2015 Toyota Tundra Brakes Problems

Soft pedal when braking goes nearly to floor before engaging. Repairs attempted flushing brakes, new brake fluid and new master cylinder at dealer still not fixed. Toyota wants to replace ABS actuator but cannot guarantee it will fix the problem. Many instances of this on Toyota and no solutions. Toyota is ignoring the problem.

Front Rotors purchased on Amazon warped in under 5,000 miles/3 months of normal highway and city driving conditions. Issue caused high vibrations in front end when braking from 40+ mph. Paired with new Wagner OEX pads when installed. Manufacturer’s Warranty period was 24,000 miles/2 years. Rear rotors also warped about 1,000 miles after front rotors did. Front rotors were turned/resurfaced at about 3,000 miles and warped again within 1,000 miles. Replaced with Raybestos high carbon steel rotors and ceramic pads and no issues since replacement (over a year). Wagner did not offer replacement equipment under warranty and Amazon offered only partial refund after return and restocking fees.

TOYOTA TUNDRA 2015 BRAKE ROTORS OVERHEATED AND DISTORTED UNDER NORMAL DRIVING CONDITIONS ON FLAT CITY FREEWAYS AT 60MPH AND HIGHER. THIS RESULTED IN SIGNIFICANT VIBRATION OF THE BRAKE PEDAL AND THE STEERING WHEEL WHEN APPLYING THE BRAKES. I AM 74 YRS OLD AND HAVE EXPERIENCE DRIVING ALL SORTS AND BRANDS OF PICK-UP TRUCKS AND SUV'S AND HAVE NEVER EVERY EXPERIENCED THIS. THE TOYOTA DEALERSHIP IS CLAIMING THIS IS NORMAL.

INSTALLED FACTORY INTEGRATED TRAILER BRAKE CONTROLLER IN 2016. CONTROLLER DOES NOT SUPPLY ENOUGH POWER TO THE TRAILER BRAKES EARLY ENOUGH TO STOP APPROPRIATELY (TRAILER PUSHES THE VEHICLE). EVEN AT MAXIMUM POWER, THE ONLY WAY TO LOCK THE TRAILER BRAKES IS WITH THE MANUAL HAND LEVER. THIS IS NOTICEABLE AT ALL TIMES WHEN ATTEMPTING TO STOP WHILE TOWING THE TRAILER.

I OWN A 2015 TUNDRA CREW CAB. THE FAMILY AND I LOVE TO CAMP, SO WE PURCHASED A BRAND NEW CAMPER. I HOOKED UP THE CAMPER TO THE TUNDRA UTILIZING THE 7 PIN CONNECTOR. THE DASH DISPLAY INDICATED THE INTEGRATED BRAKE CONTROL WAS WORKING AND FULLY FUNCTIONAL. TO MY DISMAY, THE BRAKE CONTROL DID NOT WORK TO SATISFACTION AND BORDER LINED A SAFETY ISSUE. WITH THE GAIN TURNED UP TO 10 ON ELECTRIC MODE, THE CAMPER'S BRAKES BARELY ENGAGED AND RARELY SLOWED DOWN MY TRUCK. THE CAMPER IS 7800 POUNDS. I HAVE BEEN READING FORUMS AND OTHER TUNDRA OWNERS ARE HAVING THE SAME ISSUES WITH THEIR IBC....THERE IS NOT ENOUGH BRAKING POWER WITH TOYOTA'S FACTORY IBC. SEVERAL TIMES GOING DOWN HILL I DID NOT THINK THE ELECTRIC BRAKES WERE GOING TO SLOW TO STOP MY TRUCK! MY TUNDRA DID ALL THE BRAKING. I ALWAYS HAD MY FAMILY IN THE TRUCK WITH ME. IS THERE A RECENT SERVICE BULLETIN OR UPDATE TO THIS CONTROLLER???? AFTERMARKET CONTROLLERS WORK MUCH BETTER, BUT I WANT A CLEAN LOOK TO MY CAB. THANK YOU

MY INTERGRATED TRAILER BRAKE CONTROLLER( PART # 89547-0C010) IS NOT FUNCTIONING PROPERLY. IT PROVIDES BRAKING TO MY TRAILER ONLY BY USING THE MANUAL SLIDE. WHEN BRAKING, I FEEL NO BRAKING THE TRAILER.

PARKING BRAKE BEGAN TO FAIL AT HOLDING MY TUNDRA STATIONARY IN MY DRIVEWAY (WHICH IS APPROXIMATELY A 16% GRADE) AT 10,892 MILES. FIRST SERVICE COMPLAINT TOYOTA FOUND THE PARKING BRAKE TO BE OPERATIONAL BUT ADJUSTED IT. ON MY WAY HOME, THIS ADJUSTMENT CAUSED THE LEFT PARKING BRAKE SHOE TO HEAT UP AND STICK CAUSING A 'DEATH WOBBLE'. VEHICLE TOWED TO DEALER. TOYOTA OF NWA WAS ABLE TO REPLICATE THE FAILURE DURING A TEST DRIVE TO A ROAD OF EQUAL GRADE AS MY DRIVEWAY. PARKING BRAKE SHOES WERE REPLACED AND INSIDE OF ROTORS MACHINED. PARKING BRAKE OPERATED NORMALLY FOR ONLY A FEW WEEKS THEN BEGAN TO FAIL AGAIN. TOYOTA SENT A SPECIALIST TO EVALUATE THE FAILURE. AFTER SPENDING ONLY 2 HOURS INSPECTING AND TESTING ON A RAMP, DEALER STATED PARKING BRAKE OPERATING NORMALLY BUT ADJUSTED THE CABLE FROM 12-13 CLICKS TO 8-9 CLICKS. PARKING BRAKE BEGAN TO FAIL TWO DAYS LATER AND PARKING BRAKE PEDAL TRAVEL TAKES 15 CLICKS TO THE FLOOR AND MY TUNDRA STILL ROLLS WHEN IN NEUTRAL WITH THE PARKING BRAKE ENGAGED. METAL POPPING AND CLANKING SOUNDS COMING FROM REAR END AFTER PARKING BRAKE IS ENGAGED, TRANSMISSION IS SHIFTED INTO 'PARK' AND VEHICLE IS TURNED OFF. THE PARKING BRAKE FAILURE POSES A SAFETY RISK FOR SERIOUS INJURIES AND EVEN DEATH TO MY FAMILY AS MY HOUSE IS AT THE BOTTOM OF MY DRIVEWAY. DEMAND LETTER FOR REFUND SENT TO TOYOTA.

2015 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE FAILURE. *SMD THE CONSUMER STATED AS HE WAS APPROACHING A RED LIGHT, HE ATTEMPTED SO SLOW DOWN. CONSEQUENTLY, HE REAR ENDED THE VEHICLE IN FRONT OF HIM. THE CONSUMER ALSO STATED THE AIR BAG DID NOT DEPLOY. *JB