Ram · 3500 · 2020
11
Recalls
112
Complaints
-
Not Rated
The 2020 Ram 3500 has 11 recalls and 112 owner-reported complaints on file with NHTSA. Most reported issue: fuel system, diesel (19 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2020 Ram 3500 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is fuel system, diesel with 19 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 1500, 2500, and 3500 pickup trucks. The tailgate may not latch properly due to misaligned tailgate strikers, which could result in the tailgate opening while driving.
Remedy Status
Dealers will inspect the tailgate striker alignment to the box latch and adjust, if necessary, free of charge. Owner notification letters were mailed December 22, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZB8.
FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.
Remedy Status
Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.
Chrysler (FCA US, LLC) is recalling certain 2019-2022 Ram 2500 and 2021-2022 Dodge Durango vehicles, and 2019-2022 3500 cab chassis with GVWR less than 10,000 lbs. The ABS control module software may prevent the electronic stability control (ESC) malfunction indicator light from illuminating during certain conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Remedy Status
Dealers will update the ABS control module software, free of charge. Owner notification letters were mailed March 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z20.
Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500 and Ram 3500 vehicles, Ram 3500 Cab Chassis, 4500 Cab Chassis, 5500 Cab Chassis and 3500 Cab Chassis with a gross vehicle weight rating (GVWR) of less than 10,000 lbs. The windshield wiper arms may loosen, possibly causing the wipers to function improperly and reduce the driver's visibility in certain weather conditions.
Remedy Status
Dealers will tighten the wiper nuts, free of charge. Owner notification letters were mailed February 15, 2022. This recall is an expansion of recall number 20V-208. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z08.
Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 2500, 3500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. The High Pressure Fuel Pump (HPFP) may fail, resulting in a sudden engine stall without warning.
Remedy Status
Dealers will replace the HPFP, update the Powertrain Control Module (PCM) software, and inspect and replace additional fuel system components as necessary, free of charge. Interim owner notification letters to inform owners of the safety recall were mailed on January 4, 2022. Owner notification letters were mailed on May 17, 2022. Phase 2 owner notification letters are expected to be mailed on March 2, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y78.
Chrysler (FCA US, LLC) is recalling certain 2019-2020 Ram 3500, 4500, and 5500 cab chassis vehicles equipped with a Cummins 6.7L High Output engine. The engine calibration software may not warn about low oil volume.
Remedy Status
Dealers will update the engine calibration software, free of charge. Owner notification letters were mailed June 25, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Y21.
Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.
Remedy Status
Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.
Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Remedy Status
Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 3500, 4500 and 5500 cab chassis built with a Cummins 6.7L High Output engine. Inadequate warmup protection can cause a lack of oil film on the engine connecting rod bearings while the engine is reaching operating temperature. This can result in engine damage and connecting rod failure, which could potentially puncture the engine block.
Remedy Status
Chrysler will notify owners, and dealers will flash the engine calibration software to enhance the engine warm up protection, free of charge. The recall began September 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W57.
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 2500 and Ram 3500 Pick-up trucks equipped with an accessory bed step. In certain side loading conditions, the bed step may unexpectedly fail while in use.
Remedy Status
Chrysler will notify owners, and dealers will replace the bed step support brace, free of charge. The recall began on July 9, 2020 (RAM 2500) and began on October 6, 2020 (Ram 3500). Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's numbers for this recall are W24 and W44.
Chrysler (FCA US LLC) is recalling certain 2019-2020 Ram 2500 and 3500 Pickup vehicles equipped with six-speed automatic (68RFE) transmissions. A build up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.
Remedy Status
Chrysler will notify owners, and dealers will replace the transmission valve body separator plate and reprogram the powertrain control module. The recall began March 2, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W03.
The contact owns a 2020 Ram 3500. The contact stated while driving approximately 50 MPH, the engine overheated. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and determined that the cooling fan module had failed, and the engin...
Preview excerpt
The contact owns a 2020 Ram 3500. The contact stated that while the vehicle was parked and the engine was turned off, the gear shifter shifted into the drive position when the contact's minor [XXX] child entered the vehicle to retrieve an item using the steering wheel and gear s...
Preview excerpt
The contact owns a 2020 Ram 3500. The contact stated that while the vehicle was parked and turned off, the gear shifter shifted into drive independently, causing the vehicle to roll away. The vehicle stopped before crashing. The vehicle was taken to a dealer; however, the vehicle...
Preview excerpt
The contact owns a 2020 Ram 3500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a...
Preview excerpt
After normal operation, I shut off the vehicle, and within seconds it caught fire without any external cause. Our insurance company and Look Larson Dodge investigated the incident over approximately 3½ weeks but could not determine a definitive cause of the fire.
The contact owns a 2020 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of ...
Preview excerpt
The contact owns a 2020 Ram 3500. The contact stated that while driving at an undisclosed speed, the front wheels became inoperable. The contact stated that the vehicle was pulling to one side. The vehicle was taken to the dealer to be diagnosed and the contact was informed that...
Preview excerpt
Abs module has failed twice since truck purchased.
The contact owns a 2020 Ram 3500. The contact stated while the vehicle was parked, he noticed that coolant was leaking underneath the vehicle. The EGR warning light was illuminated. The contact stated that upon adding coolant to the EGR valve, the contact noticed that coolant was...
Preview excerpt
The contact owns a 2020 Ram 3500 equipped with Atturo Tires, Tire Line: Trail Blade A/T, Tire Size: 235/80/R17, DOT Number: KA0HD80R4223. The contact stated while driving approximately 50 MPH, the front passenger's side tire experienced a blowout. The contact pulled over to the s...
Preview excerpt
Showing 10 recent complaints from 112 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2020 Ram models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2020 Ram 3500 has 11 recalls recorded by NHTSA.
NHTSA has received 112 owner-reported complaints for the 2020 Ram 3500.
NHTSA has not published a safety rating for the 2020 Ram 3500.
The most commonly reported complaint categories for the 2020 Ram 3500 are fuel system, diesel (19 reports), fuel/propulsion system (17 reports), power train (8 reports).
Yes. NHTSA has 11 recalls on record for the 2020 Ram 3500. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.