NHTSA Campaign Number
16V815000
ELECTRICAL SYSTEM:WIRING
Reported to NHTSA: October 11, 2016
Defect Description
Kia Motors America (Kia) is recalling certain model year 2008-2009 Kia Sportage vehicles manufactured August 9, 2007, to May 13, 2009. The wire harness cover on the Hydraulic Electronic Control Unit (HECU) may be improperly sealed allowing water to get onto the HECU circuit board. If the water is contaminated with salt, such as could occur from melted snow, the wire harness connector pins may corrode and the circuit board may short circuit.
Safety Consequence
If the HECU short circuits, there is an increased risk of an engine compartment fire.
Remedy
Kia will notify owners, and dealers will inspect the connector pins for corrosion, if no corrosion is found, the connector cover will be replaced. If corrosion is present, the dealer will replace the HECU assembly and the connector cover, free of charge. The recall began on November 28, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC138.
What This Recall Page Shows
This page summarizes a single NHTSA recall campaign, including the defect description, safety consequence, and manufacturer's remedy. The affected vehicles listed below are the make/model/year combinations tracked in our database — this is not a VIN-specific result. To check whether your individual vehicle is covered by this recall, enter your 17-digit VIN at nhtsa.gov/recalls. Click any vehicle below to view its full safety profile.
Affected Vehicles (2)
Browse Affected Vehicles
Affected Models
This recall information is from NHTSA campaign 16V815000. This site is not affiliated with NHTSA. Contact your dealer or call NHTSA's Vehicle Safety Hotline at 1-888-327-4236 for more information.