2008 Ford F-250 Complaint Log

RADIATOR STARTING LEAKING, REPLACED IT TWICE AND IS LEAKING AGAIN @ AROUND 60K. LEAKS COULD CAUSE OVERHEATING AND ENGINE FAILURE. *TR

SUBJECT OWNS A 2008 F250 W/ 6.4L DIESEL. AT RANDOM, WHEN ATTEMPTING TO ACCELERATE, PULL ONTO A HIGHWAY, OR OTHERWISE INCREASE SPEED, VEHICLE WILL LOSE POWER AND STUMBLE. WHITE SMOKE HAS BEEN NOTICED FROM THE EXHAUST DURING AT LEAST ONE OF THESE INCIDENTS. FORD HAS TSB 08-25-1 WHICH ATTEMPTS TO ADDRESS THIS PROBLEM, BUT VEHICLE IS PAST WARRANTY, AND OTHER OWNERS HAVE REPORTED THE PROBLEM PERSISTS EVEN AFTER HAVING THE TSB PERFORMED. THIS IS A SAFETY ISSUE, ON AUGUST 20, 2010 WE WERE PULLING A 10,000 TRAILER AND WENT TO PASS A SLOWER VEHICLE. OUR VEHICLE LOST POWER WHILE PASSING (STUMBLE/SMOKE) FOR APPROX 5 SECONDS, BEFORE REGAINING POWER. WE COULD HAVE HAD A TERRIBLE ACCIDENT IF THERE HAD BEEN ONCOMING TRAFFIC PRESENT AND/OR POWER HAD NOT RETURNED. PROBLEM IS ABLE TO BE DUPLICATED. *TR

ON 8/10/2010, AFTER DRIVING MY 2008 F-250 ON INTERSTATE 5 FOR ABOUT 6 HOURS CONTINUOUSLY AT APPROX. 70MPH IN CRUISE CONTROL MODE, I OVERRODE CRUISE CONTROL TO ACCELERATE AND PASS A VEHICLE. AS I RETURNED TO THE RIGHT SIDE DRIVING LANE, THE VEHICLE FAILED TO REDUCE SPEED AND CONTINUED TO ACCELERATE IN AN UNCONTROLLED FASHION. WITH HEAVY BRAKING I WAS ABLE CONTROL THE VEHICLE AND BRING IT TO A STOP ON THE HIGHWAY SHOULDER WHERE I SHIFTED IT INTO NEUTRAL AND CUT THE IGNITION OFF. A RESTART OF THE VEHICLE RESULTED IN AN IMMEDIATE RUN-UP IN RPM WHICH COULD ONLY BE CONTROLLED BY SHUTTING DOWN THE ENGINE. NO ENGINE OR OTHER WARNING LIGHTS WERE DISPLAYED. BY OPENING THE HOOD AND MANUALLY RESETTING THE AIR FILTER CONTAMINATION SENSOR ON THE AIR INTAKE DUCT, IT WAS POSSIBLE TO RESTART THE ENGINE AND HAVE IT OPERATE NORMALLY. I DID NOT AGAIN USE CRUISE CONTROL. THIS IS A REPEAT OF THE CONDITION PREVIOUSLY REPORTED IN ID# 10279704. THE COMMON ELEMENTS OF ALL THREE INSTANCES OF OCCURRENCE ARE THAT THE ENGINE HAS BEEN OPERATED AT 65-70 MPH FOR APPROX. SIX HOURS, CRUISE CONTROL IS ENGAGED, AND THE ENGINE IS EITHER IN OR HAS JUST COMPLETED AN EXHAUST REGEN CYCLE . FORD APPEARS TO BE UNABLE OR UNWILLING TO IDENTIFY OR ADDRESS THIS SITUATION, BUT IT CONTINUES TO BE A SEVERE SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2008 FORD F250 SD. THE CONTACT WAS REVERSING IN HER DRIVEWAY AND DEPRESSED THE BRAKE PEDAL AS IT FELL MUCH FARTHER INTO THE FLOORBOARD THAN USUAL. THE BRAKES DID NOT ENGAGE AND THE CONTACT UTILIZED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE IT WAS DISCOVERED THAT BRAKE FLUID WAS LEAKING. THE LEAK WAS CAUSED BY A FRACTURED CALIPER AND PISTONS. THE CALIPER AND PISTONS WERE REPLACED AS WELL AS BRAKE PADS AND ROTORS. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 33,000.

I BOUGHT A 2008 FORD F-250 EXTENDED CAB TRUCK AND WHEN I GO OVER A SMALL BUMP IN THE ROAD THE FRONT END SHAKES REAL BAD TO THE POINT I ALMOST LOST CONTROL GOING DOWN A HIGHWAY AT 55MPH. I CHECKED THE AIR PRESSURE IN THE TIRES AND THEY WERE AT 70PSI IN THE FRONT AND 80PSI IN THE BACK. THE DOOR STICKER SAID THE PRESSURES SHOULD BE 70 IN THE FRONT AND 80 IN THE BACK. I HAVE REPLACED THE SHOCKS AND STEERING STABILIZER SHOCK AND IT DID NOT MAKE A DIFFERENCE. THE OLD SHOCKS APPEARED TO BE IN GOOD SHAPE YET. I THEN REPLACED THE TIRES EVEN THOUGH THEY WERE STILL GOOD AND THEY WERE WORN EVENLY. STILL DID NOT FIX IT. I THEN DROPPED MY AIR PRESSURE IN THE TIRES TO 60PSI FRONT AND BACK TO IF IT MADE A DIFFERENCE. STILL DID NOT FIX IT. I HAD THE DEALERSHIP LOOK AT IT AND THEY SAID THEY COULD NOT FIND ANYTHING WRONG WITH IT. I OWNED A 1999 F-250 AND IT NEVER HAD THIS PROBLEM. I HAD 165,000 MILES ON IT WHEN I TRADED IT IN FOR THIS ONE. I GOOGLED MY PROBLEM AND FOUND A LOT OF PEOPLE WITH THE SAME PROBLEM. FORD NEEDS TO COME UP WITH A REPAIR FOR THIS SOON. I WON'T LET MY WIFE DRIVE THIS TRUCK FOR FEAR OF THIS HAPPENING AND HER ENDING UP IN A WRECK. FORD NEEDS TO THINK ABOUT THE PEOPLE AND CHILDREN THAT RIDE IN THERE VEHICLES AND THE LIVES THAT THEY COULD TAKE. I AM A FORD DRIVER ALL MY VEHICLES ARE FORD AND I'M NOT MAD AT FORD YET BUT THEY NEED TO CURE THIS PROBLEM. THIS PROBLEM IS FOR SURE A DESIGN FLAW. *TR

