2021 Toyota Corolla Complaint Log

When attempting to replace the rear glass at Safelite on 4/29/2026, the worker noticed rust on the headliner. Now the rear glass can't be replaced until a body shop replaces the rusted headliner. I began leasing this car in December 2020, and now I own it. Now I am driving with a plastic covering over the rear window, which poses a safety hazard.

The car accelerated on its own when I was attempting to park it. I had no control over the car and it ended up crashing into multiple vehicles.

The contact owns a 2021 Toyota Corolla. The contact stated that while his son was driving at 3 MPH, they were rear-ended by a BMW X5 and pushed forward, crashing into a Ford Explorer. No warning lights were illuminated. The contact stated that his son sustained injuries consisting of lacerations to his face and was taken to the hospital by ambulance, where medical attention was provided. There was no reported fire. A police report was filed, which indicated that the air bags deployed. The contact stated that the air bags did not deploy. The vehicle was towed to a towing lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 90,000.

The Clutch Slave Cylinder needs replacement

Engine maintenance required, call dealer. The engine coolant bypass valve needs to be replaced. Known issue in Toyota corolla’s yet no recall to remedy the repair.

Coolant bypass valve has shorted out. “Engine maintenance required” notification popped up on the gauge cluster

Today I noticed that both of my door front locks passenger and driver side do not even actuate to have the door locked and unlocked by key of by the alarm. They completely stopped working. Even I contacted Toyota Corporate several times about this issue (800) 331-4331 and got ignored. This is a safety issue that needs to be addressed immediately. This is a safety concern for me and family.

One night shortly after starting the car, I went to put the car in first gear amd as I let out the clutch, but pedal stayed flat to the floor. I was able to lift the pedal with my foot and drive the car back to safety. The next day, I drove the car to the nearest shop before anything catastrophic happens. This time, right in the shop parking lot, I lost all hydraulic pressure in the clutch and I could not take the car out of gear. I had to turn off the car to prevent it from stalling as the clutch slowly engaged without my doing. I had the car inspected by two repair shops—one quote at $3900, the other at $6600. The issue is a failed seal on the clutch slave cylinder, located inside the transmission. The seal is much too thin from factory to withstand normal use. There are no recalls for this issue, and MANY affected owners. This is a safety issue because the failure can be almost immediate and will leave the driver unable to take the car out of gear, leading to out of control driving.

The contact owns a 2021 Toyota Corolla. The contact stated that while driving at 20 MPH, the clutch pedal failed to function as intended. The clutch pedal was stuck, and the contact was unable to shift gear. The contact forced the clutch back into neutral while holding the clutch pedal. Once the clutch pedal was released, the vehicle went into LIMP Mode and traveled down to the floorboard. The contact pulled over to the side of the road. The contact kicked the clutch pedal upwards to continue driving back to the residence. The contact arrived at the residence and inspected the vehicle, and became aware that there was brake fluid leaking from the vehicle, and the brake fluid reservoir was empty. The vehicle was towed to an independent mechanic who diagnosed that the clutch slave cylinder had failed and damaged the clutch and the flywheel. The vehicle remained with the independent mechanic unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.

While in a parking lot, the clutch pedal suddenly lost all pressure and remained stuck to the floor, rendering the vehicle unable to shift gears. While this occurred at parked car , a sudden loss of gear engagement at highway speeds would have caused a catastrophic loss of motive power in high-speed traffic. Furthermore, this vehicle utilizes a shared reservoir for both clutch and brake fluid. A major failure of the clutch slave cylinder seals can lead to rapid fluid loss or air ingestion into the shared hydraulic system, potentially compromising braking performance. The dealership confirmed the internal clutch slave cylinder failed prematurely at only 38,000 miles. Because the part is internal to the housing, a full transmission removal was required, resulting in a total repair cost of $5,600. Despite the safety implications of a shared hydraulic failure and the extremely low mileage, Toyota has refused to cover the full cost. No warning lights or symptoms appeared prior to this sudden failure.

The contact owns a 2021 Toyota Corolla. The contact discovered brake fluid on the clutch pedal, and the brake pedal was mushy while depressed. The vehicle was taken to the dealer, who determined that the brake master cylinder needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 89,900.

“Engine Maintenance Required, See your dealer” light comes on the dashboard with a warning bell. Did a diagnostic test, and the code is the coolant bypass valve malfunction. This seems to be a common issue among 2020-2021 models. This has been inspected by professional mechanics.

