2020 Subaru Outback Complaint Log

I was reversing out of a residential driveway onto a county highway when the I had a complete loss of movement. Shortly after the total loss of power, the CEL illuminated. If I had been on the highway, the driveway is near a blind curve, I would've been sitting in the road with no way to move putting me in a dangerous situation. The transmission failed at right at the end of the driveway so I was able to put it in neutral and move the vehicle by hand. There were no symptoms or warning lights prior to the failure. I had it towed to the nearest dealership where they diagnosed a complete transmission failure and recommend a complete transmission replacement.

Vehicle: 2020 Subaru Outback Onyx/Limited/Touring XT (2.4L Turbo FA24) Component: Engine Lubrication / Oil Pan Sealant I am reporting a manufacturing defect involving the engine oil pan seal on the 2020 Subaru Outback 2.4L Turbo. Upon inspection of fluid accumulation at the transmission joint, a Subaru dealership diagnostic confirmed that the engine oil pan seal has failed. The dealership noted that engine oil is leaking and being forced rearward by airflow while the vehicle is in motion, saturating the transmission assembly. Technician Admission: The service department at the Subaru dealership explicitly stated that this is a "known manufacturing issue" with the FA24 engine series. Financial Concession: To acknowledge the nature of this premature failure, the dealership waived the $185 diagnostic fee, resulting in a $0 invoice (attached). Inadequate Coverage: Despite the dealership’s admission and a repair quote exceeding $1,100 (file is attached), Subaru has not yet issued a recall or extended warranty for this specific 2020+ turbo application, though similar issues with RTV sealant have plagued the brand’s newer engine platforms. The technician confirmed that the leak is significant enough that oil is traveling the length of the transmission. This presents a potential fire hazard if oil contacts high-temperature exhaust components (such as the turbocharger or catalytic converter) and contributes to environmental contamination. This is the Turbo (XT) model. Turbochargers generate much higher heat, which makes an oil leak significantly Subaru National Customer Service has advised me to file this complaint with the NHTSA. I am requesting that the NHTSA investigate the frequency of oil pan seal failures on the 2020+ 2.4L Turbo (FA24) engine to determine if a mandatory recall or extended warranty (similar to past CVT or engine seal settlements) is warranted to protect consumers from the high cost of a documented manufacturing flaw.

I was parking my car slowly until it suddenly accelerated. I hit a wall and car got totaled.

No warning lamps or messages. A driver in a pickup truck behind me came up close and signaled me to pull over. He got out of his truck, ran up to my window and yelled to me "get out of your car, it is on fire". I was completely unaware of any problem. I got out and could see fire coming from under the front of the car. We moved away and he called 911.

I'm writing to request assistance with my recall. This recall was first reported to the local dealership over one year ago. They have had me take the car back 4 times for inspection. Since that time as the problem has proceeded to get worse, which will now cost even more to repair, and increase the likelihood of the transmission damaging other parts of the drivetrain. Now I just received notification that they will not perform the recall as my vehicle doesn’t qualify. It has the problem of transmission slipping which is what the recall is for. I saw the pictures they took that looked exactly like the problem specified. I do not have $7000 dollars plus to fix the transmission. I can’t sell the car because the VIN will show the recall (which I’m sure they will try to just remove). All they have done is waste my time for the last year to do what? Gather enough evidence to try and get out of the recall?

The contact owns a 2020 Subaru Outback. The contact stated that while driving 65 MPH on the highway, the contact was alerted by the message “Eyesight Technology Failure”, before the battery shut down, causing the steering wheel to seize, forcing the contact to come to a complete stop in the middle of the highway. The check engine, air bags, and oil warning lights were illuminated. The contact stated that several other unknown warning lights and alerts were displayed on the instrument panel. The vehicle was jump-started, and the contact was escorted by a tow truck operator to the nearest dealer. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 37,168. The VIN was invalid.

