2004 GMC Sierra Complaint Log

the person i bought the vehicle from switched out the gauge cluster and lied about the vechiles mileage

The fan for the heater doesnt work on all speeds properly, stopped working entirely

The contact’s father owns a 2004 GMC Sierra 1500. The contact stated that after she inserted the key in the ignition and started the vehicle, the front driver’s side air bag exploded, without warning. The contact sustained an injury to her left arm, hand, neck, and head that required medical attention. The vehicle was not diagnosed or repaired. The contact stated that an unknown dealer was notified of the failure and the contact was advised to call the NHTSA Hotline. The manufacturer was not notified of the failure. The failure was approximately 200,000.

Brakes lines failed under truck do to rusted out lines

EMERGENCY BRAKES DON'T ENGAGE

CORRODED BRAKE LINES. THIS HAS BEEN REPORTED PREVIOUSLY. I WAS DRIVING DOWN RURAL ROAD GETTING READY TO TURN IN MY DRIVEWAY WHEN MY BRAKES GAVE OUT. I WAS LUCKY ENOUGH TO BE ABLE TO GET IT INTO THE GRAVEL DRIVEWAY WITHOUT KILLING SOMEONE. WHEN I LOOKED UNDERNEATH TO FIND THE BRAKE LINES WERE CORRODED AND ONE HAD BURST. I HAD PART OF THE LINE FIXED WITH COPPER TUBING. I HAVE SINCE HAD 2 MORE LINES BURST. AS WELL AS A FUEL LINE LEAK. THIS HAS BECOME FRUSTRATING.*DT*JB

Went to start truck and the air bag in the steering wheel exploded.

DURING COLD MORNINGS (WISCONSIN) I START MY TRUCK AND I HAVE NO POWER STEERING AND SOFT BRAKES. IT IS MY UNDERSTANDING THAT THE POWER STEERING RUNS THE BRAKE BOOST. ALSO, IT IS MY UNDERSTANDING THAT THERE IS A SERVICE BULLETIN THAT SAYS THAT THE POWER STEERING FLUID SHOULD BE REPLACED WITH LOW/COLD TEMP FLUID. MY CONCERN IS WHAT HAPPENS IF I LOSE POWER STEERING AND BRAKES WHILE I AM DRIVING.

When to start truck and air bag in steering wheel exploded.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT THERE WAS A BURNING ELECTRICAL ODOR INSIDE THE VEHICLE. THE CONTACT REACHED OUT TO THE MANUFACTURER REGARDING THE FAILURE OF THE BLOWER FAN RESISTER AND WAS INFORMED THAT THE EXTENDED WARRANTY HAD EXPIRED. THE CONTACT STATED THAT HE NEVER RECEIVED THE NOTIFICATION. THE VEHICLE WAS TAKEN TO COTTERS GMC (435 HALL AVE, ST MARY'S, PA 15857, 814-834-2063) AND THEY PROVIDE A VERBAL DIAGNOSIS OF THE BLOWER RESISTER FAN AND ELECTRICAL HARNESS FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 102,000.

DASHBOARD SAYS 'SERVICE AIRBAGS'

I HAVE GMC SIERRA 1500 4WD THE AIRBAG LIGHT COME ON , IF ANY RECALL PLEASE HELP

WHILE DRIVING OVER 50MPH ON THE HIGHWAY I GET A VIOLENT SHAKING IN THE ENGINE AND THE STEERING WHEEL SHAKES BAKE AND FORTH. THE ENGINE SOUND VERY LOUD WHILE ITS DOING THIS. IT ONLY OCCURS WHEN I AM AT HIGHWAY SPEEDS.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT THE VALVE HEAD WAS CRACKED AND THE ANTI-FREEZE WAS DEPLETED; HOWEVER, THERE WERE NO VISIBLE LEAKAGE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 131,000.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED A LOT OF WHITE SMOKE EMERGING FROM THE TAIL PIPE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER WARRANTY BY GWATNEY BUICK GMC (5700 LANDERS RD, NORTH LITTLE ROCK, AR 72117) FOR THE SAME FAILURE AS LISTED IN AN UNKNOWN TECHNICAL SERVICE BULLETIN REGARDING THE FUEL INJECTORS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED FOR THE RECENT FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

EXHAUST MANIFOLD BOLTS BROKEN

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. WHILE OPERATING THE VEHICLE, THE INSTRUMENT CLUSTER GAUGES FLASHED OFF AND ON AND, AT TIMES, COMPLETELY STOPPED OPERATING. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT THE LOCAL DEALER WAS NOT NOTIFIED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 97,000.

