2015 Nissan Altima Suspension Problems

I made a left turn out of my work parking lot and felt a clunk. Shortly afterward, the car started shaking violently at about 10 mph. I relocated it to the Nissan dealer near my workplace and they discovered the rear lower link/control arm was fractured from rust deterioration. I was advised that they had previously had an extended warranty for that item. I told them i was never made aware of that warranty and reached out to Nissan. They told me that because I “failed” to keep track of my warranty i was out of the window on that repair being covered. I asked how i was to know about the issue if not for the part snapping? He insisted that they sent notices (to the address i lived at when i purchased the car in 2015). He then advised that since work was already started on the car there was likely nothing they could do to offer a goodwill adjustment since I’d agreed to the repair. He advised me that i should have called before bringing the car in (to check the status on a warranty i had no idea existed). I take the tollway home. 5 minutes later and i could have died.

I drove the car and 1min after it loses control and we checked it and found out the rear suspension lower control arm broke off from the subframe

At speed, my wife was driving and without warning was pulled into oncoming traffic. Thank goodness, no accident. A completely failed and broken rear control arm (photo attached). I was told Nissan offered an extended 10 year warranty for this. We were 10 months beyond that. This is no exaggeration, people will be killed because of this. The part literally separated in 2, causing the wheel to immediately slant at a near 45-degree outward angle and shoot ther car forcefully across the lane. One day prior she was on the expressway in [XXX] . I can’t imagine the outcome there. To make this an extended warranty item and not a recall to me is this agency not looking out for the citizens of this country. Nissan is protected, but that should not be this agencies mission. This should be a recall. I can’t imagine how many thousands of people are out there this very day with this suspension part right at the breaking point. We received no notice about this extended warranty, no notice that would have prompted me to have it checked out. It was an accident-bomb waiting to explode. The repair was $1500, and despite having a part Nissan themselves admit is prone to failure, they are dodging the financial ramifications of their inadequate part. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When backing out of my garage the driver's side rear lower control arm catastrophically broke. Thankfully, I was traveling at slow speed so it did not cause and accident. This is a major safety concern for other Altima drivers and the drivers and occupants of vehicles around them if this type of failure would occur at highway speeds. This is a known issue for as there was an investigation which closed last year. That is unacceptable and there should be a recall. This is a severe product defect and the manufacturer should be held responsible.

Rear lower passenger side control arm snapped

The contact owns a 2015 Nissan Altima. The contact stated while driving approximately 30 MPH, the steering wheel jerked and caused the vehicle to shift into the left lane. The contact immediately slammed on the brake pedal and repositioned the vehicle into the intended lane, but the vehicle felt unstable as if the vehicle was driving on ice. The contact pulled over to the side of the road to inspect vehicle but found no cause for the failure. The contact drove to the residence. The contact’s husband reversed the vehicle into the garage, exited the vehicle and became aware that the rear passenger’s wheel was pushed into the wheel well, revealing that the rear control arm was fractured. The contact stated that the rear control arm had fractured while driving, causing the vehicle to veer into another lane. While reversing in the driveway, the control arm completely detached, and the wheel fell inward. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 196,000.

Rear Lower Link failure. The car has 145,XXX miles on it. I live in Wisconsin where we use Salt. I was driving the vehicle and hit a pot hole and the Driver Rear Lower Link failed in January 2026. Calling the dealer for repair I was informed of P9324 which did not cover my car. I bought replacement parts from Nissan to replace the Rear lower Links on both sides. Driver side had failed already and Passenger side was ready to fail also. I called Nissan support and I was informed that my car had a warranty extension on the Rear lower links through April 27 2025. this notice was sent to the wrong address so I was not aware of it. Also the Rear Lower link failed after the warranty extension. Nissan call person said there is nothing they can do for me. This is a know failure point Nissan know this by offering a warranty extension and P9324. All Altima's that used this same Rear lower link should have been included in P9324. Control of the car was compromised and harder to drive and not recommended with this failure. No need to reproduce failure as the part broke. No inspection besides my self as the dealer told me $500+ in labor to repair, I repaired my self. No warnings. Part can be inspected for 1 week then it will be disposed of. Pictures are attached.

I was driving going 60 mph on the highway when then I felt as I was sliding on as in the rear when my steering wheel immediately shifted right hard . I was able to pull over safely without causing an accident . My steering where was a quarter turned to the right while my car was still driving straight. Due to excessive rust from an unknown source my control completely snapped in half while the vehicle was in motion.