On December 28, 2025, my 2020 Subaru Outback lost the ability to engage any gear (Drive, Reverse, or otherwise) while maneuvering at low speed to make a U-turn. The vehicle became inoperable immediately and was towed to the dealer. The dealer confirmed via text and written estimate that there was no external damage, the failure was internal to the CVT transmission, and the transmission requires replacement. This vehicle has approximately 90,023 miles. The failure occurred under the mileage and age range covered by Subaru CVT warranty extensions for similar vehicles. Subaru of America reviewed the case and denied coverage, citing VIN exclusion and prior service gaps that predated my ownership. The vehicle is currently inoperable and presents a safety risk due to loss of propulsion. I am reporting this to NHTSA because it may indicate a systemic defect in CVT transmissions on this model year Outback.

I am reporting a safety-related defect involving the Supplemental Restraint System (SRS) on my 2020 Subaru Outback with approximately 20,480 miles. Multiple SRS and occupant detection system warning lights illuminated. Dealer diagnostics showed multiple SRS-related faults including airbag ECU malfunction, occupant detection sensor communication failures (lost communication/mismatch), and SRS power/voltage-related faults. These systems directly control airbag deployment and passenger safety. The vehicle has not been involved in any accidents and has not been misused. The dealer advised the vehicle is not safe until repaired. Subaru of America declined assistance and closed my case, stating it is outside goodwill parameters, and is requiring me to pay approximately $1,200 to repair the airbag-related system. In November of the prior year, the vehicle had a battery failure and was serviced by a Subaru-certified dealer. During that repair, wiring work was also performed. Given the current SRS faults and the prior wiring/battery service, I am concerned this may be a systemic or related defect rather than normal wear. I am requesting NHTSA review this issue as a potential safety defect involving the SRS/occupant detection system.

A fire started under the hood of my car while I was driving. There were no warning lights on in my car and the temperature gauge was in the middle where it usually is. Earlier in the day, I smelled gas, but I thought it was a different car as the smell of gas went away after a car that had a lot of exhaust coming out was no longer in sight.

Transmission is failing. Wheel bearing bad. This is a 5 year old car with regular maintenance. No warning lights.

Immediately stop every single traffic light

I was driving to a medical appointment in Ann Arbor Mi, and was in the area where [XXX] has a few big turns in the road .... like at ... [XXX] .All of he sudden the car started to accelerate a little on the turn so I attempted to brake the vehicle and I could not feel the brake pedal. I slowly moved into the right lane and frantically trying to slow the car down. I still could not feel the brake pedal and I believe when I hit the speed control off is when it slowed down and I was able to finally brake the car. It all happened in a matter of 10-20 seconds I would guess and it was absolutely terrifying. I have on occasion used the speed control to slow down the vehicle and wonder if that might have some connection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Gas cap was not secured overnight. The next day every ADAS function both safety and convenience was disabled and their lights were on. Users guide said car should recover after a few miles of driving. 100 miles and multiple restarts later it did not. It was taken to the dealer where they cleared the error for free. Poor design that a loose gas cap could cause a collision due to lack of ADAS. Dealer said it is a known condition with all Subaru models.

The contact owns a 2020 Subaru Outback. The contact stated that while attempting to make a turn, the transmission was slipping while attempting to shift gears. There was no warning light illuminated. The vehicle was taken to the dealer, but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 56,700. The VIN was not available.

Car stalled in traffic. The engine was cranking but it would not start. Had AAA tow off the road and to my home. Car sat for 10 days waiting for a fuel pump (thought this was the problem). After sitting for 10 days the battery was totally dead! New fuel pump installed battery was jumped but could not start the car. After 2 hours on the charger the battery still did not have enough energy to turn over the engine. Car is in a certified service shop (Wilhelm). Battery replaced and same starting issues with the new battery and the new battery is discharging at a very high rate even though the car is not starting. Bought the car used in 2023 so I have no knowledge of the history of the car. Service provider running factory diagnostic testing but so far no determination as to cause of the high rate of discharge. Verified that the fuel pump is fully operational. What we know is that with a fresh fully charged battery and a working fuel pump the car will not start and remain running. The engine stops and the battery drain is excessive.

