2004 Chevrolet Trailblazer Complaint Log

I was driving and a girl pulled out from a stop sign and hit my passenger side front of my trailblazer. Her airbags deployed immediately, meanwhile mine didn't deploy. My husband saved my face by throwing his arm over me!

The contact owns a 2004 Chevrolet Trailblazer. The contact stated while driving at various speeds, the headlights became inoperable. After a while, the headlights became operational. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 189,000.

The contact owned a 2004 Chevrolet Trailblazer. The contact stated that while driving at an undisclosed speed, there was smoke coming from the rear passenger side. The contact pulled over and noticed that underneath the rear passenger's seat had caught fire. The fire department was able to extinguish the fire. The contact sustained burns to his left shoulder, hands, and elbows. However, no medical treatment was received. A police report was filed. The contact was unaware if there was a fire department report. The vehicle was towed to a tow yard and deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000. Vehicle caught on fire on the inside driving.

The contact owns a 2004 Chevrolet Trailblazer equipped with Hankook tires Model:Dynapro HT Tire Size: P245/70R16 Dot Number:Unknown. The contact stated that she had both rear tires, driver side and passenger side, replaced with the Hankook tires by an independent mechanic. After the instillation, the contact stated that the vehicle would shake while driving at various speeds without warning . The vehicle was taken to another independent mechanic who inspected the tires and made adjustments; however, the shaking persisted. While driving at 65 MPH, the lost control of the vehicle's steering as the vehicle began to abruptly fishtail. As the vehicle continued to spin out of control, the contact was able to stop the vehicle moments before the vehicle hit a highway barrier. The contact discovered that the rear driver side tire tread had separated from the rim of tire. Due to the failure, the contact had the tire replaced with a spare and was able to drive the vehicle home. The contact called the place where the tires were purchased; they offered no assistance and stated they were no responsible for the failure. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The tire failure mileage was approximately 1,700. The vehicle failure mileage was approximately 89,000.

FUL PUMP

Electronic throttle body? No throttle control, motor will only idle, turn ignition switch off, then restart it will run. Reduced Engine Power light comes on. Happens for no apparent reason. Very unsafe situation.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THE HE NOTICED A FUEL ODOR EMITTING FROM UNDERNEATH THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE FUEL MILEAGE HAD ALSO DECREASED WHEN DRIVING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO HAVE AN EVAP SMOKE TEST PERFORMED ON HIS VEHICLE. THE RESULT OF THE TEST DISCOVERED THAT A CRACK HAD FORMED ON THE FUEL NECK THAT CONNECTS TO THE FUEL TANK, WHICH WAS THE CAUSE OF THE FAILURE. THE CONTACT THEN SPOKE WITH J.B.A. CHEVROLET (7327 RITCHIE HWY, GLEN BURNIE, MD 21061) WHERE HE WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 126,432.

AS YOU COME TO A COMPLETE STOP OR GO UNDER 5 MPH, THE VEHICLE'S OIL GAUGE WILL GO ALL THE WAY DOWN. ONCE YOU ACCELERATE, THE OIL GAUGE GOES BACK TO NORMAL. WHEN PUMPING GAS INTO THE VEHICLE, THE GAS PUMP WILL RESET AS IF THE GAS TANK IS FULL BUT THE GAUGE SHOWS IT'S HALF EMPTY. *TR

TL* THE CONTACT'S SON OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW LOOKED ABNORMAL. WHEN THE DOOR WAS OPENED, THE CONTACT NOTICED THAT THE DRIVER'S SEAT HAD CAUGHT FIRE AND EXTINGUISHED ITSELF OUT. FIRE AND POLICE REPORTS WERE NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER INFORMED THE CONTACT THAT THERE WAS NO RECALL TO PROVE THAT THE MALFUNCTION WAS A MANUFACTURER DEFAULT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 190,000. *LN PHOTOS ATTACHED. *JB

