2013 Dodge Dart Tires & Wheels Problems

My 2013 SXT 2.0 started to have the right front TPMS sensor stop working a few weeks back after driving the car for about 30 minutes. I assumed the issue was with the sensor itself as the car is 9 years old now and thought the sensor battery may be getting weak. Had the sensor replaced and others checked, and we were back to normal for a few weeks. Then the right front again dropped out after driving for 30-40 minutes. Checked the sensor again, and it is putting out the signal OK per the tire store, so we went on our way. So here is what is happening now. The car acts like it resets itself overnight and all the sensors behave in a normal fashion after first starting a drive. But they start to drop out beginning with right front consistently after about 30-40 minutes of driving. Then sometimes the left front goes out soon after followed by the left rear. The other thing I have noticed is the range on the fob for locking / unlocking gets really short during this same time of driving the car for a while. Fob batteries are all new. Car sits overnight for a day and things seem to be normal first thing again. Have been told this is a real common issue of late with the Darts and the RFHM (Radio Frequency Hub Module) is typically the culprit. This hub failure can also lead to other electronic issues such as dash lights / wipers / door locks / etc failing or working intermittently. Apparently to replace this module, it is expensive and can involve new keys as well.

WHEEL LUGS SWELL AND BECOME IMPOSSIBLE TO REMOVE FROM THE WHEEL HUB, MAKING IT DIFFICULT TO CHANGE A FLAT TIRE, A POTENTIALLY DANGEROUS PROBLEM ON BUSY STREETS. VEHICLE NEEDED TO BE TOWED, WITH EXPENSIVE REPAIRS, SIMPLY TO CHANGE A TIRE. AN INTERNET SEARCH CONFIRMED THIS IS A PROBLEM FOR MANY DODGE DART OWNERS.

NEED TO REPLACE ALL 20 LUG NUTS THEY ARE ALL SWOLLEN AND HAVE TO BANG THEM OFF BECAUSE TOOLS DON'T FIT BECAUSE IT'S EITHER TO BIG OR TOO SMALL. NEVER HAD THIS HAPPEN TO ANY OF MY CAR EVER. SWOLLEN LUG NUTS ARE FROM THE WAY THESE LOOK NUTS ARE MANUFACTURER FROM THE DEALER THEY GET MOISTURE IN THEM MAKING THEM SWELL. IF THEY KNOW THEY SWELL WHY MAKE THE LUG NUTS WITH THAT CAP COATING THAT EVENTUALLY CAUSES IT? THEY ARE $12 A PIECE..I NEED 20. $240 FOR DEFECTIVE LUG NUTS THAT I'M GOING TO HAVE TO KEEP BUYING IS DRAFT.. CAN'T BUY THOSE FANCY PRETTY LUG NUTS LIKE OTHER CARS.. SOMEONE IF YOU HAVE THE SWOLLEN LUG NUT ISSUE REPORT IT PLEASE. HOPEFULLY THEY'LL SUBMIT A RECALL AND STOP MAKING THOSE LUG NUTS

MY 2013 DODGE DART HAS BEEN GOING THROUGH ISSUES FOR A YEAR. MY TIRES HAVE BEEN POPPING LEFT AND RIGHT BRAND NEW AND USED TIRES JUST POPPING WHILE I'M DRIVING WITH MY KIDS IN THE CAR. THE CAR NOW HAS A BCM PROBLEM AS WELL AS A SMALL GAS LEAK. I HAVE WENT THROUGH MULTIPLE DEALERSHIP THAT LOOKED OVER THE CAR AND CAN'T DETERMINE WHERE THE GAS LEAK IS COMING FROM IN WHICH MY CHECK ENGINE IS STILL ONE WHICH LEAVE ME TO NOT BE ABLE TO GET THE VEHICLE INSPECTED OR REGISTERED AGAIN. THIS CAR HAS CAUSED ME AND MY FAMILY SO MUCH MONEY AND ISSUES. IT HARDLY WANTS TO DRIVE, MY KEY GETS STUCK IN THE IGNITION FOR SOME REASON AND I CAN'T TURN THE CAR OFF. THE DODGE AND RECALL PLACE TOLD ME THEY CAN NOT HELP ME BECAUSE MY VIN IS NOT RECALLED BUT I'VE BEEN HAVING THE SAME ISSUES AS EVERY OTHER 2013 DODGE DART.

