Ford · F-350 · 2008
7
Recalls
232
Complaints
-
Not Rated
The 2008 Ford F-350 has 7 recalls and 232 owner-reported complaints on file with NHTSA. Most reported issue: steering (38 reports).
Source: NHTSA Public Records · Updated Apr 22, 2026
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.
Remedy Status
DEALERS WILL ADD A REINFORCEMENT TO THE DRIVER'S SEAT BACK FRAME ON THE 40% SPLIT OR CAPTAIN'S CHAIR SEAT EQUIPPED WITH LUMBAR SUPPORT OR, IF NECESSARY, THE SEAT BACK FRAME WILL BE REPLACED. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
FORD IS RECALLING 64,754 MY 2008 F-250 AND F-350 SINGLE REAR WHEEL, 4X4, 156 INCH WHEEL BASE PICK UP TRUCKS EQUIPPED WITH A TWO PIECE DRIVE SHAFT FOR FAILING TO CONFORM TO THE FUEL SPILLAGE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." DURING A 30 MPH FRONTAL IMPACT INTO A RIGID BARRIER, THE FUEL TANK CAN MOVE FORWARD AND CONTACT A FRAME CROSS MEMBER, POTENTIALLY CAUSING DAMAGE TO THE FUEL DELIVERY MODULE WHICH CAN RESULT IN FUEL SPILLAGE.
Remedy Status
DEALERS WILL INSTALL A BRACKET ON THE AFFECTED VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON MAY 23, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CONTINENTAL TIRE IS RECALLING CERTAIN CONTITRAC TR TIRES, SIZE LT275/70R18 125/122S OUTLINE WHITE LETTERS AND BLACK SIDEWALL, AND CONTITRAC, SIZE LT275/70R18 125/122S, BLACK SIDEWALL, PRODUCED FROM MAY 6, 2007, THROUGH SEPTEMBER 20, 2008, SOLD AS AFTERMARKET AND INSTALLED AS ORIGINAL EQUIPMENT ON SOME MODEL YEAR 2008 AND 2009 FORD F-250 AND F-350 TRUCKS. SOME OF THESE TIRES MAY EXPERIENCE UNEVEN WEAR, VIBRATION, OR PARTICULARLY UNDER CONDITIONS OF OVERLOADING OR UNDER INFLATION IN HIGH AMBIENT TEMPERATURE USAGE, SEPARATION BETWEEN THE BELT EDGES.
Remedy Status
CONTINENTAL TIRE WILL NOTIFY OWNERS AND REPLACE THE AFFECTED TIRES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 14, 2011. OWNERS MAY CONTACT CONTINENTAL CUSTOMER SERVICE TOLL-FREE AT 1-888-799-2168.
KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.
Remedy Status
KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
Remedy Status
DEALERS WILL INSPECT THE BATTERY B+ WIRE LOCATION AND, IF NECESSARY, REPOSITION THE WIRE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
Remedy Status
DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE DRIVER AIR BAG MODULE MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Remedy Status
DEALERS WILL REPLACE YOUR DRIVER AIR BAG MODULE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
I have had multiple incidents of my truck shutting off completely while driving. The latest incident resulted in a "catastrophic engine failure". In the latest incident occurring in April 2025, I was driving on [XXX] . [XXX] is a two-lane highway with no divider, navigating through mountainous terrain. I was driving up a hilly area when my truck shut off, and I lost all power steering. There is no shoulder on this part of the freeway, with an approximate 40-foot embankment. I was able to navigate the vehicle to the side of the road and position it just before the beginning of a guard rail beginning allowing me some grace. Due to no shoulder space, I was effectively parked on the white containment line of the road. I had my [XXX] daughter and wife in the car. I had to wait for a break in traffic to be able to open the driver's door due to the proximity to the active highway. I was safely get the truck towed to the nearest FORD dealership, where it was determined the engine was in "catastrophic failure" due to oil engine overfill. I informed FORD that my last oil change was with the FORD dealership and within the recommended time frame. I was informed by a technician that there is an ongoing issue with this engine make (6.4-liter, diesel). The technician stated that FORD is aware of the issue. The technician stated that fuel gets mixed with the oil and causes an "engine oil overfill". None of these issues stems from negligence but rather an unakknowledged issue by FORD. There was a check engine light that appeared at the time of failure. The check engine light had come on, at which point I contacted a mechanic to schedule an appointment. When I arrived for my appointment, the check engine light had disappeared, and I was told that no codes would alert if the actual check engine light was not on during the inspection. That same scenario occurred on approximately 3 occasions. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle died while driving on the freeway. Towed to the local Ford who did a diagnostic and test they found that the engine is completely done with as there was an engine oil overfill, and it filled the CAC system and melted cylinder eight piston. they’re saying that they will need to replace the entire engine and HP fuel pump in order to repair and I see many others have experienced this same problem.