TL*THE CONTACT OWNS A 2008 FORD F-250. THE CONTACT STATED THAT THE VEHICLE STALLED TWICE. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT CAME ON THEN A WARNING LIGHT DISPLAYED "FIND A SAFE PLACE TO PULL OVER". WHEN THE ENGINE LIGHT AND THE MESSAGE ILLUMINATED, THE VEHICLE STALLED WITHIN A FEW SECONDS. THE VEHICLE WAS IN THE DEALERS POSSESSION WHEN THE COMPLAINT WAS FILED. THE FIRST TIME THE VEHICLE WAS TAKEN TO THE DEALER HE STATED THAT THEY COULD NOT FIND ANYTHING WRONG. THE FAILURE MILEAGE WAS 46000 AND THE CURRENT MILEAGE WAS 47000.

2008 FORD F 250 SUPER DUTY DIESEL 6.4 ENGINE - ENGINE QUIT RUNNING WITH NO WARNING, WOULD NOT RESTART. COASTED TO THE SIDE OF THE ROAD AND HAD TO BE TOWED TO DEALER. TSB 07-26-2 WAS PERFORMED TO FIX THE KNOWN PROBLEM OF AN UNPROTECTED WIRE IN THE HIGH PRESSURE FUEL PUMP GASKET CHAFFING THROUGH. A NEW AND IMPROVED GASKET WITH PROTECTED WIRE WAS INSTALLED. LUCKILY I WAS NOT TOWING MY BOAT OR TRAVEL TRAILER AT THE TIME. THIS IS A SERIOUS SAFETY RISK AND FORD SHOULD RECALL ALL EFFECTED VEHICLES ASAP! *TR

IN APRIL 2010, MY 2008 FORD F-250 SUPER DUTY'S RIGHT FRONT BRAKE CALIPER FROZE, CAUSING THE BRAKES TO HEAT UP AND BEGIN SMOKING. THE FORD DEALERSHIP CLAIMED TO FIX THE PROBLEM IN APRIL, BUT IN JULY, THE SAME THING HAPPENED TO THE FRONT DRIVERS SIDE BRAKE (SMOKE BEGAN BILLOWING FROM THE WHEEL ON THE HIGHWAY). UPON INSPECTION, THE FORD MECHANIC FOUND ALL FOUR BRAKES ON THE TRUCK SEIZED, INCLUDING THE FRONT PASSENGER SIDE BRAKE AGAIN. THE MECHANIC STATED THAT HE SEES THE PROBLEM ALL THE TIME ON THE SUPER DUTY TRUCKS, BUT FORD MOTOR COMPANY REFUSED TO ACKNOWLEDGE THAT THERE IS A PROBLEM WITH THE BRAKE DESIGN ON ITS TRUCKS. SO FAR, THE BRAKES ON MY TRUCK HAVE SEIZED TWICE WITHIN A THREE MONTH SPAN, AND THE DEALERSHIP MORE OR LESS ASSURED ME IT WOULD HAPPEN AGAIN, AND THAT I WOULD NEED TO TAKE MY VEHICLE IN FOR AN EXPENSIVE BRAKE OVERHAUL EVERY TIME IT OCCURS. THIS FAULTY DESIGN NOT ONLY PRESENTS A FINANCIAL BURDEN BECAUSE OF COSTLY REPAIRS, BUT ALSO PUTS MY LIFE, AND MY FAMILY'S LIVES, AT RISK EVERY TIME I DRIVE THIS VEHICLE. *TR

2008 FORD F250 - ALTERNATOR WENT UP ON TRUCK AFTER 41,690 MILES, THIS ALSO BURNED UP THE BATTERY, NOW THE STARTER HAS GONE UP IN THE TRUCK. GOT THE TRUCK STARTED TO TAKE HOME, TRUCK DIED. THERE IS NO POWER, LIGHTS ANYTHING AT ALL. TRUCK HAS BEEN OUT OF SERVICE FOR ALMOST 2 WEEKS. *TR

2008 FORD F250 SUPER DUTY: IGNITION SWITCH WHEN TURNED TO START/CRANKING POSITION DOES NOT RETURN TO NORMAL RUN POSITION. THIS LEAVES INSTRUMENTS BLANK AND INOPERATIVE, AND ALL POWER ACCESSORIES FAIL TO OPERATE UNTIL TRUCK IS SHUT OFF & RESTARTED. *TR

MY FORD F-250 SD ENGAGES INTO 4X4 HIGH AND LOW WHILE AT HIGHWAY SPEEDS ALL ON ITS OWN. *TR

TANK FULL OF DIESEL FUEL CONTAMINATED WITH WATER AND SOME DEBRIS. FORD WILL NOT WARRANTY BUT SEVERAL PARTS OF THE FUEL SYSTEM DEVELOPING RUST. THIS VEHICLE IS EQUIPPED WITH A FUEL WATER SEPARATOR AS STANDARD EQUIPMENT. SO FORD HAS EQUIPPED THE TRUCK WITH A FUEL WATER SEPARATOR BUT SEVERAL OF THE PARTS IN THE FUEL SYSTEM ARE VERY SUBJECT TO RUST IF THERE IS ANY EXPOSURE TO WATER. SO AS SOON AS THE VEHICLE IS EXPOSED TO WATER IN THE FUEL THERE ARE PARTS THAT WILL FAIL AND ARE NOT COVERED BY WARRANTY. *TR

2008 FORD F250 - RIGHT ROTOR ONLY DISINTEGRATING CAUSING MAJOR DAMAGE TO THE CALIPER AND RUBBER BOOT. HAD TRUCK TO DEALERSHIP TWICE AND THEY COULD FIND NOTHING WRONG WITH THE TRUCK, NOW DEALERSHIP IS SAYING THAT IT IS LACK OF MAINTENANCE ON MY PART. I SERIOUSLY BELIEVE THAT THIS IS A DEFECTIVE PART. BRAKE ON RIGHT HAND SIDE IS COMPLETELY GONE. I THINK IF THE DEALERSHIP WOULD HAVE CHECK THIS OUT BETTER THEY WOULD HAVE FOUND THE PROBLEM WHILE THE TRUCK WAS UNDER WARRANTY. *TR

