Ford · E-450 · 2002
3
Recalls
13
Complaints
-
Not Rated
The 2002 Ford E-450 has 3 recalls and 13 owner-reported complaints on file with NHTSA. Most reported issue: tires (5 reports).
Source: NHTSA Public Records · Updated May 4, 2026
The 2002 Ford E-450 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is tires with 5 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Remedy Status
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Remedy Status
DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
Remedy Status
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.
The contact owns a 2002 Ford E-450. The contact stated that while driving 60 MPH, a loud bang came from the vehicle and the vehicle was steered over to the side of the road. Additionally, the contact stated that there was a burning odor coming from the engine compartment. The veh...
Preview excerpt
I WAS DRIVING DOWN INTERSTATE 90 IN SOUTH DAKOTA AT APPROX 70MPH WHEN A VEHICLE BEHIND ME FLASHED HIS LIGHTS. I PULLED OVER AND DRAGGING BEHIND ME BY ONLY ONE HYDRAULIC LINE WAS THE REAR LEVELING SYSTEM. THIS ASSEMBLY IS ABOUT 5 FEET LONG AND HAS TWO HYDRAULIC JACKS ONE ON EACH ...
Preview excerpt
I RECENTLY PURCHASED A MOTORHOME WITH THE FORD E-450, WHILE DRIVING OUT OF MY PARK I LOST MY TURN SIGNALS AND BRAKE LIGHTS. *TR
WE WERE TRAVELING NORTH TO SOUTH JUST OUTSIDE OF LASVEGAS WHEN A SPARK PLUG BLEW OUT OF THE CYLINDER, WITH THE INJECTOR STILL PUMPING FUEL. IN OUR 31' MOTORHOME WITH A E450 ENGINE. DID WE NOT REALIZE THE SERIOUSNESS OF THE SITUATION THE ENGINE COULD HAVE CAUGHT FIRE AND CAUSED EX...
Preview excerpt
SPARK PLUG EJECTED WHILE DRIVING ON INTERSTATE CAUSING EMERGENCY BREAKDOWN RESULTING IN 550.00 BILL FOR SPARK PLUG SLEEVE REPAIR THEN 50 MILES FROM THIS INCIDENT THE FAN BELT SHREDDED RESULTING IN ENGINE OVERHEATING AND ANOTHER EMERGENCY REPAIR OF 520.00 FOR NEW BELT AND ALTER...
Preview excerpt
COOPER SRM II LT 225/75/R 16 TREAD SEPARATION OF REAR TIRE ON RV APPROXIMATELY 20 MILES OF HOME WHILE DRIVING ON INTERSTATE. TWO MONTHS EARLIER HAD SIMILAR EXPERIENCE WITH ANOTHER REAR TIRE. TIRES WERE PURCHASED AS A SET OF SIX ON 04/08 WITH LESS THAN 10,000 MILES WHEN FAILURES ...
Preview excerpt
WHILE DRIVING THE AMBULANCE THE ENGINE SHUTS OFF. THE MOST RECENT INCIDENT HAPPENED WHILE TAKING IT TO THE SHOP. WHEN THE AMBULANCE IS AT IDLE IT JUST SHUTS OFF, WHILE DRIVING DOWN THE ROAD AND THE RPM'S ARE AT IDLE THE ENGINE WILL JUST SHUT OFF. NO CRASH OR INJURIES HOWEVER I...
Preview excerpt
IN EARLY JULY MY VEHICLE SUFFERED AN ELECTRICAL FIRE IN THE ENGINE COMPARTMENT. THIS IS A VEHICLE COVERED UNDER THE EXISTING FORD RECALL FOR THE SPEED CONTROL WIRING. THE DEALER , WHO HAD REPAIRED THE VEHICLE JUST 45 DAYS EARLIER, STATED THAT THIS FIRE WAS NOT ASSOCIATED WITH...
Preview excerpt
TIRE TREAD FAILED ON CONSUMER'S 2002 FORD E450 . *TS *NM
WHILE DRIVING THE INSIDE RIGHT REAR TIRE EXPLODED. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE. *NLM THE TIRE WAS REPLACED BY THE DEALER AT NO COST. *NM
Showing 10 recent complaints from 13 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2002 Ford models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2002 Ford E-450 has 3 recalls recorded by NHTSA.
NHTSA has received 13 owner-reported complaints for the 2002 Ford E-450.
NHTSA has not published a safety rating for the 2002 Ford E-450.
The most commonly reported complaint categories for the 2002 Ford E-450 are tires (5 reports), service brakes, hydraulic (1 reports), engine (1 reports).
Yes. NHTSA has 3 recalls on record for the 2002 Ford E-450. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.