2005 Kia Sedona Complaint Log

Brake line rusted out. Lost brakes while driving.

Rear Right Hub Recall on this model

The contact owns a 2005 Kia Sedona. The contact stated while the vehicle was parked, she noticed that the vehicle was overheating. There were no warning lights illuminated. The contact stated she attempted to open the hood of the vehicle to determine the cause of the failure, but the hood would not open. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The dealer was made aware of the failure and informed the contact that the VIN was not under recall. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 88,000.

Hi my van started smell a lot to fuel so I looked for leaks and I found a big leak on the fuel rail rack dripping a lot of fuel on the side of engine when engine is running and the car is unsafe to drive and I’m very worried about this problem. This happened after my car stalled on the street and it never wanted to start again and when I make it start again it started smell gas

THE GA RECOAL BOT NEVER FXE

TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE PARKED AT THE CONTACT'S RESIDENCE, THE VEHICLE CAUGHT FIRE UNDERNEATH THE HOOD AND INSIDE THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 200,000. *AS PHOTOS ATTACHED *JB

MY 2005 KIA SEDONA WAS PARKED IN MY GARAGE AND IT CAUGHT FIRE IN THE DASH IN FRONT OF THE STEERING WHEEL. THAT IS WHERE THE FIRE DEPARTMENT SAID IT STARTED. IT WAS A TOTAL LOSS, ONLY HAD 115,000 MILES, NO ISSUES. THANK GOD IT WAS AT 8 AM AND WE WERE AWAKE, EARLIER MY WHOLE FAMILY AND OUR HOME MAY HAVE BEEN GONE AS WELL.

MY KIA SEDONA STARTS WHEN IT WANTS TO. I HAVE POWER TO THE DASH LIGHTS, RADIO, AND OTHER ELECTRONICS. THE COMPANY HAS KNOWN ABOUT THIS ISSUE SINCE THE 2002 VERSION AND WITH HIGH MILES. IT HAS TO DEAL WITH THE "AN ISSUE WITH THE FACTORY VEHICLE IMMOBILIZER CONTROL MODULE CAN CAUSE THE VEHICLE TO THINK IT IS BEING STOLEN. THIS WILL IMMEDIATELY DISALLOW THE VEHICLE FROM STARTING.". WHILE THIS IS GOOD MOST OF THE TIME, IT ISN'T GOOD SINCE IT DOESN'T SET OFF THE "ENGINE LIGHT" SO MECHANICS CAN READ THE COMPUTER. I HAVE BEEN WITHOUT MY VEHICLE FOR A MONTH AND MISSED NUMEROUS DAYS OF WORK DUE TO THIS ISSUE. THE MECHANICS THAT ATTEMPT TO WORK ON MY VEHICLE, CAN NOT GET IT TO DUPLICATE THE "NOT STARTING", IT WILL START EVERY TIME FOR THEM. MAKING ME FEEL LIKE AN IDIOT. THIS PROBLEM HAS BEEN GOING ON FOR TWO MONTHS AND IT DRAINING MY FINANCES. I DID SOME RESEARCH OF MY OWN AND DISCOVERED THAT ON WWW.REPAIRPAL.COM HAS MANY WHO HAVE THE SAME ISSUES. KIA WANTS ME TO TAKE THE VEHICLE TO THE NEAREST KIA DEALER TO HAVE IT CHECKED OUT. THE NEAREST DEALER IS 6 HRS AWAY AND THERE IS NO GUARANTEE THAT IT WOULD MAKE IT THERE. I COULDN'T EVEN DRIVE IT 2 HRS WITH OUT AN ISSUE. I FEEL SINCE THEY KNEW THERE WAS AN ONGOING ISSUE WITH THIS MODULE ON THIS VEHICLE, THEY SHOULD HAVE TO REPLACE IT AND MAKE COMPENSATION FOR THE CUSTOMER.

