2004 MINI Cooper

The contact owns a 2004 Mini Cooper. The contact received notification of NHTSA Campaign Number: 15V660000(STEERING); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure, causing the driver to lose control of the steering and drive off the road. The exact cause of the failure was not determined, and the vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 160.000. Parts distribution disconnect.

Mini felt like it was getting pushed by the wind . Realized wasn't wind Mini loss of completely all functions of steering wheel. On super busy highway. Devine intervention Was in far left car went left to right lanes then hit median gaurd rail spun around Finally got it to stop. Never Hitting and hurting anyone around me. Nobody hit me. Car is totalled ! Still at tow place. I saw my life flash as cars were zooming by me. Someone should be held responsible for my car and almost my life. Called out of work can't move upper body that well.

WAS DRIVING CAR ON 18 JULY 2020 AND POWER STEERING QUIT WORKING AND MADE STEERING DIFFICULT, ALSO COOLANT FAN,LOW SPEED AND HIGH SPEED STOPPED WORKING SAME TIME AS POWER STEERING QUIT. THE ASC LIGHT CAME ON AND IT WILL NOT TURN OFF. NO BLOWN FUSES IN ENGINE COMPARTMENT OR BY DRIVERS KICK PANEL. I WAS DRIVING THE CAR ON A STATE ROAD WHEN THIS OCCURRED.

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT ATTEMPTING TO MAKE A TURN, THERE WAS AN ABNORMAL GRINDING SOUND COMING FROM THE STEERING COLUMN. THE CONTACT ALSO STATED THAT THERE WAS A POWER STEERING FLUID LEAK PRESENT. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO MINI OF STEVENS CREEK LOCATED AT (4201 STEVENS CREEK BLVD, SANTA CLARA, CA 95051), AND DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.

THE POWER STEERING IS VERY STIFF TO DRIVE AND CANNOT DRIVE MY COOPER BECAUSE I CAN NO LONGER STEER THE VEHICLE.

WHEN YOU TURN WHEEL LEFT OR RIGHT IT MAKES A NOISE AND IT'S VERY HARD TO TURN. SO I THINK IT'S THE STEERING: ELECTRIC POWER ASSIST SYSTEM. RECALL ID # 240625.

MY WIFE WAS DRIVING OUR 2004 MINI COOPER HOME TRAVELING UPHILL ON A STEEP PAVED MOUNTAIN ROADWAY TRAVELING A MAXIMUM OF 15 MPH WHEN FOR SOME UNKNOWN REASON THE VEHICLE LEFT THE ROADWAY; STRUCK A TREE WITH ITS LEFT FRONT AND BURST INTO AN EXPLODING FIRE KILLING MY WIFE WHO WAS NOT ABLE TO ESCAPE THE BURNING VEHICLE. THE NC STATE POLICE ARE INVESTIGATING THE CAUSE OF THE FIRE AND DEATH. THEY DO NOT KNOW YET WHETHER THE VEHICLE CAUGHT FIRE PRIOR TO STRIKING THE TREE BUT, FEEL THE FIRE COULD NOT HAVE BEEN CAUSED BY THE VEHICLE STRIKING THE TREE AT A LOW IMPACT AND SPEED. NC MV ACCIDENT REPORT#[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

ALL MODELS FROM 2005 ONWARD HAVE BEEN RECALLED, YET EARLIER MODELS HAVE THE SAME PROBLEMS WITH NON FUNCTIONING AIRBAGS. THE AIRBAG WARNING LIGHT IS ON CONTINUALLY, AND THERE ARE KNOWN PROBLEMS WITH WIRING, PRESSURE MATS AND CONNECTORS IN THESE VEHICLES. BMW IS INTENTIONALLY IGNORING THESE ISSUE. MY OWN PERSONAL VEHICLE HAS THIS PROBLEM AND AS A GOVERNMENT MANDATED SAFETY DEVICE I BELIEVE THAT EARLIER MODELS OF MINI COOPERS SHOULD BE INCLUDED IN THE RECALL!

MAINLY WHILE COLD AND AT LOW SPEED'S THE WHEEL SUDDENLY BECOMES VERY HARD TO TURN AND I WAS TOLD BY A MECHANIC BUT IT'S A FAULTY HYDRAULIC POWER STEERING PROBLEM

VERY HARD TO TURN STEERING WHEEL AT TIMES ESPECIALLY WHEN MOVING SLOWLY; COMING TO A TURN AT A LIGHT, BACKING OUT OF A PARKING SPOT, ETC.

2004 MINI COOPER PURCHASED NEW APROX 62 MILES ON IT AND THE CVT TRANSMISSION IS GONE & THERE WAS A CLASS ACTION LAWSUIT FOR THE REPLACEMENT OF THIS, I WAS NEVER NOTIFIED AND WANT THIS FIXED AT NO COST TO ME. AT APROX. 50 TO 60 MPH THE CAR ENGINES GOES WAY BEYOND THE PROPER RPM.

