2004 Volvo XC90 Complaint Log

FUEL LEAK AND SMELL PASSENGER REAR VEHICLE

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE PARKED, THERE WAS A STRONG ODOR OF FUEL COMING FROM THE VEHICLE. THE SMELL WORSENED WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPAIRED. THE REPAIRS WERE NOT PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

"TAKATA RECALL" THE AIR BAG LIGHT IS ALWAYS ON. IT IS ON ALL THE TIME. I HAVE PAPER FROM THE VOLVO DEALER WAS CHECKED TO DIAGNOSTIC THE AIR BAG. I PAYED FOR IT.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT AFTER THE VEHICLE WAS PARKED, THERE WAS A FUEL ODOR EMITTING INSIDE THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 69,000.

I HAD THIS PROBLEM A FEW TIMES A YEAR AGO AND NOW IT HAS RETURNED. I WAS DRIVING MY CAR AT NIGHT IN THE RAIN ON A TWO LANE FREEWAY WHEN ALL OF A SUDDEN I LOST THE HEADLIGHTS, DASH LIGHTS, SPEEDOMETER, RADIO, POWER WINDOWS, ELECTRIC TRANSMISSION, AND MUCH MORE FUNCTION OF THE CAR. THE ENGINE IS STILL RUNNING BUT IT SEEMS TO ALMOST RESET OR SOMETHING THEN START SHUTTING STUFF DOWN. I SEE ON YOUR WEBSITE SOMEONE PUT THIS IN AS A COMPLAINT ALSO THIS IS VERY DANGEROUS YOU CANT SEE AT NIGHT THE CAR IS HARD TO DRIVE ITS OBVIOUSLY THIS SAME PROBLEM WITH WATER GETTING INTO THE ECM. I READ THROUGH YOUR INFORMATION AND IT SEEMS LIKE VOLVO KNEW SOMETHING WAS UP WITH ONES PRODUCED BEFORE OR AFTER MARCH. IT SEEMS LIKE THEY HAVE BEEN WELL AWARE OF THE PROBLEM AND STILL WANT TO CHARGE YOU $2000 TO FIX IT! PEOPLE SHOULDN'T HAVE TO PAY TO FIX A PROBLEM VOLVO HAS BEEN WELL AWARE OF AND HAS HAD A CHEAP AND EASY SOLUTION FOR YEARS. I CALLED MY LOCAL VOLVO DEALERS AND NOT ONE OF THEM HAD ANY INFORMATION OR KNOWLEDGE OF THIS PROBLEM. WHEN VOLVO HAS A SERVICE NOTICE ABOUT THIS PROBLEM AND HAS OBVIOUSLY SPENT A LOT OF TIME LOOKING INTO IT. THE PROBLEM SEEMS TO BE REALLY BAD WHEN IT RAINS OR I USE THE WIPERS FURTHER LEADING ME TO SEE THAT IT IS THE SAME THING IN INVESTIGATION PE-10-025. THESE ARE ONLY THE PEOPLE WHO ARE COMPLAINING TO YOU THIS SEEMS TO BE A VERY COMMON ISSUE THAT VOLVO IS SWEEPING UNDER THE RUG TO MAKE A BUCK. IT'S DISGUSTING.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING FAILED AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED. THE CONTACT STATED THAT A NEW ALTERNATOR WAS PLACED IN THE VEHICLE TWO DAYS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

THIS REPORT IS ABOUT A HAZARDOUS SITUATION WITH OUR 2004 XC90. THE ENGINE SHUT DOWN WITHOUT WARNING ON THE I5 FREEWAY! THE CAR SUDDENLY LOST POWER AND WE HAD TO COAST TO THE SIDE IN THE DARK. WE WERE LUCKY TO NOT GET HIT! THE DISPLAY SHOWED THE FOLLOWING ERROR CODE: ECM-981A. WE ARE AWARE OF THE FACT THAT THIS PROBLEM IS NOT NEW TO NHTSA AND THAT YOU HAVE RECEIVED SEVERAL REPORTS ON IT ALREADY. IT APPEARS THAT THE PROBLEM HAS TO DO WITH THE CRUISE CONTROL, AND EVER SINCE THE INCIDENT WE HAVE BEEN DRIVING THE CAR WITHOUT ENGAGING IT WITHOUT ANY PROBLEMS. THE MILEAGE ON THE CAR IS 138,000 MILES. THE PROBLEM OCCURRED WHEN ENGAGING THE CRUISE CONTROL ON AN UPHILL SLOPE. WE SPECULATE THAT IT MIGHT BE CAUSED BY ENGAGING THE CRUISE CONTROL AT THE SAME INSTANT AS THE CAR SHIFTS DOWN AUTOMATICALLY. I TALKED TO A VOLVO SERVICE TECHNICIAN WHO AID THAT HE HAD EXPERIENCED THE SAME PROBLEM WITH HIS OWN 2004 XC90 BUT HE WAS UNABLE TO FIND WHAT HAD CAUSED IT.