I BOUGHT MY TRUCK IN NOVEMBER 2008 BRAND NEW. AT APPROXIMATELY 13000 MILES I HAD MY RIGHT FRONT BRAKE CALIPER FREEZE UP. I WAS ON MY WAY HOME FROM WORK PULLED IN MY DRIVEWAY GOT OUT AND SAW SMOKE COMING FROM AROUND MY LEFT FRONT WHEEL. I TOOK IT IN TO THE DEALERSHIP THE FOLLOWING DAY AND THE DEALERSHIP HAD TO INSTALL A NEW CALIPER, PADS AND ROTOR. THIS WAS ALL DONE UNDER WARRANTY, UNFORTUNATELY THIS SAME THING HAS HAPPENED 3 MORE TIMES - ONCE ON THE RIGHT FRONT,ONCE ON THE RIGHT REAR, AND AGAIN ON THE LEFT FRONT. THE LAST TIME WAS AT 48000 MILES AND I HAD TO PAY FOR THE REPAIRS BECAUSE I WAS OUT OF WARRANTY. EVERY INCIDENT WAS THE SAME WITH THE RESULTING REPAIRS BEING THE SAME (NEW CALIPER, NEW ROTOR,AND NEW PADS. I HOPE THAT SOMETHING CAN BE DONE TO MAKE FORD REMEDY THIS SITUATION BEFORE SOMEONE GETS HURT. LIVING IN MICHIGAN I DRIVE ON SLIPPERY ROADS AND IF THIS WERE TO HAPPEN ON SLIPPERY ROADS I FEAR WHAT THE OUTCOME OF THE INCIDENT MAY BE. THIS I FEEL IS A VERY UNSAFE CONDITION, I PULL A 34 FOOT FIFTHWHEEL CAMPER AND WOULD NOT WANT TO EXPERIENCE THIS WHILE PULLING IT. I KNOW OF AT LEAST 5 OTHER TRUCKS WITH THIS SAME PROBLEM RANGING IN YEARS FROM 2005 TO PRESENT. IRONICALLY FORD HAS ISSUED A TSB ON THE 2010-2011 FORD SUPERDUTY FOR THIS EXACT PROBLEM. I BELIEVE THEY NEED TO EXPAND THE TSB OR ISSUE A RECALL ON ALL OF THESE TRUCKS. I AM ON THE VERGE OF GETTING RID OF MY TRUCK BECAUSE I FEEL IT IS NOT REAL SAFE TO DRIVE.HOPEFULLY SOMETHING WILL BE DONE ABOUT THIS. *TR

BOTH FRONT WHEELS ON MY 2008 FORD KING RANCH F-250 PICK-UP ARE CRACKING AND NEED TO BE REPLACED. THE CRACKS ARE IN THE WELD AREA ON THE FLAT PART OF THE WHEEL UNDER THE TIRES CAUSING THE TIRES TO NO LONGER HOLD AIR. FORD CUSTOMER SERVICE CLAIMS THE PROBLEM IS MINE SINCE THE TRUCK RECENTLY SURPASSED WARRANTY MILEAGE HOWEVER I AM CERTAIN THIS IS A SERIOUS SAFETY ISSUE. THE WHEELS ARE READY TO COME APART AND COULD HAVE CAUSED A SERIOUS ACCIDENT . IF THE TIRES HAD NOT BEGUN TO LOSE AIR I WOULD HAVE NEVER KNOWN THEY WERE CRACKING. THIS TRUCK HAS HAD THE BEST OF CARE AND HAS NEVER HIT ANYTHING OR BEEN IN ANY KIND OF ACCIDENT. FORD DENIED RESPONSIBILITY WITHOUT EVEN EXAMINING THE CRACKED WHEELS. THE TIRE SHOP BELIEVED THE SITUATION WAS SO UNSAFE THAT THEY RECOMMENDED TOWING INSTEAD OF DRIVING THE TRUCK. THIS CASE # 1526770470 WITH FORD WAS DENIED AND THEY QUOTED OVER 800 DOLLARS PER WHEEL TO REPLACE THE CRACKED WHEELS. ALL AFTER MARKET WHEELS I CHECKED ON WERE AROUND 250 DOLLARS WITH A LIFETIME GUARANTEE. I HAVE WORKED IN CONSTRUCTION FOR OVER 30 YEARS AND HAVE OWNED SEVERAL VEHICLES AND HAVE NEVER ENCOUNTERED ANYTHING LIKE THIS. *TR

MY HUSBAND WOKE UP AND WENT OUT TO START HIS TRUCK SO IT WOULD BE WARM FOR OUR 1-YR OLD TWIN BABIES TO GET IN THE CAR. WHEN HE WENT TO PUT THE BABIES IN THE BACK SEAT, THE REAR PASSENGER WINDOW WAS BLOWN OUT FROM THE INSIDE OUT; THE GLASS LOOKED BUBBLED. HE IMMEDIATELY TOOK THE CAR TO THE GLASS SHOP AND WAS ADVISED THAT BECAUSE FORD DOESN'T USE THE PROPER SEAL ON IT'S REAR WINDOWS THAT THIS CAN OCCASIONALLY HAPPEN. THE WINDOW BLEW UP FROM THE HEAT INSIDE THE CAR...IT'S 30 DEGREES HERE THIS MORNING. WE THEN TOOK THE VEHICLE THAT IS STILL UNDER WARRANTY TO OUR LOCAL FORD DEALERSHIP AND WE WERE ADVISED THAT IT'S NOT COVERED UNDER WARRANTY. SO I'M LOOKING AT $800 FOR A WHOLE ENTIRE BACK WINDOW THAT HAS TO BE REPLACED. THIS CONCERNS ME AS IF ONE OF MY BABIES WAS IN THE CAR WHEN THIS HAPPENED, WE WOULD HAVE SOME SERIOUS HEALTH ISSUES....THIS IS A HUGE SAFETY CONCERN. BECAUSE OF THEIR FAULTY SEAL, OUR WINDOW EXPLODED. *TR

TL*THE CONTACT OWNS A 2008 FORD F250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH OVER AN UNEVEN SURFACE, THE FRONT END OF THE VEHICLE WOULD SHAKE AND VIBRATE. THE STEERING AND TRACTION CONTROL ALSO FAILED. UPON DECELERATION THE FAILURE WOULD STOP. THE PROBLEM OCCURRED THREE TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT THE DEALER COULD NOT DUPLICATE THE FAILURE. THE DEALER INFORMED THE OWNER THAT SOME OF THIS YEAR AND MODEL HAD THE "DEATH SHAKE" BUT THERE WAS NOTHING THEY COULD DO ABOUT IT; SHE WAS ADVISED TO NOT DRIVE THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000. THE CURRENT MILEAGE WAS APPROXIMATELY 24,000.

