Chevrolet · Aveo · 2005
1
Recall
235
Complaints
-
Not Rated
The 2005 Chevrolet Aveo has 1 recall and 235 owner-reported complaints on file with NHTSA. Most reported issue: engine and engine cooling (50 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2005 Chevrolet Aveo page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is engine and engine cooling with 50 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Remedy Status
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
The contact's daughter owns a 2005 Chevrolet Aveo. The contact stated that intermittently, the headlights failed to illuminate. The contact's daughter had received notification of NHTSA Campaign Number: 14V261000 (Exterior Lighting). The contact made a local dealer aware of the f...
Preview excerpt
The contact owns a 2005 Chevrolet Aveo. The contact stated while driving 45 MPH and making a stop, the vehicle inadvertently lost motive power. The contact was unable to restart the vehicle after several attempts. The contact was able to push the vehicle to the nearby gas station...
Preview excerpt
Timing belt/chain broke. Car is below the 60,000 mile mark for scheduled replacement as stated from manufacturer. Car broke down suddenly in the middle of the road creating a hazard to the driver and others.
NOTHING HAPPENED, BUT I SAW THAT THE CHEVROLET AVEO'S STATUS WAS DEEMED, "RECALL INCOMPLETE," AND I WANTED TO KNOW WHAT I SHOULD DO WITH THE CAR; IF THERE ARE ANY REPAIRS THAT NEED TO BE DONE OR IF REPAIRS CANNOT BE DONE. I DON'T HAVE ANY PHOTOS BECAUSE I DON'T UNDERSTAND IN DEPT...
Preview excerpt
TACADA RECALL I BOUGHT MY CAR HAD 121000 MILES ALL A SUDDEN I HAVE NO RIGHT TAIL LIGHT NO DASH LIGHTS AN NO PASSENGERS FRONT ORANGE LIGHT THER IS NO POWER GOING TO FUSE BOX UNDER HOOD I CALLED THE DEALERSHIP THEY STATED MY VIN HAD BEEN FIXED FOR THAT RECAL AND IT HAS NOT
GM MUST NOT KNOW THIS THIS HAS TO DO WITH THE ELECTRICAL WIRE HARNESS INSIDE OF THE ENGINE BLOCK FOR THE LIGHTS. FOR SOME REASON THE POWER IS OVER WRITING THE FUSES AND NOT BLOWING AND CAUSING SMALL ENGINE FIRES THAT COULD GET OUT OF CONTROL. I CAUGHT MINE IN ENOUGH TIME AND PUT...
Preview excerpt
MY DAUGHTER CAME TO A STOP IN TRAFFIC AT A RED LIGHT 50 FEET FROM THE CAR IN FRONT OF HER AND WAS HIT IN THE REAR TRAVELING AT ABOUT 40 MILES PER HOUR KNOCKING HER IN TO THE CAR IN FRONT OF HER THE AIR BAGS DID NOT DEPLOY AND GM'S INVESTIGATION SAYS SHE WASN'T HIT HARD ENOUGH...
Preview excerpt
I BOUGHT THIS CAR BRAND NEW AND KEPT UP THE MAINTENANCE RELIGIOUSLY! I WAS HORRIFIED TO FIND OUT THAT MY TIMING BELT WENT OUT AT 46,000 MILES! MY MANUAL SAYS TO REPLACE TIMING BELT AT 60,000 MILES. I'VE READ THERE WAS A RECALL ISSUED IN 2006, BUT IT DIDN'T GO TO OWNERS; JUST ...
Preview excerpt
INTERIOR DASH AND CONSOLE LIGHTS IN-OPERATIVE AS WELL AS THE RIGHT TAIL LIGHT. JESUS CHRIST, AFTER SEEING ALL OF THE PEOPLE COMPLAINING ABOUT THIS OUR BELOVED NO GOOD FOR NOTHING GOVERNMENTAL AGENCIES SHOULD MAKE GM RESPONSIBLE FOR THE COST OF REPAIR FOR THIS OBVIOUS MANUFACTURER...
Preview excerpt
TL* THE CONTACT OWNS A 2005 CHEVROLET AVEO. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING BELT, ENGINE, AND VALVES WERE MELTED. THE VEHICLE WAS N...
Preview excerpt
Showing 10 recent complaints from 235 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2005 Chevrolet models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2005 Chevrolet Aveo has 1 recall recorded by NHTSA.
NHTSA has received 235 owner-reported complaints for the 2005 Chevrolet Aveo.
NHTSA has not published a safety rating for the 2005 Chevrolet Aveo.
The most commonly reported complaint categories for the 2005 Chevrolet Aveo are engine and engine cooling (50 reports), electrical system (27 reports), electrical system,exterior lighting (24 reports).
Yes. NHTSA has 1 recall on record for the 2005 Chevrolet Aveo. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.