MY TRUCK IS MY BACK-UP VEHICLE THAT SITS IN THE SIDE DRIVEWAY MOST OF THE TIME BUT I DRIVE WHEN I'M TRANSPORTING LARGE ITEMS OR MOVING TO A NEW HOME. I RECENTLY DROVE IT AND NOTICED THE SPEEDOMETER NOT WORKING AND WENT SEARCHING FOR INFORMATION ABOUT RELATED ISSUES ON THE INTERNET WHEN I FOUND A RECALL NOTICE POSTED ON GMC'S WEBSITE BUT THEY ARE SAYING IT'S PAST THE "TIME" ALLOWED TO GET THE PROBLEM FIXED. I DIDN'T EVEN KNOW THAT THERE WAS A PROBLEM OR A TIME FRAME TO GET THIS DONE BECAUSE I DON'T DRIVE THIS TRUCK MUCH. NOW I HAVE TO PAY FOR THE DEALERSHIP'S INSPECTION OF THE INSTRUMENT PANEL ONLY TO HAVE THEM TELL ME THAT IT'S INDEED BROKE AND THAT THEY ARE NOT GOING TO REPAIR IT UNDER THE RECALL. I'M NOT SURE WHAT TO DO BUT I'M HOPPING MAD BECAUSE THIS IS A PROBLEM THAT OTHER GMC OWNERS PROBABLY HAD REPAIRED BUT BECAUSE THIS WAS MY BACK-UP VEHICLE, I'M PENALIZED FOR NOT HAVING THE PROBLEM SURFACE EARLIER BEFORE THE "TIME" FRAME EXPIRED. THE DEALERSHIP I CURRENTLY HAVE MY TRUCK AT IS SHELDON GMC IN ROCHESTER HILLS, MI 48307 I CAN BE REACHED AT [XXX] CALL OR TEXT. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. WHILE OPERATING THE VEHICLE, THE ENGINE SUDDENLY STALLED. IT WAS DISCOVERED THAT THE VEHICLE WAS OUT OF FUEL; HOWEVER, THE FUEL GAUGE INDICATED THAT THE TANK WAS HALF FULL AT THE TIME OF THE INCIDENT. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER (GARCIA BUICK GMC, 2721 CERRILLOS RD, SANTA FE, NM 87507) WERE BOTH NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 160,000.

PULLING OUT OF A PARKING LOT, LOST BRAKES. STEEL BRAKE LINES BY FUEL TANK, LET GO CAUSING TRUCK TO LOOSE BRAKES

ME AND MY TWO BOYS WHERE HEADED HOME AND I WAS TAKING A CURVE AT 50MPH A WENT TO SLOW DOWN TO 45 WHEN I STARTED TO TAKE THE CURVE I HEARD SOME KIND OF METAL BONE BREAKING SOUND AND MY TRUCK JERKED TO THE ONCOMING LANE AND A JERKED IT BACK BUT AFTER THAT EVERYTHING WENT LOOSE AND ME AND MY BOYS WENT SIDEWAYS OF OF THE BANK OF THE CURVE AND WE ROLLED 3 TIMES BEFORE WE STOPPED TANK UP. MY AIR BAG DIDN'T GO OFF NEITHER THE PASSENGER'S AIRBAG. I HEARD A HISSING NOISE I GOT MY BOYS OUT AS FAST AS I COULD WITH SOME HELP OF BYSTANDERS BREAKING THE PASSENGER SIDE WINDOW SO WE COULD CRAWL OUT. THEY CARRIED MY BOYS AND HELPED ME HOP TO THE OTHER SIDE OF THE ROAD. ME AND MY BOYS WENT TO THE HOSPITAL. THEY WERE ALRIGHT THANK GOD I RECEIVED SOME INJURIES TO MY BACK, NECK, STOMACH AND HEAD. MY TRUCK WAS TOTALED AND IVY HALL TOWING IN JACKSONVILLE, AR KEEP MY TRUCK AND PUT A LIEN ON IT. HOW THEY EXCEPT SOMEONE TO PAY AFTER THEY WERE IN A WRECK AND LOST THEIR JOB BECAUSE NO RIDE TO GET BACK AND FORTH. MY ROLLOVER WRECK HAPPENED ON HWY 107 AND CLEVELAND IN ARKANSAS ON MARCH 21ST 2018

