2015 Ford Fusion Complaint Log

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT THE ENGINE EXPERIENCED A MISFIRE AT START-UP. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE VIBRATED ABNORMALLY WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO FORD STORE SAN LEANDRO (1111 MARINA BLVD, SAN LEANDRO, CA 94577) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

THE SYNC INTOUCH SYSTEM IN MY 2015 FORD FUSION IS NOT WORKING PROPERLY. FOR EXAMPLE, WHEN I GO TO MY CLIMATE SETTING IT STATES TEMPORARY LOST COMMUNICATION WITH THE CLIMATE SYSTEM. I'M NOT ABLE TO TURN MY VOLUME ON OR OFF/UP OR DOWN, OR CHANGE THE RADIO STATION. I'M ALSO NOT ABLE TO ROLL DOWN MY PASSENGER SIDE WINDOW. THE ISSUE HAPPENS WHETHER I'M STATIONARY OR DRIVING. *TR

BOUGHT USED IN FEB 2019. IN JULY OF SAME YEAR IT WAS DIAGNOSED BLOWN HEAD GASKET CYL 2. OUT OF WARRANTY SO HAD TO PAY $3,100.00 TO REPLACE. NOW, 9 MONTHS LATER, SAME THING CYLINDER 2. IN DECEMBER OF 2019 FORD CAME OUT WITH BULLETIN TSB 19-2375 STATING THE BLOCK NEEDS REPLACED TO SOLVE THIS PROBLEM. THAT IS AN OVER $6,000.00 REPAIR. I CALL THAT A DEFECTIVE BLOCK WHICH SHOULD WARRANT A RECALL, FORD SIMPLY TOLD ME IT'S CALLED OUT OF WARRANTY AND IT'S MY PROBLEM. MY PROBLEM IS, IT'S MY ONLY FORM OF TRANSPORTATION. SO WHAT IT IS DOING IS WHEN I START IT, IT RUNS ROUGH BECAUSE IT IS MISFIRING DO TO COOLANT LEAK INTO THE CYLINDER AND WHITE SMOKE COMES OUT OF EXHAUST. IT IS MY BELIEF THAT FORD KNOWS THIS IS A DEFECTIVE BLOCK OTHERWISE THEY WOULD NOT HAVE ISSUED THE BULLETIN. AN INTERNET SEARCH WILL SHOW MANY OTHER OWNERS OF THE 2014 THROUGH 2019 PRODUCED 1.5 LITER MOTORS HAVE THE SAME PROBLEM. I TRIED TO UPLOAD THE REPAIR BILL AND THE TSB BULLETIN BUT IT STATED FILE TOO BIG.

THE DOOR LATCH OF THE REAR LEFT DOOR WON'T LATCH. I AM UNABLE TO CLOSE THE DOOR (DOOR STAYS OPEN, UNLOCKED). I TRIED NUMEROUS TIMES TO SHUT THE DOOR CLOSED UNSUCCESSFULLY. THE CAR WAS STATIONARY THIS MORNING WHEN I WENT AND OPENED THE DOOR, BUT WHEN I TRIED TO CLOSE I NOTICE THE DOOR STAYS LOOSE OPEN.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE'S FRONT DRIVER-SIDE DOOR LOCK FAILED TO LATCH SECURELY. THE CONTACT SECURED THE DOOR WITH STRAPS. THE CONTACT CONTACTED BELL FORD (2401 W BELL RD, PHOENIX, AZ 85023, (602) 457-2144) WHO INFORMED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 20V177000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

FORD FUSIONS HAVING A COOLANT LEAK INTO THE ENGINE . I'VE HEARD FROM MULTIPLE PEOPLE HAVING THE SAME ISSUE & NOW I'M HAVING THE SAME PROBLEM AFTER ONLY HAVING MY FUSION FOR TWO YEARS & STILL MAKING PAYMENTS. CAR MAKES A SLOSHING NOISE IN DASHBOARD WHEN ACCELERATING , TURNING OR BRAKING & CAR OVERHEATS DUE TO COOLANT LEAKING INTO ENGINE & HAVING TO CONSTANTLY REFILL COOLANT . *TR

HAS PROBLEMS STARTING AFTER PUTTING GAS IN THE TANK. CHECK ENGINE LIGHT ON, MECHANIC SAYS IT'S A PURGE VALVE. KNOW ALOT OF OTHER FUSION OWNERS WITH SAME PROBLEM. SEEMS TO BE HAPPENING AROUND 40,000 MILES. HAVE TO SIT AT GAS STATION ABOUT 10 TO 15 MIN SOMETIMES. OTHERS TIMES JUST STARTS ROUGH.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V177000 (LATCHES/LOCKS/LINKAGES) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT WITHOUT WARNING, THE DRIVER'S SIDE REAR DOOR LATCH FRACTURED. THE CONTACT STATED THAT A ROPE WAS TIED TO THE DOOR HANDLE TO KEEP THE DOOR CLOSED. THE VEHICLE WAS TAKEN TO TROPICAL FORD (9900 ORANGE BLOSSOM TRAIL, ORLANDO, FL 32837) WHERE IT WAS DIAGNOSED HOWEVER, THE CONTACT WAS INFORMED THAT PARTS WERE NOT YET AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 73,000.*DT*JB

