Chevrolet · Trailblazer · 2004
2
Recalls
1,368
Complaints
-
Not Rated
The 2004 Chevrolet Trailblazer has 2 recalls and 1,368 owner-reported complaints on file with NHTSA. Most reported issue: electrical system (640 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 Chevrolet Trailblazer page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is electrical system with 640 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Remedy Status
DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Remedy Status
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
I was driving and a girl pulled out from a stop sign and hit my passenger side front of my trailblazer. Her airbags deployed immediately, meanwhile mine didn't deploy. My husband saved my face by throwing his arm over me!
The contact owns a 2004 Chevrolet Trailblazer. The contact stated while driving at various speeds, the headlights became inoperable. After a while, the headlights became operational. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not...
Preview excerpt
The contact owned a 2004 Chevrolet Trailblazer. The contact stated that while driving at an undisclosed speed, there was smoke coming from the rear passenger side. The contact pulled over and noticed that underneath the rear passenger's seat had caught fire. The fire department w...
Preview excerpt
The contact owns a 2004 Chevrolet Trailblazer equipped with Hankook tires Model:Dynapro HT Tire Size: P245/70R16 Dot Number:Unknown. The contact stated that she had both rear tires, driver side and passenger side, replaced with the Hankook tires by an independent mechanic. After ...
Preview excerpt
FUL PUMP
Electronic throttle body? No throttle control, motor will only idle, turn ignition switch off, then restart it will run. Reduced Engine Power light comes on. Happens for no apparent reason. Very unsafe situation.
TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THE HE NOTICED A FUEL ODOR EMITTING FROM UNDERNEATH THE DRIVER'S SIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE FUEL MILEAGE HAD ALSO DECREASED WHEN DRIVING THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO H...
Preview excerpt
AS YOU COME TO A COMPLETE STOP OR GO UNDER 5 MPH, THE VEHICLE'S OIL GAUGE WILL GO ALL THE WAY DOWN. ONCE YOU ACCELERATE, THE OIL GAUGE GOES BACK TO NORMAL. WHEN PUMPING GAS INTO THE VEHICLE, THE GAS PUMP WILL RESET AS IF THE GAS TANK IS FULL BUT THE GAUGE SHOWS IT'S HALF EMPTY. ...
Preview excerpt
TL* THE CONTACT'S SON OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW LOOKED ABNORMAL. WHEN THE DOOR WAS OPENED, THE CONTACT NOTICED THAT THE DRIVER'S SEAT HAD CAUGHT FIRE AND EXTINGUISHED ITSELF OUT. FIRE AND POLICE REPORTS WERE NOT FILED. THE...
Preview excerpt
WELL I HIT A TREE AN THE AIRBAGS DIDN'T DEPLOYED BUT THE AIRBAG LIGHT IS ON
Showing 10 recent complaints from 1,368 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 Chevrolet models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 Chevrolet Trailblazer has 2 recalls recorded by NHTSA.
NHTSA has received 1,368 owner-reported complaints for the 2004 Chevrolet Trailblazer.
NHTSA has not published a safety rating for the 2004 Chevrolet Trailblazer.
The most commonly reported complaint categories for the 2004 Chevrolet Trailblazer are electrical system (640 reports), fuel system, gasoline (105 reports), exterior lighting (63 reports).
Yes. NHTSA has 2 recalls on record for the 2004 Chevrolet Trailblazer. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.