2024 Kia EV6

Went to charge my vehicle in my garage on 4/15/26. When it was fully charged, I reached to disconnect the charger from the vehicle and the connector was hot to the touch; the charging hub on the vehicle was also hot, the charger had a slight plastic burning smell. I immediately tried to contact the company and learned that they had unbeknownst to me, ceased conducting operations in the US. So I ordered a new charger. I also tried it again on 4/17/26; and the heat was higher faster than it was on 4/15/26; so I hav disconnected the device and installed a new one. The electrician noted that the breaker was damaged and had to be replaced. I also recall, that a few months after the initial install of the charger, there was an incident where my wife saw sparks in the garage from the breaker and we heard a large pop; and then the charger went out. The company sent us a new one then that worked fine for a few years.

Issue was diagnosed as ICCU failure.

I had just finished charging the vehicle overnight on a Level 2 charger at a family members home. After leaving the driveway and driving a few hundred feet, an error message showed on the vehicle screen saying "Check Electric Vehicle" system, and then later a second message that said to stop the vehicle. I immediately turned the car around parked it in the driveway again and called roadside assistance to have it towed to the Kia service center. The Kia service center confirmed that it was an ICCU (integrated charging control unit) failure, which they replaced 4-5 days later after ordering the part. These error messages were the first and only indicator of the problem, there were no smaller issues leading up to the issue. Because the failure happened within a block of a family member's home, I was able to get to safety. But it could have been a completely different situation had the failure occurred even a few minutes later when I was on the freeway.

Known ICCU issue by manufacturer. While driving get alert on screen the check electrical system. Had to pull over and call tow truck for safety reasons. Charging system is not working properly and 12v battery can die at anytime.

Was trying to drive EV. As soon as I pulled out of driveway it gave me a warning sign; to check electrical system/stop vehicle and check power supply. I couldn't drive car anywhere, had to get it towed to dealership. When tow truck arrived we couldn't turn car on, it had no power. Mind you, I had full charge on EV.

I purchased this vehicle just over a year ago as a CPO model with only 8,000 miles on it. It now has just over 23,000 miles. In this short time of ownership, it has been back to the dealership 3 separate times for serious EV system issues. The first visit involved a software update intended to correct a 12-volt charging issue that could prevent the vehicle from charging and potentially cause ICCU failure. Shortly after that update, the 12-volt battery failed, despite being <18 months into service, completely bricking the vehicle and leaving me stranded waiting for a tow. The battery was replaced under warranty. Less than 2 months later, while >30 miles from home, the vehicle displayed a “Check Electrical System Failure” warning. I was able to limp-mode the car back to the dealership. I am now being told that the main EV battery has failed and must be replaced, possibly also the ICCU. The dealership cannot provide a firm timeline for repairs; parts availability could mean anywhere from 2 weeks to 4 months without the vehicle. This pattern of failures raises serious concerns about the reliability and safety of the EV6. Repeated electrical system issues create a very real risk of being stranded unexpectedly, potentially in unsafe situations such as on the side of a highway. To date, I have already lost four days of use due to service repairs, and I now face being without the vehicle for an extended and uncertain period. While a loaner vehicle is being provided, I will incur fuel expenses at a time of rising gas prices, undermining the financial rationale for purchasing an EV. Meanwhile, I continue making payments on a vehicle I cannot use, which is depreciating in value. I understand that new technology carries some risk. However, despite prior updates and even a model refresh, the ICCU issue appears unresolved, and Kia does not seem to have a clear root cause identified. For a vehicle marketed on innovation and dependability, this experience has indicated otherwise.

The driver (my wife) was operating the Kia EV6 (with approximately 10,000 miles) when the vehicle suddenly experienced a severe loss of motive power. While driving, a warning message appeared on the dashboard indicating an issue with the power supply. Immediately after, the vehicle forced itself into "turtle mode," severely restricting the maximum speed to 20 mph and refusing to accelerate further. This sudden, unexpected deceleration on an active roadway put the driver at a significant risk of a rear-end collision. The driver managed to slowly navigate the vehicle back to our residence at a maximum speed of 20 mph, which was extremely hazardous. Shortly after safely parking at the residence, the vehicle experienced a complete electrical failure. It would no longer start, could not be shifted into neutral, and ultimately had to be dragged onto a flatbed tow truck by roadside assistance because the wheels were locked. The vehicle was towed to an authorized Kia dealership, where it is currently undergoing diagnosis and inspection for what is heavily suspected to be a total failure of the Integrated Charging Control Unit (ICCU) and 12-volt battery system. The vehicle and the failed components are currently at the dealership and are available for inspection upon request. Note: This catastrophic power loss occurred just weeks after the vehicle was in the shop for nearly a month to have its entire high-voltage battery pack replaced due to severe range degradation, marking the second major electrical system failure on this vehicle.

