Kia · Sedona · 2003
4
Recalls
197
Complaints
-
Not Rated
The 2003 Kia Sedona has 4 recalls and 197 owner-reported complaints on file with NHTSA. Most reported issue: electrical system (26 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2003 Kia Sedona page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is electrical system with 26 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
ON CERTAIN MINI VANS, FREEZING CONDITIONS CAN CAUSE WATER ON THE THROTTLE CABLE TO FREEZE DURING NORMAL OPERATION. RESISTANCE TO MOVEMENT OF THE THROTTLE CABLE CAN OCCUR WHEN THE DRIVER LIFTS THEIR FOOT OFF OF THE GAS PEDAL.
Remedy Status
DEALERS WILL MODIFY A PROTECTIVE SLEEVE AROUND THE THROTTLE CABLE. THE RECALL BEGAN ON AUGUST 15, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS EQUIPPED WITH ALLOY WHEELS, MOISTURE CAN ACCUMULATE AROUND THE REAR HUB CAPS CAUSING DAMAGE TO THE OUTER WHEEL BEARING.
Remedy Status
DEALERS WILL REPLACE THE REAR HUB CAPS FREE OF CHARGE. UPON INSPECTION, SOME VEHICLES WILL ALSO REQUIRE REPLACEMENT OF THE REAR OUTER BEARINGS AND/OR HUB ASSEMBLY. THE RECALL BEGAN ON JUNE 13, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN MINI VANS, DURING ASSEMBLY, THE THROTTLE CABLE WOULD TWIST ITSELF OUT OF POSITION.
Remedy Status
DEALERS WILL REPLACE THE THROTTLE CABLE FREE OF CHARGE. VEHICLES PRODUCED FROM MARCH 20, 2001 THROUGH NOVEMBER 7, 2001 WILL HAVE A GUIDE CLIP INSTALLED ON THE THROTTLE BODY ASSEMBLY IN ORDER TO ENSURE THAT THE TENSION FORCE CABLE DOES NOT MOVE OUT OF POSITION. VEHICLES MANUFACTURED BEGINNING ON NOVEMBER 8, 2001, ALREADY HAVE THE EXTENDED GUIDE, WHICH ACCOMPLISHES THE SAME OBJECTIVE. THE RECALL BEGAN MARCH 21, 2005. OWNERS MAY CONTACT KIA AT 1-800-333-4542.
ON CERTAIN PASSENGER VEHICLES, THERE WAS A PROGRAMMING ERROR IN THE ANTI-LOCK BRAKING SYSTEM (ABS) ELECTRONIC CONTROL MODULE LOGIC. THE PROGRAMMING ERROR COULD CAUSE REDUCED BRAKING FORCE AT SPEEDS BELOW 25 MPH, WHICH COULD RESULT IN INCREASED STOPPING DISTANCES.
Remedy Status
DEALERS WILL REPROGRAM THE CONTROL MODULE. OWNER NOTIFICATION BEGAN MAY 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
My Sedona keeps catching on fire not sure why but now if I get it up to temperature it automatically catches on fire I'm going into my second fire extinguishe
The contact owns a 2003 Kia Sedona. The contact stated while driving 40 MPH, the steering wheel became difficult to steer. The contact pulled over and left the vehicle. The contact returned 2 days later and drove the vehicle home. The contact stated that the check engine, brakes ...
Preview excerpt
TL* THE CONTACT OWNED A 2003 KIA SEDONA. THE CONTACT STATED WHILE DRIVING AT 25 MPH THE VEHICLE HESITATED AND FAILED TO SHIFT INTO THE DESIRED GEAR WITH SMOKE COMING FROM UNDER THE HOOD. THE CONTACT MANAGED TO DRIVE THE VEHICLE HOME, PARKED THE VEHICLE, AND UPON OPENING THE HOOD ...
Preview excerpt
TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND SHUT OFF THE FRONT PASSENGER SIDE SEAT HAD EXPERIENCED A FIRE AND MELTED. THE CONTACT DISCOVERED SMOKE AND SOOT PRESENT INSIDE THE VEHICLE AND A BURN HOLE IN THE PASSENGER SEAT. NO PO...
Preview excerpt
THE BREAKS WERE CHANGED DUE TO GRINDING COM TO FIND OUT THERE WAS 1BOLT ON THE BREAK CALIBERS PUT THEM ON AND IT STILL GRINDS AND CAN NOT STOP
TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 35 MPH, THE BRAKE PEDAL SEIZED HALFWAY DOWN WHEN IT WAS DEPRESSED. AS A RESULT, THE CONTACT SWERVED ONTO THE SIDEWALK AND STOPPED 30 YARDS IN A PARKING LOT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT T...
Preview excerpt
ON FEB. 25, 2018, WE PURCHASED A 2003 KIA SEDONA VAN FROM CITY START AUTO SALES IN PARADISE, CA. ALL FOUR TIRES AND THE SPARE WERE GOODYEAR INTEGRITY 215/70R15. THE TIRES READ MAX. PSI 44, BUT THE VAN SAID TO RUN AT 35 PSI. SO, ONCE A WEEK ON A COOL MORNING (BETWEEN 68-75 DEGREES...
Preview excerpt
THERE BEEN WHINING NOISE DURING ACCELERATING AND DE-ACCELERATE SPEED, I HAD SOMEONE LOOK AND THOUGHT I WAS BRAKING SYSTEM. YESTERDAY MY SON WAS DRIVING IT AND TURNING RIGHT AND WE HEARD A POP, AND THE WHOLE STEERING WENT OUT. WE WERE ALMOST KILLED ON 134, HE ABLE BACK IT UP. HAD ...
Preview excerpt
TL* THE CONTACT OWNS A 2003 KIA SEDONA. WHILE DRIVING 2 MPH, THE PASSENGER SIDE AIR BAG DEPLOYED WITHOUT WARNING OR IMPACT. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THERE WAS NO CRASH OR FIRE. THE DRIVER SUSTAINED CUTS ON THE FACE AND ARMS. ...
Preview excerpt
TL* THE CONTACT OWNS A 2003 KIA SEDONA. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED WHEN IT WAS WET. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
Showing 10 recent complaints from 197 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2003 Kia models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2003 Kia Sedona has 4 recalls recorded by NHTSA.
NHTSA has received 197 owner-reported complaints for the 2003 Kia Sedona.
NHTSA has not published a safety rating for the 2003 Kia Sedona.
The most commonly reported complaint categories for the 2003 Kia Sedona are electrical system (26 reports), air bags (22 reports), engine and engine cooling (17 reports).
Yes. NHTSA has 4 recalls on record for the 2003 Kia Sedona. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.