WHILE DRIVING AT APPROX 55MPH ON BOTH A 2 LANE HWY AND THE INTERSTATE HWY, THE VAN WOULD SUDDENLY MAKE A LOUD BANG SOUND, JUMP, AND THE RPMS WOULD GO UP TO OVER 4000 AND SOUND LIKE IT WAS IN 2ND GEAR. ENG LIGHT CODE SAID INTAKE TRANS SENSOR, WHICH I HAD REPLACED. SAME PROBLEM HAPPEND 2 MORE TIMES AFTER THAT AND STILL NOT FIXED.WILL WORK FOR A WHILE AFTER SHUTTING CAR OFF AND RESTARTING IT BUT SAME PROBLEM HAPPENS AFTER ABOUT 20 MILES. CODE STILL READS INTAKE SENSOR PROBLEM EACH TIME. I TRIED USING OFF BRAND SENSORS THE FIRST 2 TIMES AND AN AUTHENTIC KIA SENSOR THE 3RD TIME. THERE WAS NO DIFFERENCE IN PERFORMANCE, JUST THE COST OF THE PARTS.

MY AIR BAG LIGHT IS ON AND I TALK TO KIA ABOUT IT THEY WANT TO CHARGE ME A PRICE FOR TO TAKE IT OFF I HAE A WHEEL BEARING PROMBLE TO. I HAD TO GET MY WHEEL BEARING REPAIR TO.

I WAS DRIVING ON ROUTE 55 WITH MY 2YR OLD DAUGHTER AND I WAS GOING 70MPH WHEN THE TREAD SEPARATED FROM THE TIRE CAUSING MY CAR TO FISHTAIL IN BETWEEN BOTH LANES ON THE HIGHWAY UNTIL I WAS ABLE TO GAIN CONTROL AGAIN AND GOT MY CAR TO THE SHOULDER OF THE HIGHWAY. THE DEFECTIVE TIRE IS A FIRESTONE WILDERNESS HT 225/70R15

STALLS WITH NO WARNING ALL SPEEDS ALL WEATHER CONDITIONS..ENGINE HOT OR COLD..STARTS RIGHT BACK UP..VERY DANGEROUS

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING LOW SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (KIA OF GRAND BLANC AT 6167 SAGINAW RD, GRAND BLANC, MI 48439, (810) 694-5600) WHERE IT WAS DIAGNOSED THAT THE VEHICLE DID NOT HAVE THE ORIGINAL CRANKSHAFT POSITION SENSOR PART. THE VEHICLE WAS NOT REPAIRED DUE TO THE DEALER NOT DIAGNOSING THE AFTERMARKET DORMAN CRANKSHAFT POSITION SENSOR THAT WAS DEFECTIVE AND CAUSED THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE CRANKSHAFT POSITION SENSOR WAS NOT A KIA PART AND DID NOT OFFER ANY FURTHER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

IN MOTION. THE BRAKES BECAME MORE AND MORE SPONGY. UPON INSPECTION I FOUND THE STUDS THAT HOLD THE MASTER BRAKE CYLINDER TO THE BOOSTER, ONE WAS BROKEN OFF AND THE OTHER HAD A LOOSE NUT.

BRAKES CONSTANTLY SQUEAK AFTER NEW BRAKES AND PADS ON. ELECTRIC WINDOWS PASSAGENER AND DRIVER SIDE NOT WORKIN

TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY SHUT OFF AND THE BRAKES AND POWER STEERING NO LONGER FUNCTIONED. THE CONTACT RAN OFF THE ROAD INTO A DITCH. THE VEHICLE CAUGHT FIRE AND EXPLODED. A FIRE REPORT WAS FILED AND THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE ORIGIN OF THE FIRE WAS UNDETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 240,000.

TIRES ARE STILL OVER 1/2 TREAD BUT BIG BULGES IN TREAD AREA

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE THE VEHICLE WAS PARKED, IT ROLLED BACK AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES SUSTAINED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE SCENE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. UPDATED 02/03/17*LJ *CN

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT THERE WAS A PROGRESSING NOISE HEARD NEAR THE BRAKE SYSTEM. THE DEALER DIAGNOSED THAT THE WHEEL BEARINGS AND HUBS PREMATURELY FRACTURED AND WERE HELD TOGETHER ONLY BY TWO BOLTS. THE PARTS HAD TO BE REPLACED ON THE FRONT DRIVER'S SIDE TIRE. THE DEALER WAS TO FURTHER INSPECT THE OTHER THREE TIRES. IN ADDITION, THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT REPAIR SHOP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT PROVIDED NO SOLUTION. THE MANUFACTURER STATED THAT THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 05V232000 (WHEELS). THE CONTACT WAS UNCERTAIN AS TO WHO WOULD REPAIR THE VEHICLE AND IF THE FAILURE WOULD RECUR. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING 20 MPH, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER SAFE. THE MECHANIC STATED THAT THE BRAKE SYSTEM NEEDED REPAIRING, BUT NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 168,000.

