Kia · Sedona · 2005
2
Recalls
185
Complaints
-
Not Rated
The 2005 Kia Sedona has 2 recalls and 185 owner-reported complaints on file with NHTSA. Most reported issue: service brakes, hydraulic (51 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2005 Kia Sedona page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is service brakes, hydraulic with 51 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Remedy Status
DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Remedy Status
DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
Brake line rusted out. Lost brakes while driving.
Rear Right Hub Recall on this model
The contact owns a 2005 Kia Sedona. The contact stated while the vehicle was parked, she noticed that the vehicle was overheating. There were no warning lights illuminated. The contact stated she attempted to open the hood of the vehicle to determine the cause of the failure, but...
Preview excerpt
Hi my van started smell a lot to fuel so I looked for leaks and I found a big leak on the fuel rail rack dripping a lot of fuel on the side of engine when engine is running and the car is unsafe to drive and I’m very worried about this problem. This happened after my car stalled ...
Preview excerpt
THE GA RECOAL BOT NEVER FXE
TL* THE CONTACT OWNED A 2005 KIA SEDONA. WHILE PARKED AT THE CONTACT'S RESIDENCE, THE VEHICLE CAUGHT FIRE UNDERNEATH THE HOOD AND INSIDE THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF T...
Preview excerpt
MY 2005 KIA SEDONA WAS PARKED IN MY GARAGE AND IT CAUGHT FIRE IN THE DASH IN FRONT OF THE STEERING WHEEL. THAT IS WHERE THE FIRE DEPARTMENT SAID IT STARTED. IT WAS A TOTAL LOSS, ONLY HAD 115,000 MILES, NO ISSUES. THANK GOD IT WAS AT 8 AM AND WE WERE AWAKE, EARLIER MY WHOLE FAMI...
Preview excerpt
MY KIA SEDONA STARTS WHEN IT WANTS TO. I HAVE POWER TO THE DASH LIGHTS, RADIO, AND OTHER ELECTRONICS. THE COMPANY HAS KNOWN ABOUT THIS ISSUE SINCE THE 2002 VERSION AND WITH HIGH MILES. IT HAS TO DEAL WITH THE "AN ISSUE WITH THE FACTORY VEHICLE IMMOBILIZER CONTROL MODULE CAN CAUS...
Preview excerpt
WHILE DRIVING AT APPROX 55MPH ON BOTH A 2 LANE HWY AND THE INTERSTATE HWY, THE VAN WOULD SUDDENLY MAKE A LOUD BANG SOUND, JUMP, AND THE RPMS WOULD GO UP TO OVER 4000 AND SOUND LIKE IT WAS IN 2ND GEAR. ENG LIGHT CODE SAID INTAKE TRANS SENSOR, WHICH I HAD REPLACED. SAME PROBLEM HAP...
Preview excerpt
MY AIR BAG LIGHT IS ON AND I TALK TO KIA ABOUT IT THEY WANT TO CHARGE ME A PRICE FOR TO TAKE IT OFF I HAE A WHEEL BEARING PROMBLE TO. I HAD TO GET MY WHEEL BEARING REPAIR TO.
Showing 10 recent complaints from 185 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2005 Kia models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2005 Kia Sedona has 2 recalls recorded by NHTSA.
NHTSA has received 185 owner-reported complaints for the 2005 Kia Sedona.
NHTSA has not published a safety rating for the 2005 Kia Sedona.
The most commonly reported complaint categories for the 2005 Kia Sedona are service brakes, hydraulic (51 reports), electrical system (10 reports), steering (9 reports).
Yes. NHTSA has 2 recalls on record for the 2005 Kia Sedona. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.