Items inside bed caught on fire due to exhaust cleaning system getting so hot to burn off pollution in DPF pipe. Dangerous truck to drive contacted ford. No one contacted me. Other ford diesels caught on fire due to this. I’m retired military and don’t have money to buy 50k trucks. Only 80k on truck.
Death wobble. First experience was September 2019
The contact owns a 2008 Ford F-350. The contact stated that on several occasions while the accelerator pedal was depressed, the contact noticed a burning odor throughout the vehicle. The contact stated that the rear driver’s and passenger’s side wheels inadvertently locked without warning then released. No warning lights were illuminated. The vehicle was taken to the dealer where the brake pedal and plunger rod was replaced with a longer plunger rod; however, the failure recurred. The contact stated that while driving at an undisclosed speed, he depressed the brake pedal however, the vehicle failed to stop. The contact stated that he had to applied pressure to the brake pedal that was depressed down to the floorboard. As a result, the vehicle glided to a stop. No warning lights were illuminated. The vehicle was taken back to the dealer where it was diagnosed that brake pedal and the brake master cylinder needed to be replaced. The vehicle was repaired; however, the failure recurred after the vehicle was retrieved from the dealer. The contact stated that while the accelerator pedal was depressed, the front driver’s side wheel locked without warning and then released. The contact stated that he steered the vehicle off the roadway and was informed by another motorist that there was smoke underneath the vehicle. The contact stated that he was assist by Law Enforcement and advised to call the NHTSA Hotline. The vehicle was then taken back to the dealer where it was diagnosed that the brake caliper, front brake lock, brake pads, master cylinder and other undisclosed brake parts needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact was advised by the technician to take the vehicle to Bob’s 151 transmission Center where it was diagnosed that the ABS had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was too old, and no further assistance was provided. The contact stated that the call was disconnected. The failure mileage was approximately 70,000
Steering went out , wouldn’t return to center
Power steering pump replaced with new unit. Major steering issues. Will not turn at some points. Almost caused 3 accidents on 10/22/2021. Have had front end and power steering pump replaced.
Death wobble and learned about class action after I had front end repaired with complete overhaul ball joints etc in January 2018 ($2100 plus dollars) by my mechanic. May 16, 2021 experienced 3 incidents of death wobble in Oklahoma City enroute toTulsa, Oklahoma. See my mechanic on June 1, 2021.
ON INTERSTATE PASSING IN LEFT LANE HIT A ROUGH PATCH TRUCKS STARTS SHAKING SO BAD I THOUGHT IT WAS GOING TO FLIP. COULD NOT GET TO SHOULDER SO HAD TO GO IN THE MEDIAM IT WAS NOT A FLAT SPOT IT WAS A HILL SO I WENT STRAIGHT AND NOT AT AN ANGLE IF I HAD I WOULD OF FLIPPED. THIS IS NOT THE FIRST TIME. IFRIST TIME I HAD APPROX $3000.00 OF FRONT IN WORK DONE TRYING TO FIX THE PROBLEM, BUT IT DID NOT.
