2019 Ford Ecosport

The contact owns a 2019 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the check engine warning light and low oil warning light were unexpectedly illuminated. The vehicle was taken to the dealer several times and was eventually diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The contact stated that after the repair, while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light and low oil warning light illuminated. The vehicle was restarted; however, it was later towed to another dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 119,000.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that after exiting the freeway, the low oil pressure warning light illuminated, the vehicle vibrated, and the check engine warning light illuminated. The contact attempted to pull into a gas station but instead pulled over to the side of the road and turned off the vehicle. The contact exited the vehicle and checked the oil level, and the oil level was at the proper level. After waiting for approximately 30 minutes, the vehicle was restarted. The contact attempted to drive, and the engine seized. The vehicle was hauled by a friend to the residence. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The vehicle remained at the residence and had not been driven since the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

The contact owns a 2019 Ford Escape. The vehicle was initially taken to the local dealer for NHTSA Campaign Number: 26V011000 (Equipment). The vehicle was taken back to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The contact stated that the engine had overheated. A diagnostic scanner was used to determine that the head overheat protection was active and there was no coolant in the coolant reservoir. The hose was not connected to the heater cooler. The donut gasket was not attached to the exhaust. There were no warning lights illuminated. The contact stated that the O-ring had failed to snap in place. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 80,000.

I have had to put a new engine in my 2019 ford ecosport 3 times due to the open recall on the vehicle. It is currently at the ford dealership due to coolant leaking into the head gasket. The problems with the vehicle have been confirmed by the dealers. And no there were ZERO warnings or signs before the vehicle completely failed on us on the highway the first time. Then the same issue happened yet again and had to put my car in the shop again for another new engine due to the recall.

The contact owns a 2019 Ford EcoSport. The contact stated that while starting the vehicle, the low oil warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the oil pump had failed, which caused the engine failure. The contact was informed that the engine needed to be repaired. The vehicle was not repaired. The dealer informed the contact that the failure was related to a previous repair completed under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); where the oil pump tensioner assembly had not been replaced, and only the oil drive pump belt had been replaced. The dealer contacted the manufacturer to request an engine replacement due to the recall-related failure. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 38,000.

I am writing to formally file a complaint with the National Highway Traffic Safety Administration regarding an unresolved safety recall on my 2019 Ford EcoSport. On February 18, 2026, at approximately 9:01 A.M., I contacted my local dealership, El Cajon Ford, to schedule the recall repair. I was informed that the required recall parts are on indefinite backorder and that there is no estimated date for availability. This leaves my vehicle unrepaired for a known safety defect with no clear timeline for remedy. Additionally, during that same conversation, I informed the dealership that my check engine light is currently illuminated, which raises further concerns given the open safety recall. I was told that if I bring the vehicle in for diagnostic testing and the issue is determined not to be related to the recall, I would be responsible for a $209 diagnostic fee. I am concerned that this creates a financial barrier to determining whether the warning light may, in fact, be related to the known safety defect. I regularly transport my [XXX] child in this vehicle. Continuing to operate a vehicle subject to an open safety recall — particularly one involving a potentially serious safety-related defect — places my family at unnecessary risk. The indefinite delay in parts availability undermines the purpose of a federally mandated safety recall. Under federal law, manufacturers are required to provide a free and timely remedy for safety-related defects. An open-ended delay with no estimated repair date does not appear to meet that standard and leaves consumers without meaningful protection. I respectfully request that NHTSA review this matter, investigate the delay in recall remedy availability, and take appropriate action to ensure that affected consumers are not required to continue operating potentially unsafe vehicles without a timely repair or interim solution. Thank you for your attention to this serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle’s engine losses power while driving. Low oil pump pressure appears on the dashboard. The problem has been confirmed by a dealer. There were no warning lamps prior to the failure. The problems started February 2026.