WRITING ON 11/3/2016 TO ALERT NHTSA TO A PROBLEM WITH PREMATURE WEAR OF MICHELIN PILOT SPORT A/S 3 AUTOMOBILE TIRES. I PURCHASED 4 TIRES AUG 2015 AT 29000 MILES ODOMETER. THE TIRES CAME WITH A 45000 MILE WARRANTY. SOON THEREAFTER THE RIGHT REAR TIRE NEEDED REPLACEMENT DUE TO "CHUNKING" (FLAKING, TEARING, AND LOSS OF BITS OF RUBBER THROUGHOUT THE TREAD SURFACE). AT 60000 (LESS THAN 75% OF WARRANTED MILEAGE) MILE RECOMMENDED MAINTENANCE ALL 4 TIRES NOTED TO BE WORN TO TREAD WEAR INDICATORS WITH TREAD WIRE SHOWING. I AM AWARE THAT OTHER CONSUMERS HAVE EXPERIENCED THE SAME PHENOMENON (SEE HTTP://WWW.E90POST.COM/FORUMS/SHOWTHREAD.PHP?T=676153). I WOULD APPRECIATE ANY ADVICE AND ASSISTANCE TO RESOLVE THIS PROBLEM THAT YOU CAN PROVIDE. MANUFACTURER NOTIFIED, RESPONSE WAS TAKE IT TO A DEALER. MY CONTACT INFORMATION IS: [XXX], TELEPHONE [XXX]. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2 KUMHO SOLUS KH25 TIRES ON MY 2013 DODGE DART HAVE HAD WEAKENED SIDEWALLS THAT BULGED CAUSING REPLACEMENT AT 14000 MILES AND 22000 MILES.

CAR HAS KUHMO TIRES FROM THE FACTORY. THIS VEHICLE CANNOT GO OVER ANY TYPE OF BUMP WITHOUT AN IMPACT BREAK FORMING ON THE TIRE.

TOOK OWNERSHIP OF CAR AT 6,420 MILES AS THE FIRST OWNER. NOTICED THAT THE FACTORY TIRES HAD "TEST TIRE" STAMPED INTO THE SIDEWALL OF ALL FOUR TIRES. CONTACTED YOKOHAMA CUSTOMER SERVICE, WHO IMMEDIATELY SHIPPED A NEW SET OF REPLACEMENT TIRES IF I GUARANTEED I WOULD SEND THE OLD TIRES BACK. NO ACCIDENT OR INJURIES OCCURRED BUT THE NEW TIRES DROVE MARKEDLY DIFFERENT THAN THE ONES THAT CAME ON THE CAR.

NOTICED EXCESSIVE TIRE NOISE WHILE DRIVING VEHICLE. UPON EXAMINATION OF THE TIRES, 3 OUT OF 4 TIRES HAD SIDEWALL BELT FAILURE WITH NOTICEABLE BULGE ON SIDEWALLS AND ONTO TREAD SURFACE. ALL TIRES WERE ORIGINAL EQUIPMENT KUMHO SOLUS KH25 SIZE 225/45R17 DOT K2X5 YAL 8 DATE CODES 4912, 4912, AND 0313.

3 OUT OF 4 HUMHO SOLUS KH25 225/45R17 K2X5 YAL8 (2X 4112 AND 3414) SIDEWALL FAILURES WITHIN ONE AND A HALF YEARS OF PURCHASE. THESE TIRES FELL JUST SHORT OF THE PRODUCT RECALL SERIAL NUMBERS, BUT CLEARLY HAVE THE SAME SIDEWALL DEFECTS. ONE TIRE BLEW OUT A SIDEWALL WHILE DRIVING AT SLOW HIGHWAY SPEEDS, THE OTHER TWO TIRES HAVE DEVELOPED GOLF BALL SIZED BULGES IN SIDEWALL.

BUBBLE ON SIDE WALL TIRE. KUMHO 225/45R17 91H DOT K2X5 YAL8 1113. *TR

KUMHO KH25 225/45/17 TIRES DEVELOPED BUBBLE ON SIDEWALL AT APPROXIMATELY 20,000 MILES. REPLACED TIRE DUE TO SAFETY ISSUE. SECOND TIRE DEVELOPED SAME PROBLEM AT AROUND 24,000 MILES. REMAINING TWO KH25 TIRES ARE LOSING AIR AND APPEAR TO BE CRACKING. THE TIRES MANUFACTURE CODE IS OUTSIDE OF THE CURRENT RECALL ON THESE TIRE WITH MANUFACTURE DATE OF 4812. *TR

KUMHO SOLUS KH 25 TIRES INCLUDED ON MY 2013 DODGE DART. BUBBLE ON SIDEWALLS. REPLACED WITH DIFFERENT TIRE AND ROTATED. SECOND TIME THIS HAS OCCURRED AND REPLACED ON AUGUST 1, 2014 ONE OF THE TIRES. TWO OTHER KUMHO SOLUS KH 25 TIRES LEAKING AIR. *TR