AFTER DRIVING FOR AT LEAST AN HOUR THE VEHICLE SUDDENLY SHUTS DOWN FOR A SPLIT SECOND. ALL GAUGES GO OUT, LOSS OF POWER BRIEFLY, WIPERS SOMETIMES KICK ON AND FOG LIGHTS RESET AND SHUT OFF AND THERE IS A THUMP FROM THE TRANSMISSION. THIS HAPPENS MAINLY AT FREEWAY SPEEDS BUT HAS HAPPENED A FEW TIMES AT 30 MPH AND SLOWER. CAN HAPPEN SEVERAL TIMES ON A 2.5 HOUR TRIP. ONCE IT HAPPENS IT CAN HAPPEN ANYTIME. DOESN'T DO IT ON TRIPS AROUND TOWN. CALLED VOLVO OF NORTH AMERICA AND THEY DENIED ANY PROBLEMS WITH THE CEM AND SAID SINCE IT'S AN '04 WITH 85,000 MILES THAT I'M OUT OF WARRANTY AND THEY CAN OFFER NO HELP.

WHILE DRIVING AT ANY SPEED THE VEHICLES ELECTRICAL SYSTEM COMPLETELY SHUTS DOWN WITH OUT WARNING AS IF THE VEHICLE WAS OFF. THE ENGINE STAYS RUNNING WITH VERY MINIMAL POWER. THIS HAPPENED TO ME AT NIGHT WHILE DRIVING ON THE HIGHWAY, IT WAS RAINING AND ALL THE LIGHTS, WIPERS, EVERY ELECTRICAL PART JUST SHUT OFF, I AM LUCKY I DID NOT CRASH. AFTER RESEARCHING I THAT A LOT OF OWNERS HAVE THE SAME PROBLEMS AND THAT VOLVO IS AWARE OF THE DANGEROUS PROBLEM BUT DOES NOTHING ABOUT IT.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHEN THE CONTACT ENTERED THE VEHICLE, THERE WAS AN ODOR OF FUEL INSIDE AND OUTSIDE THE VEHICLE. THE ODOR OF FUEL COULD BE SMELLED WHENEVER THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT FUEL WAS LEAKING FROM THE VEHICLE, HOWEVER, THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. DJR

EXITING DRIVEWAY IN REVERSE, UPON SWITCHING TO DRIVE THE DASHBOARD LIGHTS STARTED FLICKERING AND A JERK WAS FELT IN THE TRANSMISSION. SOON THE DASHBOARD GAUGES AND THE INDICATORS WENT DEAD. SEVERAL ERROR MESSAGES QUICKLY "SCROLLED" (BRAKE FAILURE, AIRBAG FAILURE, ABS FAILURE, ENGINE FAILURE) THEN THE CHECK ENGINE LIGHT CAME ON AND REMAINED ON. NO POWER TO DASHBOARD CONTROLS (GAUGES DEAD, NO LIGHTS/TURN SIGNALS, NO RADIO). FRONT WINDOWS WORK, BUT NOT REAR. VEHICLE DRIVES AS IF IN LOW GEAR. UNSAFE TO DRIVE SO HAD TOWED TO DEALER. THEY ARE RUNNING DIAGNOSTICS SO TBD ON SPECIFIC ISSUE AND COST TO REPAIR. CONCERNED AS NO RECALL AND SITUATION IS SO DANGEROUS (WHAT IF I'D BEEN ON FREEWAY!) VOLVO SHOULD RECALL ALL THE 2004 XC90 AS OTHERS REPORT SAME DEFECT

I WAS HEADING TOWARDS A SUPERMARKET ON A EXPRESSWAY ON A AN AFTERNOON WHERE THERE WAS A CLICKING SOUND NEAR THE DASHBOARD ON DRIVERS SIDE. AND THEN SUDDENLY THE DASHBOARD LIGHTS STARTED FLICKERING AND A JERK WAS FELT IN THE TRANSMISSION. SOON THE DASHBOARD GAUGES AND THE INDICATORS WENT DEAD WHILE DRIVING AND THAT TOO WITHOUT ANY WARNING. THERE WAS SEVERAL ERROR MESSAGES THAT WERE POPPING UP LIKE BRAKE FAILURE, AIRBAG FAILURE, ABS FAILURE, ENGINE FAILURE AND THEN THE CHECK ENGINE LIGHT CAME ON. THE POWER WAS TOTALLY CUT OFF AND THE STEERING WAS VERY HARD. IT APPEARED AS IF THE VEHICLE IS IN A LOW GEAR. IBHAD TO TAKE THE NEXT EXIT TO COME TO A SAFE STOP AS NO INDICATORS WERE WORKING. I TRIED TO TURN OFF THE IGNITION AND THEN TRIED TO RESTART. THE VEHICLE STARTED BUT ALL THE GAUGES ON THE DASH WERE DOWN. HAD TO PUSH THE GAS PEDAL HARD SINCE THE VEHICLE WAS BEHAVING AS IF IT WAS IN LOW GEAR. POWER WINDOWS, POWER STEERING, INDICATORS, LIGHTS, GEAR SHIFT INDICATOR, AUDIO WAS TOTALLY CUT OFF. I CALLED A LOCAL TECHNICIAN AND TO CHECK THE PROBLEM, BUT HE COULD NOT FIND THE FAULT. HOWEVER HE CLEARED THE ERRORS AND CHECK ENGINE MESSAGE. THE VEHICLE WAS RESTORED AFTER ALMOST 1 HOUR. THEN I TRIED TO RETURN BACK TO HOME. THE NEXT DAY, THE SAME PROBLEM OCCURRED, AND IT KEPT OCCURRING SEVERAL TIMES. I HEARD SEVERAL REVIEWS FROM SEVERAL CUSTOMERS ABOUT THE SAME ISSUE WITH 2004 XC90. AND EVERY ISSUE IS RELATED TO CEM. THE MODULE COSTS $1200+ WHICH IS A VERY HIGH COST. THIS SITUATION IS SO DANGEROUS WHILE YOU ARE ON FREEWAYS AND MAY CAUSE ACCIDENTS. VOLVO SHOULD RECALL ALL THE 2004 XC90S AND REPLACE THESE MODULES AND ALSO COMPENSATE ALL THE OWNERS WHO HAVE REPLACED THEIR CEMS.