DRIVING AROUND AND DIESEL FUEL SMELL CAME INTO THE CAB OF THE TRUCK AND SMOKE FROM ENGINE COMPARTMENT. THIS TRUCK HAS A 6.4L JOB 1 DIESEL. WE HAD THE TRUCK TOWED TO THE FORD DEALERSHIP BECAUSE DRIVING IT MAKES ME SICK TO MY STOMACH AND LIGHT HEADED. FORD TELLS US IT WILL HAPPEN EVERY 100-600 MILES AND LAST 10-40 MINUTES EACH TIME DURING REGENERATION. FORD SAYS THIS IS A 'NORMAL OPERATION CHARACTERISTIC OF THE VEHICLE'. THE DEALERSHIP REFERENCED TSB 09-16-9 AND TOOK THE TIME TO HIGHLIGHT CERTAIN AREAS. #1 - I WAS NOT IN COLD AMBIENT TEMPERATURE AT THE TIME THE SMOKE WAS COMING FROM THE ENGINE COMPARTMENT AND #2 - THIS IS NOT A BRAND NEW TRUCK ALTHOUGH WE DO HAVE LOW MILEAGE. HOW CAN THIS BE CONSIDERED NORMAL IF IT HAD NEVER HAPPENED BEFORE AND NOW MAKES ME SICK WHEN I DRIVE THE TRUCK? THE SMELL IS STILL FAINTLY IN THE HEADLINER OF THE TRUCK. WHAT IS IN THIS STUFF THAT MADE ME LIGHT HEADED AND SICK TO MY STOMACH?*CW

1/1/10 ISN'T THE FIRST SMOG-OUT, BUT DEFINITELY THE WORST & MOST DANGEROUS. WHILE DECENDING FROM THE TOP OF THE MOUNTAIN IN GATLINBURG IN BUMPER TO BUMPER TRAFFIC WHERE IT TOOK 45-60 MINS TO GO 2 MILES, THE EXHAUST CLEANING WAS BLOWING SUFFOCATING AND BLINDING BLUE SMOKE CONTINUOUSLY. THEN GOING THROUGH TOWN WHERE PEOPLE ARE WALKING UP & DOWN BESIDE THE ROAD (STILL IN BUMPER TO BUMPER TRAFFIC) IT WAS STILL SMOGGING THE PEOPLE WALKING AND PEOPLE DRIVING BEHIND ME COULD NOT SEE. IF A MOTORCYCLE OR PERSON ENDED UP BESIDE US WHEN WE HAD TO STOP FOR TRAFFIC LIGHTS, THEY WOULD HAVE BEEN SEVERELY BURNED. IT CONTINUED TO CLEAN DOWN TO PIGEON FORGE FOR A TOTAL OF 1-1/2 TO 2 HOURS. FORD ENGINEER WAS SUPPOSED TO RECALIBRATE TO MAKE SURE IT DIDN'T CLEAN IF UNDER 35 MPH, BUT IT DOES IT ALL THE TIME, SOMETIMES DAY AFTER DAY FOR HOURS. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE FRONT AND REAR ROTORS, THE CALIPERS AND THE FRONT AND REAR BRAKES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,000.

RADIATOR COOLANT LEAK AT TANK SEAM. *TR

1. DRIVING AT SPEEDS OF 65MPH+ IN A 2008 FORD F-250. 2. HIT A MINOR SEAM IN THE PAVED ROAD. 3. FRONT END WOBBLE (KNOWN ON MANY INTERNET SITES AT THE "FORD DEATH WOBBLE". MY TRUCK WAS UNDER WARRANTY AND I TOOK IT TO FORD DEALER THE NEXT DAY. THEY TIGHTEN THE PITMAN ARM. THERE WAS A FORD TECHNICAL SERVICE BULLETIN ISSUED FOR THIS PROBLEM AND IT INDICATED IMPROPER TIRE PRESSURE. TOTALLY NOT TRUE. THE FRONT END WOBBLE WAS SO SEVERE IT MADE ME CROSS INTO ON-COMING LANES OF TRAFFIC. LUCKILY NO ONE WAS COMING THE OTHER WAY OR THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. THE FORD DEALER ALSO REPLACED THE FRONT STABILIZER SHOCK. THE VERY NEXT DAY THE EXACT SAME THING HAPPENED. VIOLENT FRONT END WOBBLE AT 65MPH+ AND WHEN A SMALL BUMP WAS HIT. I HAD TO SLOW THE TRUCK DOWN TO 20MPH ON AN INTERSTATE FREEWAY IN ORDER TO GET THE WOBBLE TO STOP AND ALMOST CAUSED ANOTHER ACCIDENT. TWO HOURS LATER IT HAPPENED AGAIN! VIOLENT WOBBLING OF THE FRONT END. THE DEALER CLAIMS THERE IS NOTHING WRONG WITH THE TRUCK. HOWEVER, AFTER RESEARCHING THE MATTER ON THE INTERNET THERE ARE HUNDREDS OF CASES OF THIS SAME PROBLEM. CHECK OUT: WWW.SUPERDUTYWOBBLE.COM OR OTHER SITES. THIS HAS GOT TO BE A MANUFACTURING ERROR THAT DESERVES A RECALL NOTICE. THE FORD DEALER CANNOT FIND ANYTHING WRONG! PLEASE HELP! *TR