AIR BAG DASH LIGHT CAME ON ONE MORNING AND HAS NEVER GONE OUT, KIA WANTS BETWEEN 100 AND 1500 DOLLARS TO DIAGNOSE AND REPAIR, EVEN THO VEHICLE HAS NEVER BEEN IN AN ACCIDENT.

THE VEHICLE STALLED WITHOUT WARNING& I CANT BRING IT TO A STOP SAFETY CAUSE THE BRAKE PADDLE IS HARD TO PUSH IT WILL NOT RESTART RIGHT WAY IT WILL JUST START & STALL

3/29/2016...MY 2005 KIA SEDONA HAS STEERING PROBLEMS. THE STEERING WHEEL IS TIGHT OR STIFF AND OFTEN DIFFICULT TO STEER ESPECIALLY IN MAKING RIGHT TURNS. MY MECHANIC EXPERIENCED THE SAME PROBLEM THIS MORNING WHEN DRIVING IT AND SAID IT IS THE STEERING COUPLER. WHEN HE CONTACTED A LOCAL KIA DEALERSHIP THEIR PARTS DEPARTMENT TOLD HIM THAT THERE WAS A RECALL ON THIS ITEM. HOWEVER, IT SEEMS WHEN I CALLED TO ARRANGE AN APPOINTMENT TO HAVE THE RECALL ADDRESSED, I LEARNED THAT THERE IS NO OPEN RECALL ON MY VEHICLE AT THIS TIME BUT THAT THERE HAD BEEN A RECALL BACK IN 2005 ON THE STEERING COUPLER AND WORK HAD BEEN DONE. HOWEVER, I DIDN'T PURCHASE THE VAN UNTIL 2007 AND WAS UNAWARE OF THAT RECALL. I AM VERY CONCERNED ABOUT THIS STEERING PROBLEM THAT IS OCCURRING NOW IN MY KIA SEDONA VAN AND THAT IT NEEDS TO BE ADDRESSED AGAIN BY KIA AND BELIEVE THAT OTHER OWNERS MAY BE EXPERIENCING THE SAME PROBLEMS IN STEERING THEIR VANS AS I AM. THE STEERING COUPLER NEEDS TO BE RECALLED AGAIN.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO ACCELERATE, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE OCCURRED RANDOMLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SUDDENLY EXPERIENCED UNINTENDED ACCELERATION AND THE SPEED INCREASED WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE DRIVER FORCEFULLY APPLIED THE BRAKES TO STOP THE VEHICLE. AFTER RESTARTING THE VEHICLE, THE FAILURE CONTINUEDE. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 185,000.

FUEL TANK LEAKS DUE TO CORROSION NEAR FILLER TUBE. THIS IS A SIMULAR PROBLEM TO THE FUEL TANK CORROSION EXPERIENCED BY 2006-ON KIA SPORTAGES. DESCRIPTION: FUEL WILL LEAK FROM THE TANK WHEN THE TANK IS FULL DUE TO RUST/CORROSION OF THE TANK NEAR THE FILLER TUBE. THE VEHICLE IS OPERATED/OWNED IN MICHIGAN, AN AREA THAT USES LARGE AMOUNTS OF ROAD SALT DURING THE WINTER MONTHS. FUEL LEAKAGE IS POSING A POTENTIAL FIRE/EXPLOSION RISK AS FUEL VAPORS FROM THE LEAKAGE MAY BE IGNITED. FUEL LEAKAGE OCCURS BOTH WHEN THE VEHICLE IS STATIONARY AND IN MOTION. IF THE VEHICLE IS PARKED IN A CLOSED GARAGE THE VAPORS CAN ACCUMULATE, ELEVATING THE RISK FOR FIRE/EXPLOSION. (SIMULARLY THE REAR COOLANT LINES RUST THROUGH AS WELL DUE TO ROAD SALT, WHICH IS A KNOWN PROBLEM WITH THE KIA SEDONA)

