Volvo · XC90 · 2005
6
Recalls
223
Complaints
-
Not Rated
The 2005 Volvo XC90 has 6 recalls and 223 owner-reported complaints on file with NHTSA. Most reported issue: power train (46 reports).
Source: NHTSA Public Records · Updated Apr 28, 2026
The 2005 Volvo XC90 page works best as a research starting point. Complaint totals show how much owner-reported activity exists, while recalls and investigations help show whether any of that activity turned into formal safety action.
Because this is a newer-era vehicle page, it usually helps to compare this year against nearby model years before deciding whether a complaint pattern looks isolated or persistent. On this page, the most prominent complaint area is power train with 46 reported complaints.
This page combines three types of NHTSA data: recall campaigns (official manufacturer or government actions), owner complaints (unverified consumer reports), and crash test ratings (where available). A vehicle with many complaints is not necessarily less reliable — complaint volume correlates with sales volume and vehicle age. Recalls indicate identified defects, not overall quality. To compare this model year with others, use the year navigation in the sidebar or return to the model overview page.
If you are researching a used vehicle, start with the complaint categories, compare them against the recall list, and then check nearby model years to see whether the same issue profile repeats. That usually produces a better buying or research signal than treating the raw complaint total as a standalone safety ranking.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Remedy Status
VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Remedy Status
DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY.
Remedy Status
DEALERS WILL INSPECT AND ENSURE PROPER PLACEMENT OF THE JACK CRANK HANDLE AND A WARNING LABEL WITH APPROVED TEXT WILL BE AFFIXED TO THE BRACKET WHICH RETAINS THE BATTERY. THIS WARNING LABEL WILL INFORM AN OPERATOR NOT TO PLACE THE JACK CRANK HANDLE BETWEEN THE BRACKET AND THE BATTERY FREE OF CHARGE. THE RECALL BEGAN ON JULY 7, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Remedy Status
DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Remedy Status
DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.
Remedy Status
DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and ca...
Preview excerpt
I’ve had to change my fuel injection pump and catalytic convert twice on one year.
ADAS, AIR BAR Warning lights/urgent and High Gas fumes coming out from the rear seats when fully filled gas. We had called 800-458-1552 and guided us to plug in our VIN [XXX] on www.volvocars.com and nothing showed as far as recall and told us that these recalls expired and our ...
Preview excerpt
Water is leaking from the windshield into the driver and passenger side inside on the window obstructing my view while driving. Cannot drive the vehicle while it’s raining. Serious safety problem! Please recall and fix all Volvos with this problem.
WHEN CRANKING IT STALLS AND CUTS OFF AND AFTER DOING IT AROUND 10 TIMES IT FINALLY CRANKS THEN I HAVE TO HURRY TO PUT IN DRIVE TO GET THE MOTOR GOING IN ORDER TO KEEP HER CRUNK AND COUPLE WEEKS AGO BECAUSE THIS PROBLEM SHE STALLED OUT AND I HIT A HOLE IN THE ROAD AND BUSTED THE...
Preview excerpt
BOUGHT CAR AND BEEN HAVING PROBLEMS EVERY SINCE I HAVE HAD PROBLEMS I KEEP FUEL INJECTION IN IT SO I CAN MOVE THE CAR TO POINT A AND B
THE KNOWN VOLVO BALANCE SHAFT FAILURE IN THE 05 XC90 V8 B8444S ENGINES SN UP TO 6833.VOLVO HAS KNOWN THE V8 ENGINE ON THE 2005 XC90 IS FAULTY SINCE 2005.SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION & HUMIDITY.MINE HAS NOT FAILED YET.I WILL BE LUCK...
Preview excerpt
TL* THE CONTACT OWNS A 2005 VOLVO XC90. EVER SINCE THE VEHICLE WAS PURCHASED IN NOVEMBER OF 2018, THERE HAD BEEN SEVERAL ELECTRICAL FAILURES. THE HEADLIGHTS, POWER DOOR LOCKS, AND POWER REARVIEW MIRROR FAILED TO OPERATE. ALSO, THE TRANSMISSION CAUSED THE VEHICLE TO JERK AND STALL...
Preview excerpt
BEGAN SMELLING GAS ODOR AND NOTICED A SMALL LEAK. FOUND THAT THERE WAS A RECALL ON THE FUEL PUMP FOR MY MODEL AND YEAR BUT WHEN I CALL VOLVO ABOUT THE RECALL, MY VEHICLE WASN'T INCLUDED EVEN THOUGH MY VEHICLE WAS REGISTERED IN THE STATES WHERE THE RECALL WAS ASSOCIATED.
GASTANK WAS LEAKING WHEN I WAS FILLING UP IN FULL TANK NOT VERY MUCH BUT I SMELL WHENEVER I WAS PARKING
Showing 10 recent complaints from 223 total
View Full Complaint LogThe strongest comparison flow is usually: exact vehicle-year page, then nearby years of the same model, then other 2005 Volvo models. That sequence helps separate one-off year spikes from broader make-wide patterns.
The 2005 Volvo XC90 has 6 recalls recorded by NHTSA.
NHTSA has received 223 owner-reported complaints for the 2005 Volvo XC90.
NHTSA has not published a safety rating for the 2005 Volvo XC90.
The most commonly reported complaint categories for the 2005 Volvo XC90 are power train (46 reports), engine and engine cooling (30 reports), electrical system (19 reports).
Yes. NHTSA has 6 recalls on record for the 2005 Volvo XC90. Scroll up to review the published recall summaries, consequences, and remedies. To check for unrepaired recalls on your specific vehicle, use your VIN at nhtsa.gov/recalls.
Look up recalls and complaints for any year, make, and model.
This page summarizes publicly available data from the National Highway Traffic Safety Administration (NHTSA). Complaint counts reflect reports submitted to NHTSA by vehicle owners and do not by themselves prove defect severity or vehicle safety. Safety ratings may not be available for all vehicle-years. This site is not affiliated with NHTSA or any vehicle manufacturer. For official information, visit the official NHTSA page for this vehicle.