2010 Toyota Tundra Body & Structure Problems

Rusting frame on the vehicle leading to potential cracks and creating safety concerns. Truck has low miles and been well maintained.This is my second Toyota truck with a rusted frame. No help or support from Toyota on my concerns with the 2010 Tundra.

The contact owns a 2010 Toyota Tundra. The contact stated while the vehicle was in for inspection, the mechanic discovered corrosion present on the subframe of the vehicle. The contact stated that along with corrosion, the subframe was cracked and had several holes. The cause of the damage was not yet determined. The manufacturer and local dealer were notified of the failures, but no assistance was provided. The contact was informed that the vehicle was not eligible for the manufacturer's Extended Warranty coverage for the failure. The failure mileage was 82,000.

My 2010 Toyota Tundra is like new and only has 56,000 miles on it. I ordered new tires and when I brought it to have the tires installed I was told me the frame was rusted through and they couldn’t lift it off the ground. They were concerned with me driving it and suggested that I bring it to my Toyota dealership and see what they could do. The dealership said there was nothing they could do because there was no recall on my vehicle. I asked if they could look at it to see it was safe to drive, and was told there would be a $167 to just look a my vehicle. I called Toyota Customer Service (800-331-4331) to complain and opened case# 23122000824. I called a frame shop to make an appointment to have it looked at and was told that they get lots of Tundra’s in with rotted frames. Apparently Toyota is ignoring this problem. They had an issue with rusted frames on the Toyota Tacoma and they issued a recall.

The contact owns a 2010 Toyota Tundra. The contact stated while driving at an undisclosed speed, the contact stated that when she arrived at her destination her husband noticed something hanging from underneath the vehicle. The vehicle was taken to the dealer. The vehicle was diagnosed with a rusted rear fuel tank strap. The contact was informed that the fuel tank strap needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 187,000.

Rusted frame failed PA state inspection. This has been a well maintained vehicle and should not be experiencing that much corrosion.

The contact owns a 2010 Toyota Tundra. The contact stated that while the vehicle was at an independent mechanic for an inspection, the mechanic informed her that the subframe was severely corroded and unable to haul the weight of a camper. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 74,300.

The chassis on my 2010 Tundra is badly rusted. The rust is also evident in the bed of the truck. I was informed of the rust during my quarterly servicing of the vehicle. I was recently informed the rust has gotten really bad.

The frame of my truck has developed an unsafe amount of rust.

I BOUGHT THIS TRUCK NEW. IT HAS 70,000 MILES. THE BED AND BUMPERS HAVE EXTENSIVE RUST HOLES, COMPLETELY THROUGH. LAST YEAR, THE GAS TANK FELL OUT WHILE DRIVING DUE TO RUSTED THROUGH FUEL TANK STRAPS. NOW, THE REAR AXLE HAS STARTED LEAKING DUE TO A RUSTED OUT REAR AXLE HOUSING.I AM A 64 YR OLD VET AND AFRAID TO DRIVE THE TRUCK. IF I FILL UP THE REAR AXLE IT WILL GET ON THE ROAD AND TIRES I HAVE CALLED AND EMAILED TOYOTA AND THEY TOLD ME TO FIX IT AT MY EXPENSE.

FRAME CHANNEL EXCESSIVE RUSTING ONLY AFFECTING THE FRAME. *TR

7 YEAR OLD TRUCK WITH UNDER 20K MILES HAS MAJOR RUST IN THE BED. I HAVE NOT EVEN HAD ANYONE LOOK AT IT YET BUT THE SURFACE RUST ON THE DRIVERS SIDE NEAR REAR OF BED APPEARS RUSTED DOWN TO FRAME OR UP FROM FRAME. IT IS ABOUT A 3X3 INCH AREA. SAME SPOT ON PASSENGER SIDE HAS EARLY STAGES OF THE SAME RUST OCCURRING. I HAD A TOYOTA PROVIDED BED LINER IN THE BED.