Right rear passenger rear tire assembly broke off from frame of vehicle

The rear control arm corroded and disconnected from the car. While I was driving. I was backing out of my driveway and there was a loud clinking noise and I observed the drivers side control arm hanging down. And my tire is now very high in the wheel well. Thank God it did not let go while I was on the highway.

The contact owns a 2015 Nissan Altima. The contact stated that while his son was driving approximately 65 MPH, the vehicle started shaking and vibrating abnormally. The contact stated that while his son was driving at an undisclosed speed, the vehicle felt as if the vehicle was drifting to the left and was bouncing. The contact stated his son was not aware of any warning lights being illuminated. The contact stated that his son drove the vehicle back to the residence. The contact looked under the vehicle and became aware that the driver's side rear control arm was fractured. The contact stated that the driver's side rear wheel was leaning into the wheel well. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.

Driving down highway, hit dip at bridge seam, when the car bounce up from dip, the right rear control arm snapped in half. Car lost control to right, fortunately I was able to maintain control somewhat and avoided accident. Right rear wheel tilted at 45 degree angle. Car currently at repair shop with snapped lower rear control arm

My husband was pulling in a parking spot and heard a pop like noise and went out to inspect the car and saw the rear tire was falling off the car. We are told it was the lower suspension link

Over the last 2 years I had both left and right side rear "lower link" suspension elements "rot out" and break while operating the vehicle. Both times leaving me stranded roadside. After the the 2nd failure I felt it couldn't be a coincidence and found Nissan has issued a voluntary action and admitted using faulty parts in Altima's between 2013 to 2018. They voluntarily extended the warranty to 10 years and unlimited mileage. They are now denying repair of my issue because I am 2 weeks beyond their arbitrary 120 month warranty extension. I say arbitrary because how can they put a time limit on parts you know to be faulty and are corroding? I have one of these known faulty parts and simply based on random circumstances mine failed 2 weeks too late. So they dodge responsibility for selling me a poor quality car? At the urging of the dealer, I escalated with Customer Satisfaction believing they would own up to this and acknowledge responsibility. Customer Satisfaction mandated I must tow the car to Nissan to confirm failure of the part - which I did at my expense. The dealer confirmed the part failure but Customer Satisfaction parroted the "denied because it was 2 weeks too late" position. I believe Nissan 1) Minimized to the NSTB the safety risk this failure poses (breaking while at moderate to high speeds and stranding people in traffic roadside), 2) Is failing to act in good faith to cover a know manufacturers defect and 3) is employing "bait and switch" tactics by telling customer to have vehicles towed to their service centers to only then deny coverage based purely on "calendar date" (in hopes of forcing a customer to pay to use their service center).

The contact owns a 2015 Nissan Altima. The contact stated while driving 42 MPH, the rear end of the vehicle was shuddering. The vehicle was taken to an independent mechanic, where it was diagnosed that the rear passenger's side upper control arm was fractured. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: EA19002 (Suspension). The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 60,500.

The rear control arm on the driver side snapped while my wife was driving. Now the rear side sways

Rear lower control arm failed while driving. Luckily I was able to maintain control. Not sure if I would have been so lucky had I been on the highway. Car rear end was unstable and hard to control. Had vehicle towed to private repair shop then researched warranty campaign. Currently having it towed for the second time to a Nissan dealership.

I was driving along on slightly rough pavement and the car sort of twitched in the rear end and then every few rotations of the rear wheel, the car shuddered-accompanied by a grinding noise. Then I noticed, that to continue in a straight line, the steering wheel was about 30 degrees, clockwise, to the right of center! I managed to limp on down the shoulder of the road at 10 mph and made it the mile and a half to my house. I thought a wheel bearing had failed, but when I took off the driver's side rear wheel, I discovered that the lower control arm was rotten with corrosion and rust and had collapsed. I searched online for the broken part but, fortunately, found out that Nissan had extended the manufacturer warranty due to pressure from NHTSA. I had the undriveable vehicle towed to the local Nissan dealer (Matthews) and they fixed the car- SAME DAY, NO APPOINTMENT, NO CHARGE. AND they took care of the hood latch recall at the same time. I still can't believe I have my car back, and functional, in what would be considered-in the car repair business- as the 'blink of an eye'. All's well in Vestal, NY. Thank you, NHTSA.

Rear Control Arm broke while driving on the highway. We are lucky the car did not crash and cause serious injury to myself and others.

Right rear control arm broke while driving down the road causing the car to lose control. Appears to only have very small contact points to the bushing.