TL* THE CONTACT OWNS A 2004 GMC SIERRA 800 (NA) EQUIPPED WITH YOKOHAMA GEOLANDAR A/T-S TIRES, SIZE: LT 285/75/R16 (NA). WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT END OF THE VEHICLE SHOOK AND THE FRONT PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE TIRE WAS REPLACED WITH THE SPARE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE WARRANTY WAS EXPIRED. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 101,793 AND THE TIRE FAILURE MILEAGE WAS 14,000.

2004 GMC SIERRA 1500 SLE. GOODYEAR WRANGLER P255 70R16 DOT MDCUC6HR 5211. TIRES HAVE APPROXIMATELY 25K MILES ON THEM. LEFT REAR TIRE BLEW DUE TO TREAD SEPARATION. VISUALLY INSPECTED TIRES AND CHECKED PRESSURE ON ALL TIRES BEFORE A LONG ROAD TRIP. TIRE BLEW WITHOUT WARNING AND AM NOW NERVOUS ABOUT THE REMAINING TIRES. WAS ON INTERSTATE 10 AT APPROX 70MPH WHEN TIRE BLEW, LUCKILY NO ONE WAS NEXT TO ME AS THE REAR END OF THE TRUCK FISHTAILED INTO THE NEXT LANE. WAS ABLE TO PULL OVER SAFELY AND PUT ON A SPARE.

THE INSTRUMENT PANEL CLUSTER GAUGES DON'T ALWAYS WORK. WE WERE ON FREEWAY WHEN WE NOTICED SPEEDOMETER HAD FAILED AS WELL AS FUEL GAUGE , TEMP GAUGE ALL GAUGES INOPERATIVE. THIS IS THIRD TIME CLUSTER PANEL IS BEING REPLACED; FIRST TWO UNDER WARRANTY THIRD TIME WE HAD TO PAY $204.

I PURCHASED THIS VEHICLE BRAND NEW IN 2004 AND HAVE TAKEN VERY GOOD CARE AND ALMOST 100,00 MILES IN ALMOST 14 YEARS HOWEVER I APPLIED THE BRAKE AND ALL THE BRAK FLUID CAME OUT I HAD TO DRIVE OVER A PERSON LAWN TO AVOID HITTING A PERSON AND A MOVING VEHICLE ON 7/1/2017 DUE TO RUSTY BRAKE LINE AND CHECKING ALL LINES WERE RUSTED . I AM ALMOST 75 YEARS OLD AND VERY CONCERNED I WAS AWARE THE LINES WERE ALL RUSTED DUE TO IMPORTED BRAKE LINES WITH INFERIOR METALS, NEVER HEARD ABOUT AND NOTICE OR RECALL.I ALMOST INJURED A PERSON AND HIT A CAR IF I DID NOT DRIVE ON SOMEONES LAWN THE VEHIVLE WAS MOVING ABOUT 35 MPH .

BRAKES WENT OUT AS I WAS PULLING INTO MY DRIVEWAY, BRAKE LINE CORROSION

BATTERY RUNS DOWN DRAINED, CONTROL PANEL LIGHTS GOES OUT. AC QUIT WORKING. VEHICLE SITS IN OUR YARD MOST OF THE TIME. WE HAVE TO CHARGE BATTERY EVERY DAY IN ORDER TO GO ANYWHERE.

POWER TRAIN PCM DEFECTIVE WITH TRANSFER CASE WITH BAD DESIGNING WITH SHOE PUMP, AND BRAKE LINE CORRODED AND LEAK. BRAKE SYSTEM WILL NOT PREVENT VEHICLE TO STOP WHEN BRAKE LINES ARE LEAK. FOR MY 2004 I WAS LUCKY DRIVING ON SLOW SPEED ON CITY ROAD, AND I WAS ABLE TO USE EMERGENCY BRAKE TO STOP MY TRUCK.