DEATH WOBBLE-ERRATIC DRIVING WHEN THIS HAPPENED IT WAS IN MOTION ON A HIGHWAY.
WE WERE HAULING A LOAD OF LOGS ABOUT AN HOUR AWAY EVERYTHING WAS FINE WHEN ALL OF THE SUDDEN THE TRUCK DOWN SHIFTED AND WHITE SMOKE STARTED POURING OUT FROM UNDER THE PASSENGER SIDE OF THE HOOD FOLLOWED BY FLAMES. WE HAD TO TRY TO GET OFF THE ROAD WHERE WE WERE THERE WAS NO WHERE TO PULL OFF AND FINALLY COULD SWING INTO A STATE GAMESLAND AND SOMEONE CALLED THE FIRE DEPT. I AM NOW OUT OF A TRUCK I JUST PURCHASED 2 MONTHS AGO AND MY VIN NUMBER ISN'T EVEN SHOWING UP
TL* THE CONTACT OWNS A 2019 FORD F-350 SD, EQUIPPED WITH MICHELIN TIRES, TIRE LINE: LTX MS/2, TIRE SIZE: 245/75/R17, DOT NUMBER: B74345 (PARTIAL). THE CONTACT STATED WHILE DRIVING 75 MPH, THE FRONT DRIVER'S SIDE TIRE WENT FLAT AND THE STEERING CEASED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND PULLED OVER TO THE SIDE OF THE ROADWAY. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE CONTACT STATED THAT IT WAS THE SECOND TIME THE FAILURE OCCURRED. THE FIRST TIME, THE FRONT PASSENGER SIDE TIRE WENT FLAT WHILE THE CONTACT WAS DRIVING AT AN UNDISCLOSED SPEED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THERE WAS NO RECALL AND THAT THE TIRE WAS OVER THE WARRANTY COVERAGE PERIOD. THE FAILURE MILEAGE WAS 54,000. THE VIN WAS UNAVAILABLE.
DRIVING THRU TOWN 25MPH OR LESS TURNING ONE CORNER FINE THEN ANOTHER CORNER THE OPPOSITE DIRECTION AND ONLY STEERING WHEEL TURNED.MY TRUCK WENT STRAIGHT INTO THE ROCK WALL DAMAGED HOOD FENDER,BUMPER,HEADLIGHT BEZEL AND LIGHTS DRIVER WHEEL, AND WHEN DIAGNOSED THE ORIGINAL PROBLEM IT WAS THE STEERING GEARBOX FAILURE
DEATH WOBBLE OCCURS AT HIGHWAY SPEEDS IF BUMPS OCCUR CONSECUTIVELY CLOSE TOGETHER,THE ONLY WAY TO STOP WOBBLE IF YOU ABRUPTLY STOP,IT'S WORSE IF YOUR ON A TRANSITION RAMP TO ON COMING TRAFFIC.
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING AND BRAKING SYSTEM WOULD SUDDENLY MALFUNCTION CAUSING THE DRIVER TO NEARLY LOOSE CONTROL OF THE VEHICLE. DURING THE FAILURES, THE STEERING WHEEL WOULD NOT TURN IN EITHER DIRECTION AND THE BRAKE PEDAL WAS DIFFICULT TO DEPRESS. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE LOCAL DEALER TAYLOR MOTOR COMPANY LOCATED AT 524 RUSS AVE, WAYNESVILLE, NC 28786 WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 211,000.
I HAVE A 2008 FORD F-350 THAT I EXPERIENCED A VIOLENT, SHUDDERING, VIBRATION AT APPROXIMATELY 75 M.P.H. ON INTERSTATE-75 YESTERDAY, 09/19/2020, THAT ALMOST CAUSED ME TO CRASH. I LOOKED ONLINE AND THERE ARE MANY, MANY PEOPLE WHO HAVE AND ARE EXPERIENCING THE SAME, DANGEROUS PROBLEM. I FIRMLY BELIEVE THAT THERE SHOULD BE A RECALL OF THE AFFECTED F-250 AND F-350 VEHICLES AND FORD SHOULD REPAIRS THESE VEHICLES BEFORE ANYONE IS INJURED OR KILLED, IF THERE HASN'T BEEN SUCH A TRAJEDY OR TRAGEDIES ALREADY.
TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE EXPERIENCED THE DEATH WOBBLE. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK VIOLENTLY TO THE LEFT AND TO THE RIGHT. THE CONTACT SLOWED DOWN TO REGAIN CONTROL OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED WHILE DRIVING OVER A BUMPY ROAD SURFACE. BEACH FORD (2717 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452; 757-486-2717) WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 207,000.
CRUSE CONTROL SWITCH ON THE BRAKE MASTER CYLINDER DISINTEGRATED, CAUSING IMMEDIATE LOSS OF BRAKE FLUID AND BRAKING. SWITCH BODY APPEARED RUSTY, WHILE THE SWITCH NEXT TO IT ON THE MASTER CYLINDER DID NOT. VEHICLE IN MOTION, DESCENDING DRIVEWAY WHEN BRAKE PEDAL WENT TO THE FLOOR AND ALL BRAKING ACTION WAS LOST. VEHICLE STOPPED VIA EMERGENCY BRAKE.
DRIVING DOWN THE ROAD AT 65 MPH, ON OPEN HIGHWAY GOING STRAIGHT, AND ON CRUISE CONTROL, MY SUN ROOF EXPLODED. IF I HAD NOT HAD THE SUN SHADE PULLED CLOSED, WE WOULD HAVE BEEN SHOWERED IN GLASS! I HAD A TRUCK CAMPER ON THE TRUCK AT THE TIME, HOWEVER, I'VE DRIVEN TENS OF THOUSANDS OF MILES WITH THIS CAMPER, SO IT SHOULDN'T BE THAT - AND THE GLASS OUGHT TO BE STRONG ENOUGH FOR THIS USAGE ANYWAY. THIS SHOULD NOT HAVE HAPPENED, AND THE TYPE OF GLASS THAT IS USED SHOULD NOT ALLOW GLASS TO SHATTER INTO FLYING PIECES LIKE THAT! THIS IS COSTING ME A BUNDLE OF MONEY TO REPAIR, BUT MORE IMPORTANTLY, HAD THE SUN SHADE NOT BEEN CLOSED, I COULD HAVE HAD AN ACCIDENT WITH 6+ TONS OF TRUCK AND CAMPER.
I WAS IN MY DRIVEWAY AND STEPPED ON THE BRAKE PEDAL TO PUT THE TRUCK IN REVERSE AND I HEARD A LOUD 'POP' WHICH FELT LIKE THE BRAKE PEDAL BROKE AND THEN IT SANK TO THE FLOOR, I POPPED THE HOOD AND SAW BRAKE FLUID DRIPPING FROM THE BOTTOM OF THE BRAKE MASTER CYLINDER. THIS PART---"SWITCH ASSY - FORD PART-SW6349 (9F924)" HAD BLOWN OUT THE PLASTIC CONNECTOR WHILE THE METAL CASING WAS STILL ATTACHED TO THE BOTTOM OF THE MASTER CYLINDER. THIS WILL LEAVE YOU WITH NO BRAKES. IF IT HAPPENED ON THE ROAD IN TRAFFIC IT COULD BE DEADLY.
Showing 1–20 of 25 complaints
The 2008 Ford F-350 has 7 recalls recorded by NHTSA.
NHTSA has received 232 owner-reported complaints for the 2008 Ford F-350.
NHTSA has not published a safety rating for the 2008 Ford F-350.
The most commonly reported complaint categories for the 2008 Ford F-350 are steering (38 reports), engine and engine cooling (38 reports), steering,suspension (16 reports).
Yes. NHTSA has 7 recalls on record for the 2008 Ford F-350. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.