I HAVE A 2010 CREWMAX WITH 79K MILES. DURING A RECENT VISIT TO A LOCAL BODY SHOP THEY NOTICED THAT THE BED OF THE TRUCK WAS RUSTING IN FOUR SEPARATE PLACES WHERE THE CROSS MEMBERS ATTACH TO THE FRAME. A TSB WAS ISSUED, OBVIOUSLY A KNOWN ISSUE FROM TOYOTA, BUT I NEVER RECEIVED VIA MAIL. THE TRUCK WAS SERVICED AT LOCAL DEALERSHIP BUT THIS ISSUE WAS NEVER CHECKED. IT HAS A FACTORY INSTALLED TOYOTA BEDLINER. WHEN PURCHASED, I HAD THE UNDERCOATING APPLIED WITH THE EXPECTATION THAT THIS WOULD PREVENT THE RUSTING. HOWEVER, SINCE THE RUST BEGINS FROM THE BOTTOM IT IS NOT EASILY IDENTIFIED. I HAVE SPOKEN WITH BOTH THE DEALERSHIP AND MADE A PHONE CALL TO TOYOTA CORP TO NO AVAIL. THE DEALERSHIP CLAIMS NO RESPONSIBILITY AND CORPORATE IS STANDING FIRM ON THE 5 YEAR WARRANTY. VERY DISHEARTENING TO SPEND THAT AMOUNT OF MONEY ON A TRUCK THAT HAS A KNOWN ISSUE AND THE COMPANY WILL NOT BACK IT UP. I AM FOND OF THE VEHICLE BUT IF IT IS REMEDIED I WILL NOT RECOMMEND NOR PURCHASE ANOTHER TOYOTA FOR MYSELF OR MY FAMILY.

RUST IN TRUCK BED COMING FROM BOLTS THAT CONNECT BED TO FRAME. HUGE AMOUNTS OF RUST. BED CONNECTION POINTS FAILING BECAUSE OF RUST. TOYOTA HAS ISSUED A SERVICE BULLETIN ABOUT THE ISSUE THE BOLTS ARE CAUSING THE RUST BUT DID NOTHING ABOUT IT WHILE VEHICLE WAS UNDER WARRANTY. THE TRUCK CAME WITH A TOYOTA DROP IN BED LINER SO I WAS NEVER AWARE OF THE ISSUE UNTIL I LOOKED UNDER THE BED LINER RECENTLY. THE RUST HAS BEEN AN ISSUE FOR A LONG TIME BECAUSE OF THE AMOUNT OF RUST PRESENT.I CONTACTED TOYOTA AND THE REFUSE TO FIX THE ISSUE.

MY TRUCK'S BED HAS RUSTED COMPLETELY THROUGH IN ONE SPOT. TOYOTA HAS ISSUED A TSB FOR THIS (TSB-0101-12) BUT REFUSES TO COMPLY. THEY CLAIM THAT MY TRUCK'S VIN DOES NOT FOLLOW IN THE RECOGNIZED RANGE AND THAT THE RUST WARRANTY HAS EXPIRED. THIS WAS DISCOVERED WHEN THE TRUCK WAS 6.5 YEARS OLD. IT TOOK SO LONG BECAUSE THERE IS A SPRAY-IN BEDLINER THAT COVERED THE DAMAGE. THIS OCCURS FROM UNDERNEATH THE TRUCK AND PERFORATES COMPLETELY THROUGH. TOYOTA'S SOLUTION IS TO DEAL WITH IT. MY CLAIM WAS DENIED AND IN THEIR OWN WORDS: 'THE DECISION HAS BEEN REVIEWED AND WILL NOT CHANGE.' SO MUCH FOR EVER BUYING ANOTHER TOYOTA AGAIN.