WELL I HIT A TREE AN THE AIRBAGS DIDN'T DEPLOYED BUT THE AIRBAG LIGHT IS ON

WHEN DRIVING OUR VEHICLE FROM MYRTLE BEACH THIS WEEK WE NOTICED A SMELL ABOUT HALF WAY HOME THAT REEKED OF ROTTEN EGGS. THE SMELL WAS SO BAD THAT I BECAUSE NAUSEOUS AND DEVELOOED A SEVERE HEADACHE. AFTER WE REACHED OUR HOUSE AND SHUT OFF THE VEHICLE THE NEXT DAY I TRIED TO CRANK THE VEHICLE AND IT WOULD NOT CRANK SO AFTER RESEARCHING THE SMELL AND POSSIBLE CAUSES WE BOUGHT A NEW BATTERY FOR THE VEHICLE AND CHANGED THE BATTERY OURSELVES WHICH CAUSED MY HUSBAND TO DEVELOP A SEVERE COUGH AND UPPER RESPITORY PROBLEMS DUE TO THE BOILING THAT WAS OCCURING INSIDE THE BATTERY. HENCE THE SMELL OF ROTTEN EGGS.

SMELL OF GAS WHEN DRIVING VERY STRONG MUST DRIVE WITH WINDOW OPEN

MY CLUSTERBOARD IS COMPLETELY NON FUNCTIONING THE READINGS ARE NOT WORKING

ACCELERATING ON IT'S OWN AND IDLING

TAKATA RECALL/ I WAS IN A ACCIDENT AND MY AIR BAGS NEVER WENT OFF WHY IS THAT I THOUGHT IT WAS A SAFTEY FEATURE?

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT WHILE THE BRAKES WERE BEING SERVICED BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE ENTIRE FRONT END FRAME WAS RUSTED. THE DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,542.

THE CABIN SMELLS VERY STRONGLY OF GAS AND AS IS LEAKING FROM UNDER THE VEHICLE WHEN DRIVEN.

BRAKE LIGHTS FLICKER OFF AND ON. WHEN THE VEHICLE IS IN MOTION AND BRAKES ARE PRESSED, THE BRAKE LIGHTS DO NOT LIGHT UP. THIS CONTINUES TO HAPPEN WITH A NEW LIGHT BULB PLACED IN.

"TAKATA RECALL" I WAS RECENTLY IN A CAR ACCIDENT THAT WAS LISTED IN THE POLICE REPORT AS A HEAD ON COLLISION AND NOT ONE AIRBAG DEPLOYED. THE IMPACT AS I WAS TOLD WAS HARD ENOUGH THAT THE AIRBAGS SHOULD HAVE DEPLOYED.

ALL LIGHTS STOPPED WORKING, EXCEPT WHEN SWITCHING TO HIGH BEAMS. FRONT LIGHTS AND BRAKE LIGHTS DO NOT WORK. WHEN USING THE HIGH BEAMS, THE FRONT LIGHTS OPERATE ON HIGH ONLY. THE CAR CANNOT BE SAFELY DRIVEN AT NIGHT.

RUSTED FUEL LINES- GARAGE CHECKED STRONG FUEL SMELL AND DISCOVERED RUSTED FUEL FILLER AND LINES

2004 CHEVY TRAILBLAZER KEEPS GETTING CAM POSITION SENSOR FAULT. CAUSING CHECK ENGINE LIGHT TO COME ON. SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL. WE HAVE REPLACED THIS PART THREE TO FOUR TIMES ON OUR TRUCK. TRUCK BEGAN TO RUN ROUGH ENGINE KNOCKED AND HAD REDUCED POWER.

THE SAME THING RUNNING OFF THE FUSE TO THE CPU GROUNDS OUT ON THE BODY BLOWING THE FUSE MAKING IT SEEM LIKE THE CPU IS BAD. I WENT AND STARTED IT AND PUT IN DRIVE, FUSE BLEW, AND THE ENGINE SHUT DOWN