KUMHO SOLUS KH 25 TIRES INCLUDED ON MY 2013 DODGE DART. BUBBLE ON SIDEWALLS. REPLACED WITH DIFFERENT TIRE AND ROTATED. ON NOVEMBER 3, 2014 NOTICED BUBBLE ON ANOTHER KUMHO SOLUS KH 25 AND HAD TO REPLACE SECOND TIRE AT 20,000 MILES. TWO OTHER KUMHO SOLUS KH 25 TIRES LEAKING AIR. *TR

8 SIDEWALL CRACKS SIMILAR TO NHTSA CAMPAIGN NUMBER: 12T020000 ON KUMHO SOLUS KH25 225/45/R17. DOT SERIAL: K2X5 YAL8 DOT RANGE: 3612, 3712, 3812. *TR

DRIVING ON HIGHWAY WAS SLOWING DOWN FROM ABOUT 70 MPH AND THE TIRE SOUNDED LIKE IT BLEW... BUT AFTER REPLACING THE TIE COULD NOT SEE ANY DAMAGE TO THE TIRE.... *TR

HIT A POT HOLE AT 65 MILES PER HOUR ON A BRIDGE AND TIRE BLEW OUT. SAME THING HAPPENED 3 MONTHS AGO EXCEPT IT BLEW OUT THE TIRE AND TORE THE RIM WHEN A POT HOLE WAS HIT. WHEN I FINISHED CHANGING THE TIRE I LOOKED UP , AND ANOTHER DODGE DART WAS BEHIND ME WITH THE SAME FRONT DRIVERS SIDE TIRE BLOWN OUT , EXCEPT HER RIM WAS TORN . DODGE TOLD ME THE TIRES HAVE NO WARRANTY . THERE KUMHO TIRES .ARE PIECES OF CRAP .. APPARENTLY .. I WAS TOLD BY MY TIRE GUY THAT THEY ARE CHEAP AND HAVE WEAK SIDEWALLS ..THERE ARE MANY INCIDENTS OF PROBLEMS WITH THESE TIRES. I WILL CALL COVERT DODGE IN AUSTIN TOMORROW TO COMPLAIN. ILL GET 4 NEW MICHELIN TIRES PUT ON TOMORROW. THE CAR HAS 4000 MILES ON IT. MY FIRST AND LAST DODGE. THEY DON'T CARE ABOUT THE SAFETY OF THERE CUSTOMERS APPARENTLY !!!! *TR

TL* THE CONTACT OWNS A 2013 DODGE DART WITH KUMHO SOLUS KH25 TIRES, SIZE P225/45/R17. THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE HAD A SIZE OF A QUARTER BULGE ON THE OUTER WALL. THE TIRE WAS REPLACED AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WERE 6,495.

TL* THE CONTACT OWNS A 2013 DODGE DART EQUIPPED WITH KUHMO SOLUS KH25 TIRES, SIZE 225/45/R17. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE TIRE EXHIBITED BUBBLES ON THE SIDE WALL. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS CONFIRMED THAT THE FRONT PASSENGER SIDE TIRE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE TIRE WAS REPLACED. THE APPROXIMATE FAILURE AND MILEAGE OF THE TIRE AND VEHICLE WAS 17,000. KMJ

THE FIRST INCIDENT OCCURRED AFTER A COMMUTE HOME FROM WORK. MY WIFE NOTICED A BULGE IN THE KUHMO TIRE ON HER DRIVER'S SIDE REAR. THE DEALERSHIP REPLACED THE TIRE AT NO COST. THIS HAPPENED AT ROUGHLY 2000 MILES. THE SECOND INCIDENT OCCURRED ON THE COMMUTE HOME FROM WORK AS WELL. THIS TIME THE PASSENGER SIDE FRONT TIRE EXPLODED AT 55 MPH SENDING MY WIFE INTO A PANIC STATE AS SHE ATTEMPTED TO SLOW THE VEHICLE SAFELY. THIS OCCURRED AT ROUGHLY 4400 MILES. THE DEALERSHIP HAD TO REPLACE THE RIM AND TIRE AS THE EXPLOSION RUINED BOTH. THE THIRD INCIDENT OCCURRED TODAY AS SHE GOT OUT OF HER CAR AT WORK SHE NOTICED THE MOST RECENTLY REPLACED TIRE HAD A HUGE BULGE IN THE SIDE WALL AGAIN. SO I TOOK THE CAR TO THE DEALERSHIP WHO INFORMED ME THERE WAS NOTHING MORE THEY COULD DO. KUHMO AND CHRYSLER HAVE REFUSED TO SOLVE THIS ISSUE AND WE WERE FORCED TO SPEND $700.00 ON NEW TIRES SO WE COULD MAKE A FAMILY TRIP THIS MEMORIAL DAY. WE PLAN TO SEEK LEGAL ADVICE ON THIS ISSUE AND FEEL THAT NEITHER CHRYSLER OR KUHMO TAKE SAFETY SERIOUSLY. *TR