I HAVE EXPERIENCED AN ISSUE WITH MY 2008 FORD F-250 WHERE I HIT A BUMP ON THE INTERSTATE AND EXPERIENCED THE STEERING WHEEL OSCILLATING AND FRONT END WOBBLING BOTH EXTREMELY DOING 65MPH ANDWAS ALMOST THROWN INTO A SEMI TRUCK TWICE THE SAME NIGHT. I HAD JUST PURCHASED THIS TRUCK BACK IN JULY BUT HAD NOT DROVE IT ON THE INTERSTATE, ACTUALLY I HADN'T DRIVEN IT MUCH AT ALL. IT HAS LOW MILEAGE AND IS ALL FACTORY. I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THIS HAPPENS ALL THE TIME ALSO THEY STATED THAT FORDS SERVICE RECOMMENDS 75LBS TIRE PRESSURE AND THAT IS ALL THAT IS WRONG WITH IT. THE TRUCKS STICKERS RECOMMENDATION IS LESS THAN THAT. THE WHEELS ON MY TRUCK ARE STOCK FACTORY AND DO NOT HAVE LOW PRESSURE SENSORS ON THEM. I HAVE RESEARCHED SEVERAL COMPLAINTS ON THE INTERNET ABOUT THIS ISSUES AND OF ACCIDENTS AND INJURIES RESULTING FROM WHAT IS BEING CALLED THE "DEATH WOBBLE". I THINK THIS MATTER SHOULD BE INVESTIGATED AND THE PROBLEM FIXED PROPERLY BY FORD, NOT PATCHED WITH TIRE PRESSURE. I PULL A TRAILER SOMETIMES WITH THIS TRUCK. IF THIS HAPPENED WHILE PULLING ONE I AM SURE I WOULD HAVE BEEN SERIOUSLY INJURED OR KILLED AS IN OTHER CASES I HAVE HEARD ABOUT. I AM SCARED TO DEATH TO DRIVE THIS TRUCK NOW. WHY ISN'T SOMEONE DOING SOMETHING ABOUT THIS. PLEASE HELP US WHO OWN THESE VEHICLES. THE MECHANIC WHO IS A FRIEND OF MINE STATED THAT THIS WILL STILL HAPPEN SOMETIMES EVEN WITH THE INCREASE IN TIRE PRESSURE. *TR

'08 FORD F250. SEVERE FRONT END SHIMMY. FORD SAID THAT THIS IS RELATED TO TIRE PRESSURE. II HAVE OWNED 5 F250'S AND DID NOT EXPERIENCE THIS UNTIL FORD WENT TO COIL SPRING/TRAILING ARM FRONT SUSPENSION. TIRE PRESSURE ON A TRUCK IS RELATIVE TO THE LOAD CARRIED. MY DEALER JUST QUOTED THE COMPANY LINE AND DID NOTHING. THE COMPANY DID SEND OUT A NOTICE CONCERNING THE PROBLEM, SO OBVIOUSLY THEY ARE AWARE OF IT. I BELIEVE THIS IS A DESIGN FLAW THAT WARRANTS YOUR ATTENTION. THE VARIOUS FORUMS ON LINE WITH FORD TRUCK OWNERS CITES THIS AGAIN AND AGAIN. WHEN THE SHIMMY HAPPENS IT IS DIFFICULT TO CONTROL THE TRUCK, PARTICULARLY IN A CURVE. IF I PUT COMPANY RECOMMENDED PRESSURE OF 80PSI IN MY TIRES IN AN EMPTY TRUCK, IT WOULD BE A SAFETY HAZARD RELATED TO TRACTION AND ALSO GREATLY REDUCE TIRE MILEAGE. IT APPEARS TO ME THAT FORD CHANGED THE FRONT SUSPENSION DESIGN WITH NO LONG TERM RESEARCH AND DEVELOPMENT AND THEREFORE IS MARKETING A UNSAFE AND DEFECTIVE PRODUCT. I RESPECTIVELY REQUEST YOU LOOK INTO THIS MATTER AND ANYTHING YOU CAN DO WILL BE SINCERELY APPRECIATED. *TR

18" RIMS ON FORD F-250SD REPLACED IN AUG. 2009 WITH SAME STYLE RIM. OUTER COVER SEPARATES FROM RIM. NOW, OCT. 2010, SAME PROBLEM, NEED TO BE REPLACED AGAIN. ONLY THING HOLDING THE "GLUED" COVERS ON WERE THE WHEEL WEIGHTS. RIM COVERS COULD OF FLEW OFF TRUCK AT ANY TIME. FORD IS WILLING TO COMPROMISE AND HELP OUT (AFTER CONTACTING DEALER PRESIDENT) BUT STILL HAVE TO PAY MONEY TO UPGRADE TO ALUMINUM RIMS. DON'T SEE WHY I HAVE TO PAY ANYTHING FOR AN OBVIOUS FORD DEFECT. LIKE I STATED BEFORE THIS IS THE SECOND TIME IN A YEAR. *TR

I HAVE A 2008 F-250 S/D MANUFACTURED 02/08 AT THE KENTUCKY PLANT. THIS VEHICLE WAS PURCHASED NEW IN APRIL 2009 AND NOW HAS JUST UNDER 8000 MILES ON THE ODOMETER. I HAVE TWICE EXPERIENCED UNCONTROLLED INVOLUNTARY ACCELERATION WITH THIS VEHICLE. THE COMMON ELEMENTS OF THIS HAVE BEEN THAT IT OCCURRED AFTER A PERIOD OF EXTENDED DRIVING AT ABOUT 70 MPH, USING CRUISE CONTROL, JUST AFTER AN EXHAUST CLEANING CYCLE, AND WHEN I OVERRODE THE CRUISE CONTROL TO ACCELERATE TO PASS A VEHICLE IN FRONT OF ME. WHEN PULLING BACK IN TO THE TRAFFIC LANE, THE VEHICLE CONTINUES TO ACCELERATE AND CAN BE CONTROLLED ONLY BY MAINTAINING HEAVY PRESSURE ON THE BRAKES UNTIL A SAFE LOCATION CAN BE FOUND TO PULL OFF THE ROAD AND CUT OFF THE IGNITION. A RESTART IN NEUTRAL WILL RESULT IN AN IMMEDIATE RUN-UP IN RPM WHICH REQUIRES A SHUT DOWN OF THE IGNITION. THERE ARE NO "CHECK ENGINE" OR "SERVICE ENGINE" LIGHTS DISPLAYED, AND ACCORDING TO FORD DEALERSHIPS, NO CODES REGISTERED IN THE PCM. IN BOTH CASES I HAVE BEEN ABLE TO CORRECT THE PROBLEM AND CONTINUE TO DRIVE THE VEHICLE (WITHOUT USE OF CRUISE CONTROL) BY PRESSING A "RESET" BUTTON LOCATED ON THE TOP OF A WHITE SENSOR LOCATED IN THE AIR INTAKE DUCT ON THE RIGHT SIDE OF THE ENGINE COMPARTMENT. FORD SAYS THEY ARE UNABLE TO DUPLICATE THE PROBLEM AND CONSEQUENTLY CANNOT "MAKE A FIX". I AM MOST CONCERNED BECAUSE THIS IS A SIGNIFICANT SAFETY ISSUE. *TR

