDIA SOURCE... HTTP://WWW.WTHR.COM/GLOBAL/STORY.ASP?S=7434450. *TR