AIRBAG LIGHT COMES ON AND STAYS ILLUMINATED. WE ARE UNSURE IF THE SYSTEM IS WORKING PROPERLY. WE HAVE NOT RUN DIAGNOSTIC CODES ON THE SYSTEM.

I OWN A 2004 MINI COOPER. I WAS DRIVING AND LOST ALL POWER STEERING ALMOST CAUSING A ACCIDENT. THERE IS A OPEN RECALL ON THIS ISSUE. I CONTACTED MINI AND THEY INFORMED ME THAT MY VEHICLE WAS NOT INCLUDED WITH THE RECALL. I EXPLAINED THAT MY CAR WAS EXPERIENCING ALL THE ISSUES ADDRESSED IN THE RECALL, BUT THEY STILL WOULD NOT HELP ME OUT.

THE VEHICLE WAS HARD TO STEER AND SMOKE WAS COMING FROM THE ENGINE. TOOK THE CAR HOME, DID NOT SEE FLAMES, PARKED CAR IN THE DRIVEWAY SWITCHED CARS AND LEFT. RECEIVED A CALL FROM THE FIRE DEPARTMENT THAT MY MINI WAS ON FIRE AND I NEEDED TO RETURN TO MY HOUSE.

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN IN EITHER DIRECTION. THE ELECTRIC POWER STEERING WARNING INDICATOR WAS NOT ILLUMINATED. AN UNKNOWN DEALER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY, AND WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) AND NHTSA ACTION NUMBERS: EA11005 (STEERING) AND PE10038 (STEERING). THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

THE POWER STEERING IN MY 2004 MINI COOPER S FAILED LAST MONTH, PROMPTING ME TO RESEARCH WAYS TO FIX THE VEHICLE ONLINE. I FOUND THAT MINI USA HAD ISSUED A RECALL ON MY CAR, BUT WAS INFORMED BY THE DEALERSHIP AND THEN MINI THAT MY VIN NUMBER DID NOT FALL AMONG THOSE VEHICLES RECALLED. I'M WONDERING WHETHER MINI APPROPRIATELY LIMITED THEIR RECALL CONSIDERING MY VEHICLE HAS THE SAME PROBLEM THAT PROMPTED THE RECALL, AND FALLS WITHIN THE SAME MODEL AND YEAR RANGE. I THINK THE DEPARTMENT SHOULD INVESTIGATE WHETHER TO EXPANDING THE RECALL.

MINI COOPER POWER STEERING PUMP FAILURE. VEHICLE WAS RECENTLY DRIVEN AND WAS PARKED ON THE STREET. WE STARTED THE VEHICLE AND BACKED UP TO PULL OUT OF THE PARKING SPOT. THERE WAS NO POWER STEERING. WE HAD TO ATTEMPT TO BACK UP AGAIN TO GET OFF OF THE STREET AND IN TO THE PARKING SPOT. A BURNING SMELL AND SMOKE STARTED FROM UNDER THE HOOD. THE POWER STEERING PUMP AND COOLING FAN HAD FAILED. THERE ARE DOCUMENTED ISSUES WITH THIS FAILURE. WHEN I CONTACTED THE DEALERSHIP, I WAS TOLD THE EXTENDED WARRANTY FOR THIS ISSUE EXPIRED IN APRIL. THIS HAPPENED JUNE 12TH.

THE AIRBAG LIGHT IS ON FOR THE PASSENGER SIDE PRESSURE MAT BUT THE DEALERSHIP INDICATES THERE IS NO OPEN RECALL ON THIS PARTICULAR CAR EVEN THOUGH MANY CARS WITH SIMILAR PROBLEM WERE RECALLED. SCAN TOOL INDICATES PASSENGER SIDE PRESSURE MAT. THE DEALERSHIP INDICATED THIS MODEL WAS OUTSIDE OF THE RECALLED VINS. WE DON'T KNOW WHETHER THE AIRBAG WOULD WORK OR NOT IF IT WERE NEEDED.

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE'S BATTERY WAS LOCATED IN FRONT OF THE FIREWALL ABOVE THE GEAR BOX. THE BATTERY ACID LEAKED ONTO TWO SHIFTER CABLE LINKAGES, WHICH CAUSED THEM TO MELT UNEXPECTEDLY. THE VEHICLE WOULD NOT SHIFT GEARS. THE CONTACT ALSO STATED THAT THE SAME FAILURE OCCURRED ONE OTHER TIME. THE VEHICLE WAS REPAIRED SIX MONTHS AGO BECAUSE OF THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT THE VEHICLE LOST POWER STEERING AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE DEALER REFUSED TO PERFORM THE REPAIR DUE TO THE UPDATED PART PREVIOUSLY BEING INSTALLED ON THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000. PARTS DISTRIBUTION DISCONNECT.