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING AT VARIOUS SPEEDS, OR SITTING FOR 10 MINUTES, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. UPDATED 03/09/16*LJ THE CONSUMER WAS INFORMED THE CRANK SENSOR NEEDED TO BE REPLACED. UPDATED 05/10/16. *JB

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE LOST POWER WHILE DRIVING AT VARIOUS SPEEDS AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE POSITION SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING 55 MPH, THE SUN ROOF DETACHED FROM THE VEHICLE WHICH NEARLY CAUSED A CRASH. THE VEHICLE EXPERIENCED MODERATE CORROSION AROUND THE DOORS AND THE INTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE DRIVING 55 MPH, ANOTHER VEHICLE REAR ENDED THE CONTACT'S VEHICLE. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE NECK AND BACK, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE DRIVING APPROXIMATELY 30 MPH ON AN ICY ROAD, THE ENGINE JERKED AND THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE CRASHED INTO A FENCE. THE AIR BAGS HAD NOT DEPLOYED AND THE SEAT BELT HAD NOT RETRACTED. A POLICE REPORT WAS FILED. THERE WAS ONE INJURY REPORTED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 95,610.

VEHICLE IS HARD TO TURN AT <5MPH OR IDLE AND JERKS OR REFUSES TO RESPOND. *TR

WAS LEAVING OUR LOCAL WALMART ; AND WHEN ALMOST TO THE INTERSECTION; FELT THE CAR WHEEL WOBBLE LIKE I GOT A FLAT TIRE. SO I STOPPED AND GOT OUT AND LOOKED; DIDN'T SEE ANY FLATS ; STARTED TO GO AND A THUNK ; AND THEN I COULDN'T MOVE; BOTH FRONT TIRES WERE POINTING IN OPPOSITE DIRECTIONS. HAD TO HAVE IT TOWED HOME; AND HAVEN'T BEEN ABLE TO LOOK AND SEE WHAT THE PROBLEM IS BECAUSE OF THE WEATHER. I SURE AM GLAD I WASN'T GOING DOWN THE INTERSTATE AT THAT TIME; IS WHERE I WAS GOING . *TR

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT THE VEHICLE'S UNDERCARRIAGE WAS BADLY RUSTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A NEW FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE MAKING A RIGHT TURN OVER A SPEED BUMP AT 2 MPH, THE CONTACT CRASHED THE VEHICLE INTO A POLE. AS A RESULT, BOTH AIR BAGS DEPLOYED. THE CONTACT SUSTAINED INJURIES TO THE FINGERS AND SWELLING TO THE ARMS THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000.

STEERING WHEEL WILL NOT TURN AT LOW SPEEDS. THIS HAS ALMOST CAUSED ACCIDENTS ON SEVERAL OCCASIONS. STEERING WHEEL WILL NOT TURN OR BECOMES VERY DIFFICULT TO TURN WHEN I BACK OUT OF MY DRIVEWAY OR OUT OF A PARKING SPACE.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED WHILE DRIVING 5 MPH, THE STEERING WHEEL TURNED IN A FULL CIRCLE SEVERAL TIMES INDEPENDENTLY. THE AIR BAG WARNING LIGHT ILLUMINATED AND THE HORN SOUNDED PRIOR TO THE ENGINE SHUTTING OFF. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHEN DEPRESSING THE BRAKE PEDAL, THE CONTACT HEARD AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT ALSO STATED THAT THE CHECK ENGINE WARNING LIGHT FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 115,000.

