Saab · 9-3 · 2004
6
Recalls
207
Complaints
-
Not Rated
The 2004 Saab 9-3 has 6 recalls and 207 owner-reported complaints on file with NHTSA. Most reported issue: seat belts (75 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 Saab 9-3 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is seat belts with 75 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.
Remedy Status
GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
Remedy Status
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2004 SAAB 9-3 SEDANS. SOME OF THESE VEHICLES WERE PRODUCED WITH FRONT SEAT BELT RETRACTORS THAT, OVER TIME, COULD FAIL TO RETRACT.
Remedy Status
DEALERS WILL REPLACE THE DRIVER SIDE RETRACTOR FREE OF CHARGE. IF THE FRONT PASSENGER RETRACTOR WERE TO FAIL TO RETRACT, GM WILL REPLACE THE FRONT PASSENGER RETRACTOR FREE OF CHARGE UNDER A SPECIAL COVERAGE THAT WILL BE RELEASED FOR THE SAME POPULATION FOR 10 YEARS FROM NEW VEHICLE DATE OF SALE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2010. OWNERS MAY CONTACT SAAB AT 1-800-955-9007 OR AT THE OWNER CENTER AT SAABPARTS.COM/US. Note: In June 2014, GM expanded the special coverage from 10 years to be for the lifetime of the vehicle.
CERTAIN SPORT SEDAN AND CONVERTIBLE PASSENGER VEHICLES WERE PRODUCED WITH A VACUUM PIPE CHECK VALVE FOR THE BRAKE BOOSTER THAT MAY FAIL FROM EXPOSURE TO ELEVATED TEMPERATURES. THIS COULD RESULT IN SUDDEN LOSS OF POWER BRAKE ASSIST, USUALLY WITH LITTLE OR NO WARNING.
Remedy Status
DEALERS WILL INSTALL A NEW REDESIGNED CHECK VALVE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
SOME SPORT SEDANS WERE BUILT WITH SEAT BELT RETRACTORS THAT WERE DAMAGED DURING THE MANUFACTURING PROCESS. IF DAMAGED, OVER TIME, THE AUTOMATIC TENSIONING SYSTEM (ATS) CABLE IN THE SEAT BELT RETRACTOR COULD BREAK CAUSING THE BELT WEBBING TO NOT RETRACT.
Remedy Status
DEALERS WILL REPLACE THE SEAT BELT RETRACTOR ASSEMBLIES. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." THE BACKREST LOCKING MECHANISM ON SOME FRONT SEATS MAY HAVE BEEN INSTALLED INCORRECTLY.
Remedy Status
DEALERS WILL INSPECT THE VEHICLE'S FRONT SEATS TO DETERMINE IF THEY ARE EQUIPPED WITH THE IMPROPERLY INSTALLED COMPONENT. IF EITHER OR BOTH OF THE SEATS HAVE THIS COMPONENT, THEY WILL BE REPLACED. THE DEALER MAY NEED TO ORDER A COMPLETE NEW SEAT OR SEATS (INCLUDING MATCHING UPHOLSTERY) AND THE PARTS MAY TAKE UP TO TWO TO FOUR WEEKS TO ARRIVE. SAAB WILL PROVIDE A RENTAL CAR FOR THE OWNER UNTIL THE NEW SEAT(S) IS (ARE) AVAILABLE AND INSTALLED BY THE DEALER. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING FEBRUARY 2004. OWNERS SHOULD CONTACT SAAB AT 1-800-955-9007.
Retractor won't pull driver side seat belt back in
Constant random recurrence of error codes P2122 and P2138 (either together or on their own) which results in the car switching to low power mode, with very low acceleration which makes it very dangerous to merge into traffic, pull out of stops, red lights, etc. Technically suppos...
Preview excerpt
******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE THE CONSUMER PLACED THE REQUEST*DJR ******* DELETE VOQ *******
CALLED DEVOE AUTOMOTIVE IN NAPLES TO HAVE RECALLED SEATBELT FIXED, IT JUST FAILED TO RETRACT. I SENT A PICTURE OF THE VIN. AND WAS TOLD THEY COULD NOT FIND IT AND COULD NOT HELP US WITH OUT A LETTER WITH OUR VIN ON IT SAYING THE BROKEN SEATBELT WAS RECALLED, JUST BECAUSE IT ...
Preview excerpt
TL* THE CONTACT OWNS A 2004 SAAB 9-3. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT FAILED TO RETRACT WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AUTONATION CHEVROLET WEST AMARILLO (7300 I-40 FRONTAGE RD, WEST AMARILLO, TX 79106, 806-553-5673) AND WAS INFORMED THAT THE REPAIR...
Preview excerpt
AIR BAG MALFUNCTION LIGHT
I HAVE A RECALL ON THE DRIVER'S SIDE SEATBELT. IT WAS BROKEN AND IS UNSPOOLED.
TAKATA RECALL - GM DEALERS ADVISE MY CAR NOT AFFECTED BUT ON RECALL WEBSITES MY 2004 SAAB 9-3 AERO IS SHOWN TO HAVE A TAKATA AIR BAG.
FRONT DRIVER SEAT BELT RETRACTOR HAS FAILED WHEN I WENT TO FASTEN MY SEAT BELT.
WHILE DRIVING, WITHOUT ANY WARNING THE CAR ENGINE STALLS. NO WARNING AT ALL!! ONCE IT STOPS, IGNITION KEY WON'T WORK. THE ONLY WAY TO RESTART THE CAR IS TO DISCONNECT THE BATTERY. THIS IS ALL DONE IN THE EMERGENCY SHOULDERS, BREAKDOWN LANES, ITS ALSO HAPPENED ON THE HIGHWAY EX...
Preview excerpt
Showing 10 recent complaints from 207 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 Saab models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 Saab 9-3 has 6 recalls recorded by NHTSA.
NHTSA has received 207 owner-reported complaints for the 2004 Saab 9-3.
NHTSA has not published a safety rating for the 2004 Saab 9-3.
The most commonly reported complaint categories for the 2004 Saab 9-3 are seat belts (75 reports), suspension (48 reports), air bags (17 reports).
Yes. NHTSA has 6 recalls on record for the 2004 Saab 9-3. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.