1 OWNER VEHICLE - BOUGHT IN 2004 & HAD 8 MILES ON IT. HAS BEEN VERY WELL KEPT & CURRENTLY HAS ONLY 65,000 MILES ON IT AS OF 9/16/19. AS OTHERS, THE ELECTRICAL CLUSTER HAS MALFUNCTIONED. SPEEDOMETER QUIT WORKING OVER A YEAR AGO & NOW THE FUEL GAUGE HAS FAILED. PROBLEM IS WITH THE CLUSTER AS "ESTIMATED MILEAGE" STILL WORKS. HAVE NOTICED THAT OTHER GAUGES ACT ERRATIC AT TIMES. THIS HAS BEEN AN ONGOING ISSUE THAT CHEVY IS WELL AWARE OF YET FAIL TO ACT. TO TB TO DEALER FOR REPAIRS THEY STATED THERE IS NO RECALL. COST OUT OF MY POCKET FOR REPAIR WILL BE OVER $800.00. SPEEDOMETER ORIGINALLY FAILED WHILE DRIVING ON HWY. IT STARTED TO WORK AGAIN BUT FAILED AGAIN WHILE DRIVING ON THE HWY A FEW WEEKS LATER. FUEL GUAGE SIMPLY STOPPED WORKING AFTER STARTING VEHICLE.

AFTER STARTING MY 2004 CHEVY TRAILBLAZER THE GAUGES ON THE INSTRUMENT PANEL DID NOT WORK. BUT THE ABS, SEAT BELT, BREAK AND CHECK ENGINE LIGHTS ARE ON. THE INDICATOR FOR GEARS IS OUT. THE SPEEDOMETER JUMPS SO NOT ALWAYS SURE HOW FAST I'M GOING. I HAVE ONLY OWNED THIS VEHICLE FOR A SHORT TIME. BUT AFTER SOME RESEARCH I HAVE DISCOVERED THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING APPROXIMATELY 45 MPH, THE LOW BEAM HEADLIGHTS WENT OUT WITHOUT WARNING. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE; HOWEVER, THEY REPLACED THE FRONT PANEL SWITCH AND CONNECTOR. THE FAILURE RECURRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 146,577.

DRIVING CONDITIONS DARK, 11PM, UNLIT, STARS VISIBLE PAVED COUNTRY ROAD WITH HILLS, CURVES AND 2-5 FOOT DITCHES. WEATHER WET BUT DRYING. VISIBILITY GOOD. VEHICLE IN MOTION NEAR LEGAL SPEED LIMIT 80 KM/HR. OCCASIONAL ONCOMING TRAFFIC, SO OCCASIONALLY SWITCHING BETWEEN LOW AND HIGH BEAMS. NOTICED LOW BEAM HEADLIGHTS FLICKERED OCCASIONALLY. EFFECT WAS ONLY VISIBLE AFTER ONCOMING TRAFFIC HAD PASSED, BEFORE SWITCHING BACK TO HIGH BEAM HEADLIGHTS. I HAD ATTRIBUTED THE EFFECT TO MY EYES ADJUSTING AFTER THE ONCOMING HEADLIGHTS. ON ONE OCCASION, AFTER THE ONCOMING VEHICLE HAD PASSED, I SWITCHED BACK TO LOW BEAM SETTING, BUT THE LOW BEAM HEADLIGHTS WERE NOT ILLUMINATING THE ROAD AT ALL. ALL I COULD SEE WAS A SMALL AMOUNT OF YELLOWISH LIGHT OFF TO THE SIDES OF THE VEHICLE FROM THE OTHER RUNNING LIGHTS, INCLUDING YELLOW LIGHTS ON THE SIDE-VIEW MIRRORS. THERE WAS INSUFFICIENT LIGHT TO SEE ANY DISTANCE DOWN THE ROAD, SO I CEASED TO DEPRESS THE ACCELERATOR PEDAL, AND COVERED THE BRAKE APPLYING GENTLE BRAKING. I STILL HAD MY FINGERS ON THE LEVER AND WAS ABLE TO SWITCH BACK TO HIGH BEAMS AFTER SEVERAL SECONDS. FORTUNATELY THE HIGH BEAMS STILL WORKED. I BROUGHT THE VEHICLE TO A STOP AT THE NEXT AVAILABLE SAFE OPPORTUNITY, TO ASSESS WHAT HAD HAPPENED. ALL OTHER LIGHTS, INCLUDING THE FOG LIGHTS WERE WORKING. I DROVE AT REDUCED SPEED ALTERNATELY USING THE FOG LIGHTS AND HIGH BEAMS. THE LOW BEAMS OCCASIONALLY STARTED WORKING AGAIN. BY THE TIME I WAS HOME, THEY HAD CEASED TO WORK. I REPLACED THE GM HDM MODULE, AND THE LOW BEAMS WORKED FOR A YEAR OR SO UNTIL THAT MODULE FAILED. THERE IS A RECALL TO REPLACE GM HDM 15016745 WITH GM HDM 13506836 BUT THE RECALL APPARENTLY DOES NOT APPLY TO MY 2004 MODEL YEAR. NHTSA RECALL NO. : 15V-519 MANUFACTURER RECALL NO. : 14291 I CONSIDER THIS TO HAVE BEEN A SEVERE LIFE THREATENING EVENT.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING 45 MPH, THE CONTACT DETECTED A FUEL ODOR COMING THROUGH THE VENTS. THE CONTACT MENTIONED THAT THE CHECK ENGINE INDICATOR ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT ALSO STATED THAT THE INSTRUMENT PANEL DID NOT ILLUMINATE AND THE SPEEDOMETER DID NOT OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 153,000.