Car went in for recall. Ford replaced engine because they claim a bolt broke. I have taken the car about 300 miles since I received it back and the engine light appeared. I let them know. Light went off and I had another important meeting to make in DFW . This time wrench and engine light came on . It sat at airport for 2 days. Then I got back in , no warning lights on but I got home with more warnings then. Engine was super hot and making humming noise. The next day warning light again. I took videos and called Ford . They have refused to help me. I just had a new engine installed because of a recall.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. Recently, the contact stated there was an abnormal, tapping sound coming from the engine. There was no warning light illuminated. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The vehicle was not repaired. The failure mileage was approximately 32,000.

Complaint Summary: My 2019 Ford EcoSport has experienced repeated failures of a known recall‑related engine defect. The engine was replaced once due to the recall, and less than a year later the same defect occurred again. The vehicle stalled on the highway, creating a serious safety hazard. Despite multiple recall repairs, the defect persists. Ford denied my buyback request without proper review. I am requesting NHTSA investigation into the effectiveness of this recall remedy. Have had two failed attempts under this recall to correct the situation, which is putting me and my family at risk. This is especially concerning because my special-needs son travels with me in the vehicle.

The contact owns a 2019 Ford EcoSport. The contact stated while driving at approximately 35 MPH, the low oil pressure warning light illuminated and flickered. The contact stated that the vehicle started vibrating. The contact was able to drive the vehicle to a local dealer. The contact was aware that the VIN was included in NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact advised the dealer of the recall; however, the dealer informed the contact that the part to complete the recall was on national back order. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 53,713.

The contact owns a 2019 Ford EcoSport. The contact stated that the vehicle was serviced at the local dealer under NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). After retrieving the vehicle and driving approximately 10 miles down the road, the check engine warning light illuminated, and the vehicle stalled. The vehicle was towed back to the local dealer to be diagnosed, and it was determined that there was a failure in cylinder #2 and that the engine needed to be replaced. The contact was informed that the failure was not related to the recall repair previously completed. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 102,600.

I purchased a 2019 Ford EcoSport from CarMax on April 12, 2022. At the time of sale, CarMax provided documentation stating that there were no unrepaired safety recalls on the vehicle. I relied on this representation in making my purchase decision. I later discovered that the vehicle is subject to a serious manufacturer recall involving the engine oil pump, which can fail and cause loss of oil pressure, engine damage, and safety risks while driving. CarMax misrepresented the recall status of the vehicle at the time of sale. This is a material safety issue that should have been disclosed. I am still dealing with ongoing issues related to this defect and have not received proper assistance or resolution from CarMax despite multiple attempts to contact them.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The local dealer was made aware of the recall and confirmed that parts were available for the recall repair. The contact scheduled an appointment for the repair, and the vehicle was dropped off for service. The vehicle remained with the dealer despite the dealer's insistence that the parts for the repair were available. The contact was not provided a loaner vehicle and had not been given a reason for the delay in service. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact had not experienced a failure.

Our engine seized due to a safety recall while traveling on a major interstate. We received notice of the safety recall from Ford and asked to have it fixed by our local dealership. This was August 20, 2025. We were told by the dealership’s service manager that there were 2 or 3 cars ahead of us and call back the first of September. We again asked to get scheduled and were told there were cars ahead of us. We once again asked about the recall and having it repaired on Oct. 21, 2025. We was told it couldn’t be scheduled at the time and it should be okay for us to go on our scheduled 8 hour trip. The car seized on Oct. 26, 2025 and we were 4 hours away from home. At that time, we had to have it towed to local dealership there and were stranded. The low oil light came on just minutes before it seized. We contacted the state police to be there with us as we waited for help and had to pay to stay overnight. Our car is still 4 hours away and is supposed to be fixed as soon as the engine comes in. This was a safety recall and we were advised to travel in a car which was not safe and Ford knew it. We do not have any paperwork except the safety recall as it has not been repaired.