[XXX] and I were driving to Sean’s for dinner on Friday night [XXX] when the sunroof glass exploded at approximately [XXX]. [XXX] was driving on the [XXX] . We heard a loud bang and thought we were in an accident. We noticed sounds from the sunroof so I slide the cover open slightly and saw a massive hole so immediately closed it again. We pulled off and used the emergency ramp to examine the damage and take pictures. We think the glass exploded for no reason as we did not see any debris in front of us and were not under an underpass. We did not find any debris or scratches on the car indicating an external object as the culprit. I dropped my car off with Subaru Carlsbad on June 17, 2025 and am waiting for an update. My service advisor was shocked by the occurrence as she had not seen something like this. I pointed out that the glass exploded outwards and asked her to check the cabin pressure vents as we found discussion pointing to those as a potential issue when researching online. We also heard complaints that Subaru has specifically excluded this piece of glass from the warranty so I let my advisor know that I hope / expect this to be covered under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I received letter from Subaru of America saying parts available for recall repair but when I went to the dealer they did not have the parts.

No warning, or dash lights. A/C stopped working. It’s 98 degrees outside, to me that is dangerous! Wagner Subaru said it is the actuator doors ($900 in diagnosing) they said it would cost $3600. It’s a 2020. There is no reason there should be a cost that high for that new of a car.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

While in a Dairy Queen drive-up lane, I stepped on the brake pedal and it went right to the floor. The car did not stop, causing me to hit the car in front of me. When backing away from the car in front, the brakes again failed and I hit the car in back. I moved forward again , swiping the car in front again. The cars were merely feet apart and my car was thankfully moving very slowly. Had I been traveling at a higher rate of speed there could have been serious injuries. Car was taken to an Auto repair shop where the mechanic experienced the same problem with the brake pedal. He says the pedal went to the floor and the car wouldn’t stop. Car is currently at a collision shop where they report that inspection of the brakes is normal. They also report that the brakes worked when they pulled the car into the shop. The car has not yet been moved to the Subaru dealer service department for inspection of the brake pedal. There were no symptoms, warning lights or messages before the incident and there were none found by the shop after. My car was built in the same time frame as those involved with Recall #19V664000 which involves the brake pedal mechanism although my VIN was not included. The car is available for inspection. I initially received a ticket but it was dismissed after the repair shop owner reported the same failure.

Vehicle accelerated without touching gas pedal, rpm’s kept increasing even while trying to brake.

I am on my third windshield in les than a year. The tiniest pebble will crack the windshield, or sudden changes to weather has now caused a stress crack. Seems to be poor weight distribution on the design. There is extensive customer complaints on line with the same issue. Insurance will only cover two a year. There were no warnings of this issue when the car was purchased. This is an expensive hazard to keep having issues with. They need to do a recall on a fix.

Air bag sensor light came on. Took to dealership - Suburban Subaru, Troy, MI. $189 to diagnose....then received this note: Air Bag - Control Module: scanned vehicle using ssm4 and found codes B1185, B1195 and B1196. per subaru diagnostics, replacement of the SRS module is recommended to complete repair. repairs will include removal and replacement of current module as well as passenger seal Occupant Detection System relearn. $1415.16 in additional cost. This is a defect...and Subaru should cover the cost.

2020 Subaru Outback rear auto liftgate randomly automatically closes after opening. It has hit me, the owner, in the head as I was attempting to place items in the rear. It has hit various store personnel as they were attempting to load products in the rear. I have reported this to my local Subaru dealer many times over the last five years, even leaving my vehicle for several days for inspection. Their responses have been - if we don't see it, we can't help OR no problem is detected. I have reported to Subaru Consumer Advocate twice with no resolution.

The contact's husband owns a 2020 Subaru Outback. The contact stated that the vehicle was difficult to start intermittently, but was able to be jump-started. There was no warning light illuminated. The vehicle was taken to Advance Auto, where the contact was informed that the battery and the alternator were in good condition. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 56,000.

For our 2020 Subaru Outback, we are on our 3rd battery at only 49k miles. The car died again today. Thankfully AAA was able to jump it after a friend tried unsuccessfully. We suspect all of this battery drain, failure and replacement has been due to the known Data Communications Module (DCM) issue on recent Subaru’s. I have an appt w the dealer in Santa Monica tomorrow morning to have it diagnosed.