LOOKING FOR REPAIRS ON FUEL ISSUES,I READ IMPORTANT INFORMATION ON WHAT I WAS LOOKING FOR. MY VOLVO HAD STARTED TO SMELL LIKE GAS, MORE IN THE REAR RIGHT SIDES OR BACK SIDE. I HAD READ THAT IT MAYBE OR IS A RECALL ISSUE . I BOUGHT MY VOLVO IN 4/28/15 BEING ONLY THE SECOND OWNER,I NOTICED THE SMELL CALLED THE DEALER WHERE I BOUGHT THE CAR, THEY SUGGESTED A DIAGNOSTIC CHECK. CAME UP AS POSSIBLE VOLVO RECALL, SINCE A BOUGHT THE CAR AS IS THEY DIDN'T FIX IT, THEY DID SUGGEST ON CALLING VOLVO DIRECT FOR THIS ISSUE. I MADE A APPOINTMENT WITH AUTONATION VOLVO IN SAN JOSE CA ON 6/15/2015. WHEN SHOWING UP FOR SERVICE THEY DENIED THAT MY CAR WAS NOT A RECALL ON THAT PARTICULAR PROBLEM FUEL ISSUES, IT WAS A RECALL ON 157. I WAS SURPRISED BECAUSE I HAD GONE FOR A FUEL ISSUE NOT A SUSPENSION ISSUE. SO MY FUEL ISSUE IS STILL PRESENT. SO ALL I CAN SAY IS THAT MY ISSUE WITH MY VOLVO IS A RECALL WITCH VOLVO OF SAN JOSE CA DON'T WANT TO FIX BECAUSE ITS NOT IN THE YEAR, MODEL, MAKE. CLEARLY I HAVE THE MOBIL MAKE AND YEAR, 2004 XC90 VOLVO DO TO ALL THE INFORMATION FOUND. MYSELF AND MY HUSBAND DRIVE THIS CAR EVERY DAY PLUS MY 7 YR. OLD WITH MY NEWBORN PASSENGERS BEING A HAZARD TO MY FAMILY.WE TOOK IN THE VOLVO IN ON SATURDAY THE 10/17 OF 2015 BECAUSE THE SMELL IS REALLY BAD, WE NEED TO DRIVE WITH THE AC AT ALL TIMES BECAUSE THE SMELL OUTSIDE IS SO BAD. WE GOT REJECTED AGAIN, SAYING THE SAME MY CAR DOES NOT FALL IN THAT RECALL ALSO DO TO MY VIN NUMBER NOT MATCHING WHO KNOWS WHAT, I NEED THIS FIXED BAD. WE HAVE ALSO HAD PEOPLE TELL US ABOUT THE SMELL BEING STRONG. AS YOU CAN SEE ITS A SAFETY AND FIRE HAZARD FOR MY FAMILY'S SAFETY, AND AT THIS TIME FINANCIAL HARDSHIP IS IN ISSUE DO TO MATERNITY LEAVE TO BE PAYING SOMETHING THAT CLEARLY ITS A VOLVO ISSUE , I THINK VOLVO SHOULD TAKE THIS AS A BIG CONCERN. I DO HOPE THIS PROBLEM GETS RESOLVED AND DONE. THANK YOU FOR YOUR TIME AND WORK. *TR

I SWITCHED FROM HEADLIGHTS ON TO DAYLIGHT DRIVING LIGHTS ON. I RECEIVED A "BULB FAILURE" FOR THE DAYLIGHT DRIVING LIGHTS. I SWITCHED BACK TO HEADLIGHTS. I RECEIVED A "BULB FAILURE" FOR THE HIDS. I HAVE VERIFIED THAT THE FUSES ARE GOOD, AND THAT THERE ARE NOW NO WORKING HEADLIGHTS ON THE CAR. HAD THIS HAPPENED AT NIGHT IT COULD HAVE BEEN BAD, VERY BAD. THANK GOD IT HAPPENED DURING A SUNNY DAY AND THAT THE TEEN DRIVER WASN'T BEHIND THE WHEEL.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE THE VEHICLE WAS PARKED, AN EXTREMELY STRONG ODOR OF FUEL EMITTED NEAR THE FUEL TANK ON THE REAR PASSENGER SIDE. THE FUEL TANK EXHIBITED FUEL LEAKAGE, BUT THERE WAS NO FUEL VISIBLE ON THE GROUND. THE CONTACT EXPERIENCED THE SAME FAILURE AS MENTIONED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.