The Integrated Charging Control Unit (ICCU) of my KIA EV6 failed. When putting the car into reverse to leave my workplace, I heard a fuse pop and a notification appeared on dashboard screen saying "Check electric vehicle system". This is a known recall issue that I was aware could happen, and in which case the car will soon become completely inoperable, so I didn't risking driving further. I had it towed to the nearest KIA dealership, where they confirmed the ICCU had failed and replaced it at no charge under the warranty coverage. There were no warnings or symptoms prior to the failure. I was fortunate that it did not fail while I was driving.

The ICCU on the car failed and blew a fuse. KIA had to replace ICCU and fuse under warranty

Was backing out of a parking lot space when a loud popping sound was heard from the right rear portion of the car. Shortly after a check electrical system message was displayed and to pull over. Then eventually had a power limited message pop up after 12V battery charging status/condition was checked by roadside service. Would turn out to be the ICCU (Integrated Charging Control Unit) after dealership nearby (Peak Kia) was able to diagnose the problem. Unknown if the failed part is available for inspection. I wouldn't say my safety or others safety was put at immediate risk, but could have been since the car did eventually completely shut down right as I was able to get home only about 1-2 miles away. Vehicle was seen by dealership a few days later and as far as I'm aware are the only entity to do an inspection on the vehicle. No prior warning of any kind before the ICCU failed, and car had complied with all recalls that were supposed to prevent or at least reduce chances of ICCU issues.

The vehicle had an electric supply failure, suggesting a failed ICCU. This left me stranded and requiring a tow. The issue is not uncommon in this vehicle but there is no recall. Kia and Hyundai need to get this right rather than keep repairing these when they adhoc fail.

Driving car and then all of the sudden a critical battery alarm appeared and I lost the ability to go above 23 mph. It ended up being the ICCU that needed to be replaced.

Vehicle Information: 2024 Kia EV6 (VIN: [XXX] ) Mileage at time of failure: 14,005 Complaint Description: My 2024 Kia EV6 experienced a complete failure of the 12-volt battery system despite the high-voltage traction battery showing approximately 80% state of charge. The vehicle became completely inoperable without warning. The 12-volt battery was fully discharged and the vehicle would not enter READY mode. The vehicle required a jump start to become operational. After being jump started, the 12-volt system did not appear to charge properly, suggesting a failure of the Integrated Charging Control Unit (ICCU), which is responsible for converting high-voltage battery power to maintain the 12-volt battery. This failure created a significant safety concern because: The vehicle became completely disabled without warning. This failure occurred while driving in heavy traffic, it created a hazardous situation. The vehicle’s electrical systems, including safety systems, depend on the 12-volt battery. There are known reports of ICCU failures in Kia and Hyundai electric vehicles that result in identical symptoms (sudden 12-volt battery discharge despite adequate traction battery charge). This suggests a potential systemic defect rather than normal battery wear. I am filing this complaint due to concern that this issue represents a broader safety defect affecting multiple vehicles and may require investigation or expanded recall action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

* Per paperwork from the car dealer, the ICCU failed along with a 3way valve assembly and a fuse blew. * While driving, the car went into a limp mode greatly limiting its maximum speed. * I was afraid to continue driving it and had the car towed to the KIA dealership. * It took exactly a month for it to be repaired. * The dealership kept the failed parts. * No warning lamps until the failure occurred. * When the failure happened a warning message stated "Check electric vehicle system!" and a battery symbol turned red. *Since it was taking what seemed like a long time for repair, I contacted Kia-Customer-Care and they assigned case number 25902713.