ON JANUARY 24, 2017 TRAVELING ON PA TURNPIKE AT POSTED SPEED LIMIT OF 70MPH, WHEN I APPLIED BRAKES TO SLOW WHEN APPROACHING SLOWER VEHICLES. BRAKE PEDAL WENT TO THE FLOOR AND VEHICLE ALMOST RAN INTO THE REAR OF SLOWER VEHICLES. METAL BRAKE LINE RUPTURED ABOVE LEFT FRONT WHEEL. WHEN INSPECTED, ALL BRAKE LINES EXHIBITED EXTREME RUST/CORROSION TO THE POINT OF FLAKING AND THINNING. THIS IS AN EXTREME SAFETY ISSUE WHICH COULD HAVE RESULTED IN A MAJOR COLLISION AND WOULD HAVE INJURED OR KILLED OCCUPANTS. THIS PROBLEM IS A MAJOR KNOWN SAFETY DEFECT AND NEEDS TO BE REMEDIED BY GM.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT THE BRAKE LINE HAD RUSTED COMPLETELY. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT THE DETAILS OF THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 2500. THE CONTACT STATED THAT THE VEHICLE HAD A MASSIVE OIL LEAK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTORS WERE DEFECTIVE, WHICH FILLED THE CRANKCASE FULL OF FUEL AND WAS A KNOWN ISSUE. THE VEHICLE WOULD HAVE BEEN REPAIRED PER AN EXTENDED WARRANTY; HOWEVER, IT FELL OUTSIDE OF THE PARAMETERS OF THE EXTENDED WARRANTY, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 112,000.

I WAS TRAVELING SOUTH ON I-75 HIGHWAY ABOUT 70 MPH, IN MOTION, IN NORTHERN MICHIGAN AND HAD TO STOP FAST WHEN AN ACCIDENT OCCURRED IN FRONT OF ME. I SLAMMED/MASHED MY FOOT ON THE BRAKE PEDAL ONLY TO FEEL IT FALL TO THE FLOOR, THE METAL HYDRAULIC LINE FAILED AND I NOW HAVE NO BRAKES AT ALL!! I BEGAN TO PRESS ON THE PARKING BRAKE AND DOWN SHIFT THE TRANSMISSION TO ASSIST IN THE SLOWING OF THE VEHICLE. I ALSO STEERED AROUND THE STOPPED CARS INTO THE SIDE AND DITCH OF THE ROAD. I LUCKILY HAD THE RIGHT REACTIONS BUT NOT ALL PEOPLE DO OR CANNOT ACT AS FAST. THIS IS A DANGEROUS ISSUE WITH THIS GMC SIERRA 2004. PLEASE HAVE IT RECALLED. I HAD TO HAVE THE REPAIR SHOP REPLACE ALL THE METAL BRAKE LINES AS THEY WERE CORRODED. I HAVE NEVER HAD A VEHICLE FAIL ITS BRAKE LINES LIKE THIS. MY VEHICLE ONLY HAS 48,000 MILES ON IT AND IS GARAGE KEPT SUPER CLEAN.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THE HEAD GASKET LEAKS RADIATOR FLUID INTO THE MOTOR. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC THAT DIAGNOSED THAT THE ENGINE HEAD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

IN THE PAST THREE MONTHS THE FUEL LINES NEEDED REPLACEMENT AS THEY HAD RUSTED SO BADLY THAT A LEAK FORMED. YESTERDAY WHILE PULLING MY 10,000 POUND BOAT, MY BRAKES SUDDENLY FAILED BECAUSE OF A LEAK IN THE LINE BETWEEN THE ABS BOX AND THE RIGHT FRONT WHEEL. THE CATASTROPHIC FAILURE NEARLY CAUSED ME TO LOSE CONTROL OF MY VEHICLE AND BOAT. I WAS ABLE TO DOWNSHIFT AND USE BY EMERGENCY BRAKE TO BRING THE RIG TO A STOP.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 2500 HD. WHILE DRIVING 10 MPH, THE BRAKES FAILED WITHOUT WARNING. IT WAS DIAGNOSED THAT ALL THE BRAKE LINES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 176,395.