The car shifted (transmission) into neutral when cruising down the interstate at 62 MPH and stayed in neutral until the ignition was turned off. With no brake light cars were not worn and was nearly hit from behind. 2 weeks earlier the same happened on a city street. There was a previous transmission recall WRK-21Chain Slippage Recall on this vehicle that apparently didn't correct the problem.

Vehicle had 45,000 miles on it when right rear wheel bearing failed. It was covered under 5 year/60,000 mile warranty and was repaired today by a certified Subaru dealer and I no longer have the bad part for inspection. Safety risks would be anything that occurs from a bad wheel bearing like wobble, seizing, overheating, and more damage to other drivetrain components. You could hear the wheel bearing noise at 20 mph constant while driving, only getting louder with increased speed. No warning lights were present on the dash. I feel like at 45,000 miles, a wheel bearing should not be failing.

Only one issue was witnessed, that being when a fuel dispenser's auto shutoff clicked, fuel would shoot out and run down the side of the vehicle.

The contact owns a 2020 Subaru Outback. The contact stated that the front passenger’s side mirror had started to detach from the vehicle without an impact to the vehicle, and the mirror had become inoperable. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 68,000.

The Subaru front camera incorrectly detected a hazard. The automatic braking system engaged and locked the steering. I skidded off the pavement, causing damage to the car. At the time of the accident, the blind sight warning lights flashed on the dash signaling that they were disabled. I was going very slow in a driveway. No personal damage just property damage and damage to the car. I have let the insurance company know about the issue and the collision center. I have had periodic instances where the warning signals of blind sight disabled have come on the vehicle. I informed Subaru in August 2024 about the issue at my last maintenance appointment. There is also a software update required on the vehicle. I asked Subaru to update the software in August 2024, but I was told by a service technician that it was not possible to update . I had to make a separate appointment for the software update as it took a long time.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2020 Subaru Outback. The contact stated while the vehicle was parked in the garage, the contact became aware that there was a 12-inch-long crack on the windshield starting from the driver’s side of the windshield. The contact stated that there was no impact to the windshield that could have caused the windshield to crack. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 62,000.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Defective windshields. The vehicle has been in my possession for 4 years. During these 4 years i've had 5 windshield replacements. 2 of which have been from rocks. 3 of which I have no idea what caused the damage, it seemingly happened out of nowhere while driving. This is well known (but not well dealt with) issue with Subaru vehicles with eyesight. People on multiple forums have the same issue, as do many people I know personally. Its a shame nothing has been done about this despite countless reports and complaints. This is a safety hazard.

Windshield cracked from a rock chip. Within 1 day, the crack had expanded to 12 inches across the windshield.

After completing an OTA software update the screen would not load and entered continuous buffering disabling all environmental and safety functions.

Problem component: exterior mirror on driver side It was raining, I was driving, I heard what sounded like a loud explosion by my driver side window. After the initial shock, I thought a tire had blown out, but car drove ok and no tire warning light came on. It was a rural road with no shoulder, only deep stormwater ditch along the roadside, so there was no place to safely pull over in traffic to assess what may have happened. I drove about 2-3 miles before I could pull over at a safe spot.There I saw that the back side of my driver side mirror had completely disappeared. Wires were exposed. It appeared to have exploded off for no apparent reason. The body of the car was completely fine, the white exterior paint of the car was perfect, the actual housing of the mirror showed no marks, there are no dings or cracks in windows. No sign of any debris hitting the car. I reported it to Subaru general headquarters, and gave them all the info. I have an appt with local Subaru dealer this week. The mirror and housing are still on the car, minus the back, which is gone. My husband returned to the scene a few minutes later and searched for the piece that had propelled off the mirror or for any debris that could have caused the mirror to explode. There was nothing on the road, so wherever the back of the mirror went, it must have propelled far off the road. Safety issue: because an explosion like that nearly caused me to lose control of the car. And the piece that propelled off the mirror could have hit another car. Additional info. at the time of mirror exploding: my windshield wipers were on, it was a warm day so my air-conditioning was on, good chance my front dehumidifier was on. Car is equipped with heated mirrors, but heat was off.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (AIR BAGS); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while reversing, the rearview camera displayed a distorted image, compromising the back-over prevention system. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The contact related the failure to NHTSA: 20V766000 (BACK OVER PREVENTION) however, the VIN was not included. The failure mileage was 61,000. Parts distribution disconnect.