THE DRIVER'S SIDE SEAT BUCKLE FELL OFF. THE TWO WIRE CABLES HOLDING THE BUCKLE BROKE WHILE THE VEHICLE WAS NOT MOVING. *TR

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING AT 43 MPH, A DEER JUMPED IN FRONT OF THE VEHICLE WHICH CAUSED A CRASH AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE CHEST AND BACK WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING INTO A PARKING SPACE WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE SUDDENLY ACCELERATED FORWARD AND CRASHED INTO A METAL TRASH DUMPSTER. ON ANOTHER OCCASION, WHILE THE CONTACT WAS DEPRESSING THE BRAKE PEDAL AND APPROACHING A TRAFFIC LIGHT, THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION. THE VEHICLE SPED INTO A BUSY INTERSECTION AND NEARLY CAUSED A CRASH. IN ADDITION, WHILE REVERSING INTO A STORAGE SPACE, THE VEHICLE EXPERIENCED UNINTENDED ACCELERATION AND CRASHED INTO A BRICK WALL. THE DEALER CLEANED THE THROTTLE, BUT THE FAILURES CONTINUED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 87,000.

TL* THE CONTACT OWNS A 2005 KIA SEDONA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE RPMS INCREASED EXCESSIVELY AS THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT STATED THAT THE BRAKES WERE DEPRESSED AND FAILED TO RESPOND. THE CONTACT DIAGNOSED THAT THE THROTTLE CABLE WAS STUCK AND AS A RESULT, THE THROTTLE ASSEMBLY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER : 05V329000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 101,000.

WE HAVE A 2005 SEDONA WHICH WE LOVE. IT'S BEEN A GREAT CAR FOR US. UNFORTUNATELY, WE HAVE HAD ONGOING ISSUES WITH IT FOR SOME TIME NOW. OUR MAIN PROBLEM AND CONCERN RIGHT NOW IS WITH THE FRONT END STRUTS AND OR ALIGNMENT. THE NOISE AND KNOCKING AT LOW SPEEDS (ESPECIALLY WHEN ACCELERATING FROM A STAND-STILL) IS TROUBLESOME, BUT MORE TROUBLESOME IS THAT WE CONSTANTLY NEED TO REPLACE THE FRONT TIRES. WE ARE GOING ON OUR 4TH SET OF NEW TIRES (FOR THE FRONT ALONE) DUE TO ALIGNMENT ISSUES. NO BALANCING OR ALIGNMENT WORK HAS HELPED. AFTER HOURS OF RESEARCH ON LINE, IT SEEMS THAT THE FRONT BRAKES MAY BE UNDERSIZED CAUSING THE ROTORS TO OVER HEAT AND WARP. THE STRUTS ALSO SEEM TO HAVE A WRONG TYPE OF MOUNT SYSTEM AND HAVE TO BE REPLACED. THERE ARE NUMEROUS COMPLAINTS TO BE FOUND ON THE WEB FROM PEOPLE WITH SIMILAR ISSUES. THERE IS A TSB ON THE TOPIC (CHA015) REGARDING NEW STRUT MOUNTS, BUT WE ARE NOT SURE WHAT TO DO ABOUT IT NOW. HTTP://WWW.KIA-FORUMS.COM/KIA-CARNIVAL-SEDONA/26537-SEDONA-FRONT-STRUTS.HTML HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/16289/KIA/SEDONA/KIA-SEDONA-STRUT-ISSUES HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/7565/KIA/SEDONA/KIA-SEDONA-TIRES-WHEELS WE ARE SO DISAPPOINTED AND KIA SEEMS TO BE DOING NOTHING ABOUT IT. THE PROBLEM IS GETTING WORSE AND WE FEAR THAT THERE IS A SAFETY CONCERN HERE. *TR

THE COOLANT LINE CORRODED AND LEAKED COOLANT WHICH MADE THE VEHICLE RUN HOT AND STOP. I WAS LUCKY TO BE NEAR A GAS STATION AND GOT OFF OF THE ROAD. I CALLED AAA FOR A TOW. THE DEALER WOULD NOT WARRANTY THE COOLANT LINE STATING IT IS A MAINTENANCE ISSUE. MAINTENANCE ISSUE? HOW CAN THE GENERAL CONSUMER KNOW THAT THE COOLANT LINE THAT RUNS UNDER THE VEHICLE IS A MAINTENANCE ISSUE AND NOT COVERED UNDER THE MAKERS WARRANTY. *TR

I GOT THESE TIRES FROM WAL MART ON 07/03/2012 IN JULY I WENT TO TAKE WIFE TO WORK FOUND MY TIRE FLAT CHANGED OUT FOUND SIDE WALL CAME APART. THIS WAS A 60000 MILE TIRE WHY WOULD THIS HAPPENED I HAVE BEEN MECHANIC FROM OVER TEN YRS. NEVER HAD THIS PROBLEM WITH TIRES. COULD YOU TELL ME WHY?

