Ford · E-450 · 1998
2
Recalls
5
Complaints
-
Not Rated
The 1998 Ford E-450 has 2 recalls and 5 owner-reported complaints on file with NHTSA. Most reported issue: tires (5 reports).
Source: NHTSA Public Records · Updated May 4, 2026
The 1998 Ford E-450 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is an older model year, the complaint history often reflects a longer ownership window and multiple maintenance stages. That makes pattern-reading more useful than a one-number comparison against a much newer vehicle. On this page, the most prominent complaint area is tires with 5 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Remedy Status
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Remedy Status
DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
I HAVE HAD TWO BLOWOUTS OF FIRESTONE STEELTEX TIRES, P235/75R16 ON A 1998 FORD ECONONLINE WITH A WINNEBAGO RV COACH MOUNTED ON THE CHASSIS. UNDER BOTH CIRCUMSTANCES, THE TIRES WERE PROPERLY INFLATED (AT 80 PSI PER THE MANUFACTURE INSTRUCTIONS), AND IN BOTH SITUATIONS THE PRESSUR...
Preview excerpt
THIS IS THE SECOND TIME WITH THESE TIRES THAT THE TREAD CAME COMPLETELY OFF. THE FIRST TIME IT WAS A REAR TIRE AND THERE WERE 15 PASSENGERS IN THE VEHICLE, THE DRIVER WAS ABLE TO CONTROL THE BUS BECAUSE OF THE DUAL WHEELS ON THE REAR BUT THE TIRE CAUSED DAMAGE TO THE SIDE OF THE ...
Preview excerpt
THIS WAS ON A AMBLUANCE WITH A PATIENT ON GOING TO A HOSIPTAL. *AK (DOT NUMBER: VDIL1XD347 TIRESIZE: LT225R75/1)
PE00 020; CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAY AND LEFT REAR TIRE TREAD SEPARATED. FIRESTONE STEET FLEX RADIAL RS#,LT225/75R16, #DOT VD111XL. THERE WERE NO INJURIES, AND HE HAS CONTACTED FIRESTONE. *AK
IN BOTH INCIDENTS, THE TIRES WERE INFLATED TO 80 PSI AS RECOMMENDED BY MANUFACTURER. TIRES WERE MOUNTED ON THE INSIDE REAR OF THE VEHICLE AND VEHICLE IS EQUIPPED WITH REAR DUAL TIRE CONFIGURATION. OUT SIDE TEMP WAS AROUND 85 DEGEES FAHRENHEIT IN BOTH INCIDENTS. TIRES WERE SENT...
Preview excerpt
Showing 5 recent complaints from 5 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 1998 Ford models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 1998 Ford E-450 has 2 recalls recorded by NHTSA.
NHTSA has received 5 owner-reported complaints for the 1998 Ford E-450.
NHTSA has not published a safety rating for the 1998 Ford E-450.
The most commonly reported complaint categories for the 1998 Ford E-450 are tires (5 reports).
Yes. NHTSA has 2 recalls on record for the 1998 Ford E-450. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.