IN OCT. 2019 I BOUGHT A 2015 FORD FUSION SE WITH 65K MILES ON IT. SINCE THEN I HAVE PUT 4K MILES ON IT. ON 3/17/20 MY CAR STARTED CUTTING OUT AND THE SERVICE ENGINE SOON LIGHT CAME ON. I DROVE IT 1/2 MILE TO THE NEAREST STORE AND CALLED MY FRIEND TO BRING HIS CAR CODE READER. IT WAS SHOWING A MISFIRE ON CYLINDER 2. WENT AND GOT A SPARK PLUG AND NEW COIL PACK AND PUT ON IT. THE CAR WAS RUNNING ROUGH AND WAS STILL SHOWING A MISFIRE ON CYLINDER 2. HAD THE CAR TOWED TO A REPAIR SHOP IN PRATTVILLE, AL. TO SEE WHY IT WAS STILL SHOWING A MISFIRE ON CYLINDER 2. I WAS TOLD THAT THERE WAS A CRACK IN THE HEAD AROUND CYLINDER 2. I CALLED RIVERSIDE CHEVROLET IN WETUMPKA, AL BECAUSE THAT IS WHERE I BOUGHT THE CAR. THE CALLED COLLIER FORD IN WETUMPKA, AL BECAUSE OF THE LOW MILES ON IT TO SEE IF THEY COULD LOOK AT IT FOR ME AND POSSIBLE HELP ME OUT WITH THE COST. I HAD IT TOWED TO COLLIER FORD AND WAS TOLD THAT THE BLOCK IS CRACKED AND THAT THE SERVICE MANAGER AT COLLIER FORD AND THE GENERAL MANAGER AT RIVERSIDE CHEVROLET WAS IN CONTACT WITH FORD TO SEE IF THEY CAN GET THIS RESOLVED FOR ME. AS OF TODAY 3/25/20 I STILL DON'T HAVE AN ANSWER AS TO IF FORD IS GOING TO REPLACE MY MOTOR. I NOTICED AFTER DOING RESEARCH THAT THIS IS AN COMMON PROBLEM. I DON'T UNDERSTAND WHY THIS HASN'T BECOME A RECALL YET. FORD NEEDS TO STAND BEHIND THERE PRODUCT.

AFTER GETTING GAS THE VEHICLE HESITATES TO START. ONCE STARTED AND PRESSING OF THE GAS PEDAL THE CAR RESIST MOVING FORWARD. ON OCCASION A LOUD AIR SOUND COMES FROM WHERE GAS IS PUMPED IN. IF I STOP TO OPEN THE GAS DOOR AND RELEASE THE AIR IN THE LINE THE CAR CREATES ANOTHER LOUD SOUND LIKE AIR OUT OF A TIRE. YOU CAN SMELL GAS AROUND THE VEHICLE WHETHER I PUMP IT IN OR NOT. THIS HAS HAPPEN ON NUMEROUS OCCASIONS BUT THE LAST TIME WAS ON MARCH 12, 2020.

I BEGAN TO HEAR A SCRAPPING NOISE IN THE ENGINE COMPARTMENT. I TOOK THE CAR TO HAVE THE OIL CHANGED AND WAS TOLD THAT I NEEDED TO HAVE THE TRANSMISSION FLUID CHANGED AND IT WAS A CLOSED SYSTEM AND ONLY FORD WOULD BE ABLE TO DO THIS. I TOOK MY CAR TO KNOX FORD WHERE I PURCHASED IT AND HAD THEM CHANGE THE TRANSMISSION FLUID AND DIAGNOSE THE PROBLEM. I WAS TOLD THAT THE WATER PUMP WAS BAD AND NEEDED REPLACED. AFTER INVESTIGATING I FOUND THAT THIS WAS TIMING DRIVEN AND AGAIN ONLY FORD COULD DO THIS REPAIR. I TOOK THE CAR IN THE NIGHT BEFORE AND THEY QUOTED ME 672.00 FOR THE REPAIR. I WAS TOLD THIS WOULD TAKE 4.5 HOURS TO COMPLETE. AT 5PM THE FOLLOWING DAY I PICKED UP MY VEHICLE ONLY TO FIND OUT THEY HAD JUST FINISHED IT. I WAS TOLD THEN THAT IT TOOK LONGER BECAUSE THE ORIGINAL WATER PUMP WAS DISCONTINUED BECAUSE FORD KNEW THE PART WAS BAD. THEY CONTINUED TO TELL ME THAT THEY HAD TO RESEARCH HOW TO CUT THE WIRES THAT WERE NO LONGER NEEDED AND INSTALL THE NEW WATER PUMP. V

RIGHT REAR DOOR LOCK DOES NOT REMAIN LOCKED, EVEN WHEN CAR IS IN MOTION. YOU ARE ABLE TO UNLOCK AND OPEN THE DOOR FROM THE INSIDE WHEN VEHICLE IS IN MOTION. THIS HAPPENS ON CITY STREETS AT 30 MPH OR GOING DOWN THE HIGHWAY AT 55 MPH. FIRST NOTICED IN MARCH 2020, BUT ONGOING. MY GRANDSON SITS IN THE REAR IN HIS CAR SEAT AND HAD ON SEVERAL OCCASIONS HE CAN OPEN THE DOOR, WHILE DRIVING DOWN ROAD.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHCILE STALLED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER COLONIAL FORD LOCATED AT 126 FEDERAL RD #126, DANBURY, CT 06811, WHO DIAGNOSED THAT ENGINE CYLINDER #2 WAS DEFECTIVE, AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 126,000. THE VIN WAS NOT AVAILABLE.