THE 2005 KIA SEDONA AIR CONDITIONER STOPPED FUNCTIONING NORMALLY AND SOMETIMES IT TURNS ON AND SOMETIMES DOESN'T ALSO THE HEATER STARTED ACTING UP AND IT SOMETIMES WOULD TURN ON AND SOMETIMES WOULDN'T THIS HAS LED TO THE CAR GETTING TO THE POINT WHERE IT'S GOING TO OVERHEAT. *TR

DEAR OFFICER, I HAVE PURCHASED 2 SETS OF FOUR TIRES (ASSURANCE TRIPLETRED, 215/70R15) IN SUMMER 2010 AND 2011 (HYUNDAI XG AND KIA SEDONA). I FOUND THAT ONLY ONE OF TIRES SHOWS A KIND OF CRACKS A LOT ON THE SIDE (I HAVE THE PICTURE) RELATIVELY. I CHECKED THE DATE OF MANUFACTURING ON THE TIRE AND FOUND 'BLANK'. THREE OF FOUR SHOW THE YEAR AND WEEK (0923...). I ALSO FOUND THAT ONE OF FOUR TIRES IN MY ANOTHER CAR HAS NO DATE EITHER. IT'S ODD AND SUSPICIOUS TO ME. I HAVE GOT THEM ALL FROM A GOODYEAR STORE. I HAVE SOME PICTURES TO SHOW THE EVIDENCE. I AM SO SCARED WHEN I REALIZED THAT I HAVE DRIVEN MY CARS ON ILLEGALLY UPDATED OR SOLD TIRES. [XXX] P.S. I ALREADY CONTACTED GOODYEAR AND GOT FEEDBACK FROM MY CONTACT PERSON AT GOODYEAR, SAYING THAT IT'S ODD BUT CAN BE HAPPENED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

IN JUNE AND JULY OF 2011 I PURCHASED 4 YOKOHAMA 215/70R15 98S AVID TOURING S TIRES FOR MY 2005 KIA SEDONA VAN. WITHIN THE LAST 6 MONTHS I HAVE HAD TO REPLACE 3 TIRES DUE TO SEPARATION. DRIVING IS BOTH HIGHWAY AND CITY WITH AT LEAST 80 MILES HIGHWAY 5 DAYS EVER OTHER WEEK. SINCE PURCHASING THE TIRES I HAVE DRIVEN 46,000 MILES. THE FIRST SEPARATION OCCURRED AUGUST 1, 2012 WITH MILLAGE AT 157,000. THE SECOND ON NOVEMBER 21, 2012 AT 164,000 MILES. THE THIRD SEPARATION OCCURRED FEBRUARY 1, 2013 AT 176,000 MILES. THE SYMPTONS INDICATING A PROBLEM WITH THE TIRES ARE; A. WOBBLING OF THE VEHICLE AT VERY LOW SPEED, B. PULLING TO THE RIGHT OR LEFT, C. INTENSE VIBRATION AT HIGHWAY SPEED (>55). WE ARE LUCKY THERE HAVE BEEN NO ACCIDENTS RELATING TO THESE DEFECTIVE TIRES. THE FIRST TWO TIRES WERE REPLACED UNDER THE TIRE DEALERS WARRANTY PROGRAM. I LOST CONFIDENCE IN THE MANUFACTURER AND MODEL AFTER THE THIRD SEPARATION AND WITH CREDIT FROM YOKOHAMA PURCHASED FOUR NEW TIRES; DIFFERENT MAKE AND MODEL. ALL THE TIRES WERE RETAINED BY THE DEALER. THE LAST TIRE HAD A MANFACTURE DATE OF 81S0610. *TR

TL* THE CONTACT OWNS A 2005 KIA SEDONA. WHILE DRIVING AT LOW SPEEDS AND MAKING A RIGHT TURN, THE STEERING WHEEL SEIZED. AS A RESULT, THE CONTACT CRASHED INTO A CURB AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO MULTIPLE DEALERS AND INDEPENDENT MECHANICS WHO WERE UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.