Ford · E-150 · 2005
4
Recalls
26
Complaints
-
Not Rated
The 2005 Ford E-150 has 4 recalls and 26 owner-reported complaints on file with NHTSA. Most reported issue: engine and engine cooling (4 reports).
Source: NHTSA Public Records · Updated May 4, 2026
The 2005 Ford E-150 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is engine and engine cooling with 4 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
FORD IS RECALLING CERTAIN REPLACEMENT FUEL TANKS THAT COULD BE INSTALLED INTO MODEL YEAR 2004 THROUGH 2008 E-150, E-250, AND E-350 VANS AND WAGONS. THE AFFECTED FUEL TANKS HAVE AN EXTRA OBDII SENSOR HOLE ON THE TOP OF THE TANK THAT MAY NOT BE PROPERLY SEALED AND MAY LEAK FUEL.
Remedy Status
FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL TANKS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 28, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-800-232-5952.
VAN CONVERSIONS IS RECALLING 74 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Remedy Status
VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
VAN CONVERSIONS IS RECALLING 52 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES," THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Remedy Status
VAN CONVERSIONS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR VAN CONVERSIONS AT 610-837-0707.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Remedy Status
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
After driving lightning, it loses power and a wrench appears, I already changed the gasoline pump, gasoline pump module, injection rail regulator, and it remains the same
I WAS CRUSHING AT 55 MPH AND I HEARD A LOUD POP THAT WAS FOLLOWED BY A CONTINUOUS POPPING OBVIOUSLY FROM LOST COMPRESSION. I TOOK TO A LOCAL FORD DEALER AND THEY STATED THAT THIS IS A COMMON PROBLEM FOR THIS TYPE OF MOTOR TO "BLOW SPARK PLUG". THIS HAPPENED WITHOUT WARNING AND IS...
Preview excerpt
THE CAR STEERING BOX SEEMS TO WANDER ALL OVER THE ROAD AND CAUSE ME TO GO INTO THE DITCH. COULD HAVE BEEN WORST.
I WAS PARKED AT A GAS STATION. I WAS ABOUT TO REVERSE AND MY AIRBAG EXPLODED FOR NO REASON. I FILLED A POLICE REPORT WITH WITNESSES. I CONTACTED MY LOCAL FORD DEALERSHIP ABOUT THE INCIDENT AND WAS INFORMED I WOULD HAVE TO PAY FOR THE DAMAGES. THEY STATED THEY HAVE SENT LETTERS TO...
Preview excerpt
2005 FORD E-150. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE PEDAL PROBLEMS. *SMD THE CONSUMER STATED THE BRAKE PEDAL WENT TO THE FLOOR NEARLY CAUSING AN ACCIDENT. THE CONSUMER WAS ADVISED TO CHECK THE BRAKE FLUID LEVELS. THE VEHICLE WAS REPAIRED.*JS
TL* THE CONTACT OWNS A 2005 FORD E-150. WHILE DRIVING AT APPROXIMATELY 20 MPH, THE VEHICLE STALLED AND LOST ALL STEERING AND BRAKING ABILITY. THE ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE HAND BRAKE WAS ENGAGED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS ...
Preview excerpt
DRIVING AT 35MPH, VEHICLE STARTED MAKING A BACKFIRING SOUND AND LOSING POWER. PULLED VEHICLE INTO A PARKING LOT AND HAD TOWED TO FORD DEALER. FORD SERVICE ADVISER SAID #3 SPARK PLUG BLEW OUT OF ENGINE. HE HAD SERVICE TECHNICIAN PULL OTHER PLUGS AND CHECKED GAP ON PLUGS TO FIND A...
Preview excerpt
TL* THE CONTACT OWNS A 2005 FORD E-150. THE CONTACT STATED THAT HE WAS ADVISED THAT THERE WAS A FUEL LINE LEAK IN THE HIGH PRESSURE HOSE WHILE ATTEMPTING TO HAVE A STATE INSPECTION COMPLETED. THE VEHICLE WAS REPAIRED ON SITE FOR THE HIGH PRESSURE HOSE. THE MANUFACTURER HAD NOT YE...
Preview excerpt
TOTAL FAILURE OF DIESEL ENGINE. APPARENT DEFECTIVE ENGINE DESIGN IN THE FORD/NAVISTAR 6L POWESTROKE ACROSS SEVERAL MODEL YEARS HAS BEEN REPORTED ON INTERNET. *JS
THE PAINT ON THE BACK OF THE VAN FROM THE TOP TO THE BUMPER IN AN APPROXIMATE 1 FOOT SWATH HAS PEELED OFF. A BODY SHOP GUY SAID THAT THEY DIDN'T PUT A THICK ENOUGH COAT ON OR THAT THE BASE WAS FAULTY. *TR
Showing 10 recent complaints from 26 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2005 Ford models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2005 Ford E-150 has 4 recalls recorded by NHTSA.
NHTSA has received 26 owner-reported complaints for the 2005 Ford E-150.
NHTSA has not published a safety rating for the 2005 Ford E-150.
The most commonly reported complaint categories for the 2005 Ford E-150 are engine and engine cooling (4 reports), fuel system, diesel (3 reports), electrical system,engine,fuel/propulsion system (2 reports).
Yes. NHTSA has 4 recalls on record for the 2005 Ford E-150. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.