DEFECTIVE RADIATIOR IN 2008 F-250 (AND F-350 THROUGH RESEARCH OF OWNER FORUMS) ARE DEFECTIVE AND LEAK AT OVER 40,000 MILES. DEALERSHIPS ARE REPLACIING THESE AT OWNER COST BY THE HUNDREDS. *TR

TL*THE CONTACT OWNS A 2008 FORD F-250. THE VEHICLE HAS A 2006 PILOT TRAILER. THE CONTACT STATED THAT THE TRAILER CABLE THAT HOOKS ONTO THE REAR OF THE VEHICLE FAILED. THE ORIGINAL DESIGN WAS FLAWED AND CAUSED HIM TO LOSE THE TRAILER LIGHTS, AS WELL AS UNNECESSARY WEAR AND TEAR TO THE BRAKING SYSTEM. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 1,200. UPDATED 8/18/09 *CN UPDATED 08/21/09

I WAS SIMPLY DRIVING DOWN THE HWY AND HIT A SMALL BUMP IN THE ROAD, MY TRUCK BEGAN TO SHAKE UNCONTROLLABLY AND CONTINUED TO DO SO UNTIL I SLOWED WAY DOWN. I MADE IT TO THE NEXT EXIT AND DROPPED IT OFF AT THE LOCAL FORD DEALERSHIP. IT STARTLED ME SO MUCH THAT I DIDN'T WANT TO DRIVE IT LIKE IT WAS. THIS IS THE THIRD TIME THIS HAS HAPPENED BUT THE FIRST TWO TIMES WERE NOT AS EXTREME. THE DEALER SO FAR HAS TOLD ME THEY THINK IT IS TIRE PRESSURE BUT IM NOT BUYING IT.. I SEARCHED FOR RECALLS AND FOUND NONE BUT I FOUND A LOT OF COMPLAINTS ABOUT THE SAME OR SIMILAR PROBLEM. I DON'T KNOW WHAT THE PROBLEM IS BUT IT IS DEFINATELY VERY DANGEROUS AND SHOULD BE LOOKED AT FOR A POSSIBLE RECALL. IF THERE HAD BEEN MORE TRAFFIC I COULD HAVE CAUSED AN ACCIDENT AS IT WAS A VERY VIOLENT SHAKING. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER, FAILED TO ACCELERATE, THE ENGINE MADE AN ABNORMAL NOISE, AND WHITE SMOKE WAS SEEN COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.

I OWN A FORD F250, MY COMPLAINT IS ABOUT A 7 PIN TRAILER PLUG, WHAT HAPPENS IS THAT THE PLUG FALLS OFF THE CONNECTOR AS I AM DRIVING. I HAVE NOTICED THAT FORD CHANGED THERE DESIGN ON THE PLUG, THEY TURNED IT TO THE RIGHT SO THE LOCK IS SIDE, INSTEAD OF BEING ON THE TOP. I HAVE TRY TO TALK TO FORD ABOUT THIS AND THEY SAY THERE'S NOTHING THEY CAN DO. I DO BELIEVE THAT THIS IS A SAFETY ISSUE, I LOOSE MY BRAKES TO MY TRAILER EVERYTIME THIS HAPPENS MAKING IT VERY UNSAFE TO DRIVE. *TR

THE REAR U-JOINTS ON MY 2008 FORD SUPERDUTY F250 TRUCK HAS BEEN REPLACED TWICE IN LESS THAN 50,000 MILES, ONCE AT 24,000 MILES AND AGAIN AT 47,000 MILES. FORD HAS FIXED THE PROBLEM BOTH TIME AT NO CHARGE. BUT HAS NOT TRIED TO DETERMINE THE CAUSE FOR THIS PROBLEM TO PREVENT IT FROM HAPPENING AGAIN AT A INCREASED RATE. TRUCK NOW HAS 51,652 MILES ON IT. *TR

MY 2008 FORD F-250 SUPER DUTY HAS A GAS PEDAL THAT STICKS TO THE FLOOR MAKING YOU GO FULL THROTTLE. THIS HAS HAPPENED SO OFTEN THAT I AM USED TO THROWING THE TRUCK INTO NEUTRAL TO STOP FROM HITTING PEOPLE AND THEN KICKING THE GAS PEDAL UNTIL IT RELEASES. THE DEALERSHIP SAYS THEY FIND NOTHING WRONG THAT THEY CAN FIX, THEY THINK THE CARPETING IS CATCHING THE PEDAL. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 60-80 MPH AND OVER A ROAD BUMP WHEN THE FRONT END BEGAN TO SHAKE UNCONTROLLABLY CAUSING HIM TO LOOSE CONTROL OF THE STEERING. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE TIRE PRESSURE WAS TOO LOW. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000. THE VIN WAS UNAVAILABLE.