EARLIER THIS YEAR IN FEBRUARY, VEHICLE WAS IN MOTION AND FAILED TO ACCELERATE. AFTER ANOTHER ATTEMPT WAS ABLE TO GET CAR TO ACCELERATE AND MADE IT HOME. CAR WAS SHAKING AND SMOKE COMING FROM TAILPIPE. CAR WAS TOWED TO DEALERSHIP FOR DIAGNOSTICS AND WAS TOLD I NEEDED A NEW ENGINE DUE TO COOLANT LEAKING INTO ENGINE. HAD ENGINE REPLACED AND NOW 8 MONTHS LATER, I'M HAVING THE SAME ISSUE. CAR IS SHAKING UPON START AND ENGINE LIGHT IS ON. FORD HASN'T DECLARED A RECALL FOR THIS ISSUE, EVEN AFTER MULTIPLE REPORTS OF THIS BEING A KNOWN PROBLEM.

THE LUG NUTS MAKE IT IMPOSSIBLE TO REMOVE WITH EITHER THE TOOL FORD PROVIDED, A 4 WAY WRENCH OR SOCKETS WHEN I GOT A FLAT. I COULD HAVE BEEN KILLED FIGHTING WITH THIS ON THE SIDE OF THE ROAD. I BELIEVE FORD SHOULD HAVE TO REPLACE ALL OF THESE LUG NUTS AS A SAFETY CONCERN SINCE THEY ARE DEFECTIVE.

STEERING SYSTEM HAS COMPLETELY LOCKED ON INITIAL STARTING VEHICLE. CAR WILL SHIFT INTO DRIVE AND REVERSE, BUT WILL NOT STEER LEFT OR RIGHT. THIS HAPPENED ON TWO OCCASIONS, 2/14 AND 15/2020. STEERING WILL ONLY BECOME OPERATIONAL AFTER CAR HAS BECOME HEATED, AFTER APPROXIMATELY 20 MINUTES. THIS ALL HAPPENED EARLY MORNING HOUR OF TEMPERATURE OF APPROXIMATELY 8 DEGREES. THIS ALSO HAPPENED ON MY LAST FORD FUSION 2010, WHICH I TRADED IN FOR THIS FORD FUSION.

THE ENTIRE CENTER CONSOLE INSTRUMENT PANEL STOPS WORKING. THE RADIO WILL NOT WORK AND THE CLIMATE CONTROL AND REAR DEFROSTER WILL NOT WORK. I AM UNABLE TO DEFROST THE WINDOWS OR KEEP THE ENTIRE CABIN OF THE CAR WARM. IT FIRST HAPPENED THIS MORNING WHEN I WAS HEADED TO WORK. I DROVE THE CAR FOR APPROXIMATELY ONE MILE, AND EVERYTHING STOPPED WORKING. I PULLED OVER AND SHUT THE CAR DOWN AND RESTARTED IT, EVERYTHING WORKED FOR APPROXIMATELY A MINUTE BEFORE SHUTTING DOWN AGAIN.

MY CAR WAS PARKED AND WHEN I TURNED IT BACK ON I DIDN'T HAVE POWER STEERING. IT HAS BEEN DIAGNOSED A FORD DEALER (DOVI MOTORS, CORTLAND, NY) AS MY POWER STEERING GEAR MOTOR DETACHED DUE TO THE BOLTS CORRODING THAT RESULTED IN A LOSS OF POWER STEERING AND UNSAFE DRIVING. THERE IS AN ACTIVE RECALL FOR THE YEAR/MAKE/MODEL OF MY CAR FOR THIS EXACT ISSUE BUT MY VIN WAS NOT INCLUDED IN THE RECALL (NUMBER 19S26). THIS RECALL NEEDS TO BE RE-EVALUATED TO PREVENT INJURY TO OTHERS AFFECTED.

THE CONNECTOR TO THE FRONT HEATED AND COOLED SEAT MODULE NEARLY CAUGHT FIRE, WITHOUT ANY INTERVENTION OR ALTERATION.

VEHICLE HAS 100,215 MILES AND IS 5 YEARS OLD MID JANUARY 2020 CHECK ENGINE LIGHT CAME ON. CODE 303 - CYLINDER 3 MISFIRE. CHANGED SPARK PLUGS. SAME CODE. HAD VEHICLE CHECKED BY PRIVATE MECHANIC. COOLANT LOCATED IN CYLINDER 3. CASE STARTED WITH FORD MOTOR CO. VEHICLE TAKEN TO FORD DEALERSHIP WHERE IT WAS ORGINALLY PURCHASED. AFTER ADDING DYE TO THE COOLANT THEY VERIFIED THE CYLINDER #3 LEAK. THEY RECCOMEND AN ENGINE REPLACEMENT - $6550.20. THEY OFFERED TO BUY VEHICLE FROM US FOR $1500.00. OH, AND I SHOULD MENTION THAT THE VEHICLE WAS OFFICIALLY PAID OFF ONE WEEK BEFORE THE CHECK ENGINE LIGHT CAME ON AND THIS ALL STARTED. SEE ATTACHED INVOICE FROM FEBRUARY 2020

The contact owns a 2015 Ford Fusion. The contact stated while driving at various speeds, the vehicle shuddered and there was white smoke coming from the exhaust pipes. The check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that there was a coolant leak into the engine and that the engine needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to a local independent mechanic where it was diagnosed that the ignition coils and spark plugs needed to be replaced. The vehicle was repaired but the failure reoccurred. The vehicle was taken back to the local dealer where it was diagnosed and determined that the engine needed to be replaced again. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 86,000.

