Ford · F-450 · 2015
2
Recalls
6
Complaints
-
Not Rated
The 2015 Ford F-450 has 2 recalls and 6 owner-reported complaints on file with NHTSA. Most reported issue: engine (4 reports).
Source: NHTSA Public Records · Updated May 4, 2026
The 2015 Ford F-450 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is engine with 4 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
Ford Motor Company (Ford) is recalling certain 2015 F-250, F-350, F-450, Expedition, Lincoln Navigator, and MKC vehicles. The rearview camera printed circuit board terminal header connector may be loose or damaged, which can result in a blank or distorted image.
Remedy Status
Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed October 16, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S42. This recall expands previous recall number 22V-082.
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Remedy Status
VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
total engine failure
total engine failure
THIS VEHICLE IS SHUTTLE BUS, TRANSPORT PASSENGERS FROM CHICAGO O'HARE AIRPORT TO FOUR POINTS HOTELS AND BACK 24/7. THIS VEHICLE IS OWNED BY FOUR POINTS HOTEL AT SCHILLER PARK, IL AND I WORK AS DRIVER. ON OCTOBER 8 2017 JUST AFTER 7 PM I WAS DRIVING THE BUS WITH PASSENGERS ...
Preview excerpt
THE TRUCK SURGES/ENGINE REVS. FORD DOES NOT KNOW WHY ITS HAPPENING, MULTIPLE PARTS HAVE BEEN CHANGED. SEVERAL FORD ENGINEERS HAVE BEEN INVOLVED WITH NO RESOLUTION. THE TRUCK HAS BEEN AT THE DEALER FOR 7 MONTHS, PARKED FOR THE LAST 1 MONTH WITH NO ACTIVITY. I BELIEVE IT IS A SAFET...
Preview excerpt
WHILE DRIVING AT VARIOUS SPEEDS RECEIVE LOW FUEL PRESSURE / REDUCED ENGINE POWER WARNING. TRUCK ENTERS "LIMP HOME HOME" ALMOST IMMEDIATELY. REDUCED POWER AT HIGHWAY SPEED PUTS DRIVER/PASSENGERS IN HARM AS ONE CAN'T MAINTAIN SUFFICIENT SPEED TO SAFELY EXIT THE HIGHWAY. FORD WAS UN...
Preview excerpt
TL* THE CONTACT OWNS A 2015 FORD F-450. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNSURE ABOUT THE INFORMATION DISPLAYED ON THE MESSAGE BOARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MA...
Preview excerpt
Showing 6 recent complaints from 6 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2015 Ford models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2015 Ford F-450 has 2 recalls recorded by NHTSA.
NHTSA has received 6 owner-reported complaints for the 2015 Ford F-450.
NHTSA has not published a safety rating for the 2015 Ford F-450.
The most commonly reported complaint categories for the 2015 Ford F-450 are engine (4 reports), unknown or other (1 reports), wheels (1 reports).
Yes. NHTSA has 2 recalls on record for the 2015 Ford F-450. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.