2022 Hyundai Santa Fe

The fuel tank opener has become increasingly hard to operate. The fuel tank is supposed to unlock when the doors are unlocked. Sometimes it takes 10 or more times of unlocking the doors and checking the fuel door to successfully open the fuel door.

Vulnerable exposed radiator to road debris from the front and underneath my 2022 Santa Fe. It seems that this is an issue that is not covered by warranty and owners are held responsible with filing an insurance claim or pay out of pocket. Manufacturer needs to provide some type of protection for radiator or lose repeat customers.

1. Component/System: 2022 Hyundai Santa Fe 8-speed dual-clutch transmission (DCT), specifically the transmission oil pump or hydraulic pressure system. Inspection availability: The vehicle is currently at McGrath City Hyundai in Chicago and can be made available for inspection upon request. 2. The transmission exhibited slipping gears, delayed gear engagement, loud mechanical noise, and a transmission warning light. These conditions create the risk of sudden loss of drive power, unexpected stalling, or inability to control the vehicle, which could cause accidents, collisions, or injury to the driver, passengers, or others on the road. 3. A technician at McGrath City Hyundai initially informed us that the transmission oil pump had failed, which aligns with the symptoms. Later, another dealership representative claimed there was no issue, and the fluid was simply low. No written diagnostic confirmation or independent verification has been provided to date. 4. Hyundai corporate has been contacted and opened a case, but they refused to provide documentation or details of any inspection or repair, and did not assign a supervisor to provide clarification. No police, insurance, or third-party inspections have been performed. 5. Symptoms first appeared on March 9, 2026, including: Transmission warning light; Delayed gear engagement; Slipping gears; Loud mechanical noise from the transmission

1. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. 2.5-liter turbo engine use an 8-speed dual-clutch transmission (DCT). It has been in McGrath City Hyundai since March 10 for inspecton. 2. We were not harmed, but were very concerned about the safety of the car. 3. We only tried and waiting for this dealer for a ddiagnosis, but they verbally gave 2 conflicting diagnoses today. No written diagnosis report, no repair report. 4. This morning (9am), a staff informed us by phone that the vehicle has a failed transmission oil pump and that the dealership was waiting for approval for the replacement part. However, during a later call (1pm) today, another staff member stated that there is no issue for the transmission oil pump, and that the transmission fluid was simply lower than normal, with no leaks. We were told to pick up the vehicle today. We refused and waiting for them to email us a diagnosis report and a repair report. 5. The transmission warning symptoms first appeared on March 9, including a transmission warning light, delayed gear engagement, slipping gears, and loud mechanical noise. This conflicting information is extremely concerning, especially given the transmission symptoms described above. Hyundai issued Safety Recall #236 specifically for 2021–2022 Santa Fe vehicles due to the high-pressure electric oil pump in the 8-speed Dual-Clutch Transmission (DCT) potentially malfunctioning, causing a complete loss of drive power. And there is an active class action about it too.

The panoramic sunroof of a 2022 Hyundai Santa Fe Hybrid Limited spontaneously shattered while in transit on the highway. A resoundingly explosive “bang” preceded large shards of falling glass — leaving a massive hole in the sunroof’s front panel. The incident seemingly occurred without direct contact of any kind…no flying debris, no overpass roads, no inclement weather.

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving approximately 50 MPH, the glass panoramic sunroof suddenly exploded, causing glass shards to fall into the cabin of the vehicle. No injuries were reported. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that there was no impact on the panoramic sunroof glass to cause the failure. The vehicle was not yet repaired. Additionally, while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle only operated in LIMP Mode. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the fuel injector was inoperable and needed to be replaced. The fuel injectors were replaced, and the vehicle was repaired. The failure mileage was 55,000.

On my vehicle I’ve had to have the horn replaced at least three times. Paying about $500 for the last two instances. While there is no formal federal recall for the 2022 Hyundai Santa Fe horn specifically, it is affected by a widespread, known issue where water intrusion corrodes the horn's electrical contacts, leading to failure. Hyundai has addressed this with an extended warranty or service campaign in some regions to replace the horn. Saying this my vin # is not included in this but I can’t understand why.

The car was purchased new on June 30, 2021. On January 25, 2024 at 38,347 miles the horns failed to work and were replaced under warranty. About a week ago (c. January 24,2026) the horns again failed. The dealer was called and I was told that there was no recall on the horns and I would have to pay around $91 for the horns plus labor. The service manager told me that this is a common problem that has to do with where the horns are mounted on the vehicle. They are behind the front bumper and exposed to the elements. I feel that this is a serious design flaw and a safety issue that should be addressed by the manufacturer. There should be a recall instead of customers buying new horns every two years. Had the horns failure occurred during an emergency situation it could have resulted in an accident and possible loss of life.