I LIVE IN SOUTH EAST MA. WERE SAULT IS USE ALWAYS AND IT HAS ROTTED MY BRAKE LINES AT THE ABS CONTROLL A LINE LET GO ON MY TRUCK WITH FAMILY AND MY GRAND BABIES I AM A HEAVY TRUCK OPERATOR WITH A CDL SO I KNOW NOT TO PANIC I GOT MY TRUCK STOPPED WITHOUT A CRASH BUT IF MY WIFE WAS DRIVEING OR MY YOUNG DAUGHTER THEY WOULDNT BE SO LUCKY WE IN THE SAULTING STATES SHOULD HAVE STANELESS STEAL FOR SAFTY CANT BE TO MUCH TO ASK FOR YOUNG LIFES AT STAKE OR PEOPLE WHO PANIC WHAT SHOULD I DO AT THE TIME I WAS IN THE CITY OF TAUNTON I WAS COMING TO A HEAVILY TRAVELED STREET IN RUSH HOUR TRAFIC THE BRAKE LINE TO REAR BRAKES FALLED BECAUSE OF ROT ON INSPION I SEE THEY ARE ALL ROTTING AND NEED TO BE REPAIRED I DONT HAVE BODY ROT OR FRAME ROT OF ANY KIND ALWAYS CAR WASH AFTER STORMS ON NICE DAYS.

I HAVE A 2004 GMC SIERRA AND ALL OF A SUDDEN MY AIRBAG LIGHT AND ABS LIGHT CAME ON TOOK IT IN TO HAVE IT LOOKED AND THE AIRBAGS ARE NOT COMMUNICATING WITH THE SENSOR AND THEY WOULD HAVE TO GO MORE IN DEPTH ON THE ABS BUT TO GO MORE IN DEPTH THEY CHARGE $80.00 AN HOUR JUST TO BE ABLE TO FIGURE IT OUT. I HAVE SEEN SIMILAR RESPONSES ON THE AIRBAG LIGHT FOR THIS VEHICLE PLEASE HELP.

COMPLETE BRAKE FAILURE, DUE TO BRAKE LINE CORROSION OF SUBSTANDARD MATERIAL USED IN METAL BRAKE LINES ROUTED WITHIN AND UNDER VEHICLE.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE CONTACT WAS ABLE TO AVOID AN ACCIDENT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,900....UPDATED 02/04/16 *BF; 05/02/18*JB

BRAKE LINES ARE RUSTING CAUSING BRAKE FAILURE DUE TO PRESSURE/FLUID LOSS

RUSTED BRAKE LINE

GMC REPLACED ALL 8 FUEL INJECTORS UNDER WARRANTY AT 95,000 MILES. SAME PROBLEM AGAIN AT 135,000 AND WILL NOT COVER THEM. ESTIMATED $5,500 TO REPLACE BY CONSUMER WITH ONLY A 12 MONTH WARRANTY. CREATES POOR FUEL ECONOMY, EXCESSIVE SMOKE AT IDLE AND WILL NOT PASS SMOG IF NOT CORRECTED.

BOUGHT TRUCK 15 DAYS AGO. HAD A NAIL IN MY TIRE SO I PUT ON THE SPARE TIRE WHICH WAS RUSTY AND PROBABLY NEVER LOOKED AT FOR 11 YEARS BUT HAD TO PUT THIS ON TO AVOID BEING STRANDED. THIS VEHICLE WAS JUST INSPECTED AND WAS WONDERING IF THE SPARE TIRE IS INCLUDED IN THE INSPECTION PROCESS. DUE TO RUSTY TIRE CONDITION THE LUGS LOOSENED AND TIRE FELL OFF WHILE DRIVING ON THE HIGH WAY AFTER I CHANGED IT. I WAS TOLD BYE THE MECHANICS THAT THE LUGS LOOSENED DUE TO A RUSTY FAULTY SPARE. DOES THIS FALL UNDER ANY LAWS DUE TO JUST PURCHASING THIS VEHICLE AND IT GOING THROUGH THE DEALERS INSPECTION STICKER. THIS CUSSED A SERIOUS ACCIDENT AND WANT TO KNOW IF THEY SHOULD BE HELD ACCOUNTABLE OR IF I AM LIABLE FOR THIS.

