2011 BMW X3

I had my car towed into bmw dealership for a vanos recall repair,it went in for the repair the repair was "done" but before picking it up they told me they were unable to qc/start my engine to verify the repair claiming that because my camshaft position sensor was removed (it was removed to ultimately figure out it was the vanos system that failed)and that my car had no battery at the time of the repair they could and would not start my engine to verify the repair and that they turned it over by hand only,upon them releasing the car back to me I brought a battery and started my car and left the dealership within ten miles my engine failed and locked up due to oil starvation,I had it towed back immediately and explained what happened,and they refuse to take any responsibility for my car failing on the road while driving cause my engine to smoke and push the smoke into the cab mid traffic,this happened In July of 2025 and I am still going back and forth trying to get them to take responsibility and replace my engine,they did not follow proper procedures to ensure my vehicle was safe for pickup violating safety standards

The fuse box in trunk caught fire There are tons of these incidences if you search the web Bmw has done nothing I willhope your “ safety “ agency will. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2011 BMW X3 with an N55 engine and am experiencing VANOS-related issues consistent with TSB SIB 11 02 13 and Recall 23V-707. While my VIN isn’t currently listed, my vehicle falls within the affected model years, and I’m seeing identical DME fault codes (130E11, 120408) and drivability symptoms. I’m concerned about potential engine damage and request an inspection and consideration for goodwill repair or inclusion in the recall.

The contact owns a 2011 BMW X3. The contact stated that "Engine temperature" message was displayed on the instrument panel with the temperature gauge indicating that the engine was hot(H). Upon inspection of the vehicle, the contact discovered that steam on the radiator, and a coolant leak. The contact removed the cooling fan and shroud and discovered that the wiring from the electric water pump was burned and inoperable. Upon investigation, the contact discovered NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the year and model vehicle was not included in the recall. The dealer was notified of the failure and the contact was informed that the VIN nor the vehicle was included in the recall for the electrical connector. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 188,000.

In 2021, my car broke down due to the VANOS gear brackets; the bolts had snapped off. The only way I found out what was wrong was by taking the car to multiple places and paying for diagnostic services, but nobody could identify the issue. Eventually, I brought it to BMW, where they were the only ones who diagnosed the problem. However, they quoted me an exorbitant amount to fix it. I felt I had no choice but to take the car home and handle it myself. I discovered that three bolts were broken, and I suspect the other two had fallen into the oil pan. I managed to acquire both parts for the two VANOS gears and installed them myself since dealing with this issue. After reinstalling the gears, I encountered a problem with the valve cover; I wasn't sure if one of the broken bolts had hit the top of it, but I knew I needed to replace it as well. To get an update on the situation, I took my car to the first BMW dealership in Hartford. There were complications regarding the loaner car, a $200 deposit on my credit card, and coverage under my full insurance. I contacted BMW headquarters to file a complaint, and during that conversation, the BMW manager told me not to come back, to which I agreed. After filing the complaint and discussing the situation with BMW headquarters, I scheduled an appointment at the Waterbury location. When I took my car there yesterday, April 1, 2025, they refused to address the issue because they claimed they could not see the broken bolts. I explained that the bolts had already broken off and that I had previously brought the vehicle to BMW for a diagnosis, which confirmed that the problem involved the gear brackets and the bolts. I also mentioned that the broken bolts had damaged my valve cover, which I had to replace. However, all they did was inspect the car and dismissed the work I had done as if it were performed by them. My car hasn’t felt the same since, and I’ve been struggling with this ongoing issue. Damage that already a cured to my car

The contact owns a 2011 BMW X3. The contact stated that while his granddaughter was attempting to start the vehicle, there was smoke coming from under the driver’s side hood, and the vehicle failed to start. The vehicle was towed to the local mechanic who diagnosed that the PCV heater had overheated and burned along with the fuse box. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure and informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,744.

The contact owns a 2011 BMW X3. The contact stated while driving at an undisclosed speed, the contact discovered that an unknown substance was leaking from the vehicle. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was a coolant intrusion into the cylinder, and that the thermostat and several other unknown parts needed to be replaced. The contact was made aware of an unknown recall however, the VIN was not included. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The car had all of the symptoms of the vanos bolt recall. It started in October of 2023. I received an email notice for the said recall. I called BMW for 9 months, as I was without a car. That's not a timely manner to fix anything. I finally called last month and saw a remedy was available. After taking it in to the dealership, I came home and my car is now shaking violently at speeds above 40 mph. Another person stated this same thing happened to their car after the recall fix.

See attached document for complaint.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I have been stuck on the road twice due to the engine stalling and the car just does not accelerate. This last time I was stuck in between 2 lanes and could not get the car to start. I was in danger with my daughters. I was able to get the car towed to the dealer and they are saying it is not the recall but everything that happened was what the recall is for. I now have to pay the dealer for a diagnostic that clearly is what the recall is. They are giving me the run around every time I bring up the recall and this is clearly a safety issue.

The contact owns a 2011 BMX X3. The contact stated while driving at an undisclosed speed, the vehicle began to shake, with the "Drivetrain Malfunction," message displayed. The contact stated that the vehicle lost motive power and was unable to accelerate above 20 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed failures with the spark plugs and ignition coil. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling). The VIN was included, but parts were not yet available. The manufacturer was not notified of the failure. The failure mileage was 218,000.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the check engine light warning illuminated while driving at an undisclosed speed. The failure mileage was 75,000. VIN tool confirms parts not available.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

At this time nothing has happened yet. However, the recall notification clearly indicates the possible dangerous situations that can result. And, it seems to me that the idea behind a recall is to remedy the problem and avoid the possibility of a harmful event happening on the road. I have spoken with a BMW dealer and no one has suggested that the car should be inspected to see if there nis a problem or not.. Also, there have been no warning lamps or other symptoms or messages yet. Safety for myself and the vehicle is put at risk by the very fact that this recall has been issued as of October 20, 2023. I would very much like to avoid the possibility of any of the incidents happening that are listed in the "Additional Details" list below.

I purchased my vehicle less than three years ago for a large sum of money. It is a 2011 BMW X3 and shouldn’t have any engine problems especially at 130,000 miles. My engine is currently stalling and is a safety hazard to drive as it will stall while driving in high volume traffic. It has put me at risk for accidents and I have spent thousands trying to fix it. My mechanic found metal pieces that broke throughout the engine which he mentioned were the vanous bolts that hold the engine together. BMW has not issued a recall remedy and because of which, I currently have an undrivable vehicle that nobody will purchase. There are over 155,000 vehicles affected by this recall and BMW has not been helpful at all in prioritizing a solution as these are older vehicles and do not take “precedent” according to the BMW staff I have spoken with. Additionally they have not provided me with any sort of remedy in the interim stating that because it is an older car they cannot give me a loaner. They clearly do not treat all customers the same and prioritize remedies based on the newness of the car.

The contact owns a 2011 BMW X3. The contact received notification of NHTSA Campaign Number: 23V707000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while stopped at a traffic light, the light changed, and the contact depressed the accelerator pedal and heard an abnormal sound coming from under the floorboard and the vehicle stalled. The contact observed that the shifter had shifted independently into neutral (N) and a warning light flashed on the instrument panel but the vehicle lost electrical power and stalled. The contact attempted to restart the vehicle however, the vehicle was unable to be restarted. The contact had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the timing chain needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 139,000. VIN tool confirms parts not available.