Took my 22 Sante fe to the Hyundai dealership to have the blower motor checked since I have no air flow in my car. Dealership informed me that the engine harness needs replaced and that it melted the fuse box under the hood. So, I am not able to replace my blower motor at this time due to the melted fuse box. Dealership also advised that they have seen the same problem in multiple 22 Sante Fe. and that there is likely more with the same issue within the United States. I have been noticing a melting/hot smell in the car before the airflow quit and I took it to the dealership to be diagnosed.

The air bags sensor is on which means none of the air bags will deploy if I am in an accident. The dealership stated it is not covered by the warranty. The sensors were not tampered with but the sensor is not working

My Windshield is the problem. My granddaughter drives with me often and afraid the glass will shatter. Yes, the corporate office for Hyundai. No, this was done while driving, all occasions.

Engine control harness with under fuse box due to melted fuse box. This caused my blower motor and relay to go bad. No air flow currently in car due to control harness. Dealership stated that there has been several Sante Fe that has came in this year with the same issue.

I HAVE HAD THE HORN IN MY 2022 SANTA FE REPLACED 3 TIMES OVER THE COURSE OF 3 YEARS, and now it doesn't work again. I realized the newest horn is not working when a truck almost backed into me yesterday and I had no way to warn them to stop backing up.

THE CARS HORN HAS BEEN REPLACED 3 TIMES IN THE LAST 3 YEARS AND IT STOPPED WORKING AGAIN.THE HORN LAST ABOUT 1 YEAR, THIS IS 2022 SANTA FE,

The fuel injectors have repeatedly failed. I am on my third replacement

The vehicle has activated it emergency breaking feature several times now on the last couple of months witouth any reason to do so. Presenting a major risk for the occupants and to other vehicles on the roads.

I purchased my 2022 Hyundai Santa Fe Hybrid brand new and in three years, both horns (high and low) have stopped working every year. I have had the horns replaced in March 2023, January 2024 and as I type this complaint, both horns are out again. It is a serious safety issue driving a vehicle without a horn. There is no warning that the horn is going to stop working; and I have discovered the malfunction while driving when I needed to alert another driver before we potentially collided. It has also been extremely inconvenient for me to take off work to take the car in for more service. What's more frustrating is I was told by a service manager that they (Hyundai USA) are aware of the defect with these particular horns but has chosen to continue to replace the defective horns with more defective horns. Now I drive an unsafe vehicle until I can take off work again to have my horns replaced with parts that will last for one year, if I'm lucky. I am asking for some assistance with this matter since it is clear that Hyundai USA has not made it a priority to solve this ongoing safety problem for all its customers who are having the same issue. Thank you.

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving approximately 20 MPH, the vehicle failed to properly accelerate, as if the transmission was stuck in high gear. The vehicle was taken to an independent mechanic, where it was diagnosed with transmission failure. The contact believed that the failure was associated with Manufacturer Recall: 236. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 98,300.

In November 2025, my 2022 Hyundai Santa Fe began to hesitate when accelerating and would almost "jerk" when I pressed the gas pedal. Soon after my check engine light came on and I made an appt to take it for the closest Hyundai dealership (as it's still under warranty 33k miles) Upon running a check the dealership notified me that Fuel Injector 1 has misfired and will be replaced. I receive my vehicle back and not even 100 miles later my check engine light in on again and the same issues are arising. Back to the dealership to see now Fuel Injector 3 has misfired and there is an open TSB showing all 4 Fuel Injectors need replaced. My vehicle was finally returned to me in January 2026. It is now February 16, 2026 and my check engine light in on YET AGAIN. I've been given the run around from Hyundai Corp about fixing this vehicle. Why is this acceptable treatment when a vehicle is under warranty ?

Vehicle experienced a spontaneous interior fire while parked and turned off. No collision, no injuries. Fire originated under the driver-side lower dash/kick panel near the fuse/BCM wiring, then spread into the driver door harness/trim. Exterior body and engine bay show no impact or external origin. Details: Heavy charring/melt concentrated at lower dash/junction area with upward/sideways spread along wiring paths; interior plastics, dash switches, and door wiring damaged. Vehicle was unoccupied. Aftermarket: No hardwired accessories in the origin zone. A dashcam was powered via center console USB/12V with a small battery pack (not connected to the under-dash fuse block). Status: Towed to [Dealer, City/State]; Hyundai Corporate Case #XXX opened. Insurance comprehensive fire claim opened; origin-and-cause inspection pending. Request: NHTSA investigation into potential electrical/wiring defect in driver lower dash/door-harness area on this model/year; safety risk of parked, unattended fires. Photos/videos available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)