MY SISTERS VEHICLE HAS STARTED ROLLING DOWN HER DRIVEWAY AND SHE GOT BACK IN THE CAR AND SEEN THAT THERE IS A TRANSMISSION NOT IN PARK MESSAGE AND WE FOUND THAT THE GEAR SELECTOR CABLE HAS BROKE OFF THE GEAR SELECTOR LEVER. IT IS NOT SAFE FOR MY SISTER TO DRIVE THIS VEHICLE. IT'S A DRIVING HAZARD. I HAVE FOUND A RECALL FROM 2014 ABOUT POTENTIAL VEHICLE ROLLAWAY FOR HER VEHICLE BUT IT'S NOT OPEN ON HER VEHICLE ANYMORE. SHE HAD THIS PROBLEM BEFORE AND TOOK IT INTO THE DEALERSHIP TO GET THIS FIXED AND IT HAPPENS AGAIN

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE DIAGNOSTIC TROUBLE CODE INDICATED A MISFIRE ON CYLINDER #1. THE CONTACT STATED THAT THE VEHICLE SHUDDERED WHILE DRIVING WITH AN ABNORMAL KNOCKING SOUND COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO FORD OF TUSCOLA, INC (406 E SOUTHLINE RD, TUSCOLA, IL 61953, (217) 253-3353) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT COOLANT LEAKED INTO THE CYLINDER AND THAT THE ENGINE BLOCK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE REPAIR WAS NOT COVERED UNDER WARRANTY OR A RECALL. A CASE WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

MILEAGE OF CAR IS 53,100. WIFE (DRIVER) REPORTED THAT WHILE DRIVING IN NORMAL TRAFFIC AT NIGHT, THE CAR LOST ALL ELECTRICAL POWER: LIGHTS, MOTOR FUNCTION, RADIO, ETC. SHE TURNED ON THE EMERGENCY FLASHERS AND CAME TO A STOP. SHE TURNED THE KEY TO RESTART AND CAR FUNCTIONED NORMALLY. I CHECKED THE CAR THE FOLLOWING DAY AND NO PROBLEMS DETECTED.

I WAS DRIVING BACK FROM GROCERY SHOPPING WHEN I LOST CONTROL OVER STEERING. THE MOMENT WHEN I LOST CONTROL WAS DURING MY SLIGHT RIGHT TURN MOVING AT SPEED OF ABOUT 30MPH I DID NOT KNOW WHAT HAPPENED AT THE MOMENT BECAUSE I WAS MORE FOCUSED TO NOT HIT ANYONE PRESENR AT THAT MOMENT ON THE ROAD. GOOD THING IS THAT SCHOOL ACROSS THE ROAD WAS CLOSED BECAUSE TIMING WHEN THIS HAPPEN WAS AROUND THE TIME WHEN PARENTS USUALLY PICK THEIR KIDS FOR SCHOOL. AFTER I PARKED CAR I INVESTIGATE TO SEE WHAT HAD HAPPEN. THERE WERE THREE MESSAGES INDICATING THAT SOMETHING WAS WRONG: 1. STEERING ASSIST FAULT - SERVICE REQUIRED, 2. SERVICE ADVANCETRAC AND 3. HILL START ASSIST NOT AVAILABLE. I WAS SEARCHING TODAY TO SEE OTHER PEOPLE EXPERIANCE AND RESULTS WERE POSITIVE A LOT OF CASES LIKE THIS ONE. THINGS THAT ALL REPORTS HAVE IN COMMON IS THAT ALL OWNERS NEEDED TO PAY TO FIX CAR NO OPTION FOR RECAL. EVENTHOUGH THAT MODELS LIKE THIS ONE USED TO HAVE SEVERAL THINGS THAT NEEDED TO BE CHANGED ON SIMILAT THINGS IN THE PAST.

DRIVING FROM CA TO CO FOR CHRISTMAS. WHILE DRIVING DOWN THE ROAD, THE "DOOR OPEN" LIGHT CAME ON AND THE CHIME SOUNDED AS LOCKED LEFT REAR DOOR OPENED!! UNACCEPTABLE FOR A COMPANY THAT HAS MADE VEHICLES FOR OVER 100 YEARS! I DID A GOOGLE SEARCH ON THE PROBLEM LOOKING FOR A FIX. I FOUND A RECALL FOR YEARS 2013-2014 ONLY. NO RECALL FOR MY 2015, WHEN IT IS OBVIOUS THE COST SAVING MEASURES STILL APPLY. I HAD TO TIE THE DOOR CLOSED WITH THE SEATBELT, BUT IT'S NOT TIGHT ENOUGH TO KEEP THE WARNINGS OFF. NO ONE CAN SIT IN THE BACK SEAT DUE TO SEATBELTS BEING USED! WE ARE AFRAID THE OTHER DOOR LATCHES WILL SOON FAIL AS WELL. WE STILL HAVE TO DRIVE BACK TO CA! *DT *DL