TRANSMISSION OIL COOLER LINES ARE CORRODED TO THE POINT WHERE THEY ARE LEAKING FLUID AND THE VEHICLE ONLY HAS 130000 MILES ON IT.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY RUSTED. THE CONTACT BECAME AWARE OF THE CORROSION BY VISIBLY INSPECTING THE VEHICLE. THE CONTACT STATED THAT THE REAR STABILIZER BAR WAS TOTALLY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE SUBFRAME THAT SUPPORTED THE REAR SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 8-4669457241. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

THE LOW BEAM HEADLIGHTS BURN OUT WHILE DRIVING THE VEHICLE. THIS HAS HAPPENED 3 TIMES IN THE LAST 6 MONTHS. ALL 3 TIMES BOTH LOW BEAM BULBS BURN OUT AT THE SAME EXACT TIME WHILE TRAVELING ON A RURAL ROAD IN NH..

FUEL PRESSURE REGULATOR IS LEAKING

MY GAUGES RANDOMLY SAY LOW OIL PRESSURE BUT THERE IS NO PROBLEM AND SENSOR WAS REPLACED. NOW THE ENTIRE INSTRUMENT PANEL IS DEAD.

STRONG SMELL OF RAW GAS

MY FAMILY WAS DRIVING HOME ON THE FREEWAY WHEN THE COMPLETE THIRD TAILLIGHT COVER BLEW OFF. IT APPEARS THAT THE ADHESIVE THAT ATTACHES THE REAR SPOILER TO THE GLASS OF LIFT GATE HAS LOOSENED DUE TO A MANUFACTURER DEFECT.

INSTRUMENTAL PANEL/ GAGE CLUSTER. ALL GAGES CONTINUE TO FAIL SPIKING ALL OVER THE PLACE PRIOR TO FAILING. AIR BAG LIGHT CONTINUES TO BLINK ON THEN OFF RANDOMLY

MY DRIVING LIGHTS TURN OFF AND ON WHILE IM DRIVING I TOOK IT TO CHECK AND THEY SAID IS A FACTORY PROBLEM WITH ELECTRIC SYSTEM BUT MY LIGHTS TURN OFF WHILE IM DRIVING

CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 4 -WHEEL DRIVE FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, NO. 110, NO. 114, NO. 225, NO. 209, & NO. 208. VECHICLES WERE BUILT WITH A LEFT -FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGHT OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED,BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT BRAKE PERFORMANCE WOULD BE REDUCED UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. MISSING WELDS ON THE REAR FLOW PLAN THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.