MY 2004 VOLVO XC90 WITH A 2.5T ENGINE, 7 PASS, INTERMITTENTLY AND INADVERTENTLY STALLS WHILE DRIVING IT. IT IS SCARY BECAUSE ALL ELECTRICAL GOES OFF, INSTRUMENT PANEL, RADIO, LIGHTS, ETC, SEVERAL WARNING MESSAGES APPEARS, SUCH ABS, AIR BAGS FAILURE, BRAKE FAILURE, ENGINE FAILURE, ETC. IT WON'T RESPOND TO ACCELERATION AND BRAKES ARE VERY HARD TO PUSH, THE ENGINE DOES NOT STOP. I HAVE TO STOP, TURN IT OFF, WAIT FEW MINUTES, THEN START IT, EVERYTHING COMES TO NORMAL AGAIN BUT WITH THE CHECK ENGINE AND THE AIR BAGS MESSAGE, THEN AFTER SOME MINUTES OF DRIVING THE SAME STALLING AND ELECTRICAL ISSUES HAPPEN AGAIN. THIS IS SERIOUS BECAUSE YOU ARE ON FREEWAY AND YOU LOOSE BRAKES AND ENGINE CONTROL, NO INFORMATION IN INSTRUMENT PANEL, ETC. I FOUND THAT THE RELAYS IN THE CEM (CONTROL ELECTRONICS MODULE) ARE SUPER HOT POSSIBLY DUE TO LOOSE CONNECTIONS, IN THE VIDEO BELOW YOU WILL SEE THE PROBLEMS AND INFRARED PICTURES OF THE CEM. PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE HELP!!!!!! PLEASE SEE MY YOUTUBE VIDEO AND OTHER VIDEOS WITH THE SAME ISSUE SEARCH FOR XC90 ISSUES, XC90 STALLING, XC90 ELECTRICAL PROBLEMS, ETC. HTTPS://WWW.YOUTUBE.COM/WATCH?V=FWULB1SKSIE&FEATURE=YOUTU.BE THANK YOU *TR

I HAVE A VOLVO XC90 2004. I WAS DRIVING AND SUDDENLY I HEARD A NOISE UNDER THE CAR. I STOP THE CAR AND CALL MY ROAD SERVICE PROVIDER TO SEND ME A TOW TRUCK. WE TOOK THE CAR TO THE AUTO CENTER TO HAVE IT INSPECTED, THEY CALL ME TO GIVE ME BAD NEWS THEY SAID IT WAS THE TRANSMISSION SHAFT, SOMETHING COMING OUT APART AND THAT WILL BE EXPENSIVE TO FIX AND THAT I NEEDED TO TAKE IT TO VOLVO DEALER TO GET IT FIX . I WAS IN SHOCK. I DIDN'T EXPECTED THIS SO SOON MY VOLVO CAR IT HAS 87,000 MILES AND I FEEL THIS IS A MANUFACTURER MALFUNCTION PROBLEM . THIS SHOULD BE A RECALL, ITS TOO SOON TO GIVE ME THIS HEADACHE PLEASE INVESTIGATE THIS MATTER SOON TO HELP OTHERS I WILL REALLY APPRECIATED IF I HAVE A ANSWER SOON. *TR

TO WHOM IT MAY CONCERN: I CURRENTLY OWN A 2004 XC90 T6, AND HAVE NOW ENCOUNTERED THE SAME ISSUE TWICE WITH MY VEHICLE. LAST YEAR AROUND THE SAME TIME FRAME, THERE WAS A TERRIBLE SCENT OF GASOLINE FUMES THROUGHOUT THE CABIN AND EXTERIOR OF THE VEHICLE. THE STRONGEST CONCENTRATION OF THE ODOR OCCURRED AROUND THE BACKSEAT, PASSENGER SIDE. I TOOK THE VEHICLE TO MY MECHANIC AND IT WAS CONCLUDE THAT THE WAS A FUME LEAK OCCURRING FROM THE SEAL AROUND THE FUEL PUMP. I PURCHASED A NEW PUMP AND SEAL FROM VOLVO AND HAD THE UNIT REPLACED. EXACTLY AROUND THE SAME TIME OF THE YEAR, A YEAR LATER, I AM ENCOUNTERING THE SAME EXACT ISSUE AGAIN. THERE IS AN OFFENSIVELY STRONG ODOR FROM GASOLINE FUMES IN AND AROUND THE VEHICLE ORIGINATING IN THE SAME PLACE. I DID SOME RESEARCH ON THE WEB, AND IT LOOKS LIKE THERE HAVE BEEN HUNDREDS OF SIMILAR ISSUES REPORTED. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO JERK AND THE INSTRUMENT PANEL FAILED. THE ACCELERATOR PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED FREQUENTLY. THE CONTACT ALSO STATED THAT ON SEVERAL OCCASIONS IT TOOK SEVERAL ATTEMPTS TO START TO VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE IN PARK, THE CONTACT NOTICED FUEL VAPORS EMITTING FROM INSIDE AND OUTSIDE THE VEHICLE. IN ADDITION, THE SERVICE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE) BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED AND LOST POWER. THE CONTACT ALSO HEARD WATER RUNNING ON THE RIGHT PASSENGER SIDE DOOR AND UNDERNEATH THE DASHBOARD. THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,00. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STOPPED INDEPENDENTLY. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