TRAVELING IN TRAFFIC AROUND 25 MPH WITH TRAFFIC SLOWING TO A STOP THE BRAKE PEDAL WENT SOFT AND WAS PRESSED TO THE FLOOR WITH ALMOST NO BRAKING AT ALL. THIS RESULTED IN A REAR END COLLISION.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT AT START-UP, THERE WAS AN ENGINE MISFIRE WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT AND THE SPARK PLUGS WERE REPLACED. ONE MONTH AFTER THE SPARK PLUGS WERE REPLACED THE FAILURE RECURRED. THE VEHICLE WAS THEN TAKEN TO A SECOND INDEPENDENT MECHANIC WHERE THE SPARK PLUGS WERE REPLACED A SECOND TIME HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A THIRD INDEPENDENT MECHANIC WHERE SPARK PLUG NUMBER 4 WAS REPLACED HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS THEN TAKEN TO RUXER FORD LINCOLN, INC. (123 PLACE RD, JASPER, IN 47546, (812)482-1200) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THERE WAS A HAIRLINE FRACTURE ON THE ENGINE BLOCK. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WARRANTY WAS EXPIRED. THE FAILURE MILEAGE WAS 43,000.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT UPON STARTING HER VEHICLE, THE VEHICLE BEGAN SMOKING FROM THE TAILPIPE AND WAS EMITTING A GAS ODOR. THE CONTACT WAS UNAWARE IF ANY WARNING LIGHTS ILLUMINATED ON THE VEHICLE. THE CONTACT HAD THE VEHICLE TOWED TO TINDOL FORD LOCATED AT 1901 E FRANKLIN BLVD, GASTONIA, NC 28054 WHERE THE VEHICLE WAS DIAGNOSED WITH A DEFECTIVE INJECTOR WHICH CAUSED THE FUEL TO SEEP THROUGH THE INJECTOR AND MIX WITH THE OIL, CAUSING THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED AFTER THE DIAGNOSIS. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. *DT*JB

TL* THE CONTACT OWNS A 2015 FORD FUSION. AFTER THE VEHICLE CAME TO A COMPLETE STOP, THE SHIFT LEVER WAS PLACED IN PARK. AFTER EXITING THE VEHICLE, IT STARTED TO ROLL BACKWARDS. THE CONTACT STATED THAT THE FAILURE OCCURRED ONCE WITH THE SHIFT CABLE BEING FRACTURED. THE VEHICLE WAS REPAIRED PER A WARRANTY PROGRAM AT LONG-LEWIS FORD LINCOLN VOLKSWAGEN MITSUBISHI (2800 WOODWARD AVE, MUSCLE SHOALS, AL 35661, (256) 386-7800) IN SEPTEMBER OF 2017. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 18V471000 (POWER TRAIN) OR 19V362000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,500.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE THE CONTACT WAS AT A DRIVE THRU, THE BRAKES WENT OUT AND DID NOT STOP THE VEHICLE. THE CONTACT USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO MAC HAIK FORD (713-932-5000, LOCATED AT 10333 KATY FWY, HOUSTON, TX 77024) WHERE IT WAS DIAGNOSED THAT THERE WAS A FAILURE IN THE FRONT BRAKE LINE. THE VEHICLE WAS LEFT AT THE DEALER FOR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 49,800. *DT*JB

The contact owns a 2015 Ford Fusion Energi. The contact stated that the engine control module failed to shutoff the vehicle causing the battery to drain. The contact was then unable to start the vehicle. The failure happened several times over a two-year period. The contact stated that to restart the vehicle he would break into the vehicle through the trunk to get to the battery and jumpstart the vehicle. The contact had taken the vehicle to the dealer and was informed that there was no recall associated with the VIN and that there were no known issues. The contact stated that the manufacturer knew about the issue but decided not to issue a recall. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the issue. The contact was referred to NHTSA for assistance. The approximate failure mileage of 96,000. Consumer found a website explaining exactly what was happening with consumer's car was found on lenberglaw.com lemon law vehicles.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE DRIVING AT AN UNKNOWN SPEED, SEVERAL WARNING INDICATORS ILLUMINATED. THE INTERIOR DOME LIGHT ILLUMINATED AND THE AIR CONDITIONER ACTIVATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO DAHL FORD DAVENPORT (1310 E KIMBERLY RD, DAVENPORT, IA 52807, (563) 391-2600) WHERE IT WAS DIAGNOSED THAT THE OCCUPANT RESTRAINT CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT PREVIOUSLY THE VEHICLE HAD BEEN INCLUDED IN A FRONT END COLLISION HOWEVER, THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS CONCERNED THAT THE FAILURE TO DEPLOY MAY HAVE BEEN DUE TO AN ISSUE WITH THE ORC MODULE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE DRIVING 25 MPH, THE DRIVER'S SIDE BRAKE LINE MALFUNCTIONED. THE BRAKE PEDAL WAS VERY LOOSE AND TRAVELED TO THE FLOORBOARD. THE CONTACT WAS ABLE TO PULL INTO A PARKING LOT AND BUMP AGAINST A CURB TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPAIRED THE DRIVER'S SIDE BRAKE LINE THAT WAS LEAKING BRAKE FLUID. THE FAILURE RECURRED WITH THE PASSENGER SIDE BRAKE LINE, WHICH WAS ALSO REPAIRED BY THE SAME MECHANIC. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED. THE MECHANIC CHANGED A COIL PACK ON CYLINDER NUMBER FOUR ON THE ENGINE, BUT THE FAILURE RECURRED THE FOLLOWING. THE CONTACT STATED THAT THE ENGINE SHOOK AND EXCESSIVE SMOKE POURED OUT OF THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO RIVERSIDE FORD (2089 RIVERSIDE DR, MACON, GA 31204, (478) 464-2900) WHERE THEY CHANGED A SPARK PLUG ON CYLINDER NUMBER FOUR. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE DEALER FOUND COOLANT IN THE ENGINE WITH THE FLUID ENTERING THROUGH THE CYLINDER NUMBER FOUR BLOCK. THE DEALER QUOTED THE COST TO REPLACE THE ENTIRE ENGINE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE CONTACT RESEARCHED THE FAILURE AND FOUND THAT IT OCCURRED MANY TIMES WITH A POSSIBLE ENGINE DESIGN CRACK. THE MANUFACTURER DID NOT ASSIST AND REFERRED THE CONTACT TO NHTSA. THE BRAKE FAILURES WERE REPAIRED. THE FAILURE MILEAGE WAS 86,000. *LN