We are on our 3rd battery in < 4 years. Subaru is well aware of this issue in their engineering in the parasitic drain from the Starlink module. AAA won’t even replace these batteries anymore because the problem is so prevalent. Meanwhile, I’m about to have to buy a 4th battery less than 4 years after purchasing the car.

The contact owns a 2020 Subaru Outback. The contact stated that while his wife was accelerating from a stop at approximately 10 MPH, the vehicle stalled. The vehicle failed to move. There were unknown warning lights illuminated after the failure. The vehicle was towed to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The dealer informed the contact that there was no warranty coverage on the vehicle. The dealer confirmed the vehicle was not covered under NHTSA Campaign Number: 21V955000 (Power Train). The vehicle was not repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 70,158.

I have 2020 Subaru Outback and have had 14 windshield replacements/repairs. The windshield has spider cracked out of nowhere and has been unable to take the smallest impact without cracking in multiple locations. I have submitted multiple complaints to Subaru and was informed the issue is unique to my vehicle, but the car has never been inspected by Subaru, regardless of countless requests to do so. All but one windshield replacement has been submitted through my insurance, Subaru has covered one replacement. The last time I spoke with a Subaru representative I was informed it was not Subarus issue. No one was hurt during any windshield incidents but the quality and safety of the windshield is dangerous. Subaru has refused to thoroughly inspect my windshield and the safety of my vehicle.

ACC eye sight is intermittent. It normally fails within 5 minutes of operations and just turning the car on.

The contact owns a 2020 Subaru Outback. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermo-control valve. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 90,000.

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while operating the vehicle with a front seat passenger seated inside the vehicle, the warning message "Air Bag Off" flashed off and on. The cause of the failure was not determined. The failure mileage was 44,300. VIN tool confirms parts not available.

After an automatic software download update, the RAB off light came on. The RAB light comes on when the car is put in Reverse and provides the option to turn that function off. After the update, the RAB icon is no longer displayed. It is the only system so far that I noticed that malfunctioned after the software update

We are on our 3rd broken windshield in 3 years. We do not drive the car very often or drive any extreme ways. This is more broken windshields than I have had in my whole life in just a few years having this car. There must be something wrong with the way it’s made.

This recall for Subaru outbacks has been in effect since March but there is no remedy available yet. I would like to have my car repaired as soon as possible because of safety concerns. Is there a timeline for when a remedy will be available?

This is a safety issue regarding the durability of windshields. I have had 2 incidents now with my 2020 subaru outback having a cracked windshield. Both times it came on suddenly with at least a foot long crack or more the first time and an 18 inch crack the second time just recently. I reported the incident to the service manager this time and he put me in touch with customer advocacy at subaru who is waiting for a report from the diagnosis on Monday, July 22. The first crack was in March 2024. Prior to the crack happening, I noticed a drip of dried substance running down the inside of my windshield from the top of the windshield. I thought it must be sealant and was going to contact subaru. However, without warning, I pulled out of my garage one morning to find a crack across the driver side of the windshield at least a foot or longer. There had been no incident of any rock hitting my windshield that I noticed and there was no damage to the paint on frame close to where the crack started which was on the outer edge of the windshield. The crack grew larger and crossed over the driver's visibility. I asked if there had been a recall since I thought this was odd and spontaneous but there was none. The service repair person said if a rock chip occurs in the defroster area in the perimeter of the windshield, the windshield will sustain a long crack. So I believed that something like that must have happened in my lack of knowledge of prior issues with subaru windshields. I had a $1000 deductible on my insurance and the repair was over that. Subaru refused to negotiate with State Farm to reduce the price so I paid the entire amount out of pocket. The second crack occurred while I was driving in the rain. I turned off my wipers to find an 18 inch long crack on the passenger side of the windshield starting at outer edge of glass. No incident of a rock chip, no damage to paint on frame.

I am on my 4th windshield on a 2020 Subaru Outback