I BOUGHT A 2010 TOYOTA TUNDRA NEW. I RECENTLY NOTICED SIGNIFICANT RUST IN THE BED OF MY TRUCK. AFTER SOME RESEARCH I DISCOVERED THAT THE RUST IS ALSO IN THE FRAME OF MY TRUCK. I HAVE FOUND THAT THERE ARE MULTIPLE CASES OF TOYOTA TRUCKS WITH THIS SAME ISSUE. THERE HAVE BEEN RECALLS AND CLASS ACTION LAWSUITS FILED AGAINST TOYOTA FOR THIS SAME PROBLEM. HOWEVER MY MODEL AND YEAR ARE NOT INCLUDED IN THESE. I TOOK THE TRUCK TO TOYOTA AND THEY SAID YES THIS IS A PROBLEM WE KNOW ABOUT HOWEVER YOURE OUT OF THE 5 YEAR WARRANTY PERIOD AND WE WILL NOT COVER THE DAMAGE. THE PROBLEM WITH THE WARRANTY PERIOD IS THAT THE START OF THE ISSUE IS COMPLETELY HIDDEN AND THERE'S NO WAY TO KNOW YOU HAVE A PROBLEM UNTIL IT'S TOO LATE AND YOU'RE OUT OF WARRANTY. THE FRAME OF MY TRUCK IS QUITE RUSTED AND WILL CAUSE SAFETY ISSUES IN THE NEAR FUTURE. THERE ARE TWO DISTINCT RUST SPOTS IN THE BED WHERE THE FRAME ATTACHES TO IT. THE ONE SPOT WHICH IS WORSE ACTUALLY HAS A HOLE IN THE METAL BOTTOM OF THE BED. I CAN'T GET PICTURES OF THE FRAME OF THE TRUCK BUT I DID INCLUDE PICTURES OF THE TWO RUST SPOTS IN THE BOTTOM OF THE BED. THE TWO SPOTS ARE LOCATED TOWARD THE CAB AND ARE IN THE SAME SPOT OF THE BED BUT ON OPPOSITE SIDES. I LIVE IN A VERY DRY CLIMATE SO FLOODING AND HUMIDITY ARE NOT THE CAUSE OF THIS RUST. YOU CAN TELL FROM THE LOCATION OF THE SPOTS THAT THIS IS A MANUFACTURER DEFECT.

FRAME IS RUSTING. REAR BUMPER HAS HOLES THROUGH IT. TRUCK ONLY HAS 50,000 MILES ON IT.

THE TRUCK TAILGATE WAS NOTICED TO HAVE PAINT BUBBLING TOWARD THE BOTTOM ON THE TAILGATE. FURTHER INSPECTION SHOWS MODERATE RUST ON THE INNER LIP OF THE BOTTOM OF THE TAILGATE WHERE TWO PANELS COME TOGETHER, AND IS NOTICABLE WHEN IT IS IN A LOWERED POSITION. AFTER CALLING TOYOTA CORPORATE NATIONAL CUSTOMER SERVICE LINE AND NOTIFYING THEM OF THE ISSUE, I WAS ASKED IF RUST WAS ON THE FRAME. FURTHER MORE, I WAS TOLD THERE IS NO PROGRAM THEY HAVE TO HELP WITH SUCH AN ISSUE. I HAD NOT HAD THE ABILITY TO INSPECT THE FRAME AND UNDERCARRIAGE AT THE TIME OF THE CALL, BUT UPON ENDING OF THE CALL, WAS ABLE TO HAVE A LOOK AT IT. THERE IS CONSIDERABLE RUST ON SEEMS OF THE FRAME WELDS THROUGHOUT THE BOTTOM AND OTHER AREAS.

THE TRUCK BED HAS RUST COMING FROM UNDERNEATH

DRIVING ON THE EAST 118 GOING ON THE 3RD LANE JUST BEFORE DESOTO AVE. THE TRUCK STARTS TO BOUNCE VIOLENTLY. I WAS TRAVELING AT ABOUT 65 MPH AND MOVED TO THE NUMBER 4 LANE, SAME THING--BED BOUNCE WAS VIOLENT FOR ABOUT 2 MILES. THIS IS VERY DANGEROUS BECAUSE IT FELT LIKE I HAD VERY LIMITED CONTROL OF THE TRUCK WHILE BOUNCING. I HAVEN'T HAD A CHANCE TO LOOK AT THE BED OR THE BACK OF THE CAB TO SEE IF EITHER WAS AFFECTED. THIS IS NOT HOW A NORMAL VEHICLE SHOULD OPERATE. *TR

I JUST PURCHASED A 2010 TUNDRA TWO WEEKS AGO. WHILE ON HIGHWAY THIS TRUCK SHAKES UNCONTROLLABLY. IT FEELS LIKE IT IS BENDING IN THE MIDDLE BETWEEN A CABIN AND A BED. WHILE DRIVING EVERYONE IN THE TRUCK KEEPS BOUNCING OFF THE SEAT AT TIMES. IF THIS WAS DISCLOSED AS "NORMAL" AS DEALER SAYS I WOULD HAVE NEVER BOUGHT THIS TRUCK. ALSO I NOTICED SCRATCHES STARTED APPEARING ON MY TRUCK AND IT HAS ON 500 MILES ON IT ESPECIAL AROUND DOOR HANDLES. I AM AFRAID TO WASH IT. *TR