2024 EV6 GT-Line with 13,165 miles suddenly showed multiple faults, including "Check electric vehicle system” followed shortly by "Stop vehicle and check power supply". The vehicle almost immediately stopped in the roadway, and my wife (driver) was unable to move the vehicle or even put the vehicle in neutral so the vehicle could be moved. The car is at a Kia dealership for repair who confirmed an ICCU failure. This is an exceptionally dangerous situation.

While operating my 2024 Kia EV6, the vehicle began displaying repeated warnings related to the power system and 12-volt battery. The instrument cluster first showed a “Power limited” message, followed shortly by a “Stop vehicle and check power supply” warning. At the same time, the vehicle indicated that the 12-volt battery was low, despite the high-voltage traction battery being at or near full charge. Shortly thereafter, the 12-volt battery became fully depleted, resulting in a complete loss of low-voltage electrical power. I was unable to electronically unlock the doors, and the vehicle could not be started or shifted into gear. The vehicle became immobilized and inoperable, requiring towing. This failure occurred without warning and created a safety concern, as loss of power could potentially occur while driving or leave occupants stranded and unable to access the vehicle. The vehicle had previously been serviced at a Kia dealership for known power system concerns related to the Integrated Charging Control Unit (ICCU). During that visit, the dealership applied a firmware update only and did not replace the ICCU hardware. The current failure occurred after that firmware update, suggesting the issue was not resolved. This incident represents a loss of motive power and loss of vehicle electrical systems, which could present a serious safety risk if it occurs while the vehicle is in motion or in unsafe environments. The inability to unlock doors or start the vehicle due to complete 12-volt battery depletion is particularly concerning. When roadside assistance arrived to tow the vehicle to the dealership, the vehicle’s 12-volt battery was completely depleted, preventing normal recovery procedures. A portable jump starter was temporarily connected, but the vehicle would not remain powered on long enough to complete the steps required to place the vehicle into neutral or tow mode.

ICCU FAILURE. COMMON ISSUE REPORTED WITH EV6s 2022-2025.

The ICCU failed while I was driving my car on a 50 mph road. Check electrical system warning lights appeared. Maximum speed was reduced to 19mph and my car became a road hazard for other cars on the road. I managed to pull off the road once I found a safe spot. After visiting the Kia dealership, the problem was confirmed as a failed ICCU (Integrated Charging and Control Unit) and replaced under warranty. No problems appeared prior to the failure. Vehicle was required to be towed to the repair facility.

After starting the car, a message displayed on dashboard "Check Electrical System." I tried driving the car out of the garage and then a message displayed to the effect of "Stop the car and check battery." I called the dealer and they said to have the car towed to them. After having the car towed to the dealer, they ended up replacing the Integrated Charging Control System (ICCU) and fuse. The danger is that the failure of this ICCU part could cause immediate loss of power when driving. Luckily, that didn't happen to me since I was only creeping slowly out of my garage.

Driving with my wife and [XXX] child, there was a pop sound from under the car, and the car suddenly showed multiple faults, including "Check electric vehicle system”, which cleared on their own. I parked and turned the car off and on again and the faults reappeared. I started driving home, and during the drive it showed "Stop vehicle and check power supply" and audibly alarmed. As I was only half a mile from my house on local quiet roads, I made it. A few minutes later, I tried to turn on the car and some displays were off, there was no drive power, the steering wheel did not turn, the door locks were flakey, and I wasn't able to tell if I had shifted into Park or if the parking brake was engaged. When the tow truck arrived, the car was completely unresponsive and there was no way to release the parking brake or shift the car in neutral, so the car was dragged across the pavement and onto the tow truck. The failure was quick and comprehensive and could have easily caused injury. There are many highways near me with fast, busy traffic and either no emergency shoulder or a very narrow one. If my car tells me that I need to stop the vehicle, that can create a very dangerous choice between stopping somewhere less safe quickly or risking the car being completely disabled while in the travel lane while I look for a safer spot. Loss of cabin heat can easily become dangerous very quickly in the winter. Many drivers may not even understand the urgency of the warning until the car starts failing to drive. The car is at a Kia dealership for repair who confirmed an ICCU failure. See related NHTSA recall no 24V-867 and others. ICCU failures are endemic to Kia and Hyundai EVs. ICCU failures are widely discussed on many internet forums and seem much more common than the 1% failure rate claimed by Hyundai/Kia. FYI, an interesting root cause analysis was shared on a German EV forum: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)