PURCHASED NEW 2008 F-250 ON 3/21/09. UPON DETAILED INSP OF VEHICLE'S UNDECARRIAGE, I NOTICED THE SPARE TIRE WAS 2" SMALLER THAN THE ROAD TIRES. 18" VICE 20". I WAS TOLD BY THE DEALER THAT THIS IS STANDARD PRACTICE. THIS TRUCK WAS PURCHASED WITH THE INTENT OF TOWING A FIFTH WHEEL CAMPER. IF I AM 30-100 MILES FROM CIVILIZATION AND HAVE A FLAT, THE TIRE SIZE DIFFERENCE WITH THE LOAD ON THE TRUCK CAN'T BE THAT SAFE. IS THIS A LEGAL PRACTICE? *TR

SUDDEN INTENSE INTENSE SMOKE FROM TAILPIPE AT TIME OF EXHAUST CLEANING FROM MY 2008 FORD F250 DIESEL PICKUP (FORD CONSIDERS NORMAL OPERATION OF SYSTEM) WHILE ENTERING A TOLL PLAZA CREATED A SUDDEN AND UNSAFE CONDITION FOR OTHER DRIVERS BEHIND ME. THE SMOKE WAS SO HEAVY I COULD NOT SEE VEHICLE BEHIND WHILE PASSING THROUGH A TOLL PLAZA. THE LANE I WAS IN UTILIZES A TRANSPONDER TO COLLECT TOLL WHILE TRAFFIC IN THAT LANE NORMALLY DOES NOT STOP. IF A VEHICLE HAD BEEN STOPPED THE DRIVERS BEHIND ME WOULD NOT HAVE BEEN ABLE TO REACT IN TIME. IT WAS ALSO POSSIBLE THAT THEIR VISIBILITY OF THE STRUCTURES OF THE TOLL PLAZA ITSELF WERE SUFFICIENTLY DIMINISHED THAT A COLLISION WITH THE STRUCTURE WAS POSSIBLE. I PASS THROUGH THREE TOLL PLAZAS EACH WAY, TO AND FROM WORK, 5 DAYS A WEEK. *TR

2008 FORD F250 CREW! WHERE DO I BEGIN? I'VE HAD THIS TRUCK IN MORE TIMES THAN I CAN COUNT! MOST RECENTLY FOR POWER STEERING ISSUES! I'M HAVING IT WORKED ON FOR THE THIRD TIME TODAY! ALONG WITH ANOTHER PROBLEM WITH THE FRONT DRIVE SHAFTS, WHICH IT HAS BEEN IN AT LEAST TWO OTHER TIMES FOR! THE POWER STEERING DOESN'T WORK AT LOWER SPEEDS WHEN TRYING TO MANEUVER AROUND OR EVEN WHEN TRYING TO TURN AROUND! YOU LITERALLY HAVE TO CRANK AS HARD AS YOU CAN TO GET IT TO TURN AND BEING A FAIRLY FIT 28 YEAR OLD CONSTRUCTION WORKER I SHOULDN'T HAVE TO WORK THAT HARD TO TURN THE WHEEL ON A TRUCK THAT HAS POWER STEERING! I JUST ABOUT RAMMED A LIGHT POLE WHILE OUT PLOWING AT ABOUT 15 MILES AN HOUR WITH MY 2 YEAR OLD RIDING IN THE BACK! THIS OF COURSE WAS BEFORE I HAD IT IN THE LAST TIME AND IT IS A LITTLE BETTER BUT THE PROBLEM PERSISTS AND I DON'T WANT TO BE DRIVING THIS TRUCK TRYING TO GET ONTO A ROADWAY WITH ANY OF MY FOUR CHILDREN WHEN IT DECIDES TO ACT UP AND GET HIT BY A MACK TRUCK! I HOPE SOMETHING CAN BE DONE WITH THIS AND HOPE TO HEAR BACK! THANK YOU!!! *TR

TL*THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE HESITATES WHEN THE ACCELERATOR PEDAL IS DEPRESSED. THE FAILURE HAS BEEN OCCURRING EVER SINCE THE DEALER CHANGED THE COMPUTER IN THE INTERNAL ENGINE. THE CONTACT RECEIVED A NOTICE STATING THAT IT NEEDED TO BE CHANGED. THE DEALER STATED THAT THE VEHICLE WAS FINE, ALTHOUGH IT HAS BEEN IN THE REPAIR SHOP APPROXIMATELY THREE TIMES FOR THIS SAME ISSUE. THE FAILURE IS DUE TO THE COMPUTER MODULE, WHICH HAS CAUSED THE VEHICLE TO HAVE POOR FUEL MILEAGE. THE DEALER ACKNOWLEDGES THE FAILURE AND THE CONTACT BELIEVES IT IS A SAFETY ISSUE. THE FAILURE MILEAGE WAS 16,000 AND CURRENT MILEAGE WAS 23,000. UPDATED 8/10/09 *CN UPDATED 08/13/09.*JB

TL*THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE LOST ALL POWER, BRAKE, AND STEERING ABILITY. THE DEALER REPLACED THE POWER STEERING PUMP AT THE CONTACT'S EXPENSE. THE DEALER STATED THAT THEY WERE AWARE OF THE FAILURES, BUT COULD NOT PROVIDE A REMEDY. THE FAILURE HAS OCCURRED INTERMITTENTLY APPROXIMATELY 100 TIMES. THE FAILURE MILEAGE WAS 300 AND CURRENT MILEAGE WAS 60,000. UPDATED 06/08/09 *BF THE CONSUMER STATED THE VEHICLE NOW HAS A POWER STEERING FLUID LEAK. UPDATED 06/18/09.*JB

MANUFACTURER DEFECT ON THE RADIATOR FOR A TWO YEAR OLD F-250 SUPER DUTY. THE DEFECT IS ON THE SEAM OF THE RADIATOR. *TR

TL*THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING 10 MPH ON ICY ROAD CONDITIONS, THE CONTACT NOTICED THAT HIS FOUR WHEEL DRIVE WOULD NOT ENGAGE ON TWO DIFFERENT OCCASIONS. THE RISK OF A CRASH WAS INCREASED. THE DEALER STATED THAT THE VACUUM HOSE FOR THE FOUR WHEEL DRIVE WAS MANUFACTURED TOO SHORT. THEREFORE, WHEN MAKING SHARP TURNS, THE COMPONENT WOULD EASILY FAIL. THE HOSE HAS BEEN REPLACED TWICE AT THE COST OF $56 PER HOSE. THE FAILURE MILEAGE WAS 40,000 AND CURRENT MILEAGE WAS 44,000. UPDATED 3/24/09 *CN UPDATED 03/27/09.*JB