NOTICED THE SMELL OF FUEL WHILE EXITING THE VEHICLE. LOOKED UNDER THE VEHICLE AND NOTICED A FUEL LEAK UNDER THE DRIVER'S SIDE PASSENGER DOOR. FUEL WAS LEAKING AT THE APPROXIMATE RATE OF 3 GALLONS PER 24 HOURS. DROVE THE CAR TO THE DEALER THE NEXT MORNING. DEALER DIAGNOSED THE PROBLEM AS A CRACK IN THE FUEL SENDER LOCATED ON TOP OF THE GAS TANK (NOT THE FUEL PUMP WHICH WAS REPLACED UNDER THE PRIOR RECALL). WHEN ASKED HOW THE LEAK DEVELOPED THE DEALER STATED THAT THE PLASTIC FITTING CRACKED DUE TO THE CYCLING OF TEMPERATURES (SAME REASON FOR FUEL PUMP FAILURE AND RECALL). *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 122,000.

2004 VOLVO XC90. CONSUMER WRITES IN REGARDS TO A BROKEN FUEL PUMP AND LEAKING GAS. *SMD THE CONSUMER NOTICED A STRONG GAS SMELL IN THE GARAGE. THE CONSUMER DISCOVERED RECALL # 09V483000. HOWEVER, HE WAS NEVER INFORMED. *JB

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE IN PARK, THE CONTACT HEARD A NOISE. ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL FAILED TO ILLUMINATE AND THE VEHICLE STALLED. IN ADDITION, THE CONTACT STATED THAT THE ODOMETER DISPLAYED AN INCORRECT READING AND THERE WAS A FUEL ODOR IN THE VEHICLE. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TOWED BACK TO THE INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CENTRAL ELECTRONIC MODULE AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS NOTIFIED OF NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE FRONT END OF THE VEHICLE INDEPENDENTLY TRAVELED OUT OF LANE. IN ADDITION, THE ANTI SKID WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000. KMJ

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT WHEN SERVICING THE VEHICLE, THE TECHNICIAN DISCOVERED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 133,675.

SMELLED GASOLINE, TOOK IT TO A SHOP, THEY FOUND FUEL PUMP CRACKED, REPLACED FUEL PUMP. THEN WE FOUND OUT THE WAS A RECALL IN SOUTHERN STATES FOR THIS PROBLEM SPECIFICALLY. WE LIVE IN THE NEW ENGLAND AREA AND WAS TOLD IT WOULD NOT BE CONSIDERED UNDER THE RECALL. I FEEL COMPLETELY WRONGED IN THIS SITUATION. THE RECALL WAS SPECIFIC TO HEAT CYCLING. NO WERE IN THE US IS THIS MORE APPARENT THAN NEW ENGLAND. *TR

I AM PAYING FOR THE THIRD LIGHT BALLAST IN THIS VOLVO 700-1000 DOLLARS EACH TIME. I KNOW THIS HAS BEEN REVIEWED BY YOUR ORGANIZATION IN 2010 IT IS ONLINE. LET ME TELL YOU WHAT HAPPENS. WHEN THE BALLAST FAILS THE HEADLIGHT GO OFF. SOMETIME 1 LIGHT, SOMETIMES BOTH. I WAS ON THE HIGHWAY AT NIGHT, THE PAST TWO TIME THAT THE LIGHTS WENT OFF. GUESS WHAT, THERE IS NO BACK UP LIGHT . SO I HAD TO DRIVE TO THE NEXT EXIT IN TOTAL FEAR OF CRASHING DURING THE RAIN. OH, AND I DID PULL OVER IN THE SIDE PROBLEM THERE WAS NO SHOULDER, CONSTRUCTION. ALL YOU NEED TO LIGHT A BULB IS A FEW WATTS, THE BALLAST SYSTEM IS A JOKE AND COSTLY. IT WILL RESULT IN SOMEONE CRASHING AND DEATH. PLEASE DO NOT IGNORE THIS , CHECK ONLINE YOU WILL SEE THIS IS A VERY COMMON PROBLEM IN THIS MODEL AND YEAR. OH , ALSO HAD THE TRANSMISSION RECALLED . MINE FAILED AT 75000 MILES , STILL PAID 1500 FOR THE WORK NICE COMPANY. *TR