At approximately 5 years and 2 months of ownership, with approximately 53,000 miles, the clutch slave cylinder failed in such a way that contaminated both the clutch and flywheel with brake fluid. Repair of this issue requires replacement of the slave cylinder, clutch, and flywheel, as described by Toyota of Pullman in Pullman, WA who performed the inspection and quoted the repair. The symptoms of this failure included an inability to shift the manual transmission between gears, most notably out of 1st gear to get to 2nd. This inability to change gears resulted in limited speed in traffic, and created an obstruction. In less fortunate traffic conditions, this speed restriction could have created a collision. Other owners of the same model vehicle online have reported active failures in traffic, some of which have resulted in damage to the transmission as well as the clutch and flywheel. Toyota appears to have redesigned the slave cylinder at least twice, implying that they know the parts for these vehicles are subpar, and there are no flywheels available for the repair, which also implies this may be an all too common repair.

NOTE: This has not happened to me yet, but it appears that most Corollas manufactured before 2022 or 2023 have this issue. However I did recently flush the fluid from my clutch system and it was very clearly contaminated, possibly indicating early evidence of a failure. Clutch system, specifically the slave cylinder is faulty on these vehicles. It is a known issue on these cars that the clutch slave cylinder (inside the transmission) is made out of resin and fails. When the slave cylinder fails, brake fluid from the shared clutch/brake reservoir leaks out onto the clutch and flywheel, damaging them and resulting in an expensive repair. In addition to this, the brake fluid leak results in a "low braking power" message on the dashboard, indicating a problem with the braking system. Obviously this is a safety issue that could cause an accident. This issue has been confirmed by many dealers and the solution is to replace the slave, clutch, and flywheel and flush & refill the brake fluid reservoir. The vehicle has not been inspected by the dealer as of yet, but in the interest of safety I am considering an early replacement of the cylinder. The only warnings of this issue are a clutch stuck to the floor, and in some cases a "low braking power" warning on the dashboard. A low brake fluid level may also be an indicator of this issue if caught in time. Incident report below is of the clutch flush, showing the contaminated brake fluid from the clutch hydraulic system. It's important to note that flushing the clutch is not a recommended maintenance item at any point on these vehicles as it is expected to be done with the braking system, although that won't remove contaminants from the clutch cylinder.

On December 12, 2025, I was in a head on car accident in my 2021 Toyota Corolla nightshade. I was slammed into the steering wheel which caused injury. My car has over $14,000 worth of damage to the front yet my airbags did not deploy. I have taken my car to Toyota several times over the past few years and every time I’ve asked about a remedy for this recall I’ve been told there is no remedy as early as June or July 2025 I had to bring my car in for a manufacturer defect with the engine that Toyota fixed for free. I asked them about the recall on the airbags. They again told me there was no remedy.

I am filing this complaint regarding a serious defect in my 2021 Toyota Corolla (Manual). At approximately 42,000 miles, the clutch slave cylinder failed. This defect caused hydraulic fluid to leak and contaminate the clutch assembly, resulting in significant damage and loss of proper function. Despite the fact that this issue stems from a defective part, the dealership has refused to cover the repair of the clutch assembly, stating that the clutch is not covered under warranty. Instead, they are requiring me to pay for the repair out-of-pocket, which would not have been necessary if the damage had not been caused by the defective clutch slave cylinder. I believe this is unfair and unsafe, as the failure of a clutch slave cylinder directly impacts the drivability and safety of the vehicle. This is a significant safety issue. A defective clutch slave cylinder can lead to sudden clutch failure, loss of vehicle control, and increased risk of accidents. This is not a wear-and-tear issue but a manufacturing defect that compromises the safety of the vehicle. I respectfully request that NHTSA investigate this matter to determine whether similar failures are occurring in other Toyota Corolla vehicles of this model year. If this is a widespread defect, I urge NHTSA to take appropriate action, including a recall or requiring Toyota to cover repairs.

The contact owns a 2021 Toyota Corolla. The contact stated that while driving in a parking lot, the clutch pedal failed to function as intended. The clutch pedal was depressed and failed to return after being released. The contact used his foot to raise the clutch pedal. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the slave cylinder had failed. The vehicle remained at the dealer unrepaired. Upon further investigation, the contact related the failure to the six-speed manual transmission. The manufacturer was notified of the failure and assisted with the labor cost. The failure mileage was approximately 58,000.

While attempting to change a flat tire on a 2021 Toyota Corolla Hatchback, two wheel studs sheared off completely, leaving the wheel unsafe to drive. My wife was stranded alone in the mountains with no cell service. She managed to loosen three lug nuts, but the final two were seized. When a passerby assisted, both seized studs snapped. The spare could barely be mounted. The vehicle has been serviced exclusively by Toyota dealers since new. Lancaster Toyota later replaced the broken studs free of charge, yet simultaneously claimed that another dealer, Frontier Toyota, had “switched the tyres.” so Lancaster are not responsible. That claim is false — Frontier’s invoice (Sept 25 2025) clearly shows only an oil change and inspection, no tire or wheel service of any kind. Replacing the studs at no charge while denying responsibility suggests an attempt to quietly resolve what may be a dealer-induced over-torque or defective-stud failure. The broken studs were not returned to us despite multiple requests — effectively withheld by the dealer, which constitutes unauthorized retention of customer property and prevents independent verification of failure cause. Toyota Corporate (case #251103002581) was notified but refused to investigate, referring the issue back to the same dealer. This complaint is being filed so NHTSA can document a potential wheel-stud safety defect or service-related failure and dealer mishandling of critical evidence that could conceal a wider safety problem.