TL* THE CONTACT OWNED A 2015 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE HYDROPLANED WHILE TRAVELING ON THE HIGHWAY. THE VEHICLE SLID INTO A DITCH, ROLLED OVER SEVERAL TIMES, CRASHED HEAD ON INTO AN EMBANKMENT, AND LANDED ON ITS ROOF. NONE OF THE SEVEN AIR BAGS DEPLOYED. THE VEHICLE SUSTAINED SEVERE FRONT END DAMAGE AND WAS DEEMED DESTROYED. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY FOR INVESTIGATION. THEIR FINDINGS WERE STILL PENDING. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 97,500.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE THE CONTACT'S HUSBAND WAS DRIVING 25 MPH, THE FRONT DRIVER'S SIDE DOOR OPENED ON ITS OWN AND THE DOOR AJAR WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS TAKEN TO LAWLEY'S TEAM FORD (LOCATED AT 100 AZ-90, SIERRA VISTA, AZ 85635, (888) 874-9117) WHERE IT WAS DIAGNOSED WITH NEEDING THE FRONT DRIVER'S SIDE DOOR LATCH REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,283. *DL

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT THE STEERING WHEEL WAS LOOSE AND JIGGLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO COWLES PARKWAY FORD (703-986-5500, LOCATED AT 13779 NOBLEWOOD PLZ, WOODBRIDGE, VA 22193) WHERE A DIAGNOSTIC TEST WAS RECOMMENDED. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 65,002.

TL* THE CONTACT OWNS A 2015 FORD FUSION. CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE AND AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE LOSS MOTIVE POWER AND ACCELERATION. THE CONTACT DROVE THE VEHICLE BACK TO THE RESIDENCE. THE VEHICLE WAS TAKEN TO MEL HAMBELTON FORD, INC,(11771 W KELLOGG DR, WICHITA, KS 67209, (888) 489-1719) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE COOLANT WAS PRESSED INTO THE CYLINDER AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

ON FRIDAY, NOVEMBER 8TH I STARTED MY VEHICLE AND NOTICED MY STEERING WHEEL SHAKE FOR APPROXIMATELY ONE MINUTE. AS I PULLED OUT OF THE DRIVEWAY, I NOTICED DIFFICULTY ACCELERATING THE IDLE. AS I PULLED OUT OF MY NEIGHBORHOOD I NOTICED MORE PUSHBACK AS I ACCELERATED THE IDOL AND MY ENGINE LIGHT STARTED FLASHING. I IMMEDIATELY TURNED MY VEHICLE AROUND AND RETURNED HOME IN FEAR OF GETTING INTO A CAR ACCIDENT. I PROCEEDED TO TAKE MY VEHICLE TO A MECHANIC SHOP AND WAS QUOTED A STARTING $1,700 REPAIR FOR A HEAD GASKET REPAIR. AFTER SEARCHING THE INTERNET, I WAS SHOCKED HOW COMMON THIS REPAIR IS AND WAS IN DISBELIEF THIS PART IS NOT RECALLED AFTER I SEARCHED NHTSA.GOV. AS A CONSUMER, I'D LIKE TO REPORT THE HEAD GASKET IN THE 2015 FORD FUSION 2.5L TO THE NHTSA FOR REVIEW AND RE-CALL CONSIDERATION.

The contact owns a 2015 Ford Fusion. The contact stated while driving approximately 60 MPH, the vehicle began to lose motive power. The contact depressed the accelerator pedal and the vehicle lunged forward and then lost motive power again. The contact stated no warning light was illuminated. The contact stated that the vehicle went into LIMP Mode. The contact exited the highway and drove to a dealer at approximately 25 MPH. The contact stated that the dealer diagnosed the vehicle and determined that coolant had entered the engine block and that the engine needed to be replaced. The dealer informed the contact that the engine was not the original engine and was a replacement. The contact stated that he was the second owner of the vehicle. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 83,507.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT AN UNKNOWN WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER PAUL CLARK FORD (464046 STATE RD 200, YULEE, FL 32097) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO THE NUMBER 3 CYLINDER MISFIRE, WHICH CAUSED FLUID TO ENTER INTO THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.