I JUST PURCHASED THIS VEHICLE USED A FEW DAYS AGO AND NOW NOTICE THERE IS A SMELL OF GASOLINE WHEN WE GET OUT OF THE CAR. I WENT ON LINE AND DISCOVERED THAT THERE WAS A RECALL FOR THE FUEL PUMP WHICH SITS ON TOP OF THE GAS TANK. I CONTACTED VOLVO AND THEY SAID TO TAKE IT TO THE LOCAL DEALER IN WATERBURY CT. THEY TOLD ME IT WOULD BE $800 TO REPAIR THE PART BECAUSE THE WARRANTY RAN OUT IN MAY OF THIS YEAR, AND THIS IS NOVEMBER. THIS IS A KNOWN SAFETY ISSUE AND FEEL THAT VOLVO SHOULD REPLACE THE DEFECTIVE PART FREE OF CHARGE. VOLVO SAID THAT THE RECALL ONLY APPLIES TO THAT MODEL LOCATED IN THE SOUTH OR SOUTHWESTERN US. I AM THE SECOND OWNER AND HAVE NO WAY OF KNOWING IF THIS CAR WAS DRIVEN FOR LONG PERIODS IN THOSE REGIONS. ALSO, HOW CAN THEY KNOW IF THEIR KNOWN PROBLEM WITH THIS FUEL PUMP HAS NOT SPREAD TO OTHER AREAS AS WELL? *TR

TRAVELING ON HIGHWAY AT 65 MPH, HIT A LARGE DEER, NO AIR BAG DEPLOYMENT. THE DEER SMASHED IN THE FRONT END OF VEHICLE. *TR

IN OCTOBER 2014 MYSELF MY BOYFRIEND AND MY 7 YEAR OLD WE'RE DRIVING HOME WHEN ALL OF A SUDDEN THE CAR WOULD NOT ACCELERATE WHEN I TRIED TO PUSH THROUGH THE TRAFFIC LIGHT THE VEHICLE THEN SLOWED DOWN IN THE MIDDLE OF THE ROAD THEIR WAS NO WAY OF ME TRYING TO PULL OVER BC THE CAR COMPLETELY STOPPED I THEN PROCEEDED TO GET MY 7 YEAR OLD OUT THE TRUCK AND HER SPELT BELT IN THE BACK WAS STUCK AND WOULD NOT COME OUT WE WERE ALMOST HIT FROM THE BACK DUE TO THE VEHICLE STALLING IN THE MIDDLE OF THE ROAD IN A CURVE WE WERE STRANDED FOR ABOUT THREE HOURS IN THE DARK WHEN WE WERE FINALLY TOWED HOME I WAS TOLD THAT THE TRANSMISSION WAS NO GOOD AND THIS IS THE REASON OUR VEHICLE STALLED AND WAS DISABLED. *TR

DRIVING ALONG A RURAL ROAD IN E. OREGON AT AROUND 7:30 PM AND ALL FRONT LIGHTS WENT OUT AT ONCE (ALL OF THEM). THIS CAUSED A DANGEROUS SITUATION AS WE WERE NOT IN A CELL PHONE AREA AND HAD TO SLEEP IN CAR OVERNIGHT AND DROVE OUT OF AREA AT DAYLIGHT THE NEXT DAY. THE CAR WORKED FINE EXCEPT FOR A COMPLETE LIGHTING FAILURE, WHICH IS IMPORTANT AS YOU ARE DRIVING DOWN COUNTRY ROADS IN THE DARK. *TR

CAR LOST ALL POWER AND MESSAGE WINDOW READ "REDUCED ENGINE PERFORMANCE". WE WERE TRAVELING IN THE LEFT LANE AND HAD TO COAST THROUGH TRAFFIC TO THE SHOULDER. THERE WAS ABSOLUTELY NO THROTTLE RESPONSE, SO WE SHUT THE CAR OFF. UPON RESTARTING IT, THE MESSAGE DISAPPEARED AND WE WERE ABLE TO CONTINUE OUR TRIP. IT HAPPENED AGAIN, AND WE RESET IT ONCE AGAIN. WE STOPPED AT THE FIRST VOLVO REPAIR FACILITY WE FOUND AND HAD THEM SCAN ALL THE COMPUTERS USING THE VOLVO DIAGNOSTIC EQUIPMENT. THE CODE THEY RETRIEVED WAS ECM-981A. THEY CLEARED OUR COMPUTER USING THE VOLVO COMPUTER, BUT THE PROBLEM RETURNED ON OUR RETURN HOME. WE WERE BARELY ABLE TO GET OUT OF THE WAY OF A SEMI BARRELING UPON US! THE PROBLEM STILL PERSISTS, AND I FINALLY WENT TO MY COMPUTER TO FIND SOME INFORMATION ON MY OWN. APPARENTLY, THIS IS NOT SO UNCOMMON A PROBLEM WITH THESE CARS. THERE IS ALREADY A RECALL ON SOME OF THE 2003-2004 S60'S AND V70'S. WE HAVE ALREADY SPENT CLOSE TO $2,000.00 TRYING TO REMEDY THIS PROBLEM, BUT THAT BECOMES INCONSEQUENTIAL IF SOMEONE GETS KILLED BECAUSE THE ISSUE DOESN'T GET RESOLVED. *TR

