Volvo · XC90 · 2004
6
Recalls
462
Complaints
-
Not Rated
The 2004 Volvo XC90 has 6 recalls and 462 owner-reported complaints on file with NHTSA. Most reported issue: power train (107 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2004 Volvo XC90 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is power train with 107 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Remedy Status
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Remedy Status
DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Remedy Status
DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Remedy Status
DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT WHEEL SPEED SENSORS MAY BE DEFECTIVE, CAUSING AN ERRONEOUS WHEEL SPEED SIGNAL.
Remedy Status
DEALERS WILL REPLACE THE FRONT WHEEL SENSORS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
Remedy Status
DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Instrument panel shuts down while driving on street. I believe it is the central electronic module that fails. It has happened numerous times and it is unsafe to drive without a speedometer, tachometer, odometer fuel gauge, and temperature gauge. It has now stopped altogether. Ga...
Preview excerpt
Unsure of what the issue is with the vehicle but smells like gas in my garage and I found a recall I was never notified about I moved from Washington to Las Vegas and never received any info regarding the fuel pump recall as well as a noise that’s been going on for a year now whe...
Preview excerpt
Few days ago I came home, parked the car inside the garage and went inside. An hour later I went to the garage for something and noticed a very strong gasoline odor coming from the car. It is not coming from the reservoir and I did not put any fuel recently, so it can't be explai...
Preview excerpt
The rear right door cannot be open from inside the car. It opens fine from outside. I am aware there is a child safety lock, but in this case the problem is somewhere else. Regardless of the child safety lock position, the door cannot be open. This is a hazard, because in case oo...
Preview excerpt
Unknown..but water accumulated under the passenger seat under the amp and electrical components after a storm or rainy day.and its a lot of water when I brake i can hear a water fall..and water rushing and moving along the bottom. Of the car as I am steering im worried that the w...
Preview excerpt
The contact owns a 2004 Volvo XC90. The contact stated that after his wife started the vehicle, she smelled the odor of gasoline. The contact had been advised by his wife that the vehicle was taking longer to start up and sometimes required two or three attempts to start the vehi...
Preview excerpt
On May 26, 2022, I was stuck in traffic for four hours, and the car's CEM (central electronic module) overheated causing the dashboard to shut down three times, meaning I lost all instrument readings. After each time the dashboard shut down, I had to pull over and reset fuse #27...
Preview excerpt
While driving on the highway "SRS urgent" text came on, also hear clicking sounds under dash on driver side, then dashboard indicator lights completely disappear (speed, fuel, temperature, etc) . Extremely hot under driver side dash. Fortunately, still able to steer and brake. T...
Preview excerpt
INSIDE SMELLS OF GASOLINE AFTER STARTING, AND WHILE DRIVING. PERSISTENT. NAUSEATING WHILE DRIVING. WINDOWS MUST BE LET DOWN WHILE DRIVING.
THE FUEL PUMP UNDER THE BACK SEAT IS CRACKED AND LEAKING FUEL. THIS IS REFERENCED IN NHTSA RECALL NUMBER 09V483000. O'STEEN VOLVO IN JACKSONVILLE REFUSES TO ACKNOWLEDGE THERE WAS EVER A PROBLEM WITH THIS. IT IS ALL OVER THE INTERNET.THE VEHICLE IS NOT DRIVEABLE AS IS. THE CAR IS...
Preview excerpt
Showing 10 recent complaints from 462 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2004 Volvo models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2004 Volvo XC90 has 6 recalls recorded by NHTSA.
NHTSA has received 462 owner-reported complaints for the 2004 Volvo XC90.
NHTSA has not published a safety rating for the 2004 Volvo XC90.
The most commonly reported complaint categories for the 2004 Volvo XC90 are power train (107 reports), electrical system (84 reports), fuel system, gasoline (37 reports).
Yes. NHTSA has 6 recalls on record for the 2004 Volvo XC90. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.