NHTSA Investigation
EA10001
Inadvertent airbag deployment
Key Takeaways
- Investigation EA10001 currently maps to 3 tracked vehicle-year pages across 1 make.
- This page summarizes the public investigation subject, status, timing, and affected tracked vehicles linked from NHTSA source data.
- The linked component on this record is air bags.
- This investigation record also references recall campaign 11V107000.
What This Investigation Page Shows
This page summarizes a public NHTSA investigation record tied to one or more tracked vehicle-year pages in our database. Investigation records sit between owner complaints and recall campaigns: they can remain open, close without a recall, or connect to a later remedy action. Use this page to see which tracked vehicles are linked to the record, then open the individual vehicle pages for complaints, recalls, and crash test context.
Investigation Summary
ODI opened this investigation based on reports of inadvertent airbag deployment.Data provided by Ford indicated that the airbag clockspring jumper wire, which is situated inside the steering wheel assembly, was installed in a manner that would allow it to rub (abrade) against a sharp metal edge on the nearby horn plate.Because the horn plate is electrically grounded the abrasion of an airbag wire on the sharp edge could cause a short circuit condition.As a result the airbag light may illuminate and/or the airbag may inadvertently deploy.Inadvertent deployments are most likely to occur during the airbag system's self-diagnostic test that initiates when the ignition switch is turned on.Ford modified the vehicle design in late January 2006 adding a protective tape over the sharp metal edge of the horn plate.Ford made additional design changes on MY 2007 vehicles to the horn plate, the clockspring jumper, and the connector layouts to further address this issue.ODI identified 318 deployment incidents with 121 alleged injury reports from subject vehicles.All but one of the incident and injury reports occurred in vehicles built before the January 2006 modification.In addition, there was one incident and alleged injury reported in the MY 2006 Mark LT vehicles that share the same design. In letters dated February 21 and April 11, 2011, Ford announced a recall of all of the approximately 1.3 million MY 2004-2006 F-150 vehicles built prior to January 24, 2006, the date the initial vehicle modification was made.In addition, approximately 14,000 MY 2006 Mark LT vehicles built prior to January 24, 2006 will also be recalled.Vehicles built after that date, which contain the modification, are not within the recall scope.Accordingly the investigation is closed.
Manufacturer listed on the source record: Ford Motor Company
Component listed on the source record: AIR BAGS
Affected Vehicles (3)
Browse Affected Vehicles
Affected Models
All data is sourced from NHTSA public records. This site is not affiliated with, endorsed by, or operated by the National Highway Traffic Safety Administration or any government agency. Complaints are unverified consumer reports submitted to NHTSA and may not reflect confirmed defects. For official information, visit nhtsa.gov.
Data synced from NHTSA on May 4, 2026