I HAVE EXPERIENCED THE KNOWN ISSUE WITH THE CENTRAL ELECTRONIC MODULE MANY TIMES NOW. I HAVE BEEN DRIVING AT HIGHWAY SPEEDS AND THEN EXPERIENCE THE MOMENTARY JERKING, LOSS OF POWER, LOSS OF INSTRUMENT PANEL, AND MORE. SOMETIMES I START MY VEHICLE AND IT STARTS IN LIMP HOME MODE. VERY FRUSTRATING AND DANGEROUS. THIS SHOULD BE RECALLED AND REPAIRED BY VOLVO. *TR

OUR 2004 VOLVO XC-90 DEVELOPED A WARNING LIGHT THAT THE STABILITY CONTROL WAS INACTIVE. IN ADDITION, WE EXPERIENCED A "SLOSHING" SOUND IN THE PASSENGER COMPARTMENT AKIN TO A BOTTLE OF WATER ROLLING AROUND THE BACK. UPON INSPECTION IT WAS DETERMINED THAT THE YAW SENSOR WAS DAMAGED DUE TO CORROSION FROM DEFECTIVE SUN-ROOF DRAINS WHICH ALLOWED WATER INTRUSION INTO THE VEHICLE BODY. NO EXTERNAL LEAKS OR ISSUES WERE EVIDENT AND THE ISSUE WAS WELL DESCRIBED UPON AN INTERNET SEARCH. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 55 MPH, THE VEHICLE STALLED INTERMITTENTLY. THE CONTACT STATED THAT THE INSTRUMENT PANEL AND RADIO WOULD SHUT OFF AND THE WINDSHIELD WIPERS ACTIVATED. ALSO, THE ABS AND ANTI SKID TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 104,000. UPDATED 10/8/14*CN THE CONSUMER STATED THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLES AGE. UPDATED 3/23/15 *JS

AS I WAS TAKING MY KIDS HOME THE TRUCK WENT INTO LIMP MODE EVEN THOUGH IT WAS STILL IN DRIVE LEAVING ME AND MY TWO KIDS STRANDED IN THE MIDDLE OF THE HIGHWAY MY DAUGHTER AND I HAD TO ACTUALLY PUSH THE VEHICLE OFF THE ROAD TO SAFETY. NOW I FIND OUT THAT IT NEEDS A NEW TRANSMISSION WHICH WE AREN'T ABLE TO LOCATE. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING 65 MPH, THE ENGINE RPMS DECREASED AS IF THE BRAKE PEDAL WERE DEPRESSED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 135,000....UPDATED 01/27/16 *BF *JS

2004 VOLVO XC90 2.5T ...DRIVING AT ABOUT 65 MPH WITH NO WARNING ALOUD THUMP NOISE, WINDSHIELD WIPER COMES ON RADIO GOES OFF DASH LIGHTS GO OFF, LAST FOR A SEC. THEN RESUMES TO NORMAL . THIS HAS HAPPENED SEVERAL TIMES NOW, WHILE I HAVE ONLY OWNED THIS VEHICLE FOR A MONTH. TODAY IT HAPPENS AGAIN ONLY WORSE ..AFTER THE INITIAL THUMP AND JERK IT HAPPENS THREE MORE WITHIN 5 MILES THE LAST TIME I WAS GOING ABOUT 35 MPH, BIG THUMP AND JERK, WIPERS COMES ON , RADIO GOES OFF , ALL DASH LIGHTS OFF ..NO HAZARDS AVAILABLE AND I GET SEVERAL WARNINGS ON DASH BRAKE FAILURE , SRS FAILURE AND ANTI SKID FAILURE. .I TURN CAR OFF THEN BACK ON AND CONTINUE HOME...IT HAPPENS AGAIN 5 MINUTES LATER AT 15 MPH....I AM READING MANY, MANY COMPLAINTS LIKE MINE. THIS ISSUE NEEDS TO BE ADDRESSED ASAP. .I ALMOST WAS REAR ENDED TWICE. VOLVO NEEDS TO TAKE RESPONSIBILITY. *TR

DRIVING VEHICLE AT 45MPH AND KEY SWITCHED OUT OF THE "RUN" POSITION WHILE BEING DRIVEN. VEHICLE'S ENGINE COMPLETELY SHUT OFF, RENDERING POWER BRAKES, POWER STEERING AND AIRBAGS AS NOT OPERATIONAL. *TR