ODI 11676608 Since initial contact to your office the transmission issue has worsened An extended warranty was purchased. After 30 days the car was taken to the repair location suggested by the warranty company. No warning lights were on, but the car was running very rough. It was not getting enough power to get thru intersections and very sluggish to keep the speed with traffic. The tool light had come on a couple of times, but would reset when I shut down the car and restarted it. The warranty provider was aware that the light was not on and I was taking it to the be serviced as a precaution. I was not comfortable driving an unreliable auto. The repair shop determined that I again need a transmission. The warranty company states it will not pay for the repair, Ford says they won't assist since I was now dealing with a repair shop rather than a dealership and I am stuck with this pile of metal. March 29, 2023 my car had 56,000 miles and the dealership did an (over haul), the car now has 96,000 miles. Way too soon for any car to be put down! I have spoken to several mechanics about this issue and the conclusion verbalized to me has been, the transmissions on these cars are crap and get rid of the carl

I contacted the local Ford dealer, Confidence of Norman in Oklahoma, twice regarding correspondence from Ford about the ongoing recall. I had made appointments on both occasions. During my first visit, the dealership representative stated that they would only address the issue if my vehicle had an actual malfunction and would take no action in the meantime. Last week, I scheduled a follow-up appointment after receiving another letter from Ford. This appointment took place today; however, I was again refused service. The dealership claimed that, despite my scheduled appointment, they lacked the necessary tools to perform the repairs. They did not offer an alternative appointment or provide an estimated timeline for when the issue might be fixed. Ultimately, their response indicated that my visit was unproductive. Besides this complaint, I don’t know what else I can do to fix this problem.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The contact stated that the vehicle failed to start. No warning lights were illuminated. A mobile mechanic stopped by the residence, removed the battery, and took the battery to a specialty shop to be tested. The mobile mechanic returned to the residence and tested the vehicle, and diagnosed that the alternator had failed and needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,500.

I bought a used 2019 Ford Ecosport SE in January 2022. I received a recall notice (#23S64: “ENGINE OIL PUMP BELT AND TENSIONER REPLACEMENT FINAL REPAIR”). A paper notice I received from Ford dated June 2024 mentioned a remedy expected in Q1 2025. The estimation was pushed back, and parts were eventually ready in Q3, some time in August. Before I could take my vehicle to a dealership, on [XXX], while driving my vehicle it stalled, smoked, and smoldered. I made no collisions with any other object, person, or vehicle. I called my insurance and the fire department (incident number: [XXX]). I believe the damage was related to the recall. It was described to me that there was even damage to some wiring, as a result of the fire. I called my insurance, and they towed my vehicle to Larry H. Miller Ford Dealership on September 30, 2025. It was scheduled for its first service on October 1, 2025, but technicians inspected it on October 16, 2025. The repair cost exceeded the vehicle’s value, as I needed a new engine and transmission. After long periods without progress and updates, on January 7th, I was informed by the dealership that I’d either be paid or my vehicle would be repaired, but the final decision rested with Ford Motor Company. The dealership had submitted everything, as a service manager with Larry H. Miller told me on January 7, 2026. I called Ford Motor Company and asked for specific repair dates, but I received no more information than from the dealership. I was told by the dealership that I should have an answer on repairs “by the end of the week”on January 26, 2026, but it’s now February 3, 2026. I’ve been without a vehicle for four months, impacting my flexibility and affecting my vehicle loan. I accepted a loaner vehicle on January 7, 2026. I seek a prompt and fair resolution, whether it’s a payment or a repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was notified over a year ago about the recall on my car and continue to be told there’s no remedy for the problem. If Ford is aware that the parts that have been recalled can cause other problems why is there still no remedy for the situation?!?!?! I barely drive my car now because I’m worried my entire car is going to break down. Which is very likely. The last couple of times I did drive it I noticed it doesn’t seem to drive right. Now whether that has something to do with the recalled part I don’t know for sure, but I will be taking it to the shop to figure out what the issue it and if it’s related to the recalled part. If so, I will be reaching out to my attorney for further assistance.