2008 FORD F-250 SUPERDUTY DRIVING AT 40-70 MPH STRAIGHT OR TURNING (IE: ON A FREEWAY FLY-OVER). THE FRONT-END SHAKES/SHIMMIES WHEN YOU HIT A BUMP, POTHOLE, OR SURFACE THAT IS UNEVEN TO THE POINT YOU LOSE CONTROL OF VEHICLE. HAPPENS MOST ALL THE TIME IF ON FLY-OVER, AND ON STRAIGHT ROADS SOMETIMES. DEALER SAYS IT IS TIRE PRESSURE, DOES NOT WORK. THEN TOLD TO REPLACE STRUTS OR ADJUST STEERING DAMPER. WORKS TEMPORAILY. NO USED PARTS. *TR

MY DAUGHTER AND HER FIANCE WERE INVOLVED IN A WRECK. HIS 2008 FORD F-250 SUPER DUTY TRUCK FLIPPED END OVER END. THEY WERE VERY BADLY INJURED. THE DRIVER AIR BAG NOR THE PASSENGER SIDE AIR BAG DEPLOYED. HIS NECK WAS BROKEN BY THE STEERING WHEEL OR DASH AND SHE RECEIVED INJURIES TO HER FACE AND HAD TO GET STITCHES, ALONG WITH OTHER INJURIES. WE SAW A FORD F-150 A FEW DAYS LATER WITH DAMAGE TO THE FRONT END AND PASSENGER SIDE AND THE AIR BAGS DEPLOYED. I WANT TO KNOW IF THIS IS A DEFECT IN HIS PICKUP AND WHAT CAN WE DO. *TR

DETAILS: INSTRUMENT CLUSTER, . ALL OF THE GAUGES DISPLAYED ZERO. THE VEHICLE WOULD OPERATE, BUT NOTHING WOULD DISPLAY ON THE INSTRUMENT PANEL. *TR

RADIATOR HAS FAILED FOUR TIMES. THE FOURTH TIME IT FAILED IT WAS OUT OF WARRANTY. FORD REFUSES TO ACKNOWLEDGE THE DEFECT. *TR

TL* THE CONTACT OWNS A 2008 FORD F-250. WHILE DRIVING VARIOUS SPEEDS AND WHEN DRIVING OVER BUMPS IN THE ROAD, THE FRONT END OF THE VEHICLE SUDDENLY BECAME EXTREMELY UNSTABLE, SHOOK, AND VIBRATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 13.

TL* THE CONTACT OWNS A 2008 FORD F250. THE CONTACT STATED WHEN DEPRESSING THE BRAKE PEDAL, THE ACCELERATOR PEDAL WAS SIMULTANEOUSLY DEPRESSED. THE CONTACT BELIEVED THAT THE TWO PEDALS WERE MANUFACTURER TOO CLOSE TO EACH OTHER. THE DEALER WAS NOTIFIED OF THE PROBLEM BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000. THE VIN WAS NOT AVAILABLE. UPDATED 06/24/11 *BF THE CONSUMER OWNS FOUR OTHER 2008 FORD F-250'S. UPDATED 09/16/11

ON 2 OCT 2008, RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING AT LEFT LOWER CORNER AT 6,240 MILES AND WAS REPLACED BY FORD UNDER 3YR/36000 WARRANTY. FORD INSTALLED DEGAS BOTTLE "T" FITTING TO ELIMINATE ANY FURTHER RADIATOR FAILURE. ON 12 MAR 2012, RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING FROM LEFT LOWER CORNER AT 47,895 MILES. FORD SAID FAILURE WAS CAUSED DUE TO AN HYPER-EXTENDED THERMOSTAT. FORD REPLACED THERMOSTAT UNDER WARRANTY BUT WOULD NOT COVER RADIATOR UNDER WARRANTY. RADIATOR WAS REPLACED BY NON-FORD MECHANIC. ON 25 APR 2013 RADIATOR WAS DISCOVERED TO BE CRACKED AND LEAKING FROM RIGHT SIDE SEAM AT 58,520 MILES. FORD WAS CONTACTED AND OFFERED NO HELP OUTSIDE OF WARRANTY. RADIATOR WAS REPLACED BY NON-FORD MECHANIC OUTSIDE OF WARRANTY. IT DOESN'T TAKE A ROCKET SCIENTIST TO KNOW THERE IS SOMETHING SERIOUSLY WRONG WITH THE 08 F250 6.4 COOLING SYSTEMS THAT FORD FAILS TO TAKE RESPONSIBILITY FOR. I TOW A 35FT 5TH WHEEL SEVERAL TIMES A YEAR AND MY BIGGEST FEAR IS THE RADIATOR GOING OUT WHILE TOWING. IF THE RADIATOR BLEW AND THE TRUCK WENT INTO "REDUCED POWER" MODE, THERE IS A GREAT POSSIBILITY THAT A LIFE THREATENING INCIDENT COULD OCCUR, ESPECIALLY WHILE TOWING ON A STEP INCLINE. I HOPE FORD FIGURES THIS OUT SOON BEFORE SOMEONE GETS HURT.

WE HAVE A NUMBER OF 2008 FORD F-250 PICK UP TRUCKS IN OUR FLEET. THE RIGHT SIDE MIRROR CONSTANTLY VIBRATES OUT OF POSITION, CAUSING A DANGEROUS SITUATION WHEN BACKING UP. IT SHAKES OUT OF POSITION WITHIN 5 MINUTES OF SETTING IT. IT IS A MANUAL ADJUSTING MIRROR. WE ARE A MUNICIPALITY LOCATED IN OHIO, AND HAVE TAKEN THE VEHICLES TO FORD, WHO STATE THERE IS NOTHING THAT THEY CAN DO. *TR

TL*THE CONTACT OWNS A 2008 FORD F-250. THE VEHICLE HAS FOUR CONTINENTAL TIRES. THE CONTACT STATED THAT THREE OF THE TIRES WERE LEAKING AIR. THE REMAINING TIRE HAS NINE HOLES INSIDE THE THREAD AND THE CONTACT HAS TO PLACE AIR IN IT EVERYDAY. THE MANUFACTURER DOES NOT WANT TO REPLACE THE TIRES. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT FORD WOULD NOT HONOR THE REPAIR. THE TIRE LINE AND SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND CURRENT MILEAGE WAS 8,000.