WHILE GOING UP A HILL ABOUT 45 MILE PER HOUR THE LIGHTS ON MY DASH AS WELL AS THE RADIO TURNED OFF. I PULLED OVER TURNED THE CAR OFF AND BACK ON ALL THE LIGHTS RETURNED HOWEVER MY GAS GAUGE NO LONGER WORKS AS WELL AS UNLOCKING BACK DOORS AND DOOR TO GAS TANK. THERE ARE MANY COMPLAINTS ABOUT THIS PART I DON'T SEE WHY THERE ARE NO RECALLS THIS IS VERY UNSAFE I COULD'VE EASILY CRASHED DUE TO LOSS OF POWER BREAKS AND THE CAR NOT MAKING IT UP THE HILL. *TR

TL* THE CONTACT OWNS A 2004 VOLVO XC90. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD STALL AND UNKNOWN WARNING INDICATORS WOULD ILLUMINATE. IT TOOK THE CONTACT NUMEROUS ATTEMPTS TO RESTART THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE WINDSHIELD WIPERS ACTIVATED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT AFTER SEVERAL ATTEMPTS THE VEHICLE FAILED TO START. THE CONTACT MENTIONED THAT FOR A MOMENT THE ENTIRE INSTRUMENT PANEL ILLUMINATED, BUT THEN THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE CE MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 18,000.

UPON LEAVING OUT FOR THE DAY VEHICLE HESITATED SOMEWHAT WHEN I WOULD ACCELERATE ON GAS PEDAL. AFTER DRIVING FOR ONLY 5 MLS. VEHICLE STARTED SPUTTERING, I THOUGHT MAYBE I SHOULD STOP AND GET GAS THAT WOULD SOLVE THE PROBLEM BUT NO THE PROBLEM CONTINUED AND GOT WORSE, AS LONG AS I WAS JUST COASTING IT WAS OK, BUT UPON ACCELERATING IS WHEN IT FELT LIKE IT WAS ABOUT TO STALL AND THERE WAS ALSO FUEL SMELL WHEN ACCELERATING. THE SPUTTERING & SHAKING AND ROUGH SOUND WORSEN AS WELL. I SPOKE WITH AN AUTO REPAIRMAN AND HE INFORMED ME OF THE VEHICLES RECALLS ON FUEL SYSTEM AND THAT IT WAS MOST DEFINITELY WHAT MY SITUATION WAS WITH MY VOLVO. *TR

WHILE ON THE INTERSTATE AT 60MPH, EXPERIENCED TEMPORARILY LOSS OF POWER, THE IP DISPLAYS AND AN ABNORMAL 'JERKING' IN THE TRANSMISSION/DRIVETRAIN. THE SRS AIRBAG AND BRAKE FAILURE ERROR MESSAGES APPEARED IN THE IP ERROR DISPLAY. THE WIPERS MOMENTARILY CAME ON. LIGHTS DIMMED. POWER FAILURE WAS ONLY FOR A SPLIT-SECOND (AT 60MPH) BEFORE RETURNING TO NORMAL. AFTER NORMAL POWER WAS RESTORED, ERROR MESSAGES CONTINUED TO BE SHOWN IN THE IP ERROR DISPLAY. THE BRAKE FAILURE MESSAGE INSTRUCTED ME TO PULL OVER AND BRING THE VEHICLE TO A SAFE STOP. UPON BRINGING THE VEHICLE TO A SAFE STOP AND TURNING OFF IGNITION, I HEARD EXCESSIVE ELECTRICAL CLICKING UNDER THE DASH (LIKE RELAYS CLICKING). ALL IP DISPLAYS WERE NON-RESPONSIVE (DARK). I LOCKED THE CAR (ALARM ARMED) AND LATER RETURNED WITH A TOW-TRUCK. UPON RETURN TO THE CAR, I WAS UNABLE TO UNLOCK IT OR DISARM THE ALARM. CAR WAS UNRESPONSIVE. ALARM WAS ARMED (UNABLE TO BE DISARMED) AND THE ENGINE BYPASS FEATURE OF THE ALARM PREVENTED ME FROM STARTING THE CAR. COULD ONLY GAIN ENTRY INTO THE CAR FROM THE DRIVER'S SIDE DOOR WITH PHYSICAL KEY. CAR WAS PLACED IN NEUTRAL AND LOADED ONTO A FLATBED TRUCK FOR TOW BACK TO VOLVO DEALERSHIP. TEMPERATURE AT TIME OF FAILURE WAS 110F. *TR

SUN ROOF GLASS SHATTERED WHILE DRIVING 55+ MPH ON THE INTERSTATE FREEWAY UNDER NORMAL CONDITION DURING MY COMMUTE HOME. I CALLED THE POLICE THINKING THAT SOMEONE HAD THROW A ROCK DOWN FROM A BRIDGE OVERHEAD, BUT ONCE STOPPED I FOUND NO EVIDENCE OF AN OBJECT BEING THE CAUSE OF THE GLASS SHATTERING. THERE WERE NO MARKS ON THE ROOF OF THE VEHICLE OR ANY OBJECT FOUND INSIDE THE VEHICLE. IT WAS A SPONTANEOUS SHATTERING OF THE SUN ROOF GLASS ON AN OTHERWISE NORMAL DRIVE HOME ON A SUNNY DAY, NO WEATHER, TEMP WAS AROUND 75 DEGREES.