Complete failure of the slave cylinder under at 62k miles. changed fluid at 30k. Called to see if Toyota would still help with failure under warranty but did not help. Had to replace slave cylinder due to seal bursting. Left stranded on road.

Dunlop SP Sport 5000 - 225/40R18 - DOT EUT74DDR5220 3 of the 4 tires are splitting on the side walls

My car wouldn’t start and the dashboard says “Engine Stopped / Power steering low” car will stop driving completely randomly. No codes are popping up when I test the car.

The contact owns a 2021 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

The problem of windshield wipers going off either once, or at varying speeds has not been able to be reproduced by my Toyota dealership. It goes off right when I turn the car on 50% of the time and is very inconsistent. Wipers typically go off after using the turn signal, making long turns (such as into a parking spot), and driving on long curved roadways. It has been inspected and nothing has been found. There are no warning lights or messages.

The contact owns a 2021 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

I turned on the vehicle and an Engine Maintenance Required light and warning went off on my car. I noticed the warning would only come up once I turned on the A/C so I presumed it was an issue with the Coolant Bypass Valve

Odometer Fraud. The contact purchased a 2021 Toyota Corolla. The contact stated that while attempting to sell the vehicle to a Toyota dealer, the dealer informed the contact that there was a mileage discrepancy. The vehicle was a used car dealer sale. At the time of purchase in October 2024, the vehicle mileage was 60,000, and the current mileage was 74,000. However, the dealer informed the contact that the mileage on the Carfax report was 110,000.

The contact owns a 2021 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I was driving yesterday morning to work in freeway and a Message appeared in the dash saying Engine Maintenance Required. The message stills appears and it’s a safety issue that needs to be addressed by Toyota for defective parts or defective car and Toyota needs to replace my current vehicle for a new car. Furthermore this is a safety issue for me and others while the car is running.

Data communication module activation failed message at start of car. It's loud and my baby gets woken up by this..

red light on dashboard indicates passenger airbag is not working, I would like to have this taken care of.

Coolant bypass valve broken

Engine maintenance required P268115 engine coolant bypass valve

The car shows the message “Engine Maintenance Required” that leads to the coolant bypass hose being bad.

The engine maintenance required sign popped up on my 2021 Toyota Corolla and took it to a dealer to get it diagnosed and they reported back it was the coolant bypass valve. They want 1,000$ to fix the issue even tho the person I was dealing with at the dealer shop said it’s happening to all the corollas from 30,000 miles to 50,000 miles .

Clutch pedal sticks. Even after Toyota dealership bled lines. Apparent slave cylinder issue. Failure ranges from 35k to 80k miles. Faulty design using polymer is the internet’s general opinion.

The navigational systems shuts off in the middle of driving. The screen will go completely black making it unsafe when using navigational directions. The system also shuts off at the slightest pot holes. Windows also won’t work when trying to put them down from the drivers side

The contact owns a 2021 Toyota Corolla equipped with Yokohama Tires, Tire Line: Blue Earth, Tire Size: 205/55/R16, DOT Number: FD8K-LL012. The contact stated that while driving approximately 65 MPH, the vehicle started to shake and vibrate abnormally. The contact stated that after stopping to inspect the vehicle, the contact discovered that the rear passenger’s side tire had experienced a sidewall blowout and tread separation. The cause of the failure was not yet determined. The local Toyota dealer was notified of the failure. The tire manufacturer was not contacted. The failure mileage was 53,253.

Coolant bypass valve has failed. AutoNation Toyota in Cerritos has verified issue. This issue has caused potential engine overheating, engine maintenance required warning light has popped up in my vehicle, was told by AutoNation that my vehicle is not covered for this repair and I will have to pay out of pocket.

Dashboard warning: Engine Maintenance, Visit Dealer Toyota service center diagnostic found code P268115 - engine coolant bypass hose valve circuit short (recommend replacement of coolant bypass hose) An identical error is addressed with Toyota's Customer Support Program 24TE04 covering certain 2020-2021 Corollas (up to mid-January 2021). Reported vehicle's manufacture date is not covered under this Program notice.