THE BRAKES ON MY TRUCK FAILED DUE TO THE BRAKE LINE CORROSION. I PUSHED ON MY BRAKES WHILE BACKING OUT OF MY DRIVEWAY LOST ALL BRAKING POWER AND HAD MY BRAKE . LUCKILY I WAS IN MY DRIVEWAY WHEN THIS HAPPENED. ALL OF THE BRAKE FLUID LEAKED ONTO THE GROUND, I HAD MY VEHICLE TOWED TO THE DEALERSHIP AND HAD THE BRAKE LINES REPLACED. UPON SPEAKING WITH THE SERVICE ADVISOR HE SAID THAT THIS WAS COMMON AND THAT THE NEW BRAKE LINES WERE COATED AND WILL NOT RUST. NONE THE LESS THE REPAIR COST AND TOWING COST WAS QUITE EXPENSIVE.

TL* THE CONTACT OWNS A 2004 GMC 2500. THE CONTACT STATED THAT THE EMERGENCY BRAKE WAS INOPERABLE. THE CONTACT MENTIONED THAT THE PARKING BRAKE WAS DEPRESSED AND AN ABNORMAL NOISE EMITTED FROM THE UNDER CARRIAGE OF THE VEHICLE. THE CONTACT BELIEVED THAT THE PARKING BRAKE CABLE WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 197,000.

I EXPERIENCED A BRAKE LINE FAILURE ON MY 2004 GMC SIERRA CREW CAB PICKUP TRUCK. I WAS TRAVELING AT A SLOW RATE OF SPEED AND COMING UP TO A TRAFFIC LIGHT AND THE BRAKE PEDAL PUSHED ALL THE WAY TO THE FLOOR BOARD. THE REAR EMERGENCY BRAKE WAS USED TO STOP THE VEHICLE. I FOUND THE AREA AROUND THE BRAKE MODULE, IN THE FRAME AREA UNDER THE DRIVER'S AREA, SOAKED WITH BRAKE FLUID AND CORRODED BRAKE LINES.

I DROVE DOWN THE STREET AND THE TRUCK STARTED SMOKING. THE SMOKE STARTED TO INCREASE SO I TURNED THE TRUCK AROUND AND PARKED IT OUT FRONT OF MY HOUSE AND ALL OF THE SUDDEN FLAMES STARTED TO APPEAR. NEEDLESS TO SAY THE TRUCK JUST BLEW UP. *TR

AS I APPROACHED A MAJOR INTERSECTION THE TRAFFIC LIGHT TURNED YELLOW AND I APPLIED THE BRAKES PREPARING TO STOP. THE BRAKES FAILED AND THE PETAL WENT TO THE FLOOR. THE TRUCK ROLLED HALFWAY INTO THE INTERSECTION BEFORE I WAS ABLE TO STEP ON THE EMERGENCY BRAKE AND FULLY STOP THE TRUCK. THE DASHBOARD FLASHED ON INDICATING "REPAIR BRAKES"...A LITTLE TOO LATE TO HELP. IF I HAD A VEHICLE IN FRONT OF ME , I WOULD HAVE HIT IT AND POSSIBLE INJURIES WOULD HAVE RESULTED. I HAD MY DAUGHTER IN THE FRONT PASSENGER SEAT AND WAS GLAD FOR SEAT BELTS.

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. WHILE DRIVING AT 45 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO STOP. IN ADDITION, THE CONTACT STATED THAT THE CHECK BRAKE SYSTEM WAS DISPLAYED ACROSS THE MESSAGE BOARD. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE BRAKE LINES WERE CORRODED AND FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.

AGAIN. MY TRUCK HAD COMPLETE BRAKE FAILURE AGAIN DUE TO CORROSION ON THE STEEL LINES. THIS IS AN OTHERWISE NICE TRUCK WITH BRAKE LINES THAT LOOK LIKE THEY'VE BEEN IN THE OCEAN THEIR ENTIRE LIVES. GM DEALER QUOTED OVER $1,700 TO FIX. GM OWNED WARRANTY COMPANY REFUSES TO COVER REPAIR. GM CUSTOMER SERVICE TELLS ME TO POUND SAND. *TR