MY WIFE CALLED ME FROM WORK COMPLAINING OF STRONG GAS SMELL, AFTER LOOKING AROUND AND UNDER VEHICLE FOUND NOTHING LOOKED AGAIN WHEN WE BROUGHT IT HOME ,BUT LEFT IT RUNNING THIS TIME AND GAS IS POURING OUT FROM RUSTED FITTINGS ON TOP OF THE TANK.

FUEL GAUGE NOT WORKING ALONE WITH ALL THE OTHER GAUGES AND TURNING SIGNAL NOT WORKING

VEHICLE'S REDUCED ENGINE POWER LIGHT COMES ON, AND VEHICLE LOSES POWER IN DANGEROUS PLACES. LOST OF PROBLEMS CONSIST OF SEVERAL PARTS HAVING TO DO WITH ACCELERATION. THIS PROBLEM HAPPENED SUDDENLY, ANDNIS A DANGER TO HIMAN SAFETY BECAUSE OF IT HAPPENING SEVERAL TIMES INCLUDING O N THE HIGHWAY.

CRACKED EXHAUST MANIFOLD

GEAR SHIFT LOCKED INTO THE PARKED POSITION WHILE VEHICLE STILL MOVING AND IN DRIVE. BRAKE PEDAL ALSO LOCKED.MY AUTISTIC SON WAS IN THE VEHICLE WITH ME. GM KNOWS ABOUT THIS ISSUE AS FAR BACK AS 2002 . DO THEY CARE ABOUT THE IMPACT ? I AM THE 3RD OWNER ,BOUGHT THIS VEHICLE BECAUSE OF SAFETY RATING AND THAT IT HAS LESS THAN 92000 MILES ON IT. I HAVE OWNED IT FOR 5 YEARS.

STARTER RELAY SHORTED OUT AND CAUSED A FIRE IN THE FUSEBOX. THE VEHICKLE WAS PARKED AND IGNITION WAS OFF.

PEP BOYS AUTO PARTS TOLD ME I HAD A RECALL ON THE TURN SIGNAL SWITCH

SPEEDOMETER DISPLAYS 50 MILES PER HR AND THE VEHICLE IS IN PARK AND NOT EVEN MOVING.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING 30 MPH, THE HEADLIGHTS FAILED AND INDEPENDENTLY TURNED OFF WITHOUT WARNING. THE CONTACT WAS ABLE TO TURN THE HEADLIGHTS BACK ON, BUT THE FAILURE RECURRED SEVERAL MORE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,500.

AUTOMATIC TRANSMISSION SHIFT CABLE CAME LOSE AND THE CAR COULD NOT BE PLACED IN GEAR. IT WAS STUCK INTO PARK. THE PLASTIC CABLE CONNECTOR TO THE TRANSMISSION CRACKED, WHICH ALLOWED THE BALL TO COME OUT OF THE TRANSMISSION PREVENT THE CAR NOT BEING ABLE TO BE PUT INTO GEAR.

INSTRUMENT CLUSTER IS VERY FAULTY. AT TIMES WHEN IT IS HOT OUTSIDE THE BATTERY AND OIL PRESSURE GAUGE WON'T FUNCTION PROPERLY. THE RPM GAUGE WENT OUT AT ONLY 36,000 MILES. I JUST WENT OVER 70,000 MILES RECENTLY AND NOW THE SPEEDOMETER WILL NOT WORK. AS A MATTER OF FACT THE ONLY GAUGE THAT HAS ALWAYS WORKED PROPERLY IS THE FUEL GAUGE.

MOST OF THE GAUGES ARE VERY ERRATIC WHEN IN MOTION OR STOPPED. TACHOMETER JUMPS AROUND, OIL PRESSURE READS ALL OVER, SPEEDOMETER GOES TO ZERO OR FULL SCALE, AMP METER DROPS BELOW 14 AND LIGHTS DIM WHEN THIS HAPPENS, (HAVE HAD THE ALTERNATOR REPLACED 3 TIMES, THIS IS QUITE A SAFETY CONCERN FOR ME AS I HAVE NO IDEA WHAT TO BELIEVE ON ANY OF THE GAUGES. NO REPAIR SHOP HAS BEEN ABLE TO SOLVE THE PROBLEM.