Chevrolet · Malibu · 2002
4
Recalls
582
Complaints
-
Not Rated
The 2002 Chevrolet Malibu has 4 recalls and 582 owner-reported complaints on file with NHTSA. Most reported issue: electrical system (202 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2002 Chevrolet Malibu page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is electrical system with 202 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Remedy Status
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Remedy Status
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Remedy Status
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME OF THESE VEHICLES WERE PRODUCED WITH A LEFT LOW-BEAM HEADLAMP THAT DOES NOT MEET THE PHOTOMETRIC PERFORMANCE REQUIREMENTS OF THE STANDARD.
Remedy Status
DEALERS WILL INSPECT THE LEFT LOW-BEAM HEADLAMP AND REPLACE IT IF IT DOES NOT MEET REQUIREMENTS. OWNER NOTIFICATION BEGAN MAY 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
The anti-theft/ passlock system fault in this generation of GM vehicles is very widespread and effects a large percentage of vehicles in this generation. I am sure there have been hundreds if not thousands of complaints about same issue and GM refuses to fix the problem. The prob...
Preview excerpt
THE TURN SIGNALS WORK SOMETIMES AND SOMETIMES THEY DON'T WORK. I RESEARCHED THIS ON THE INTERNET AND IT SEAMS TO BE A SERIOUS PROBLEM WITH THIS CAR MAKE. IF THERE ARE NO RECALLS ON THIS THERE SHOULD BE. THIS IS A MAJOR SAFETY HAZARD. I JUST BOUGHT THIS CAR FOR MY TEENAGE SON.
THE HYDRAULIC BRAKE LINES BETWEEN THE FRONT AND REAR OF THE CAR CORRODED AND QUICKLY LEAKED FLUID OUT SO THE BRAKES NO LONGER FUNCTIONED. THE FLUID LEAKED OUT WHEN THE CAR WAS PARKED AFTER DRIVING ON THE HIGHWAY THE NIGHT BEFORE. IF THIS HAPPENED WHEN I WAS DRIVING THE RESULTS C...
Preview excerpt
THE CHARACTERISTICS OF THE PROBLEM ARE AS FOLLOWS: THE ENGINE JUST DIES RANDOMLY. WHEN THE ENGINE DIES, I NOTED THE GAUGES ALL INDICATED THE KEY WAS IN THE OFF POSITION, EVEN THOUGH THE KEY HAD NOT BEEN TOUCHED. THEY BY TURNING THE KEY TO THE OFF POSITION AND WIGGLING IT ONLY AF...
Preview excerpt
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE HESITATED WHEN STARTED. ALSO, THE INSTRUMENT PANEL LIGHTING BECAME VERY DIM AND THE DATA ON THE SCREEN WAS NOT VISIBLE. ALSO, THE PASSENGER DOOR WOULD NOT LOCK AND THE WINDOWS FAILED TO ROLL DOWN. AL...
Preview excerpt
PASSLOCK CENSOR IN THE IGNITION LOCK CYLINDER FAILING. SECURITY RELEARN NEEDED. VEHICLE WAS STATIONARY.
CAR WOULD NOT START, HAD TO REPLACE ALTERNATOR. ONE WEEK LATER SAME PROBLEM, HAD A MECHANIC CHECK IT NOW SAYING ITS THE BATTERY SO REPLACED THAT. WAS STARTING OK THEN IT WOULDN'T START SO WE WIGGLED KEY AROUND AND IT STARTED. WAS ABLE TO DRIVE SEVERAL DAYS DOING THIS BUT THEN IT ...
Preview excerpt
TL* THE CONTACT OWNS A 2002 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE KEY FELT HOT WHILE IN THE IGNITION. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 92,000.
MY 2002 CHEVROLET CLASSIC HAS A DANGEROUS CONDITION WHERE THE TURN SIGNAL/HAZARD WARNING FLASHERS BECOME INOPERATIVE. THE CONDITION IS COMPLETELY RANDOM AND OCCURS INTERMITTENTLY. THIS HAS CREATED SURPRISE UNSAFE SITUATIONS WHEN MAKING LANE CHANGES AND LEFT AND RIGHT HAND TURNS. ...
Preview excerpt
MY CAR CUTS OFF AND GOES INTO THE ANTI-THEFT SYSTEM WHILE I'M GOING DOWN THE ROAD WHEN THIS HAPPENS MY CAR HAS TO BE PUSHED OFF THE ROADWAY AND THEN I HAVE TO SIT WITH MY DRIVER SIDE DOOR OPEN AND MY KEY TURNED ON FOR 10 MINUTES UNTIL IT RESETS ITSELF THIS IS VERY DANGEROUS AND...
Preview excerpt
Showing 10 recent complaints from 582 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2002 Chevrolet models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2002 Chevrolet Malibu has 4 recalls recorded by NHTSA.
NHTSA has received 582 owner-reported complaints for the 2002 Chevrolet Malibu.
NHTSA has not published a safety rating for the 2002 Chevrolet Malibu.
The most commonly reported complaint categories for the 2002 Chevrolet Malibu are electrical system (202 reports), exterior lighting (108 reports), engine and engine cooling (48 reports).
Yes. NHTSA has 4 recalls on record for the 2002 Chevrolet Malibu. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.