Pontiac · Grand Prix · 2004
9
Recalls
454
Complaints
-
Not Rated
The 2004 Pontiac Grand Prix has 9 recalls and 454 owner-reported complaints on file with NHTSA. Most reported issue: engine (64 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 Pontiac Grand Prix page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is engine with 64 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Remedy Status
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Remedy Status
GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Remedy Status
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Remedy Status
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Remedy Status
DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Remedy Status
DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
CERTAIN PASSENGER VEHICLES HAVE A CONDITION WHERE THE FRONT FRAME REAR BODY MOUNT BRACKET MAY FRACTURE.
Remedy Status
DEALERS WILL INSPECT THE FRONT FRAME ASSEMBLY AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKING SYSTEMS." ON SOME OF THESE VEHICLES, THE RIGHT REAR BRAKE HOSE FITTING MAY NOT BE TIGHTENED PROPERLY, AND A BRAKE FLUID LEAK COULD OCCUR.
Remedy Status
DEALERS WILL TIGHTEN THE RIGHT REAR BRAKE HOSE FITTING TO THE PROPER TORQUE SPECIFICATION, AND ADD BRAKE FLUID IF NECESSARY. OWNER NOTIFICATION BEGAN AUGUST 28, 2003. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.
The contact owned a 2004 Pontiac Grand Prix. The contact stated that the "Low Oil" message was displayed monthly, requiring oil to be added to the engine. While driving at approximately 5 MPH, the contact noticed smoke in the cabin near the floor on the passenger’s and driver’s s...
Preview excerpt
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING ENGINE OIL WHILE DRIVING. THE CONTACT STATED THAT OCCASIONALLY WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO STOP AS DESIGNED, CAUSING THE BRAKING DISTANCE TO BE EXTENDED. ...
Preview excerpt
THE IGNITION KEY GETS SUCK AND WON'T TURN AND LEAVES MARKS ON KEY. SOMETIMES THE KEY WON'T START THE CAR
OIL LEAKING ,TRACTION CONTROL KEEPS SHUTTING ON AND OFF,EVAC LEAK,IN MOTION,SMOKE AND OIL STAINS COMING FROM CAR. SCANNER READS MISFIRE NEEDS PLUGS AND WIRES BUT JUST GOT PLUGS AND WIRES.
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED WHILE DRIVING 24 MPH, A CLICKING SOUND WAS HEARD IN THE STEERING WHEEL. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT DROVE TO A BUSINESS PARKING LO...
Preview excerpt
FIRE DEPARTMENT SAID MY CAR BURNED UP COLD IN THE YARD ELECTRICAL FROM THE FUSE BOX PASSENGER SIDE. THE ALARM WENT OFF I LOOKED OUTSIDE FLAMES WAS GOING THRU WINDSHIELD THRU THE DASH TIRES WAS BURNING CALLED FIRE DEPT. 02/04/2020. CAR IS TOTALLED. I NEVER HAD ANY ISSUES WITH THE...
Preview excerpt
ABS AND TRACTION CONTROL LIGHTS ARE ILLUMINATED. SOMETIMES WHILE BRAKING, A WEIRD HYDRAULIC SOUND IS HEARD AND THE BRAKES DONT WANT TO STOP THE CAR. THE PEDAL WONT GO DOWN FURTHER UNLESS SOMETIMES YOU FORCE IT AND LOCK UP THE TIRES AND BRAKES. NO CODES ARE SHOWING FOR THE ABS OR ...
Preview excerpt
I TOOK MY CAR IN FOR THE 2015 RECALL FOR THE VALVE COVER ON 3/1/16. IT WAS ABOUT 63,000 AT THE TIME THIS RECALL SERVICE WAS PERFORMED. HOWEVER, EVEN AFTER THE RECALL WAS DONE, OIL AND ENGINE COOLANT STILL LEAKS FROM THE VALVE COVER AND FROM THE FRONT EXHAUST MANIFOLD. I WENT IN T...
Preview excerpt
PONTIAC OIL LEAK RECALL I BOUGHT A PONTIAC GRAND PRIX. I WAS DRIVING IT HOME ONE DAY WHEN I LOOKED IN THE MIRROR AND SAW SMOKE SO I PULLED OVER AS SOON AS I COULD. I HAD AN ISSUE WITH RPMS FALLING AS I WAS TRYING TO FIND A SAFE PLACE TO PULL OFF THE HIGHWAY. UPON STOPPING THE V...
Preview excerpt
ENGINE CAUGHT FIRE AS I WAS COMING HOME I PUT IT OUT WITH WATER .CAR DROVE JUST FINE HAS FRESH OIL CHANGE
Showing 10 recent complaints from 454 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 Pontiac models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 Pontiac Grand Prix has 9 recalls recorded by NHTSA.
NHTSA has received 454 owner-reported complaints for the 2004 Pontiac Grand Prix.
NHTSA has not published a safety rating for the 2004 Pontiac Grand Prix.
The most commonly reported complaint categories for the 2004 Pontiac Grand Prix are engine (64 reports), electrical system (58 reports), steering (38 reports).
Yes. NHTSA has 9 recalls on record for the 2004 Pontiac Grand Prix. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.