TL* THE CONTACT OWNS A 2015 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT HIGH SPEEDS, THERE WAS AN ABNORMAL SOUND COMING FROM THE FUEL TANK. WHILE THE VEHICLE WAS STOPPED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS HOWEVER, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO ED BUTTS FORD (1515 N HACIENDA BLVD, LA PUENTE, CA 91744, (800) 960-3673) BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.

2015 FORD FUSION SE. THE PASSENGER SIDE DAYTIME RUNNING LIGHT BULB WAS OUT AROUND 1 NOVEMBER, 2019. THE FORD DEALER REPLACED IT ON 11/14/2019 AND OFFERED TO REPLACE THE DRIVER SIDE LIGHT AT THE SAME TIME, BECAUSE IT IS EXPENSIVE TO TAKE THE FRONT BUMPER OFF TO DO THE JOB ($210 LABOR PLUS $35 FOR THE LIGHT AND $29 FOR ADD'L SHOP SUPPLIES.). HE INDICATED THAT THE DRIVER SIDE BULB WOULD PROBABLY BURN OUT SOON. I DENIED THE CHANGE; I THOUGHT IT WAS A RIPOFF. TURNS OUT HE WAS RIGHT BUT WHY DOES THE LIGHT BURN OUT AT ALL. THE PASSENGER SIDE BULB WAS OUT LESS THAN 5 YEARS AFTER I BOUGHT IT. SEEMS THEY COULD DESIGN A LIGHT THAT WOULD LAST FOREVER, NO? I REALIZE THESE ARE THE DAYTIME RUNNING LIGHTS AND THEY ARE ON WHENEVER THE CAR IS ON IF YOU USE THE RIGHT SETTING, BUT IT SEEMS THEY DESIGNED IN OBSOLESCENCE,

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHEN THE VEHICLE WAS STARTED, THE STEERING ASSIST WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL SEIZED. THE CONTACT WENT TO JOE HOLLAND CHEVROLET & IMPORTS (210 MACCORKLE AVE SW, SOUTH CHARLESTON, WV 25303, (304) 744-1561) WITHOUT HER VEHICLE AND WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 19V632000 (STEERING). THE DEALER INFORMED THE CONTACT TO TAKE THE VEHICLE TO A FORD DEALER. THE CONTACT WENT TO TODD JUDY FORD (1900 PATRICK ST PLAZA, CHARLESTON, WV 25387, (304) 344-1601) AND WAS INFORMED THAT THE ONLY RECALL ASSOCIATED WITH HER VEHICLE WAS FOR THE TAKATA AIR BAGS. THE CONTACT WAS PROVIDED A COST ESTIMATE FOR A DIAGNOSTIC TEST TO DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS INFORMED THAT THE ONLY RECALL THEY FOUND ON THE VEHICLE WAS FOR THE AIR BAGS. THE MANUFACTURER OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE DRIVING 35 MPH, THERE WAS AN ABNORMAL SUCTION NOISE COMING FROM NEAR THE FUEL TANK AREA. ALSO, THE VEHICLE SHUDDERED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THE PURGE VALVE AND PCV) NEEDED TO BE REPLACED. JENKINS & WYNNE FORD, HONDA, & LINCOLN (2655 TRENTON RD, CLARKSVILLE, TN 37040, (931) 542-4886) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS CONTACTED AND PROVIDED THE SAME INFORMATION AS THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.

2015 FORD FUSION SE WITH 66,997 MILES ON IT STARTED TO RUN ROUGH THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO LOCAL CAR PARTS STORE FOR CHECK ENGINE LIGHT DIAGNOSIS THEY SAID IT WAS A MISFIRE IN CYLINDER 2. I THEN TOOK THE CAR TO MY MECHANIC AND 6000 DOLLARS LATER I WAS TOLD THERE WAS A CRACK IN THE BLOCK. THE CODES GAVE NO CLUE TO WHAT WAS WRONG AND CAR NEVER OVERHEATED. THIS IS RIDICULOUS FOR A 4 AND 1/2 YEAR OLD CAR THAT WAS BOUGHT BRAND NEW. I WOULD LIKE FORD TO ACKNOWLEDGE THIS AND REMBURSE ME.