Vehicle: 2021 Toyota Corolla Apex, 2.0L Engine Component Failure: The Engine Coolant Bypass Valve (also called Water Valve) malfunctioned. Its plastic housing cracked and leaked coolant, corroding the electrical connector. This prevents proper electronic control of engine temperature. The failed component is available for inspection if removed. Safety Risk: This issue poses a safety risk due to potential engine overheating. Overheating can lead to sudden loss of power or engine stall while driving, increasing the risk of a collision, especially at high speeds. A roadside breakdown in unsafe conditions is also a risk. Confirmation: A Toyota dealership service center confirmed the problem, diagnosing it as a leaking coolant bypass valve requiring replacement. Inspection: The vehicle was inspected by a Toyota dealership technician. It has not been inspected by the manufacturer, police, or insurance representatives. Warnings/Symptoms: The primary symptom was the "Engine Maintenance Required" message illuminating in the instrument cluster. This first appeared approximately [State how long ago, e.g., "3 weeks ago" or "at 45,000 miles"]. No other immediate symptoms like visible leaks or temperature fluctuations were initially noticed, though a leak was confirmed later.

The contact owns a 2021 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

My vehicle was backed into while ì was inside of it in a parking lot. Due to my horn failing., I was unable to alert the other driver to see me. The clock spring is what failed the first time at 95k they replaced it. I'm now at 147k and it failed again . Now I'm discovering that if it does not work, there's an electrical circuit failure and that the airbag will not deploy if I get in an accident. This is a serious safety issue and I feel Toyota should be responsible for it for the life of the vehicle . A horn should never go out. Especially if it not working will keep my air bag from functioning properly . 850 out of my pocket is way steep. The replacement part lasted half as long as the original part did when I bought the car that to me seems like a faulty part this should be obvious and they should just fix the problem cuz I might have to just consult an attorney should they choose not to. The attached photo shows what happens when you can't beep your horn at somebody who's about to back into your car !!! my car still has not turned on any kind of warning lamp for the airbag or any kind of malfunction light, no warnings on my radio. I have noticed that my Lane departure warning seems to work intermittently along with the automatic high beams that like to flash my high beams in people's face for some unapparent reason which also seems like a safety issue. If I had to take my car to an inspection station it would not pass an inspection due to the horn not working ! You cannot take your child to the Department of Motor Vehicles and let them take their drive test if your horn does not work ! which happened to be my case !! Very disappointing to say the least especially when you've paid $30,000 for a car.

My 2021 Corolla showed an ENGINE MAINTENANCE REQUIRED message. This message pertains to replacing the ENGINE COOLANT BYPASS VALVE - a common occurrence for the 2019-2023 corolla/rav4 models. I have seen multiple instances online of complaints of this same issue around the 50k-60k mark of the vehicle. This SHOULD be a RECALL due to how common the problem is. I’m here to add on to that TALLY of complaints that have already been submitted.

I just had to replace my transmission. 2 days later I have my check engine light, secondary collision, pre collision and parking brake malfunction lights came on. There is a osc recall that could cause these issues, but they’re saying stated my specific vehicle isn’t under a recall

I was coming to a stop and the clutch slave master cylinder just sank to the floor and wouldn’t activate the clutch. There were no symptoms of the clutch failing or having trouble changing gears prior to its failure. It was inspected by the Toyota tech and he couldn’t give me a reason for its premature failure.

See attached document for complaint.

The contact owns a 2021 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The horn has failed to work now for the second time. I first had this problem at approximately 97000 right before my warranty was up, and toyota had to replace the entire horn assembly they said that the wiring got wrapped up behind steering wheel and they weren't sure how . Now it started intermittently working the day I was going to let my daughter take her dmv drive test so she was not able to use my car it was sounding sick when I pressed it. Now it will not work at all . My car currently has 140k on it . Complete Safety hazard when someone pulls out of a parking space and you can't alert them to not hit your car! YOU PANIC!!!! . This is A Safety Issue!!!! And I have had no warning lights that came on, nor any messages on my system warning screen on my radio. I've checked all my fuses they are fine. Nobody should have to worry about replacing an 800$ horn assembly every 40k that's ridiculous i have never had a horn failure. I feel this needs to be investigated I may not be the only one with this problem. I think they should be required to fix something of this nature just as they should all air bag and seat belt issues . It SHOULD NEVER FAIL!!!!

On my 2021 Toyota Corolla SE at 43k miles the “service engine needed” notification came on. As I’m researching it’s a known issue with these models and RAV4 models. The cooling valve is needing to be replaced and Toyota does not cover it costing us about $500-$700 at the dealership.

When the windshield wipers are set to intermittent they would swipe as if they were set to lo and then they would come to a complete stop at a 45° angle sometimes starting up again but other times I would need to turn the windshield wipers off then back on for them to go again.