ON 10/7/2019 I BROUGHT MY CAR IN TO FORT MILL FORD (SC) FOR A TIRE CHANGE AND REGULAR SERVICE. WHEN I CAME TO PICK IT UP ON 10/10/2019, THE CAR WOULD NOT START. UPON ADVISING MY TECH BRITTANY OF THE ISSUE, THEY SENT OUT A TECH TO JUMP START THE CAR THAT WAS JUST SERVICED. WHEN THE CAR WAS JUMP STARTED, AN ENGINE LIGHT APPEARED ON THE DASHBOARD. THE VEHICLE WAS AT 62000 MILES. I WENT BACK TO MY ADVISER BRITTANY AGAIN AND SHE STATED THAT THE ENGINE LIGHT IS NOTHING TO WORRY ABOUT AND THAT FORD ACTIVATES THOSE WHEN SEASONS CHANGE AND IS PART OF THEIR SOFTWARE. SHE INSISTED THAT EVERYTHING WAS OK WITH THE CAR AND REFERENCED THE INSPECTION LIST I WAS GIVEN FOR MY 2015 FORD FUSION SE. NOT THREE WEEKS LATER, THE ENGINE LIGHT WENT FROM BEING CONSTANTLY ON, TO FLASHING. THIS ALSO CAUSED AN INTENSE WHITE SMOKE FROM THE EXHAUST AND A STRONG GAS PRESENCE IN THE VEHICLE. WHILE I WAS DRIVING TO WORK, THE ENGINE LIGHT STARTED FLASHING AND THE CAR STARTED JERKING ON I-77 HIGHWAY. I TOOK THE CAR BACK TO FORT MILL FORD ON 11/18/2019 FOR INSPECTION. THE NEXT DAY, BRITTANY CALLED ME AND SAID THEY FOUND AN ISSUE WITH MY SPARK-PLUG AND THAT IT MIGHT COST ANYWHERE FROM $200 TO $6000.00 TO REPAIR IT. SINCE THE ISSUE WAS NOT CAUSED BY ME I WAS NOT GOING TO TAKE RESPONSIBILITY FOR THE CHARGES AND AFTER WEEKS OF IGNORING ME, FORD MOTOR COMPANY (OFFICE OF ELENA FORD) DECIDED TO GET INVOLVED. HOWEVER, THE CAUSE WENT FROM SPARK-PLUGS TO COOLANTS THEN CYLINDERS AND I WAS NEVER GIVEN A SPECIFIC CAUSE. I DID NOT HAVE MY CAR FOR OVER 60 DAYS BECAUSE ALL PARTS WERE ON BACK ORDER. I GOT MY CAR BACK ON 1/21/2020 AND IT IS STILL SHOWING ISSUES WITH ACCELERATION. OUT OF 91 NHTSA COMPLAINTS ON ENGINE ISSUES, OVER 31 HAVE THESE SAME SYMPTOMS. PLEASE SEE ATTACHED DOCUMENTS DETAILING THIS ISSUE. THIS FORM DOES NOT OFFER ENOUGH SPACE FOR RELEVANT INFORMATION AND I WAS NOT ABLE TO UPLOAD THE LAST EMAIL THREAD. *DT*JB

42K. ENGINE LIGHT CAME ON, DIAGNOSTICS REPORTED A BAD 02 SENSOR. NEVER HAD ANY KIND OF ISSUES WITH AN 02 SENSOR. CAN'T BELIEVE IT HAPPENED ON A 2015 MODEL.

2015 FORD FUSION 1.5L ECOBOOST ENGINE. ENGINE COOLANT LEAK - BLOWN INNER COOLER ASSEMBLY AND COOLANT INTAKE MANIFOLD ASSEMBLY. PROBLEM INITIALLY NOTICED WHILE DRIVING ON FREEWAY. ENGINE TEMPERATURE GUAGE MOMENTARILY SPIKED WHILE DRIVING. NO SMOKE OR UNUSUAL NOISE NOTICED WHILE DRIVING. PULLED OVER AND NOTICED COOLANT OVERFLOW TANK NEAR EMPTY. COOLANT REFILLED AN DRIVEN HOME. THIS HAPPENED ON 9/28/2019. TOOK TO NTB NEXT DAY ON 9/29/2019 TO HAVE PRESSURE TEST ON COOLANT SYSTEM. CAR SAT TILL MONDAY 10/30. NTB MISDIAGNOSED ISSUES STATING OVERFLOW RESERVOIR HAD SLOW LEAK. ON 10/1 NTB IDENTIFIED THAT THERE WAS A BLOWN GASKET SOMEWHERE ON THE CARS ENGINE THAT CAUSED COOLANT TO LEAK INTO ENGINE. 3 OF 4 SPARK PLUGS SATURATED WITH ENGINE COOLANT AND CAR WOULD NOT START. ON 10/1 CAR IMMEDIATELY TOWED TO NEAREST FORD MOTOR SERVICE CENTER. ENGINE TECHNICIAN STATED THAT ENGINE INNER COOLER ASSEMBLY AND INTAKE MANIFOLD ASSEMBLY HAD BLOWN AND COOLANT ENTERED THE ENGINE. THIS RESULTED IN NEARLY $1,400 WORTH OF INITIAL REPAIRS AND POSES A SAFETY HAZARD. FORD ENGINE TECHNICIAN STATED HE HAS SEEN A SIMILAR ISSUES ON QUITE A FEW OF THESE CARS. UPON INVESTIGATION I HAVE FOUND THAT IN 2017 THE 2013-2014 FORD FUSION HAD A RECALL FOR RELATED ISSUES THAT CAUSED COOLANT TO LEAK INTO THE ENGINE AND MAY POSSIBLY CAUSE THE ENGINE TO START ON FIRE. CURRENTLY MANY CUSTOMER REPORTS ON THE 2015 FUSION AS WELL BUT NO ACTION ON FORD MOTORS BEHALF.

TL* THE CONTACT OWNS A 2015 FORD FUSION. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AND "TRANSMISSION NOT IN PARK" APPEARED ON THE MESSAGE CENTER. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. THE FOLLOWING DAY, THE VEHICLE WAS PICKED UP BY LAFAYETTE FORD LINCOLN (5202 RAEFORD RD, FAYETTEVILLE, NC 28304) AND THEY ALSO BROUGHT A LOANER VEHICLE. THE VEHICLE WAS TAKEN TO THE SAME DEALER SIX TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.